NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
14 reportsClear category filter13,677 miles · Sep 8, 2014
Service Brakes, Hydraulic
2006 CADILLAC CTS. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE PEDAL ISSUES. *SMD THE CONSUMER STATED WHEN SHE APPLIED THE BRAKE TO SLOW DOWN, TO MAKE A TURN, A NOISE WAS IMMEDIATELY HEARD. ONCE SHE STOPPED, A BURNING SMELL WAS PRESENT AND THE BRAKES DID NOT HAVE THE SAME FEEL AS THE PEDAL FELT LOOSE AND VERY CLOSE TO THE FLO…
Read full complaint
2006 CADILLAC CTS. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE PEDAL ISSUES. *SMD THE CONSUMER STATED WHEN SHE APPLIED THE BRAKE TO SLOW DOWN, TO MAKE A TURN, A NOISE WAS IMMEDIATELY HEARD. ONCE SHE STOPPED, A BURNING SMELL WAS PRESENT AND THE BRAKES DID NOT HAVE THE SAME FEEL AS THE PEDAL FELT LOOSE AND VERY CLOSE TO THE FLOOR. SHE MANAGED TO MAKE IT TO HER DESTINATION. ONCE SHE PARKED, THE BURNING SMELL WAS VERY NOTICEABLE AND THE RIM ON THE LEFT FRONT TIRE WAS VERY HOT. THE NEXT DAY, SHE HAD THE VEHICLE TOWED TO A LOCAL DEALER. A FEW DAYS LATER, THEY INFORMED THE CONSUMER, THE CALIPER HAD LOCKED UP ON THE DRIER'S FRONT WHEEL AND THE BRAKE HOSES NEEDED TO BE REPLACED, ALL AT A COST OF $ 1500.00. THE DEALER STATED THERE WERE NO RECALLS ON THE VEHICLE. HOWEVER, WHEN THE CONSUMER RETURNED HOME SHE DISCOVERED HER VEHICLE WAS RECALL IN 2010. *JB
NHTSA ODI #10630805
59,000 miles · May 16, 2014
Service BrakesService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2006 CADILLAC CTS. THE CONTACT STATED THAT WHILE TURNING AND DEPRESSING THE BRAKES, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE M…
Read full complaint
TL* THE CONTACT OWNS A 2006 CADILLAC CTS. THE CONTACT STATED THAT WHILE TURNING AND DEPRESSING THE BRAKES, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 59,000 AND THE CURRENT MILEAGE WAS 85,000.
NHTSA ODI #10588882
35,000 miles · May 5, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE DRIVING APPROXIMATELY 5 MPH AND ATTEMPTING A LEFT TURN INTO A PARKING SPACE, THE CONTACT DEPRESSED THE BRAKE PEDAL AND EXPERIENCED SUDDEN ABNORMAL ACCELERATION. THE CONTACT CONTINUED TO APPLY PRESSURE TO THE BRAKE PEDAL UNTIL THE BRAKE ENGAGED. THE FAILURE RECURRED THREE DIFFERENT …
Read full complaint
TL* THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE DRIVING APPROXIMATELY 5 MPH AND ATTEMPTING A LEFT TURN INTO A PARKING SPACE, THE CONTACT DEPRESSED THE BRAKE PEDAL AND EXPERIENCED SUDDEN ABNORMAL ACCELERATION. THE CONTACT CONTINUED TO APPLY PRESSURE TO THE BRAKE PEDAL UNTIL THE BRAKE ENGAGED. THE FAILURE RECURRED THREE DIFFERENT TIMES INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.
NHTSA ODI #10399176
49,850 miles · Apr 25, 2011
Service Brakes, Hydraulic
MY WIFE AND I PURCHASED A 2006 CADILLAC CTS WITH AN EXTENDED WARRANTY IN 2008. EVER SINCE WE'VE HAD IT, WE'VE EXPERIENCED INTERMITTENT BRAKING FAILURE AT LOW SPEEDS WHILE TURNING. YESTERDAY THIS ISSUE CAUSED MY WIFE TO BUMP ANOTHER VEHICLE WHILE PARKING. THIS PROBLEM IS ESPECIALLY DANGEROUS AS IT ONLY HAPPENS OCCASIONALLY SO IT …
Read full complaint
MY WIFE AND I PURCHASED A 2006 CADILLAC CTS WITH AN EXTENDED WARRANTY IN 2008. EVER SINCE WE'VE HAD IT, WE'VE EXPERIENCED INTERMITTENT BRAKING FAILURE AT LOW SPEEDS WHILE TURNING. YESTERDAY THIS ISSUE CAUSED MY WIFE TO BUMP ANOTHER VEHICLE WHILE PARKING. THIS PROBLEM IS ESPECIALLY DANGEROUS AS IT ONLY HAPPENS OCCASIONALLY SO IT CATCHES THE DRIVER OFF GUARD. WE HAVE SENT CADILLAC A DESCRIPTION OF THE ISSUE IN FALL OF 2010 BUT THEY NEVER EVEN RESPONDED. WE TOOK THE CAR TO THE DEALER AND THEY SAID THAT IT WOULD BE COVERED UNDER WARRANTY BUT THEY CANNOT REPLICATE THE ISSUE. THERE ARE FORUMS OF PEOPLE WHO'VE HAD THE SAME ISSUE. WE JUST WANT THE ISSUE FIXED AS OTHER THAN THAT, WE LIKE THE CAR. THIS HAS EVEN HAPPENED AT INTERSECTIONS AND FORTUNATELY THERE WAS NO ONE COMING. THIS ISSUE MAY HAVE ALREADY RESULTED IN DEATH OR SERIOUS INJURY ELSEWHERE AND WE WOULD LIKE THE MANUFACTURER TO ACKNOWLEDGE THE ISSUE AND CORRECT IT BEFORE SOMEONE ELSE IS INJURED OR KILLED. *TR
NHTSA ODI #10397331
68,000 miles · Oct 29, 2010
Service Brakes, Hydraulic
ABS LIGHT COMES ON AND VEHICLE WILL NOT BRAKE AT SLOW SPEEDS WHILE TURNING. VERY DANGEROUS! *TR
NHTSA ODI #10362897
20,000 miles · Jul 29, 2010
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE BACKING OUT OF THE DRIVEWAY AT APPROXIMATELY 5 MPH, THERE WAS AN UNUSUAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FIVE DIFFERENT OCCASIONS IN WHICH THERE WERE NO RESOLUTI…
Read full complaint
TL* THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE BACKING OUT OF THE DRIVEWAY AT APPROXIMATELY 5 MPH, THERE WAS AN UNUSUAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FIVE DIFFERENT OCCASIONS IN WHICH THERE WERE NO RESOLUTIONS. THE TECHNICIAN REPLACED THE FRONT AND REAR BRAKES. ALSO, FOUR TIRES WERE REPLACED AT A DIFFERENT TIME. THE FAILURE CONTINUED AFTER THE REPAIRS WERE PERFORMED. THE FAILURE MILEAGE WAS 20,000.
NHTSA ODI #10346182
12,000 miles · May 31, 2010
Service Brakes, HydraulicCrash
2006 CTS. WHILE IN BUMPER TO BUMPER TRAFFIC I FELT THE CAR "HYDROPLANE" FOR A SECOND. IT WASN'T RAINING AND I SAW NOTHING IN THE REAR VIEW MIRROR TO CAUSE IT. I CONTINUED ON AT ABOUT 30MPH AND BEGAN TO DEPRESS THE BRAKE SLOWLY AS A RED LIGHT WAS AHEAD. THE BRAKES DID NOT ENGAGE AND I PLOWED INTO THE CAR IN FRONT OF ME. CADILLA…
Read full complaint
2006 CTS. WHILE IN BUMPER TO BUMPER TRAFFIC I FELT THE CAR "HYDROPLANE" FOR A SECOND. IT WASN'T RAINING AND I SAW NOTHING IN THE REAR VIEW MIRROR TO CAUSE IT. I CONTINUED ON AT ABOUT 30MPH AND BEGAN TO DEPRESS THE BRAKE SLOWLY AS A RED LIGHT WAS AHEAD. THE BRAKES DID NOT ENGAGE AND I PLOWED INTO THE CAR IN FRONT OF ME. CADILLAC REPAIR CAN FIND NOTHING WRONG. NOW I'M FRIGHTENED TO DRIVE THE CAR AGAIN. SOMETHING HAS TO BE WRONG YET I CAN GET NO ASSISTANCE. *TR
NHTSA ODI #10333934
42,000 miles · Nov 13, 2008
Service Brakes, HydraulicVehicle Speed ControlCrash
TL*THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE PARKING THE VEHICLE WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE ACCELERATED AND STRUCK A BUILDING. BOTH AIR BAGS DEPLOYED. THERE WERE NO INJURIES. THE DEALER WAS NOTIFIED AND A COMPLIANT WAS FILED. THE VEHICLE IS CURRENTLY IN THE COLLISION SHOP, WAITING TO BE SEEN BY AN ADJUSTE…
Read full complaint
TL*THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE PARKING THE VEHICLE WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE ACCELERATED AND STRUCK A BUILDING. BOTH AIR BAGS DEPLOYED. THERE WERE NO INJURIES. THE DEALER WAS NOTIFIED AND A COMPLIANT WAS FILED. THE VEHICLE IS CURRENTLY IN THE COLLISION SHOP, WAITING TO BE SEEN BY AN ADJUSTER. . THE FAILURE AND CURRENT MILEAGES WERE 42,000. UPDATED 12/16/08 *CN UPDATED 12/19/08.*JB
NHTSA ODI #10248708
8,000 miles · Feb 11, 2008
Electrical SystemPower TrainService Brakes, Hydraulic
TL*THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE DRIVING 50 -70 MPH, THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTS DIMMED. THE LIGHTS ILLUMINATED AGAIN MINUTES LATER. THE FAILURE OCCURRED INTERMITTENTLY USUALLY AFTER DRIVING FOR 2 HOURS. THE INSTRUMENT PANEL ALSO FAILED DURING THE DAYTIME. ONSTAR STATED THAT THE LIGHTS DO NOT RE…
Read full complaint
TL*THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE DRIVING 50 -70 MPH, THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTS DIMMED. THE LIGHTS ILLUMINATED AGAIN MINUTES LATER. THE FAILURE OCCURRED INTERMITTENTLY USUALLY AFTER DRIVING FOR 2 HOURS. THE INSTRUMENT PANEL ALSO FAILED DURING THE DAYTIME. ONSTAR STATED THAT THE LIGHTS DO NOT REMAIN OFF LONG ENOUGH TO DETERMINE THE CAUSE OF THE FAILURE. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE MILEAGE WAS 8,000 AND CURRENT MILEAGE WAS 20,000. UPDATED 03-04-08 *BF THE REAR DIFFERENTIAL WAS NOISY, THE ABS WOULD ENGAGE ON THEIR OWN
NHTSA ODI #10217709
5,548 miles · Jan 24, 2008
Air BagsService Brakes, HydraulicSuspensionCrashInjury
TL*THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE DRIVING 20 MPH, THE VEHICLE BEGAN DRIVING ROUGHLY. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE WOULD REV AS IF IT WERE ATTEMPTING TO ACCELERATE. ON OCTOBER 9, 2007, WHILE BACKING OUT OF A PARKING SPACE WITH HER FOOT ON THE BRAKE PEDAL, THE VEHICLE LUNGED FORWARD AND MADE A LO…
Read full complaint
TL*THE CONTACT OWNS A 2006 CADILLAC CTS. WHILE DRIVING 20 MPH, THE VEHICLE BEGAN DRIVING ROUGHLY. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE WOULD REV AS IF IT WERE ATTEMPTING TO ACCELERATE. ON OCTOBER 9, 2007, WHILE BACKING OUT OF A PARKING SPACE WITH HER FOOT ON THE BRAKE PEDAL, THE VEHICLE LUNGED FORWARD AND MADE A LOUD NOISE. THE VEHICLE CRASHED INTO A TREE. THE BRAKES DID NOT WORK AND THE STEERING WHEEL WOULD NOT TURN. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE SUSTAINED FRONT END DAMAGE, INCLUDING THE TWO FRONT TIRES. THE CONTACT HAS PICTURES. THE CONTACT SUSTAINED A CONCUSSION, HAS HEADACHES AND DIZZY SPELLS, 50% HEARING LOSS, AND CRACKED TWO FRONT TEETH. A POLICE REPORT WAS FILED. THE VEHICLE WAS REPAIRED, BUT STILL RIDES ROUGHLY. NHTSA CAMPAIGN ID NUMBER 07V589000 (SUSPENSION: REAR AXLE: SPINDLE) WAS REFERENCED. THE POWERTRAIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 5,623 AND FAILURE MILEAGE WAS 5,548.
NHTSA ODI #10215856
Official recalls
6Sep 9, 2014
General Motors LLC (GM) is recalling certain model year 2004-2007 Cadillac CTS-V vehicles manufactured October 6, 2003, to March 15, 2007, and 2006-2007 Cadillac STS-V vehicles manufactured June 23, 2005, to March 15, 2007. In the affected vehicles, the electrical terminals of the fuel pump module may overheat resulting in the melting of the flange material.
Consequence & remedy
Consequence: If the flange melts, a hole may be created allowing the fuel pump to leak fuel, causing the vehicle to stall, increasing the risk of a vehicle crash. Additionally, leaking fuel in the presence of an ignition source increases the risk of a fire.
Remedy: GM will notify owners, and dealers will replace the fuel module and fuel tank jumper harness, free of charge. GM sent out interim notices in late October. The recall began on March 12, 2015. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14405.
Jul 2, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 2, 2014 that they are recalling 554,328 model year 2003-2014 Cadillac CTS vehicles manufactured August 16, 2001, to April 28, 2014, and 2004-2006 Cadillac SRX vehicles manufactured March 20, 2003, to August 11, 2006. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 15, 2014. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14172.
Dec 17, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2007 CADILLAC CTS VEHICLES. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH REPEATED FLEXING OF THE PASSENGER SENSING SYSTEM MAT IN THE FRONT PASSENGER SEAT MAY CAUSE THE MAT TO KINK, BEND, OR FOLD. THIS FLEXING CAN BREAK THE CONNECTIONS IN THE MAT. IF THIS OCCURS, THE SENSOR MAY NOT DETECT THE PRESENCE OF A FRONT SEAT PASSENGER AND WILL DISABLE THE AIR BAG.
Consequence & remedy
Consequence: NON-DEPLOYMENT OF THE FRONT PASSENGER AIR BAG IN THE EVENT OF A CRASH NECESSITATING THAT AIR BAG'S DEPLOYMENT MAY REDUCE PROTECTION OF THE PASSENGER AND INCREASE THE RISK OR SEVERITY OF INJURY TO THEM.
Remedy: DEALERS WILL REPLACE THE PASSENGER SENSING SYSTEM FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 15, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Mar 17, 2010
GENERAL MOTORS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2003-2007 CADILLAC CTS VEHICLES CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON D.C., WEST VIRGINIA AND WISCONSIN. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE FRONT BRAKE HOSE FITTING AT THE CALIPER MAY CORRODE DUE TO SNOW OR WATER, CONTAINING ROAD SALT OR OTHER CONTAMINANTS, ENTERING AND BEING RETAINED IN THE ROUTING SLEEVE. IF THE FITTING CORRODES SIGNIFICANTLY, THE BRAKE HOSE-TUBE INTERFACE MAY DEVELOP A LEAK.
Consequence & remedy
Consequence: THE BRAKE HOSE-TUBE INTERFACE MAY RUPTURE SUDDENLY WITHOUT PRIOR WARNING AND INCREASE VEHICLE STOPPING DISTANCE MAY OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS ARE TO REPLACE BOTH FRONT BRAKE HOSE ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Dec 20, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
Jan 25, 2006
CERTAIN VEHICLES EQUIPPED WITH V6 ENGINES MAY HAVE A CONDITION WHERE FUEL IS NO LONGER SUPPLIED TO THE ENGINE. THIS CONDITION OCCURS WITHOUT THE ILLUMINATION OF THE FUEL LEVEL LOW INDICATOR LIGHT OR THE WARNING CHIME.
Consequence & remedy
Consequence: IF THE ENGINE STOPS RUNNING, THE OPERATOR WILL NOT BE ABLE TO RESTART THE VEHICLE WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE (ECM) WITH NEW SOFTWARE FREE OF CHARGE. OWNERS WERE NOTIFIED IN DECEMBER 2005 AND ASKED TO MAINTAIN AT LEAST 1/4 OF A TANK FUEL LEVEL TO AVOID THIS CONDITION UNTIL THE PARTS ARE AVAILABLE. THE PARTS ARE NOW AVAILABLE, OWNER RENOTIFICATION BEGAN ON MARCH 23, 2006. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ11001 · Iee Passenger Sensing System Mats
Opened Feb 7, 2011 · Closed Jul 19, 2011
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
On December 17, 2010, General Motors (GM) notified the NHTSA that it had decided certain 2005 - 2007 model year Cadillac CTS vehicles contain a safety related defect.GM stated that certain CTS vehicles contain a passenger sensing system mat, manufactured by IEE, in the front passenger seat that may flex causing the mat to kink, bend or fold.If this flexing causes the connections in the mat to break, the passenger airbag could become disabled.Non-deployment of the front passenger air bag in the event of a crash necessitating that air bag's deployment may reduce protection of the passenger and increase the risk or severity of injury to them.This issue was assigned recall number 10V-644.On February 8, 2011, RMD mailed an information request (IR) letter to IEE requesting a list of purchasers for any company that was sold the same or similar defective mats.RMD also requested IEE supply the year, make and models of compatible vehicles for each of the mats it listed in its response.IEE responded on February 15, 2011, reporting that the mats recalled in GM recall 10V-644 were developed specifically for the 2005-2007 Cadillac CTS.IEE noted that, ...the CTS Sensor Mat is not the same or similar to any other sensor mat manufactured by IEE.IEE further explained that the sensor mats were sold to Lear Corp. (Lear), for incorporation into seat assemblies, with the seat assemblies finally being sold to GM.Also, some sensor mats were sold to Integrated Manufacturing and Assembly, LLC (IMA) who would then re-sell the mats to GM to use as service parts.Ultimately, these parts were all sold to GM for use in the 2005-2007 Cadillac CTS vehicles.According to its 10V-644 Defect Report, GM reported that some vehicles outside the recall population have ...significantly lower incident rates and will be provided a special coverage.This special coverage includes a free repair should the same issue occur to non-recalled 2005-2007 Cadillac CTS vehicles up to 10 years or 120,000 miles.On April 7, 2011, RMD mailed an IR letter to GM to gather more information on GM's decision to only recall a portion of the vehicles that contained the subject IEE mats.RMD also requested that GM provide updated to current warranty claims, field reports, and other field information for CTS vehicles both recalled and those under the special coverage.On May 19, 2011, GM responded with a letter and several CD attachments that were submitted to NHTSA's Office of the Chief Counsel along with a request for confidentiality.GM confirmed that the IEE mats recalled in 10V-644 were only used in the 2005-2007 Cadillac CTS.GM also explained its reasoning in only recalling a portion of the CTS vehicles containing IEE mats.Due to various production phases, error detections, and false corrections, certain vehicles were more prone to mat failures than other vehicles.GM identified 4 distinct seat assembly production periods and chose to recall CTS vehicles depending on which seat assembly each vehicle received.Examining the data submitted in regards to warranty claims, field reports, and incidents, the CTS vehicles that were included in the safety recall were responsible for about 80% of the overall claims.CTS vehicles included in the special coverage (essentially an extended warranty), those with seat assemblies from other identified production phases, were responsible for about 20% of the overall claims.As GM has provided clear data to support its recall decision and since no other manufacturer has installed these same or similar passenger sensing system mats / seat assemblies in their vehicles, this Equipment Query is satisfied.This EQ is cl
EA07017 · Rear Drivetrain Component Failure
Opened Dec 7, 2007 · Closed Jul 16, 2008
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
IN JULY OF 2007 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE07-037 TO INVESTIGATE ALLEGATIONS THAT THE REAR DIFFERENTIAL MAY FAIL CAUSING A LOSS OF MOTIVE POWER, AND IN SOME INSTANCES A LOSS OF CONTROL, IN MODEL YEAR (MY) 2004 THROUGH 2006 CADILLAC CTS, CTS-V, AND STS VEHICLES.AS A RESULT OF THAT INVESTIGATION GM ISSUED RECALL 07V-589 TO CORRECT A LEAKING PINION SEAL PROBLEM.EA07-017 WAS OPENED TO INVESTIGATE COMPLAINTS OF FRACTURED REAR DIFFERENTIAL HOUSINGS OR REAR HALF SHAFTS IN HIGH PERFORMANCE CADILLAC CTS-V VEHICLES.ACCORDING TO GM, THESE FAILURES RESULTED FROM THE CUMULATIVE DAMAGE FROM MULTIPLE POWER HOP EVENTS THAT CAN OCCUR DURING VERY AGGRESSIVE DRIVING. IN FEBRUARY 2008 INVESTIGATORS FROM ODI MET WITH GM REPRESENTATIVES TO CONDUCT TESTING OF THE SUBJECT CTS-V VEHICLES.DURING THE TESTING THE SUBJECT VEHICLES WERE SUBJECTED TO CONSIDERABLE TORSIONAL FORCES FROM STANDING STARTS AND WHILE DRIVING.POWER HOP OCCURRED DURING SOME OF THE MOST AGGRESSIVE DRIVING MANEUVERS.THE TESTING DID NOT RESULT IN FAILURE OF ANY REAR DRIVETRAIN COMPONENTS.THE ENGINEERING DESIGN AND TESTING DATA SUPPLIED TO ODI BY GM AND THE RESULTS OF THE TESTING CONDUCTED BY ODI TEND TO SUPPORT GM'S POSITION THAT THE DIFFERENTIAL DESIGN IS NOT DEFECTIVE. COMPLAINTS LISTED IN THE FAILURE REPORT DO NOT INCLUDE THOSE INDICATIVE OF FAILURE OF THE REAR PINION SEAL IN CTS-V VEHICLES COVERED BY RECALL 07V-589. FURTHER INVESTIGATION IN THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.
Illustration