IllustrationWHENEVER ABS BRAKES ARE APPLIED VEHICLE FAILS TO STOP, RESULTING IN EXTENDED STOPPING DISTANCE. SOMETIMES WOULD LOCK UP UNEXPECTEDLY. HAD BEEN TO DEALER & HAD ABS BRAKES REPAIRED. THE BRAKING PROBLEM HAS REAPPEARED. *AK
1992 Chevrolet Astro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Chevrolet Astro do not stand out strongly from the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 132 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 53 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports6 fire reports10 injury reports
Service Brakes, Hydraulic complaints
53 reportsWHILE DRIVING AT 35 MPH AND APPLYING THE BRAKES, BRAKE PEDAL WENT HALF WAY TO THE FLOORBOARD, CAUSING THE CONSUMER TO REAR END THE VEHICLE IN FRONT. *AK
WHEN DRIVING AT 60 MPH OR MORE AND APPLYING THE BRAKES PEDAL IS HARD AND WON'T GO DOWN. CONSUMER HAS TO WAIT UNTIL THE VEHICLE SLOWS DOWN BELOW 60 MPH AND APPLY THE BRAKES, AND THEN VEHICLE WILL COME TO A STOP. *AK
WHEN APPLYING BRAKES THE PEDAL GOES TO THE FLOOR, AND THE VEHICLE DOES NOT STOP. ALSO THERE IS A HONKING NOISE COMING FROM THE BRAKES. DEALER CAN'T DUPLICATE THE PROBLEM. *AK
ANTI-BRAKE SYSTEM EXPERIENCE LOCK-UP. VEHICLE HAS TO BE COOLED OFF, THEN THE BRAKES WOULD RELEASE BY THEMSELVES. DEALER NOTIFED, INFORMING CONSUMER THAT NOTHING COULD BE DONE UNLESS CONSUMER PICKS UP THE EXPENSES FOR REPAIRS. SEEKING HELP OR FURTHER INFORMATION FROM NHTSA. *AK *YC
WE HAVE HAD PROBLEMS STOPPING THE VAN. WHEN YOU USE THE BRAKES YOU MUST BE VERY VERY FAMILIAR WITH THEM AND NOT HIT THEM HARD, THEY MUST BE APPLIED VERY GENTLY OTHERWISE THEY WILL NOT STOP THE VEHICLE. IT WILL JUST KEEP ON GOING THEY LOCK UP OR SOMETHING, I AM NOT A MECHANIC AND THE WORD LOCK UP MIGHT NOT BE RIGHT. THE BOTTOM LI…
Read full complaint
WE HAVE HAD PROBLEMS STOPPING THE VAN. WHEN YOU USE THE BRAKES YOU MUST BE VERY VERY FAMILIAR WITH THEM AND NOT HIT THEM HARD, THEY MUST BE APPLIED VERY GENTLY OTHERWISE THEY WILL NOT STOP THE VEHICLE. IT WILL JUST KEEP ON GOING THEY LOCK UP OR SOMETHING, I AM NOT A MECHANIC AND THE WORD LOCK UP MIGHT NOT BE RIGHT. THE BOTTOM LINE IS THEY DO NOT STOP THE VAN IF YOU DO NOT APPLY JUST THE RIGHT AMOUNT OF PRESSURE. IN AN EMERGENCY THEY WOULD BE EXTREMELY DANGEROUS. WE ALWAYS JUST LIVED WITH IT AND ADAPTED, BUT IT IS NOT RIGHT I THINK. *AK
DRIVING AT APPROXIMATELY 30 MPH CONSUMER EXPERIENCED COMPLETE BRAKE FAILURE. BRAKES WENT COMPLETELY TO THE FLOOR, CAUSING THE VEHICLE TO ACCELERATE AND RESULTING IN AN ACCIDENT. *AK
TRAVELING 30MPH WHEN ABS BRAKE LIGHT CAME ON. HAPPENS WHEN THE BRAKES ARE APPLIED HARD. TOOK VEHICLE TO DEALER & INFORMED NEEDED A PRESSURE MODULATOR VALVE. *AK
ABS FAILURE.
AFTER A QUICK STOP TO AVOID AN ACCIDENT, WHICH THE QUICK STOP HAD TO TURN RIGHT TO AVOID THE OTHER VEHICLE, THE ABS FAILED OR SO THE IDICATOR LIGITS SAYS. HAD SYSTEM CHECKED AND ABS VALVE BODY HAD TO BE REPLACED. COST $1400.00 I KNOW NHTSA WAS INVESTIGATING THE GM ANTILOCK BRAKE SYSTEMS, THOUGHT IT WOULD BE HELPFUL. WOULD APP…
Read full complaint
AFTER A QUICK STOP TO AVOID AN ACCIDENT, WHICH THE QUICK STOP HAD TO TURN RIGHT TO AVOID THE OTHER VEHICLE, THE ABS FAILED OR SO THE IDICATOR LIGITS SAYS. HAD SYSTEM CHECKED AND ABS VALVE BODY HAD TO BE REPLACED. COST $1400.00 I KNOW NHTSA WAS INVESTIGATING THE GM ANTILOCK BRAKE SYSTEMS, THOUGHT IT WOULD BE HELPFUL. WOULD APPRECIATE ANY NEWS AS TO POSSIBLE REIMBURSEMENT BY GM FOR FAULTY ABS SYSTEMS. PROPER USE OF THE BRAKE SYSTEM WAS DONE. (I.E. FULL BRAKE WITHOUT PUMPING).
Official recalls
194V177000 · Seats:front Assembly:head Restraint
Sep 14, 1994
THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Remedy: SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP92012 · Apv Fires
Opened Jun 9, 1992 · Closed Jun 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
APV FIRES