IllustrationMy front door latch doesn't work often leaving me locked out of the car. If the car is off I can use the auto roll down feature, but if the car is on i can't. This is a safety issue if I am in danger or my child is in the car.
2020 Cadillac CT5
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all CT5 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 38 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports1 injury reports
Electrical System complaints
8 reportsThe electronic exterior door handle on my CT5 has failed and raises a concern of what if there was an accident and nobody was able to open the door if I was unconscious. I believe that having a key access is not enough and there should be a mechanical exterior door handle instead of an electronic handle that fails and is costly …
Read full complaint
The electronic exterior door handle on my CT5 has failed and raises a concern of what if there was an accident and nobody was able to open the door if I was unconscious. I believe that having a key access is not enough and there should be a mechanical exterior door handle instead of an electronic handle that fails and is costly to repair.
The contact owns a 2020 Cadillac CT5. The contact stated that the check engine warning light was illuminated. The contact had noticed an oil leak and that the battery charge was abnormally low. The contact received an alert from OnStar pertaining to the critically low battery. Additionally, the contact noticed that there was an…
Read full complaint
The contact owns a 2020 Cadillac CT5. The contact stated that the check engine warning light was illuminated. The contact had noticed an oil leak and that the battery charge was abnormally low. The contact received an alert from OnStar pertaining to the critically low battery. Additionally, the contact noticed that there was an abnormal squishing sound coming from the dashboard, and the contact believed that the sound was coming from an animal that had intruded into the vehicle. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The vehicle was taken to a tire center where all four TPMS sensors were replaced. The failure mileage was approximately 75,000.
CT5 2020 Doors will not unlock.
I have had many issues with Onstar failing. I bought the 2020 Cadillac CT5 AWD 10/2020. It took Onstar over a month to connect to my car to provide AT&T internet plan (via Onstar). On 4/22/21 I was hit in my driver front & wheel, Onstar failed- never contacted us & the airbags did not deploy. I noticed my Onstar light was red. O…
Read full complaint
I have had many issues with Onstar failing. I bought the 2020 Cadillac CT5 AWD 10/2020. It took Onstar over a month to connect to my car to provide AT&T internet plan (via Onstar). On 4/22/21 I was hit in my driver front & wheel, Onstar failed- never contacted us & the airbags did not deploy. I noticed my Onstar light was red. Onstar was repaired during the body shop repair. Soon after I picked up the car (approximately 1 month) the SRS light came on & Onstar turned red again on 7/31/21. Dropped off the car to be repaired 8/13/21. After repair, SRS light came on again on 8/29/21. Then 10/4/21 the entire CUE system malfunctioned, could not use Carplay, Car Internet would not work, & Navigation would not load. 10/30/21 I cranked my car & left keys in car, the doors locked- which it should not have done. My Onstar app could not unlock the car. I called Onstar to unlock the vehicle & was told they were receiving a "busy signal, spinning sign" when trying to reach my car. My car finally shut off after idling for so long, and it unlocked the doors. I dropped off for service again 11/4/21. GM & Onstar both investigated car for the failures following the accident that occurred 4/22/21-both companies said no issue was found. GM downloaded data from wreck data, I received the report and it was missing data.
There are multiple issues with the electrical / electronics The dealer has never found any data in the systems that shows issues. Driver speedometer screen disappears and will be gone for hours or a trip. Restarting car does not fix. Center console screen that shows camera information disappears and you have no camera. Can be …
Read full complaint
There are multiple issues with the electrical / electronics The dealer has never found any data in the systems that shows issues. Driver speedometer screen disappears and will be gone for hours or a trip. Restarting car does not fix. Center console screen that shows camera information disappears and you have no camera. Can be one or multiple trips and restarting car does not fix Dealer says the previous two issues are known but no fix or recall has have been implemented as far as we are are aware. This has been a year approx. Drivers assist package threw the car into a curb creating minor damage to divers side wheels. Cadillac found no issues in recent service. When backing car up it has engaged the parking brake When driving the car it has shifted itself into neutral. The last 3 items the dealer spent weeks going thru the car with Cadillac and found nothing. No parts have ever been replaced in multiple visits The last 3 are huge safety issues
TL* THE CONTACT OWNS A 2020 CADILLAC CT5. THE CONTACT STATED WHILE STARTING THE VEHICLE, THE SERVICE SAFETY RESTRAINT SYSTEM AND AIR BAG WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER - DUBLIN CADILLAC (4200 JOHN MONEGO CT, DUBLIN, CA 94568: (925) 526-4384) AND MATAGA BUICK GMC CADILLAC (3261 AUTO CEN…
Read full complaint
TL* THE CONTACT OWNS A 2020 CADILLAC CT5. THE CONTACT STATED WHILE STARTING THE VEHICLE, THE SERVICE SAFETY RESTRAINT SYSTEM AND AIR BAG WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER - DUBLIN CADILLAC (4200 JOHN MONEGO CT, DUBLIN, CA 94568: (925) 526-4384) AND MATAGA BUICK GMC CADILLAC (3261 AUTO CENTER CIR, STOCKTON, CA 95212, (209) 951-2600) HOWEVER, THE MECHANICS WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 20.
PURCHASED MY 2020 CT5 IN APRIL 2020. SINCE THEN THE VEHICLE HAS BEEN AT THE DEALERSHIP 5 TIMES FOR THE SAME SERVICE DRIVER ASSIST AND FORWARD COLLISION SYSTEM UNAVAILABLE. GM HAS DISPATCHED A SENIOR ADVISOR TO TEST THE VEHICLE AND EVEN LEFT A CODE READER IN THE VEHICLE TO TRACK ITS PERFORMANCE. MESSAGES CAME ON AGAIN. I RECORDED…
Read full complaint
PURCHASED MY 2020 CT5 IN APRIL 2020. SINCE THEN THE VEHICLE HAS BEEN AT THE DEALERSHIP 5 TIMES FOR THE SAME SERVICE DRIVER ASSIST AND FORWARD COLLISION SYSTEM UNAVAILABLE. GM HAS DISPATCHED A SENIOR ADVISOR TO TEST THE VEHICLE AND EVEN LEFT A CODE READER IN THE VEHICLE TO TRACK ITS PERFORMANCE. MESSAGES CAME ON AGAIN. I RECORDED IT AS INSTRUCTED AND THE DEVICE WAS SENT BACK TO THE GM ENGINEERS. IT HAS BEEN OVER A MONTH TODAY 18 SEPTEMBER AND STILL NO UPDATE AS TO WHAT'S WRONG WITH THIS CAR. THEY'VE REPLACED AND REINSTALLED CAMERAS AND DEVICES AND IT STILL DIDN'T FIX THE ISSUE. I GET A CALL TODAY FROM THE DEALERSHIP SAYING THE RECALL CAME OUT. I'M EXTREMELY FRUSTRATED AND I KNOW THEY STILL CAN'T FIX THE ISSUE AFTER MY CAR HAS BEEN THE FIRST CASE AND GUINEA PIG OF RESEARCH. THIS HAS BEEN GOING ON SINCE DATE OF PURCHASE. IT'S INTERMITTENT AND AT ANY TIME OF DAY
Official recalls
425V148000 · Power Train:automatic Transmission
Mar 6, 2025
General Motors LLC (GM) is recalling certain 2019-2020 Cadillac CT6, 2020-2021 CT4, CT5, and 2020-2022 Chevrolet Camaro vehicles equipped with a 10-speed transmission. The transmission may become damaged internally and cause the wheels to lock-up.
Consequence & remedy
Consequence: Wheel lock-up while driving increases the risk of a crash.
Remedy: Dealers will install transmission control module monitoring software, free of charge. Owner notification letters were mailed April 7, 2025. Owners may contact Cadillac customer service at 1-800-333-4223 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242480630.
22V903000 · Exterior Lighting:lighting Control Module:software
Dec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
21V611000 · Air Bags; Air Bags:side/window:curtain
Aug 5, 2021
General Motors, LLC. (GM) is recalling certain 2020-2022 Cadillac CT4 and CT5 vehicles. The roof rail side-curtain air bags may not have been installed correctly, which could result in an improper air bag deployment during a crash.
Consequence & remedy
Consequence: Air bags that do not deploy properly can increase the risk of injury in a crash.
Remedy: Dealers will inspect both left and right-side roof rail air bags and reinstall the air bags, as necessary, free of charge. Owner notification letters were mailed on August 30, 2021. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212342780.
Additional source detail variants (2)
Air Bags:side/window:curtain
General Motors, LLC. (GM) is recalling certain 2020-2022 Cadillac CT4 and CT5 vehicles. The roof rail side-curtain air bags may not have been installed correctly, which could result in an improper air bag deployment during a crash.
Consequence: Air bags that do not deploy properly can increase the risk of injury in a crash.
Remedy: Dealers will inspect both left and right-side roof rail air bags and reinstall the air bags, as necessary, free of charge. Owner notification letters were mailed on August 30, 2021. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212342780.
Air Bags
General Motors, LLC. (GM) is recalling certain 2020-2022 Cadillac CT4 and CT5 vehicles. The roof rail side-curtain air bags may not have been installed correctly, which could result in an improper air bag deployment during a crash.
Consequence: Air bags that do not deploy properly can increase the risk of injury in a crash.
Remedy: Dealers will inspect both left and right-side roof rail air bags and reinstall the air bags, as necessary, free of charge. Owner notification letters were mailed on August 30, 2021. Owners may contact Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212342780.
20V588000 · Service Brakes
Sep 24, 2020
General Motors LLC (GM) is recalling certain 2020 Chevrolet Corvette and Cadillac CT4, CT5 and XT4, 2021 Chevrolet Trailblazer, and 2020-2021 Buick Encore GX vehicles. Sensor connection contamination in the electronic brake boost system may cause an interruption of communication between the sensor and the brake boost system.
Consequence & remedy
Consequence: If communication with the sensor is interrupted, the electronic brake boost assist could be lost. Extra pedal force will be required to slow and stop the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the electronic brake boost module, free of charge. The recall began December 9, 2020. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-333-4223, or Buick customer service at 1-800-521-7300. GM's number for this recall is A202307260.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21010 · Air Bag Malfunction
Opened Apr 9, 2021 · Closed Aug 24, 2023
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:srs Malfunction Warning Lamp/light
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models), XT4 and MY 2021 Escalade, Suburban, Tahoe, Yukon SUVs.Technical Service Bulletin (TSB) 21-NA-005, issued in March 2021, addresses air bag MIL illumination with diagnostic trouble codes (DTCs) B0001-1B or B0012-0D. It cites rust particles in the connection terminal interface of the driver air bag inflator housing as the cause of the air bag MIL illumination. Illumination of the air bag MIL under these circumstances may result in a non-deployment of the frontal driver air bag during a frontal collision and increased risk of injury to the driver.GM stated a correlation exists between production delays due to the pandemic shutdown and premature corrosion initiation on the surface of the air bag inflator housing, which, in some cases, caused rust development during a seven (7) month period of vehicle production. In the rare instance when a rust particle dislodges from the driver air bag inflator housing and enters the air bag connector prior to assembly, an intermittent resistance spike at the air bag connector may result. The condition generates excessive resistance in the air bag electrical system when the steering wheel horn cover is manipulated or the steering wheel is turned. This excessive resistance is momentary. A crash commanding air bag deployment would need to occur exactly when the momentary excessive resistance occurs. Thus, there is a very low likelihood the hazard will present a risk during a crash of sufficient severity to warrant a commanded deployment. This failure mechanism occurs early in life and results in an air bag MIL illumination that corresponds to a DTC warning the driver that the vehicle requires service. The vehicle's air bag remains functional while the MIL is illuminated, and the DTC is present.Once the connection of the driver air bag module to the clockspring is made at the plant, or at the dealership for service, there is no longer an opportunity for rust migration into the connection point. The connector is sealed and has gold terminals, eliminating the expectation of fretting corrosion. All subject vehicles passed standard corrosion validation testing for extensive corrosion with no issue of air bag non-deployment.There is a low rate of occurrence: 1.41 incidents per thousand vehicles (IPTV) for all related occurrences, and 0.04 IPTV for occurrences with a mention of visible rust and/or corrosion on the air bag inflator housing. The average occurrence mileage for the subject vehicles is approximately 2,100. Every occurrence related to the alleged defect experienced an air bag MIL illumination and there are no verified allegations of air bag non-deployment within all data sources.To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate, and the nature of early-life failure, the high detectability of failures, and low potential hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers: 11537927, 11528888, 11525020, 11521401, 11506057, 11493107, 11486767, 11441525, 11433146, 11425658, 11423440, 11385267, 11376429, 11373466, 11366995.
Additional source detail variants (4)
Air Bags:frontal:driver Side:inflator Module
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models), XT4 and MY 2021 Escalade, Suburban, Tahoe, Yukon SUVs.Technical Service Bulletin (TSB) 21-NA-005, issued in March 2021, addresses air bag MIL illumination with diagnostic trouble codes (DTCs) B0001-1B or B0012-0D. It cites rust particles in the connection terminal interface of the driver air bag inflator housing as the cause of the air bag MIL illumination. Illumination of the air bag MIL under these circumstances may result in a non-deployment of the frontal driver air bag during a frontal collision and increased risk of injury to the driver.GM stated a correlation exists between production delays due to the pandemic shutdown and premature corrosion initiation on the surface of the air bag inflator housing, which, in some cases, caused rust development during a seven (7) month period of vehicle production. In the rare instance when a rust particle dislodges from the driver air bag inflator housing and enters the air bag connector prior to assembly, an intermittent resistance spike at the air bag connector may result. The condition generates excessive resistance in the air bag electrical system when the steering wheel horn cover is manipulated or the steering wheel is turned. This excessive resistance is momentary. A crash commanding air bag deployment would need to occur exactly when the momentary excessive resistance occurs. Thus, there is a very low likelihood the hazard will present a risk during a crash of sufficient severity to warrant a commanded deployment. This failure mechanism occurs early in life and results in an air bag MIL illumination that corresponds to a DTC warning the driver that the vehicle requires service. The vehicle's air bag remains functional while the MIL is illuminated, and the DTC is present.Once the connection of the driver air bag module to the clockspring is made at the plant, or at the dealership for service, there is no longer an opportunity for rust migration into the connection point. The connector is sealed and has gold terminals, eliminating the expectation of fretting corrosion. All subject vehicles passed standard corrosion validation testing for extensive corrosion with no issue of air bag non-deployment.There is a low rate of occurrence: 1.41 incidents per thousand vehicles (IPTV) for all related occurrences, and 0.04 IPTV for occurrences with a mention of visible rust and/or corrosion on the air bag inflator housing. The average occurrence mileage for the subject vehicles is approximately 2,100. Every occurrence related to the alleged defect experienced an air bag MIL illumination and there are no verified allegations of air bag non-deployment within all data sources.To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate, and the nature of early-life failure, the high detectability of failures, and low potential hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers: 11537927, 11528888, 11525020, 11521401, 11506057, 11493107, 11486767, 11441525, 11433146, 11425658, 11423440, 11385267, 11376429, 11373466, 11366995.
Air Bags:frontal
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models), XT4 and MY 2021 Escalade, Suburban, Tahoe, Yukon SUVs.Technical Service Bulletin (TSB) 21-NA-005, issued in March 2021, addresses air bag MIL illumination with diagnostic trouble codes (DTCs) B0001-1B or B0012-0D. It cites rust particles in the connection terminal interface of the driver air bag inflator housing as the cause of the air bag MIL illumination. Illumination of the air bag MIL under these circumstances may result in a non-deployment of the frontal driver air bag during a frontal collision and increased risk of injury to the driver.GM stated a correlation exists between production delays due to the pandemic shutdown and premature corrosion initiation on the surface of the air bag inflator housing, which, in some cases, caused rust development during a seven (7) month period of vehicle production. In the rare instance when a rust particle dislodges from the driver air bag inflator housing and enters the air bag connector prior to assembly, an intermittent resistance spike at the air bag connector may result. The condition generates excessive resistance in the air bag electrical system when the steering wheel horn cover is manipulated or the steering wheel is turned. This excessive resistance is momentary. A crash commanding air bag deployment would need to occur exactly when the momentary excessive resistance occurs. Thus, there is a very low likelihood the hazard will present a risk during a crash of sufficient severity to warrant a commanded deployment. This failure mechanism occurs early in life and results in an air bag MIL illumination that corresponds to a DTC warning the driver that the vehicle requires service. The vehicle's air bag remains functional while the MIL is illuminated, and the DTC is present.Once the connection of the driver air bag module to the clockspring is made at the plant, or at the dealership for service, there is no longer an opportunity for rust migration into the connection point. The connector is sealed and has gold terminals, eliminating the expectation of fretting corrosion. All subject vehicles passed standard corrosion validation testing for extensive corrosion with no issue of air bag non-deployment.There is a low rate of occurrence: 1.41 incidents per thousand vehicles (IPTV) for all related occurrences, and 0.04 IPTV for occurrences with a mention of visible rust and/or corrosion on the air bag inflator housing. The average occurrence mileage for the subject vehicles is approximately 2,100. Every occurrence related to the alleged defect experienced an air bag MIL illumination and there are no verified allegations of air bag non-deployment within all data sources.To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate, and the nature of early-life failure, the high detectability of failures, and low potential hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers: 11537927, 11528888, 11525020, 11521401, 11506057, 11493107, 11486767, 11441525, 11433146, 11425658, 11423440, 11385267, 11376429, 11373466, 11366995.
Air Bags
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models), XT4 and MY 2021 Escalade, Suburban, Tahoe, Yukon SUVs.Technical Service Bulletin (TSB) 21-NA-005, issued in March 2021, addresses air bag MIL illumination with diagnostic trouble codes (DTCs) B0001-1B or B0012-0D. It cites rust particles in the connection terminal interface of the driver air bag inflator housing as the cause of the air bag MIL illumination. Illumination of the air bag MIL under these circumstances may result in a non-deployment of the frontal driver air bag during a frontal collision and increased risk of injury to the driver.GM stated a correlation exists between production delays due to the pandemic shutdown and premature corrosion initiation on the surface of the air bag inflator housing, which, in some cases, caused rust development during a seven (7) month period of vehicle production. In the rare instance when a rust particle dislodges from the driver air bag inflator housing and enters the air bag connector prior to assembly, an intermittent resistance spike at the air bag connector may result. The condition generates excessive resistance in the air bag electrical system when the steering wheel horn cover is manipulated or the steering wheel is turned. This excessive resistance is momentary. A crash commanding air bag deployment would need to occur exactly when the momentary excessive resistance occurs. Thus, there is a very low likelihood the hazard will present a risk during a crash of sufficient severity to warrant a commanded deployment. This failure mechanism occurs early in life and results in an air bag MIL illumination that corresponds to a DTC warning the driver that the vehicle requires service. The vehicle's air bag remains functional while the MIL is illuminated, and the DTC is present.Once the connection of the driver air bag module to the clockspring is made at the plant, or at the dealership for service, there is no longer an opportunity for rust migration into the connection point. The connector is sealed and has gold terminals, eliminating the expectation of fretting corrosion. All subject vehicles passed standard corrosion validation testing for extensive corrosion with no issue of air bag non-deployment.There is a low rate of occurrence: 1.41 incidents per thousand vehicles (IPTV) for all related occurrences, and 0.04 IPTV for occurrences with a mention of visible rust and/or corrosion on the air bag inflator housing. The average occurrence mileage for the subject vehicles is approximately 2,100. Every occurrence related to the alleged defect experienced an air bag MIL illumination and there are no verified allegations of air bag non-deployment within all data sources.To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate, and the nature of early-life failure, the high detectability of failures, and low potential hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers: 11537927, 11528888, 11525020, 11521401, 11506057, 11493107, 11486767, 11441525, 11433146, 11425658, 11423440, 11385267, 11376429, 11373466, 11366995.
Air Bags:srs Malfunction Warning Lamp/light
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models), XT4 and MY 2021 Escalade, Suburban, Tahoe, Yukon SUVs.Technical Service Bulletin (TSB) 21-NA-005, issued in March 2021, addresses air bag MIL illumination with diagnostic trouble codes (DTCs) B0001-1B or B0012-0D. It cites rust particles in the connection terminal interface of the driver air bag inflator housing as the cause of the air bag MIL illumination. Illumination of the air bag MIL under these circumstances may result in a non-deployment of the frontal driver air bag during a frontal collision and increased risk of injury to the driver.GM stated a correlation exists between production delays due to the pandemic shutdown and premature corrosion initiation on the surface of the air bag inflator housing, which, in some cases, caused rust development during a seven (7) month period of vehicle production. In the rare instance when a rust particle dislodges from the driver air bag inflator housing and enters the air bag connector prior to assembly, an intermittent resistance spike at the air bag connector may result. The condition generates excessive resistance in the air bag electrical system when the steering wheel horn cover is manipulated or the steering wheel is turned. This excessive resistance is momentary. A crash commanding air bag deployment would need to occur exactly when the momentary excessive resistance occurs. Thus, there is a very low likelihood the hazard will present a risk during a crash of sufficient severity to warrant a commanded deployment. This failure mechanism occurs early in life and results in an air bag MIL illumination that corresponds to a DTC warning the driver that the vehicle requires service. The vehicle's air bag remains functional while the MIL is illuminated, and the DTC is present.Once the connection of the driver air bag module to the clockspring is made at the plant, or at the dealership for service, there is no longer an opportunity for rust migration into the connection point. The connector is sealed and has gold terminals, eliminating the expectation of fretting corrosion. All subject vehicles passed standard corrosion validation testing for extensive corrosion with no issue of air bag non-deployment.There is a low rate of occurrence: 1.41 incidents per thousand vehicles (IPTV) for all related occurrences, and 0.04 IPTV for occurrences with a mention of visible rust and/or corrosion on the air bag inflator housing. The average occurrence mileage for the subject vehicles is approximately 2,100. Every occurrence related to the alleged defect experienced an air bag MIL illumination and there are no verified allegations of air bag non-deployment within all data sources.To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate, and the nature of early-life failure, the high detectability of failures, and low potential hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers: 11537927, 11528888, 11525020, 11521401, 11506057, 11493107, 11486767, 11441525, 11433146, 11425658, 11423440, 11385267, 11376429, 11373466, 11366995.