IllustrationABS LOCK INTERMITTENTLY, CAUSING STEERING TO LOCK UP
1992 Chevrolet Astro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Chevrolet Astro do not stand out strongly from the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 132 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports6 fire reports10 injury reports
What owners actually said
132 reportsTHE DRIVER'S SEATBACK COLLASPED AS OWNER WAS GETTING INTO THE VAN. THE SEAT HAS NOT BEEN REPAIRED. *AK
PEDAL TO FLOOR FAILURES OF BRAKES SOMETIMES OBSERVED AT LOW-MODERATE SPEEDS WITH RAPID/HARD BRAKING PRESSURE.
NOTHING
ABS FAILURE. PEDAL WENT TO FLOOR WHEN TRYING TO STOP QUICKLY AT LOW TO MODERATE SPEEDS.
THE POWER STEERING PUMP AND POWER BRAKE PUMP ARE ONE UNIT, THEREFORE WHEN FAILURE OCCURRED, BOTH UNITS WERE EFFECTED.
ANTI-LOCK BRAKES FAILED SEVERAL TIMES, ONCE RESULTIN GIN A COLLISION. *AK
ABS BRAKES FAILED TWICE. ALSO, ABS WARNING LIGHT CAME ON/OFF. *AK
WHILE DRIVING BRAKE FLUID BUILDS UP IN THE ELECTRIC CONTROL MODULE AND CAUSES THE ABS TO MULFUNCTION, RESULTING IN ABS FAILURE. ALSO, MASTER CYLINDER LEAK CAUSED BRAKE PEDAL TO GO TO THE FLOOR DURING STOP. *AK
BRACKETS HOLDING FRON TDIFFERENTIAL/TRANSMISSION DISCONNECTED FROM FRAME, FALLING DOWN ON STEERING COLUMN ROD, CAUSING STEERING TO LOCK. *AK
Official recalls
194V177000 · Seats:front Assembly:head Restraint
Sep 14, 1994
THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Remedy: SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP92012 · Apv Fires
Opened Jun 9, 1992 · Closed Jun 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
APV FIRES