NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
10 reportsClear category filter165,000 miles · Mar 13, 2012
Fuel System, Gasoline
MY VEHICLE STARTED STALLING ABOUT THREE WEEKS AGO, IT WOULD SUDDENLY JUST CUT OFF AS IF THE GAS WAS NO LONGER FUELING THE VEHICLE. IT WOULD STOP AND WOULD NOT START AGAIN FOR ABOUT AND HOUR. AFTER STARTING IT WOULD RUN FOR ABOUT TWENTY MIN. IT WOULD THEN STOP AGAIN. I CHANGED THE FUEL PUMP WITH A NEW ONE AND IT DID THE SAME THIN…
Read full complaint
MY VEHICLE STARTED STALLING ABOUT THREE WEEKS AGO, IT WOULD SUDDENLY JUST CUT OFF AS IF THE GAS WAS NO LONGER FUELING THE VEHICLE. IT WOULD STOP AND WOULD NOT START AGAIN FOR ABOUT AND HOUR. AFTER STARTING IT WOULD RUN FOR ABOUT TWENTY MIN. IT WOULD THEN STOP AGAIN. I CHANGED THE FUEL PUMP WITH A NEW ONE AND IT DID THE SAME THING. IT APPEARS THERE IS NO SOLUTION FOR THIS PROBLEM. *TR
NHTSA ODI #10451355
113,000 miles · Sep 24, 2009
Fuel System, GasolineFire
TL* THE CONTACT OWNS A 1997 CADILLAC ELDORADO. THE CONTACT STATED THAT HE WAS NOT NOTIFIED OF RECALL # 04V110000, FUEL SYSTEM GASOLINE, DELIVERY HOSES, LINES, PIPING, AND FITTINGS. AS A CONSEQUENCE IN 2008, THE FUEL LEAKAGE LEAD TO AN ENGINE COMPARTMENT FIRE. HE WAS ABLE TO SAFELY EXTINGUISH THE FLAMES. HE NOTIFIED THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 1997 CADILLAC ELDORADO. THE CONTACT STATED THAT HE WAS NOT NOTIFIED OF RECALL # 04V110000, FUEL SYSTEM GASOLINE, DELIVERY HOSES, LINES, PIPING, AND FITTINGS. AS A CONSEQUENCE IN 2008, THE FUEL LEAKAGE LEAD TO AN ENGINE COMPARTMENT FIRE. HE WAS ABLE TO SAFELY EXTINGUISH THE FLAMES. HE NOTIFIED THE MANUFACTURER AND A REPRESENTATIVE STATED THAT SINCE THE COMPANY FILED BANKRUPTCY THEY WOULD NOT ASSUME ANY RESPONSIBILITY. HE HAS PHOTOS OF THE FAILED COMPONENT. THE FAILURE AND CURRENT MILEAGES WERE 113,000.
NHTSA ODI #10285152
66,500 miles · Jun 16, 2009
Fuel System, Gasoline
VEHICLE IS HAVING A DIFFICULT TIME STARTING. CONSUMER FEELS THAT IT IS RELATED TO THE GAS LINE. DEALER HAS BEEN CONTACTED. *AK OWNER HAS BEEN SMELLING GASOLINE ODOR OFF AND ON FOR 6 WEEKS. HAS NOT STARTED ON SEVERAL OCCASSIONS OVER THE LAST 6 MONTHS. TAKEN TO ED MORRIS CADILLAC (KEN FAGAN)
NHTSA ODI #10050421
113,200 miles · Aug 28, 2008
Fuel System, GasolineFire
TL*THE CONTACT OWNS A 1997 CADILLAC ELDORADO. THE CONTACT SMELLED GASOLINE WHILE DRIVING AT AN UNKNOWN SPEED. ONCE HE ARRIVED HOME, HE OPENED THE HOOD AND NOTICED FLAMES. THE MANUFACTURER STATED THAT BECAUSE HE WAS THE SECOND OWNER OF THE VEHICLE, HE DID NOT RECEIVE A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 04V110000 (FUEL…
Read full complaint
TL*THE CONTACT OWNS A 1997 CADILLAC ELDORADO. THE CONTACT SMELLED GASOLINE WHILE DRIVING AT AN UNKNOWN SPEED. ONCE HE ARRIVED HOME, HE OPENED THE HOOD AND NOTICED FLAMES. THE MANUFACTURER STATED THAT BECAUSE HE WAS THE SECOND OWNER OF THE VEHICLE, HE DID NOT RECEIVE A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 04V110000 (FUEL SYSTEM, GASOLINE DELIVERY HOSES, LINES/PIPING, AND FITTINGS). THE MANUFACTURER WOULD NOT ASSIST. THE VEHICLE HAS NOT BEEN REPAIRED BECAUSE THE CONTACT WANTS THE MANUFACTURER TO PAY FOR THE REPAIR. THE FAILURE AND CURRENT MILEAGES WERE 113,200. UPDATED 09/24/08 *BF UPDATED 10/01/08. *JB
NHTSA ODI #10240099
Mileage unknown · Oct 25, 2007
Fuel System, Gasoline
I WAS NOTIFIED OF A SAFETY RECALL ON MY 1997 CADILLAC EL DORADO THAT TUBING USED IN THE FUEL RAIL CONST. MAY DEGRADE AND CRACK. I WAS TOLD IT WOULD BE REPAIRED AT NO CHARGE. WHEN I WENT TO THE DEALER TO HAVE IT DONE I WAS TOLD THAT THEY POSSIBLY WOULD HAVE TO REPLACE THE FUEL PUMP, AND I WOULD HAVE TO PAY FOR IT. I FEEL THIS IS…
Read full complaint
I WAS NOTIFIED OF A SAFETY RECALL ON MY 1997 CADILLAC EL DORADO THAT TUBING USED IN THE FUEL RAIL CONST. MAY DEGRADE AND CRACK. I WAS TOLD IT WOULD BE REPAIRED AT NO CHARGE. WHEN I WENT TO THE DEALER TO HAVE IT DONE I WAS TOLD THAT THEY POSSIBLY WOULD HAVE TO REPLACE THE FUEL PUMP, AND I WOULD HAVE TO PAY FOR IT. I FEEL THIS IS COMPLETELY UNFAIR, I DIDN'T CREATE THIS PROBLEM AND FEEL GM SHOULD HAVE TO MAKE IT SAFE BY REPLACING IT AT NO CHARGE. ANYWAY! I THOUGHT I WOULD LET YOU KNOW WHAT IS GOING ON. LET ME KNOW IF YOU CAN DO ANYTHING. THANKS GREG *TR
NHTSA ODI #10206897
Mileage unknown · Aug 2, 2007
Fuel System, GasolineCrashInjury
RECALL REQUEST FOR ENGINEERING ANALYSIS CUSTOMER IS ASKING FOR INFO ABOUT RECALL EA04-003**CC THE CONSUMER STATED HE WAS INJURED DUE TO HIS FRIENDS 1997 CADILLAC ELDORADO STALLING. THE CONSUMER REFERENCED RECALL NUMBER 04V110000. *JB
NHTSA ODI #10199132
110,000 miles · Jun 23, 2004
Fuel System, Gasoline
RECALL 04V110000 CONCERNING FUEL RAIL FAILURE. WHILE FILLING THE GAS TANK CONSUMER SMELLED A STRONG ODOR OF FUEL. A MECHANIC EXAMINED THE VEHICLE, AND FOUND THAT THE FUEL RAIL HAD PIN HOLES, AND NEEDED REPLACEMENT. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
NHTSA ODI #10079707
72,067 miles · Nov 23, 2003
Fuel System, Gasoline
FUEL SYSTEM GASOLINE, FUEL INJECTION, FUEL RAIL. *LA
NHTSA ODI #10047432
Mileage unknown · Mar 28, 2003
Fuel System, Gasoline
THE FUEL READING WAS OFF, THE VEHICLE STOPPED AS IF THERE WAS NO GAS, HOWEVER THERE WAS A HALF TANK. *JB
NHTSA ODI #10014705
90,000 miles · Mar 28, 2003
Fuel System, Gasoline
THE VEHICLE STALLED WITHOUT WARNING. WHEN THE CONSUMER PULLED OVER AND LIFTED UP THE HOOD, HE DISCOVERED THAT GASOLINE HAD LEAKED ALL OVER THE ENGINE. *JB DEALER REPLACED LEAKING FUEL RAIL ASSEMBLY.
NHTSA ODI #10014702
NHTSA investigations
2EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Illustration