TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT THE VEHICLE JERKED BACKWARD AND WOULD NOT ACCELERATE. THE CONTACT SHUT OFF THE VEHICLE AND ONCE RESTARTED, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. ADDITIONALLY, THE CONTACT ST…
Read full complaint
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT THE VEHICLE JERKED BACKWARD AND WOULD NOT ACCELERATE. THE CONTACT SHUT OFF THE VEHICLE AND ONCE RESTARTED, THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. ADDITIONALLY, THE CONTACT STATED THAT THE KEY WOULD BECOME STUCK IN THE IGNITION SWITCH OR WOULD BE DIFFICULT TO REMOVE. THE POWER WINDOWS ALSO FAILED AND WOULD OPEN AND CLOSE INDEPENDENTLY, AS WELL AS THE RADIO BECOMING INOPERABLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE TRANSMISSION AND THE IGNITION SWITCH NEEDED TO BE REPLACED. THE IGNITION SWITCH WAS REPLACED BUT NOT THE TRANSMISSION. THE CONTACT LATER DISCOVERED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V394000 (ELECTRICAL SYSTEM) THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 119,000.
NHTSA ODI #10672471
51,250 miles · Oct 4, 2014
Power Train
SHIFTING GEARS WAS ACCOMPANIED BY CLUNKING IN REAR DIFFERENTIAL. THIS OCCURRED WHEN SHIFTING OR WHEN LETTING OFF THE ACCELERATOR. IN MARCH OF 2014 A WHINING ALSO ACCOMPANIED DRIVING AT SPEEDS OF 50 - 70 MPH. MY CADILLAC DEALER REPLACED THE DIFFERENTIAL WITH A NEW ONE UNDER A PRIVATE WARRANTY PROGRAM. WITHIN 2 WEEKS THE DIFFEREN…
Read full complaint
SHIFTING GEARS WAS ACCOMPANIED BY CLUNKING IN REAR DIFFERENTIAL. THIS OCCURRED WHEN SHIFTING OR WHEN LETTING OFF THE ACCELERATOR. IN MARCH OF 2014 A WHINING ALSO ACCOMPANIED DRIVING AT SPEEDS OF 50 - 70 MPH. MY CADILLAC DEALER REPLACED THE DIFFERENTIAL WITH A NEW ONE UNDER A PRIVATE WARRANTY PROGRAM. WITHIN 2 WEEKS THE DIFFERENTIAL WAS AGAIN MAKING THE SAME NOISES. DEALER SAID THAT CADILLAC WOULD NOT DO ANYTHING ABOUT THE PROBLEM. NOTE: SERVICING MECHANIC NOTED AFTER CHANGING THE DIFFERENTIAL FLUID, THAT THE FLUID TAKEN FROM THE NEWLY INSTALLED DIFFERENTIAL WAS BURNT BLACK. *TR
NHTSA ODI #10641390
46,450 miles · Mar 20, 2014
Power Train
CLUNKING SOUND AND FEEL FROM REAR AXLE WHEN SHIFTING GEARS . APPEARS TO BE GETTING WORSE. *TR
NHTSA ODI #10573689
82,000 miles · Jan 9, 2014
EnginePower Train
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE RADIATOR FAILED AND CAUSED COOLANT TO LEAK INTO THE TRANSMISSION. AS A RESULT, THE RADIATOR AND TRANSMISSION BOTH NEEDED TO BE REPLACED. THE MANU…
Read full complaint
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE RADIATOR FAILED AND CAUSED COOLANT TO LEAK INTO THE TRANSMISSION. AS A RESULT, THE RADIATOR AND TRANSMISSION BOTH NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 86,000.
NHTSA ODI #10559226
55 miles · Sep 30, 2013
EnginePower TrainSteeringCrashInjury
I WAS HIT FRONT END NEVER HAD A CHANCE TO REACT. 110 MPH IMPACT. ENGINE TRANSMISSION BRACKETS THAT ARE DESIGNED TO SHEAR OFF TO KEEP ENGINE FROM GOING INTO DRIVER COMPARTMENT DID NOT . EVERYTHING CAME FORWARD CAUSING EXTENSIVE DAMAGE, HORRIBLE INJURIES. *TR
NHTSA ODI #10546127
121,500 miles · Jun 29, 2013
Power Train
I WAS TRAVELING ON THE INTERSTATE WHEN IT FELT LIKE SOMEONE HAD HIT US FROM BEHIND EXCEPT THERE WAS NO ONE THERE. I SAW SMOKE COMING FROM THE BACK END OF CAR AND IT SMELLED LIKE SOMETHING WAS BURNING. I PULLED OFF TO THE SIDE AND STOPPED MY VEHICLE. AFTER STOPPING THE CAR IT I COULD NO LONGER GET IT TO MOVE FORWARD. IT ACTED LIK…
Read full complaint
I WAS TRAVELING ON THE INTERSTATE WHEN IT FELT LIKE SOMEONE HAD HIT US FROM BEHIND EXCEPT THERE WAS NO ONE THERE. I SAW SMOKE COMING FROM THE BACK END OF CAR AND IT SMELLED LIKE SOMETHING WAS BURNING. I PULLED OFF TO THE SIDE AND STOPPED MY VEHICLE. AFTER STOPPING THE CAR IT I COULD NO LONGER GET IT TO MOVE FORWARD. IT ACTED LIKE IT WAS NOT ABLE TO GO INTO GEAR. HAD A TOW TRUCK HAUL IT HOME FROM EL CENTRO, CALIF TO YUMA, AZ. THE CAR HAD TO LITERALLY BE DRAGGED ONTO THE TOW TRUCK CAUSE THE REAR WHEELS WERE FROZEN IN PLACE. LUCKILY THE WHEELS DIDN'T CEASE WHILE WE WERE STILL MOVING. AFTER REMOVAL OF DIFFERENTIAL WE DISCOVERED IT WAS BONE DRY. I HAD REPLACE A BUSHING NOT TO LONG AGO BUT SAW NO SIGN OF LEAKS. I PURCHASED THE 2005 CTS NEW FROM A DEALER IN YUMA AND NEVER RECEIVED ANY NOTICE OF A RECALL FOR THE SEALS. OR FOR ANYTHING. *TR
NHTSA ODI #10522339
120,000 miles · Sep 24, 2012
Power Train
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT THE VEHICLE WOULD NOT RESPOND WHEN IN REVERSE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE FORWARD. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE TRANSMISSION NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED BECAUSE THE DEAL…
Read full complaint
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT THE VEHICLE WOULD NOT RESPOND WHEN IN REVERSE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE FORWARD. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE TRANSMISSION NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED BECAUSE THE DEALER ADVISED THE CONTACT THAT THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE SAME THING. THE FAILURE MILEAGE WAS 120,000.
NHTSA ODI #10476915
73,000 miles · Aug 2, 2012
Power Train
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE JERKED TO THE RIGHT AND NEARLY CAUSED A CRASH. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS AND THE CONTACT WAS INFORMED OF POSSIBLE UNDERGROUND WIRE DEFECTS. T…
Read full complaint
TL* THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE JERKED TO THE RIGHT AND NEARLY CAUSED A CRASH. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS AND THE CONTACT WAS INFORMED OF POSSIBLE UNDERGROUND WIRE DEFECTS. THE VEHICLE WAS REPAIRED AND THE DEALER OFFERED NO FURTHER ASSISTANCE. THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 73,000 AND THE CURRENT MILEAGE WAS 74,000.
NHTSA ODI #10468990
112,000 miles · Jul 16, 2012
Fuel System, GasolinePower TrainFire
WHILE DRIVING ON THE HIGHWAY UNDER NORMAL OPERATING CONDITIONS, MY PROPERLY MAINTAINED AND UNMODIFIED 2005 CADILLAC CTS CAUGHT FIRE. THE FIRE CAUSED SIGNIFICANT DAMAGE TO THE DRIVE TRAIN AND FUEL TANK WITH THE PLASTIC FUEL TANK SECONDS AWAY FROM BEING TOTALLY BREACHED BY FLAMES AND LIKELY SIGNIFICANT INJURIES INCLUDING DEATH.…
Read full complaint
WHILE DRIVING ON THE HIGHWAY UNDER NORMAL OPERATING CONDITIONS, MY PROPERLY MAINTAINED AND UNMODIFIED 2005 CADILLAC CTS CAUGHT FIRE. THE FIRE CAUSED SIGNIFICANT DAMAGE TO THE DRIVE TRAIN AND FUEL TANK WITH THE PLASTIC FUEL TANK SECONDS AWAY FROM BEING TOTALLY BREACHED BY FLAMES AND LIKELY SIGNIFICANT INJURIES INCLUDING DEATH. THE FIRE BURNED FOR 30-40 MINUTES UNTIL THE RESPONDING FIREFIGHTERS WERE ABLE TO JACK UP THE VEHICLE AND EXTINGUISH THE FIRE WITH WATER FROM UNDERNEATH. FORTUNATELY, THE FIREFIGHTERS WERE ABLE TO EXTINGUISH THE VEHICLE FIRE PRIOR TO THE FUEL TANK BREACH WITH NO APPARENT RELATED INJURIES. PURSUANT TO AN EXPERT ANALYSIS AND REPORT, THE FOLLOWING MANUFACTURING AND/OR DESIGN DEFECTS SEQUENTIALLY CAUSED SAID FIRE: 1. WHILE DRIVING, THE REAR CARRIER PINION BEARING FAILED; 2. FAILED CARRIER PINION CAUSED EXCESSIVE PLAY IN THE PINION GEAR; 3. EXCESSIVE PLAY IN THE PINION GEAR CAUSED FAILURE OF THE PINION GEAR SEAL IN THE RING AND PINION HOUSING; 4. FAILED PINION GEAR SEAL ALLOWED THE REAR CARRIER LUBRICANT TO LEAK; 5. WITH VEHICLE IN MOTION, REAR CARRIER LUBRICANT CONTACTED ROTATING DRIVESHAFT ASSEMBLY; 6. ROTATING DRIVESHAFT AND PINION YOKE "SPRAYED" LUBRICANT IN THE REAR AXLE HOUSING AREA INCLUDING ONTO EXHAUST, PLASTIC FUEL TANK, RUBBER DRIVESHAFT COUPLER AND FLOOR PAN; 7. HEAT FROM EXHAUST OR PINION GEAR IGNITED LUBRICANT & SUBSEQUENT FIRE QUICKLY SPREAD ACROSS THE BOTTOM OF THE VEHICLE. EXPERT REPORT CONCLUDED THAT MANUFACTURING AND / OR DESIGN DEFECTS WERE PREVIOUSLY WELL-DOCUMENTED BY NHSA 2005 CADILLAC CTS NHSA OWNER COMPLAINTS AND SAID FIRE COULD HAVE BEEN PREVENTED BY VEHICLE MANUFACTURER THROUGH RECALL NOTICES AND USE OF NON-COMBUSTIBLE MATERIALS.
NHTSA ODI #10466203
62,000 miles · Apr 28, 2011
Power Train
TL*THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THE REAR AXLE PINION SEAL LEAKED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED HIS VIN WAS NOT INCLUDED IN THE RECALL AND THAT IT WOULD COST $315 TO BE REPAIRED. NHTSA RECALL CAMPAIGN ID NUMBER: 07V589000, POWER TRAIN: AXLE ASSEMBLY: AXLE SHAFT: SEAL WAS RELATED TO TH…
Read full complaint
TL*THE CONTACT OWNS A 2005 CADILLAC CTS. THE CONTACT STATED THE REAR AXLE PINION SEAL LEAKED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED HIS VIN WAS NOT INCLUDED IN THE RECALL AND THAT IT WOULD COST $315 TO BE REPAIRED. NHTSA RECALL CAMPAIGN ID NUMBER: 07V589000, POWER TRAIN: AXLE ASSEMBLY: AXLE SHAFT: SEAL WAS RELATED TO THE FAILURE. THE MANUFACTURER WAS CONTACTED AND STATED HIS VIN WAS NOT INCLUDED IN THE RECALL AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 62,000.
General Motors LLC (GM) is recalling certain model year 2004-2007 Cadillac CTS-V vehicles manufactured October 6, 2003, to March 15, 2007, and 2006-2007 Cadillac STS-V vehicles manufactured June 23, 2005, to March 15, 2007. In the affected vehicles, the electrical terminals of the fuel pump module may overheat resulting in the melting of the flange material.
Consequence & remedy
Consequence: If the flange melts, a hole may be created allowing the fuel pump to leak fuel, causing the vehicle to stall, increasing the risk of a vehicle crash. Additionally, leaking fuel in the presence of an ignition source increases the risk of a fire.
Remedy: GM will notify owners, and dealers will replace the fuel module and fuel tank jumper harness, free of charge. GM sent out interim notices in late October. The recall began on March 12, 2015. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14405.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 2, 2014 that they are recalling 554,328 model year 2003-2014 Cadillac CTS vehicles manufactured August 16, 2001, to April 28, 2014, and 2004-2006 Cadillac SRX vehicles manufactured March 20, 2003, to August 11, 2006. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 15, 2014. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14172.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2007 CADILLAC CTS VEHICLES. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH REPEATED FLEXING OF THE PASSENGER SENSING SYSTEM MAT IN THE FRONT PASSENGER SEAT MAY CAUSE THE MAT TO KINK, BEND, OR FOLD. THIS FLEXING CAN BREAK THE CONNECTIONS IN THE MAT. IF THIS OCCURS, THE SENSOR MAY NOT DETECT THE PRESENCE OF A FRONT SEAT PASSENGER AND WILL DISABLE THE AIR BAG.
Consequence & remedy
Consequence: NON-DEPLOYMENT OF THE FRONT PASSENGER AIR BAG IN THE EVENT OF A CRASH NECESSITATING THAT AIR BAG'S DEPLOYMENT MAY REDUCE PROTECTION OF THE PASSENGER AND INCREASE THE RISK OR SEVERITY OF INJURY TO THEM.
Remedy: DEALERS WILL REPLACE THE PASSENGER SENSING SYSTEM FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 15, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2003-2007 CADILLAC CTS VEHICLES CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON D.C., WEST VIRGINIA AND WISCONSIN. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE FRONT BRAKE HOSE FITTING AT THE CALIPER MAY CORRODE DUE TO SNOW OR WATER, CONTAINING ROAD SALT OR OTHER CONTAMINANTS, ENTERING AND BEING RETAINED IN THE ROUTING SLEEVE. IF THE FITTING CORRODES SIGNIFICANTLY, THE BRAKE HOSE-TUBE INTERFACE MAY DEVELOP A LEAK.
Consequence & remedy
Consequence: THE BRAKE HOSE-TUBE INTERFACE MAY RUPTURE SUDDENLY WITHOUT PRIOR WARNING AND INCREASE VEHICLE STOPPING DISTANCE MAY OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS ARE TO REPLACE BOTH FRONT BRAKE HOSE ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
CERTAIN VEHICLES EQUIPPED WITH V6 ENGINES MAY HAVE A CONDITION WHERE FUEL IS NO LONGER SUPPLIED TO THE ENGINE. THIS CONDITION OCCURS WITHOUT THE ILLUMINATION OF THE FUEL LEVEL LOW INDICATOR LIGHT OR THE WARNING CHIME.
Consequence & remedy
Consequence: IF THE ENGINE STOPS RUNNING, THE OPERATOR WILL NOT BE ABLE TO RESTART THE VEHICLE WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE ELECTRONIC CONTROL MODULE (ECM) WITH NEW SOFTWARE FREE OF CHARGE. OWNERS WERE NOTIFIED IN DECEMBER 2005 AND ASKED TO MAINTAIN AT LEAST 1/4 OF A TANK FUEL LEVEL TO AVOID THIS CONDITION UNTIL THE PARTS ARE AVAILABLE. THE PARTS ARE NOW AVAILABLE, OWNER RENOTIFICATION BEGAN ON MARCH 23, 2006. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EQ11001 · Iee Passenger Sensing System Mats
Opened Feb 7, 2011 · Closed Jul 19, 2011
Status: closed (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
On December 17, 2010, General Motors (GM) notified the NHTSA that it had decided certain 2005 - 2007 model year Cadillac CTS vehicles contain a safety related defect.GM stated that certain CTS vehicles contain a passenger sensing system mat, manufactured by IEE, in the front passenger seat that may flex causing the mat to kink, bend or fold.If this flexing causes the connections in the mat to break, the passenger airbag could become disabled.Non-deployment of the front passenger air bag in the event of a crash necessitating that air bag's deployment may reduce protection of the passenger and increase the risk or severity of injury to them.This issue was assigned recall number 10V-644.On February 8, 2011, RMD mailed an information request (IR) letter to IEE requesting a list of purchasers for any company that was sold the same or similar defective mats.RMD also requested IEE supply the year, make and models of compatible vehicles for each of the mats it listed in its response.IEE responded on February 15, 2011, reporting that the mats recalled in GM recall 10V-644 were developed specifically for the 2005-2007 Cadillac CTS.IEE noted that, ...the CTS Sensor Mat is not the same or similar to any other sensor mat manufactured by IEE.IEE further explained that the sensor mats were sold to Lear Corp. (Lear), for incorporation into seat assemblies, with the seat assemblies finally being sold to GM.Also, some sensor mats were sold to Integrated Manufacturing and Assembly, LLC (IMA) who would then re-sell the mats to GM to use as service parts.Ultimately, these parts were all sold to GM for use in the 2005-2007 Cadillac CTS vehicles.According to its 10V-644 Defect Report, GM reported that some vehicles outside the recall population have ...significantly lower incident rates and will be provided a special coverage.This special coverage includes a free repair should the same issue occur to non-recalled 2005-2007 Cadillac CTS vehicles up to 10 years or 120,000 miles.On April 7, 2011, RMD mailed an IR letter to GM to gather more information on GM's decision to only recall a portion of the vehicles that contained the subject IEE mats.RMD also requested that GM provide updated to current warranty claims, field reports, and other field information for CTS vehicles both recalled and those under the special coverage.On May 19, 2011, GM responded with a letter and several CD attachments that were submitted to NHTSA's Office of the Chief Counsel along with a request for confidentiality.GM confirmed that the IEE mats recalled in 10V-644 were only used in the 2005-2007 Cadillac CTS.GM also explained its reasoning in only recalling a portion of the CTS vehicles containing IEE mats.Due to various production phases, error detections, and false corrections, certain vehicles were more prone to mat failures than other vehicles.GM identified 4 distinct seat assembly production periods and chose to recall CTS vehicles depending on which seat assembly each vehicle received.Examining the data submitted in regards to warranty claims, field reports, and incidents, the CTS vehicles that were included in the safety recall were responsible for about 80% of the overall claims.CTS vehicles included in the special coverage (essentially an extended warranty), those with seat assemblies from other identified production phases, were responsible for about 20% of the overall claims.As GM has provided clear data to support its recall decision and since no other manufacturer has installed these same or similar passenger sensing system mats / seat assemblies in their vehicles, this Equipment Query is satisfied.This EQ is cl
EA07017 · Rear Drivetrain Component Failure
Opened Dec 7, 2007 · Closed Jul 16, 2008
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
IN JULY OF 2007 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE07-037 TO INVESTIGATE ALLEGATIONS THAT THE REAR DIFFERENTIAL MAY FAIL CAUSING A LOSS OF MOTIVE POWER, AND IN SOME INSTANCES A LOSS OF CONTROL, IN MODEL YEAR (MY) 2004 THROUGH 2006 CADILLAC CTS, CTS-V, AND STS VEHICLES.AS A RESULT OF THAT INVESTIGATION GM ISSUED RECALL 07V-589 TO CORRECT A LEAKING PINION SEAL PROBLEM.EA07-017 WAS OPENED TO INVESTIGATE COMPLAINTS OF FRACTURED REAR DIFFERENTIAL HOUSINGS OR REAR HALF SHAFTS IN HIGH PERFORMANCE CADILLAC CTS-V VEHICLES.ACCORDING TO GM, THESE FAILURES RESULTED FROM THE CUMULATIVE DAMAGE FROM MULTIPLE POWER HOP EVENTS THAT CAN OCCUR DURING VERY AGGRESSIVE DRIVING. IN FEBRUARY 2008 INVESTIGATORS FROM ODI MET WITH GM REPRESENTATIVES TO CONDUCT TESTING OF THE SUBJECT CTS-V VEHICLES.DURING THE TESTING THE SUBJECT VEHICLES WERE SUBJECTED TO CONSIDERABLE TORSIONAL FORCES FROM STANDING STARTS AND WHILE DRIVING.POWER HOP OCCURRED DURING SOME OF THE MOST AGGRESSIVE DRIVING MANEUVERS.THE TESTING DID NOT RESULT IN FAILURE OF ANY REAR DRIVETRAIN COMPONENTS.THE ENGINEERING DESIGN AND TESTING DATA SUPPLIED TO ODI BY GM AND THE RESULTS OF THE TESTING CONDUCTED BY ODI TEND TO SUPPORT GM'S POSITION THAT THE DIFFERENTIAL DESIGN IS NOT DEFECTIVE. COMPLAINTS LISTED IN THE FAILURE REPORT DO NOT INCLUDE THOSE INDICATIVE OF FAILURE OF THE REAR PINION SEAL IN CTS-V VEHICLES COVERED BY RECALL 07V-589. FURTHER INVESTIGATION IN THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.
2005 Cadillac Cts Problems, Complaints & Recalls | Skip That Year
Illustration