NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
277 reports197,300 miles · Sep 2, 2020
Electronic Stability Control (esc)EngineFuel/propulsion System
FIRST ECM MODULE NEEDING TO BE REPLACED, WE REPLACED IT THEN AFTER THAT STARTED RUNNING ROUGH, TOOK IT TO AUTO ZONE, 12 CODES POPPED UP. DID NORMAL MAINTENANCE OF VEHICLE, OIL CHANGE SPARK PLUGS . THEN A FEW DAYS LATER WE WERE ON THE HIGHWAY AND ALL OF A SUDDEN WE LOST ALL POWER, PUSHED ON ACCELERATOR NO POWER, FRONT END STARTED…
Read full complaint
FIRST ECM MODULE NEEDING TO BE REPLACED, WE REPLACED IT THEN AFTER THAT STARTED RUNNING ROUGH, TOOK IT TO AUTO ZONE, 12 CODES POPPED UP. DID NORMAL MAINTENANCE OF VEHICLE, OIL CHANGE SPARK PLUGS . THEN A FEW DAYS LATER WE WERE ON THE HIGHWAY AND ALL OF A SUDDEN WE LOST ALL POWER, PUSHED ON ACCELERATOR NO POWER, FRONT END STARTED SHAKING, SO PULLED OVER, VEHICLE WAS VERY HOT AND SMELLS LIKE GAS, HAD IT TOWED COMPRESSION TEST WERE NO GOOD, WAS TOLD GASKET WERE BAD, ALSO WAS TOLD TO CHECK THE RECALL LIST. IM UP SET BECAUSE OUR CHILDREN WERE IN THE VEHICLE WITH US. I HOPE WE ARE ABLE TO GET WHATEVER NEEDS TO BE FIXED ON THIS VEHICLE. THANK YOU.
NHTSA ODI #11352691
110,000 miles · Aug 10, 2020
Power TrainSteering
THE VEHICLE IS EQUIPPED WITH A VERY WEAK REAR DIFFERENTIAL THAT WAS USED IN THE LESSER HORSEPOWER V6 AND WHEN TAKING OFF HARD THE CAR BEGINS TO WHEEL HOP AND DESTROYS THE REAR END THE VEHICLE WAS IN MOTION ON A CITY STREET THIS HAS OCCURRED TWICE IN LESS THEN A YEAR AND A HALF
NHTSA ODI #11348468
114,000 miles · Jun 16, 2020
Air BagsSeat BeltsCrashInjury
TL* THE CONTACT OWNED A 2005 CADILLAC CTS. THE CONTACT STATED THAT WHILE THE DRIVER DROVE AT AN UNKNOWN SPEED, SHE APPLIED THE BRAKES TO AVOID HITTING AN ANIMAL AS A RESULT THE VEHICLE SWERVED, ROLLING OVER SEVERAL TIMES. THE CONTACT STATED THAT NO AIR BAGS DEPLOYED AS AND THE DRIVER'S SEAT BELT BECAME UNLATCHED AS THE DRIVER WA…
Read full complaint
TL* THE CONTACT OWNED A 2005 CADILLAC CTS. THE CONTACT STATED THAT WHILE THE DRIVER DROVE AT AN UNKNOWN SPEED, SHE APPLIED THE BRAKES TO AVOID HITTING AN ANIMAL AS A RESULT THE VEHICLE SWERVED, ROLLING OVER SEVERAL TIMES. THE CONTACT STATED THAT NO AIR BAGS DEPLOYED AS AND THE DRIVER'S SEAT BELT BECAME UNLATCHED AS THE DRIVER WAS EJECTED THROUGH THE REAR WINDOW. THE CONTACT STATED THERE WERE NO WARNING LIGHTS ILLUMINATED WHILE THE FAILURE OCCURRED. THE DRIVER SUSTAINED A COMA, BROKEN VERTEBRA, HIP CONTUSION, BRUISING AND MEMORY LOSS AS SHE WAS TRANSPORTED TO THE HOSPITAL BY AMBULANCE. THE FRONT PASSENGER SUFFERED HIP, CHEST, BREAST, WAIST, ARMS, SHOULDER, HEAD INJURIES AS WELL AS THE REAR DRIVER'S SIDE PASSENGER SUSTAINED CHEST, HIP, AND NOSE INJURIES ALL OCCUPANTS WERE TRANSPORTED TO THE HOSPITAL BY AMBULANCE. THE CONTACT WAS READING THE ACCIDENT INFORMATION FROM A NEWS PAPER ARTICLE. THE NEW MEXICO STATE POLICE WAS PRESENT AND A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT WAS ALSO PRESENT. THE VEHICLE WAS TOWED TO A TOW LOT AND DEEMED A TOTAL LOSS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 114,000. *LN
NHTSA ODI #11329163
Mileage unknown · Jan 19, 2020
Electrical SystemEngineFuel/propulsion System
I WENT TO CADILLAC TO GET THE RECALL FIXED THEY SAID IT WAS CLOSED OUT AND COULDN'T FIX IT AND NOW I CAN'T SMOG MY CAR AND I CAN'T TELL IF I HAVE GAS OR NOT AND I'M SCARED TO DRIVE IT WITHOUT GETTING THE FUEL PUMP FIXED
NHTSA ODI #11300281
109,000 miles · Sep 14, 2019
Air Bags
MY 2005 CADILLAC CTS DOES HAVE RECALLS ON THOSE MODELS HOWEVER IN CONTACTING CADILLAC THEY ARE TELLING ME I NEED TO PAY TO HAVE THIS FIXED. I HAVE A SREVICE AIR BAG SHOWING UP ONSREEN AND IN MIRROR OF MY CAR. I AM HOPING I CAN FORCE THEM TO FIX THIS
NHTSA ODI #11255514
149,656 miles · Aug 30, 2019
Air BagsElectrical System
AIRBAG ON NO PASSENGER AIRBAG. LIGHTS INSIDE WORK SOMETIMES. CAR WAS MOVING.
NHTSA ODI #11252407
170,000 miles · Aug 9, 2019
Engine
I JUST PURCHASED THIS CAR IN FEBRUARY 2019 AND IT WENT DOWN IN LATE APRIL OR EARLY MAY OF THIS YEAR. THE SERVICE ENGINE LIGHT WOULD COME ON FOR A FEW DAYS THEN IT WOULD GO OFF FOR A FEW DAYS. THE ENGINE WOULD RATTLE WHEN FIRST CRANKED AND THEN IT GOT TO THE POINT WHERE IT WOULD CONSTANTLY KEEP TRYING TO CRANK BUT NEVER WOULD AND…
Read full complaint
I JUST PURCHASED THIS CAR IN FEBRUARY 2019 AND IT WENT DOWN IN LATE APRIL OR EARLY MAY OF THIS YEAR. THE SERVICE ENGINE LIGHT WOULD COME ON FOR A FEW DAYS THEN IT WOULD GO OFF FOR A FEW DAYS. THE ENGINE WOULD RATTLE WHEN FIRST CRANKED AND THEN IT GOT TO THE POINT WHERE IT WOULD CONSTANTLY KEEP TRYING TO CRANK BUT NEVER WOULD AND NOW IT IS COMPLETELY OUT. I HAD IT TOWED TO MECHANIC AND WAS TOLD THAT THEY HAD TO PUT 5 QUARTS OF OIL IN IT BUT I HAD THE OIL CHANGED A MONTH BEFORE THE CAR DIED. THEY SAY THE OIL IS GOING SOMEWHERE BUT WHERE? I WAS ALSO TOLD THE TIMING CHAIN HAD FAILED. WHEN THIS HAPPENS IT CAN CAUSE THE PISTONS AND EVERYTHING ELSE TO FAIL WITH THE ENGINE. IT WILL COST ME OVER $2000 TO GET REPAIRED. THIS IS RIDICULOUS! SOMETHING NEEDS TO BE DONE ABOUT THIS. CADILLIAC MAKES EVERYTHING SO EXPENSIVE SO I WOULD NOT RECOMMEND GETTING ONE UNLESS YOU CAN ABSOLUTELY AFFORD IT AND NOT BE IN DEBT BEHIND IT. I WAS IN LOVE WITH THIS CAR BUT THIS IS HORRIBLE. THIS IS MY SECOND TIME TRYING TO GET IT REPAIRED AND NOW I'M DONE.
NHTSA ODI #11242853
184,980 miles · Aug 8, 2019
Air Bags
I AM THE OWNER OF A 2005 CADILLAC CTS WHICH WAS NOT INCLUDED IN THE AIRBAG RECALL, ACCORDING TO THE NHTSA AND GM WEBSITES, BUT HAS THE SAME YEAR, MAKE, MODEL, AND DEFECTIVE AIRBAG AS THE ONES INCLUDED. I TOOK MY CADILLAC TO GET A 27 POINT INSPECTION, OIL CHANGE, ETC., ON 2/16/18, AND I WAS INFORMED THAT THE FRONT SEAT AIRBAG SEN…
Read full complaint
I AM THE OWNER OF A 2005 CADILLAC CTS WHICH WAS NOT INCLUDED IN THE AIRBAG RECALL, ACCORDING TO THE NHTSA AND GM WEBSITES, BUT HAS THE SAME YEAR, MAKE, MODEL, AND DEFECTIVE AIRBAG AS THE ONES INCLUDED. I TOOK MY CADILLAC TO GET A 27 POINT INSPECTION, OIL CHANGE, ETC., ON 2/16/18, AND I WAS INFORMED THAT THE FRONT SEAT AIRBAG SENSOR NEEDED TO BE REPLACED BECAUSE IT WAS NOT WORKING. MY VEHICLE SHOULD BE INCLUDED IN THE GM MANUFACTURING RECALL OF TAKATA AIRBAGS.
NHTSA ODI #11242445
Mileage unknown · Jul 15, 2019
Electrical System
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT THE KEY WOULD NOT RELEASE FROM THE IGNITION. THE CONTACT CALLED GENESIS CADILLAC (19900 E 9 MILE RD, ST CLAIR SHORES, MI 48080, (586) 772-8200) AND WAS INFORMED THAT AN UNKNOWN RECALL WAS ISSUED, AND THE VEHICLE COULD BE REPAIRED WITHOUT BRINGING THE VEHICLE IN TO…
Read full complaint
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT THE KEY WOULD NOT RELEASE FROM THE IGNITION. THE CONTACT CALLED GENESIS CADILLAC (19900 E 9 MILE RD, ST CLAIR SHORES, MI 48080, (586) 772-8200) AND WAS INFORMED THAT AN UNKNOWN RECALL WAS ISSUED, AND THE VEHICLE COULD BE REPAIRED WITHOUT BRINGING THE VEHICLE IN TO BE SERVICED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11232089
Mileage unknown · Jun 11, 2019
Electrical SystemService BrakesSuspension
NOT DRIVABLE
NHTSA ODI #11219266
Official recalls
6Sep 9, 2014
General Motors LLC (GM) is recalling certain model year 2004-2007 Cadillac CTS-V vehicles manufactured October 6, 2003, to March 15, 2007, and 2006-2007 Cadillac STS-V vehicles manufactured June 23, 2005, to March 15, 2007. In the affected vehicles, the electrical terminals of the fuel pump module may overheat resulting in the melting of the flange material.
Consequence & remedy
Consequence: If the flange melts, a hole may be created allowing the fuel pump to leak fuel, causing the vehicle to stall, increasing the risk of a vehicle crash. Additionally, leaking fuel in the presence of an ignition source increases the risk of a fire.
Remedy: GM will notify owners, and dealers will replace the fuel module and fuel tank jumper harness, free of charge. GM sent out interim notices in late October. The recall began on March 12, 2015. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14405.
Jul 2, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 2, 2014 that they are recalling 554,328 model year 2003-2014 Cadillac CTS vehicles manufactured August 16, 2001, to April 28, 2014, and 2004-2006 Cadillac SRX vehicles manufactured March 20, 2003, to August 11, 2006. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 15, 2014. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14172.
Dec 17, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2007 CADILLAC CTS VEHICLES. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH REPEATED FLEXING OF THE PASSENGER SENSING SYSTEM MAT IN THE FRONT PASSENGER SEAT MAY CAUSE THE MAT TO KINK, BEND, OR FOLD. THIS FLEXING CAN BREAK THE CONNECTIONS IN THE MAT. IF THIS OCCURS, THE SENSOR MAY NOT DETECT THE PRESENCE OF A FRONT SEAT PASSENGER AND WILL DISABLE THE AIR BAG.
Consequence & remedy
Consequence: NON-DEPLOYMENT OF THE FRONT PASSENGER AIR BAG IN THE EVENT OF A CRASH NECESSITATING THAT AIR BAG'S DEPLOYMENT MAY REDUCE PROTECTION OF THE PASSENGER AND INCREASE THE RISK OR SEVERITY OF INJURY TO THEM.
Remedy: DEALERS WILL REPLACE THE PASSENGER SENSING SYSTEM FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 15, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Mar 17, 2010
GENERAL MOTORS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2003-2007 CADILLAC CTS VEHICLES CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON D.C., WEST VIRGINIA AND WISCONSIN. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE FRONT BRAKE HOSE FITTING AT THE CALIPER MAY CORRODE DUE TO SNOW OR WATER, CONTAINING ROAD SALT OR OTHER CONTAMINANTS, ENTERING AND BEING RETAINED IN THE ROUTING SLEEVE. IF THE FITTING CORRODES SIGNIFICANTLY, THE BRAKE HOSE-TUBE INTERFACE MAY DEVELOP A LEAK.
Consequence & remedy
Consequence: THE BRAKE HOSE-TUBE INTERFACE MAY RUPTURE SUDDENLY WITHOUT PRIOR WARNING AND INCREASE VEHICLE STOPPING DISTANCE MAY OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS ARE TO REPLACE BOTH FRONT BRAKE HOSE ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Dec 20, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
Jan 25, 2006
CERTAIN VEHICLES EQUIPPED WITH V6 ENGINES MAY HAVE A CONDITION WHERE FUEL IS NO LONGER SUPPLIED TO THE ENGINE. THIS CONDITION OCCURS WITHOUT THE ILLUMINATION OF THE FUEL LEVEL LOW INDICATOR LIGHT OR THE WARNING CHIME.
Consequence & remedy
Consequence: IF THE ENGINE STOPS RUNNING, THE OPERATOR WILL NOT BE ABLE TO RESTART THE VEHICLE WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE (ECM) WITH NEW SOFTWARE FREE OF CHARGE. OWNERS WERE NOTIFIED IN DECEMBER 2005 AND ASKED TO MAINTAIN AT LEAST 1/4 OF A TANK FUEL LEVEL TO AVOID THIS CONDITION UNTIL THE PARTS ARE AVAILABLE. THE PARTS ARE NOW AVAILABLE, OWNER RENOTIFICATION BEGAN ON MARCH 23, 2006. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EQ11001 · Iee Passenger Sensing System Mats
Opened Feb 7, 2011 · Closed Jul 19, 2011
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
On December 17, 2010, General Motors (GM) notified the NHTSA that it had decided certain 2005 - 2007 model year Cadillac CTS vehicles contain a safety related defect.GM stated that certain CTS vehicles contain a passenger sensing system mat, manufactured by IEE, in the front passenger seat that may flex causing the mat to kink, bend or fold.If this flexing causes the connections in the mat to break, the passenger airbag could become disabled.Non-deployment of the front passenger air bag in the event of a crash necessitating that air bag's deployment may reduce protection of the passenger and increase the risk or severity of injury to them.This issue was assigned recall number 10V-644.On February 8, 2011, RMD mailed an information request (IR) letter to IEE requesting a list of purchasers for any company that was sold the same or similar defective mats.RMD also requested IEE supply the year, make and models of compatible vehicles for each of the mats it listed in its response.IEE responded on February 15, 2011, reporting that the mats recalled in GM recall 10V-644 were developed specifically for the 2005-2007 Cadillac CTS.IEE noted that, ...the CTS Sensor Mat is not the same or similar to any other sensor mat manufactured by IEE.IEE further explained that the sensor mats were sold to Lear Corp. (Lear), for incorporation into seat assemblies, with the seat assemblies finally being sold to GM.Also, some sensor mats were sold to Integrated Manufacturing and Assembly, LLC (IMA) who would then re-sell the mats to GM to use as service parts.Ultimately, these parts were all sold to GM for use in the 2005-2007 Cadillac CTS vehicles.According to its 10V-644 Defect Report, GM reported that some vehicles outside the recall population have ...significantly lower incident rates and will be provided a special coverage.This special coverage includes a free repair should the same issue occur to non-recalled 2005-2007 Cadillac CTS vehicles up to 10 years or 120,000 miles.On April 7, 2011, RMD mailed an IR letter to GM to gather more information on GM's decision to only recall a portion of the vehicles that contained the subject IEE mats.RMD also requested that GM provide updated to current warranty claims, field reports, and other field information for CTS vehicles both recalled and those under the special coverage.On May 19, 2011, GM responded with a letter and several CD attachments that were submitted to NHTSA's Office of the Chief Counsel along with a request for confidentiality.GM confirmed that the IEE mats recalled in 10V-644 were only used in the 2005-2007 Cadillac CTS.GM also explained its reasoning in only recalling a portion of the CTS vehicles containing IEE mats.Due to various production phases, error detections, and false corrections, certain vehicles were more prone to mat failures than other vehicles.GM identified 4 distinct seat assembly production periods and chose to recall CTS vehicles depending on which seat assembly each vehicle received.Examining the data submitted in regards to warranty claims, field reports, and incidents, the CTS vehicles that were included in the safety recall were responsible for about 80% of the overall claims.CTS vehicles included in the special coverage (essentially an extended warranty), those with seat assemblies from other identified production phases, were responsible for about 20% of the overall claims.As GM has provided clear data to support its recall decision and since no other manufacturer has installed these same or similar passenger sensing system mats / seat assemblies in their vehicles, this Equipment Query is satisfied.This EQ is cl
EA07017 · Rear Drivetrain Component Failure
Opened Dec 7, 2007 · Closed Jul 16, 2008
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
IN JULY OF 2007 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE07-037 TO INVESTIGATE ALLEGATIONS THAT THE REAR DIFFERENTIAL MAY FAIL CAUSING A LOSS OF MOTIVE POWER, AND IN SOME INSTANCES A LOSS OF CONTROL, IN MODEL YEAR (MY) 2004 THROUGH 2006 CADILLAC CTS, CTS-V, AND STS VEHICLES.AS A RESULT OF THAT INVESTIGATION GM ISSUED RECALL 07V-589 TO CORRECT A LEAKING PINION SEAL PROBLEM.EA07-017 WAS OPENED TO INVESTIGATE COMPLAINTS OF FRACTURED REAR DIFFERENTIAL HOUSINGS OR REAR HALF SHAFTS IN HIGH PERFORMANCE CADILLAC CTS-V VEHICLES.ACCORDING TO GM, THESE FAILURES RESULTED FROM THE CUMULATIVE DAMAGE FROM MULTIPLE POWER HOP EVENTS THAT CAN OCCUR DURING VERY AGGRESSIVE DRIVING. IN FEBRUARY 2008 INVESTIGATORS FROM ODI MET WITH GM REPRESENTATIVES TO CONDUCT TESTING OF THE SUBJECT CTS-V VEHICLES.DURING THE TESTING THE SUBJECT VEHICLES WERE SUBJECTED TO CONSIDERABLE TORSIONAL FORCES FROM STANDING STARTS AND WHILE DRIVING.POWER HOP OCCURRED DURING SOME OF THE MOST AGGRESSIVE DRIVING MANEUVERS.THE TESTING DID NOT RESULT IN FAILURE OF ANY REAR DRIVETRAIN COMPONENTS.THE ENGINEERING DESIGN AND TESTING DATA SUPPLIED TO ODI BY GM AND THE RESULTS OF THE TESTING CONDUCTED BY ODI TEND TO SUPPORT GM'S POSITION THAT THE DIFFERENTIAL DESIGN IS NOT DEFECTIVE. COMPLAINTS LISTED IN THE FAILURE REPORT DO NOT INCLUDE THOSE INDICATIVE OF FAILURE OF THE REAR PINION SEAL IN CTS-V VEHICLES COVERED BY RECALL 07V-589. FURTHER INVESTIGATION IN THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.
Illustration