2012 CAN-AM Spyder Rt

VEHICLE HAS EXHIBITED EXCESSIVE GAS FUMES AND LIQUID CONDENSATION FROM FUEL TANK VENT SINCE NEW. THIS CREATES A FLAMMABILITY HAZARD. PROXIMITY OF EXHAUST PIPES TO FUEL TANK CAUSES BOILING INSIDE THE TANK THAT CAN BE SMELLED, SEEN, AND HEARD. PROXIMITY OF CATALYTIC CONVERTER TO UNDERSIDE OF TANK CONTRIBUTES TO THE ROOT CAUSE. PROBLEM IS ESPECIALLY EVIDENT AFTER PROLONGED RIDING AS COMPONENTS UNDER THE BODYWORK GET HEAT SOAKED DUE TO RADIANT HEAT. FACTORY INSTALLED GAS TANK INSULATION IS INADEQUATE. MY INSTALLATION OF OFF THE SHELF EXHAUST WRAP PRODUCT AND OTHER INSULATION HAS IMPROVED, BUT NOT ELIMINATED THE PROBLEM. IT IS ALSO EVIDENT THAT THIS FORCED BOILING OF GAS EXCEEDS THE CAPACITY OF THE CHARCOAL CANISTER AND ALLOWS FOR CONDENSATION INSIDE THE CANISTER, RENDERING IT INEFFECTIVE. MY OPINION IS THAT ONLY A HIGH PERFORMANCE INSULATION PACKAGE, INSTALLED ON THE EXHAUST PIPES AND GAS TANK, IN CONJUNCTION WITH A CATALYTIC CONVERTER HEAT SHIELD, WILL TRULY ELIMINATE THE ROOT CAUSE. DESIGN MODIFICATIONS TO ENHANCE UNDER BODYWORK AIRFLOW ARE ALSO NEEDED TO PREVENT RIDER DISCOMFORT AND INJURY DUE TO EXCESSIVE BODY WORK TEMPERATURES. *TR

A VERY STRONG ODOR OF GASOLINE UPON SHUT DOWN AFTER EXTENDED RIDES OF MORE THAN 10-15 MILES AT VARYING SPEEDS. APPEARS TO HAPPEN MORE OFTEN WHEN MULTIPLE STOPS (ENGINE SHUT DOWN OF SHORT DURATION) OCCUR DURING THE SAME RIDE. RIDING MORE THAN 10 - 15 MILES RESULTS IN VERY HIGH HEAT EMANATING FROM UNDER SEAT ON RIGHT SIDE AND EXTREME HEAT NEAR RIGHT ANKLE AND FOOT. PASSENGER ALSO COMPLAINED ABOUT HEAT TO RIGHT ANKLE AND FOOT. WHEN PARKING SPYDER IN MY ENCLOSED ATTACHED GARAGE, GARAGE DOOR MUST BE LEFT OPEN TO DISSIPATE GASOLINE FUMES, OTHERWISE FUMES ENTER HOUSE LIVING AREAS. IT SHOULD BE NOTED THAT MY NATURAL GAS FIRED WATER HEATER (WITH PILOT LIGHT) IS IN THE SAME GARAGE AS MY PARKED SPYDER. SO FAR (KNOCK ON WOOD) THERE HAVE BEEN NO FIRES BUT I ATTRIBUTE THAT TO VENTILATING GARAGE COMPLETELY BEFORE CLOSING GARAGE DOOR. THE GASOLINE FUMES ARE A DEFINITE SAFETY HAZARD THAT SHOULD BE ADDRESSED AND THE HIGH HEAT, WHILE A COMFORT PROBLEM, COULD ALSO BE A DISTRACTION SAFETY PROBLEM. IT IS MY SINCERE HOPE THAT THESE CONCERNS ARE ADDRESSED SOONER RATHER THAN LATER. *TR

PURCHASED FROM DEALER USED ON JULY 19 2014 WITH 2 MONTHS WARRANTY LEFT. 6100 MILES ON IT. AFTER A RIDE ON AUGUST 31, FOUND A FLUID LEAK. CHECKED AND NO OIL AND LITTLE TRANSMISSION FLUID. TOOK TO DEALER. 10 DAYS LATER [XXX] AT DEALER CALLED. SAID THE CLUTCH COVER IS WARPED FROM IMPROPER FACTORY INSTALLATION. APPARENTLY CLUTCH COVER ALSO COVERS OIL PUMP. SAID THEY HAD SEEN IT BEFORE BUT NO RECALLS. PART NOT AVAILABLE FOR REPAIR FOR 4 MONTHS. DID NOTICE DIFFICULTY SHIFTING DURING RIDE. THANK GOODNESS TRANSMISSION DID NOT GO OUT WHILE RIDING. DEALERS HANDS ARE TIED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

OVERWHELMING FUEL SMELL AFTER RIDING ON WARM/HOT DAYS. AFTER RIDING IN WARMER WEATHER THERE IS A STRONG FUEL SMELL. THE SMELL WAS SO OVERWHELMING ONE DAY IN THE GARAGE MY WIFE THOUGHT I HAD DUMPED OR SPILLED FUEL IN THE GARAGE AS THE SMELL WAS EVEN COMING INTO THE HOUSE. THIS OBVIOUSLY SCARED MY WIFE AND DAUGHTER ( I JUST LEFT IN MY CAR TO GO TO WORK). I NORMALLY LEAVE THE SPYDER OUTSIDE TO COOL AFTER RIDING BECAUSE OF THE RAW FUEL SMELL VAPORS. I ALSO NOTICE THAT WHEN RIDING AND I NEED TO STOP FOR FUEL THE REMAINDER OF THE FUEL IN THE FUEL TANK IS BOILING (SURE THIS HAS SOMETHING TO DO WITH THE FUEL SMELL). I THOUGHT THAT THE NEW CAP THEY SENT ME FOR THE PRIOR RECALL WOULD HAVE RESOLVED THIS BUT IT HAD NO EFFECT. I WOULD SUSPECT THAT THE VAPOR IS EXPLOSIVE BUT I WOULD PREFER NOT TO TEST THAT THEORY. CURRENTLY HAVE OVER 9,000 MILES ON THE SPYDER. HAVE NOT COMPLAINED AS EVERYONE AT DEALER AND ON ALL FORUMS SEEMS TO BE VERY AWARE OF THIS PROBLEM. *TR