Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
1725–50K
1750–75K
1575–100K
13100–150K
3150K+
99 reports with mileage · 21 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Latches/locks/linkages. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
SLIDING DRIVER'S SIDE REAR DOOR OPENED WHILE I WAS FUELING THE CAR. MY WIFE PUSHED THE OPEN DOOR BUTTON. A VERY DANGEROUS SITUATION DEVELOPED AS THE SLIDING DOOR SLID BACKWARDS TOWARD THE GASOLINE HOSE. I JAMMED THE DOOR WITH MY BODY AND ATTEMPTED TO PRESS THE DOOR BUTTON BUT THE DOOR KEPT TRYING TO SLIDE BACK. I SQUEEZED TH…
Read full complaint
SLIDING DRIVER'S SIDE REAR DOOR OPENED WHILE I WAS FUELING THE CAR. MY WIFE PUSHED THE OPEN DOOR BUTTON. A VERY DANGEROUS SITUATION DEVELOPED AS THE SLIDING DOOR SLID BACKWARDS TOWARD THE GASOLINE HOSE. I JAMMED THE DOOR WITH MY BODY AND ATTEMPTED TO PRESS THE DOOR BUTTON BUT THE DOOR KEPT TRYING TO SLIDE BACK. I SQUEEZED THE HANDLE AND YANKED THE HOSE OUT OF THE GAS TANK FILLER. I SPLASHED QUITE A BIT OF GAS ON THE SIDE OF THE CAR. THERE SHOULD BE SOME SAFETY SWITCH THAT WOULD PREVENT THE SLIDING DOOR FROM OPERATING WHEN THE GAS TANK DOOR IS OPEN. MY WIFE WAS DISORIENTED AT THE TIME BECAUSE OF A DIABETIC SUGAR LOW AND FELT SHE NEEDED AIR. I HAD VISIONS OF THE SLIDING DOOR STRIKING THE GAS HOSE AND STARTING A FIRE. THE DOOR HAS A SAFETY SWITCH THAT PREVENTS IT FROM CLOSING IF AN OBJECT IS IN THE WAY. BUT THERE IS NOTHING TO PREVENT THE DOOR FROM OPENING EVEN WHEN IT IS HELD OR STRIKES SOMETHING. *JB
NHTSA ODI #10201682
4,258 miles · Apr 11, 2007
Latches/locks/linkages
TL*THE CONTACT OWNS A 2005 BUICK TERRAZA. ON THREE OCCASIONS THE KEY FOB IN THE CONTACTS POCKET PRESSED AGAINST SOMETHING AND UNLOCKED ALL OF THE DOORS, INCLUDING THE SLIDING DOOR. THE SLIDING DOOR REMAINS OPEN. THE DEALER STATED THAT THE KEY FOB WAS OPERATING NORMALLY. THE CURRENT MILEAGE IS 4,268, AND FAILURE MILEAGE WAS …
Read full complaint
TL*THE CONTACT OWNS A 2005 BUICK TERRAZA. ON THREE OCCASIONS THE KEY FOB IN THE CONTACTS POCKET PRESSED AGAINST SOMETHING AND UNLOCKED ALL OF THE DOORS, INCLUDING THE SLIDING DOOR. THE SLIDING DOOR REMAINS OPEN. THE DEALER STATED THAT THE KEY FOB WAS OPERATING NORMALLY. THE CURRENT MILEAGE IS 4,268, AND FAILURE MILEAGE WAS 4,258.*AK UPDATE 05/04/07*TR
DT*: THE CONTACT STATED THE HEADLIGHTS FLICKERED WHEN THE VEHICLE WAS DRIVEN 0-60 MPH. WHEN THE VEHICLE WAS TAKEN TO THE SALES/SERVICE DEALER, THE PROBLEM COULD NOT BE RECREATED. THE VOLTAGE REGULATOR WAS REPLACED, BUT THE PROBLEM CONTINUED. THE LIGHTS FAILED TO REMAIN BRIGHT ENOUGH TO SEE WELL AT NIGHT. THE COMPUTER PROGRAM…
Read full complaint
DT*: THE CONTACT STATED THE HEADLIGHTS FLICKERED WHEN THE VEHICLE WAS DRIVEN 0-60 MPH. WHEN THE VEHICLE WAS TAKEN TO THE SALES/SERVICE DEALER, THE PROBLEM COULD NOT BE RECREATED. THE VOLTAGE REGULATOR WAS REPLACED, BUT THE PROBLEM CONTINUED. THE LIGHTS FAILED TO REMAIN BRIGHT ENOUGH TO SEE WELL AT NIGHT. THE COMPUTER PROGRAMMING WAS REFLASHED. THE VEHICLE ALSO HAD AN ONGOING ISSUE WITH THE STARTER, SLIDING DOOR OPENING BY ITSELF WHEN THE VEHICLE WAS PARKED OR WHILE IDLING IN PARK. ON ONE OCCASION, THE CHILD PASSENGER FELL OUT OF THE VEHICLE WHEN THE DOOR OPENED. THERE WERE NO INJURIES SUSTAINED. THERE WAS A PROBLEM WITH THE STEERING WHICH RESULTED IN THE CONTACT SIDE SWIPING A MAILBOX POST ON THE SIDE OF THE ROAD. AT A LATER DATE WHEN THE VEHICLE WAS PARKED IN THE GARAGE, THE VEHICLE CAUGHT ON FIRE. THERE WERE NO REPORTS TAKEN BY THE POLICE OR FIRE DEPARTMENT. THE MANUFACTURER WAS NOTIFIED AND THE SERVICE DEALER TOWED THE VEHICLE BACK TO THE DEALERSHIP.
NHTSA ODI #10175575
Mileage unknown · May 7, 2006
Electrical SystemLatches/locks/linkages
WHILE DRIVING AT NIGHT FROM A FIELD TRIP WITH MY DAUGHTER AND HER GIRL SCOUT BROWNIE TROOP, THE STABILITY TRACK SYSTEM WENT ON IN ERROR AND I LOST CONTROL OF THE CAR. IT WENT FROM 40 MPH TO 5 MPH WITHIN A SECOND. THE STEERING WOULD NOT WORK, EITHER. VERY, VERY SCARY! I CONTACTED ONSTAR IN THE CAR AND THEY COULD NOT SEE A PRO…
Read full complaint
WHILE DRIVING AT NIGHT FROM A FIELD TRIP WITH MY DAUGHTER AND HER GIRL SCOUT BROWNIE TROOP, THE STABILITY TRACK SYSTEM WENT ON IN ERROR AND I LOST CONTROL OF THE CAR. IT WENT FROM 40 MPH TO 5 MPH WITHIN A SECOND. THE STEERING WOULD NOT WORK, EITHER. VERY, VERY SCARY! I CONTACTED ONSTAR IN THE CAR AND THEY COULD NOT SEE A PROBLEM, BUT SENT A TOW TRUCK. THE DEALERSHIP REPLACED A SHORT-WIRE AND SAID IT WAS FIXED. BUT COULD IT HAPPEN AGAIN? ALSO, MY AUTOMATIC DOORS NEVER WORK PROPERLY. WE BOUGHT THIS CAR FOR FAMILY TRIPS AND FIELD TRIPS, BUT NOW I'M TOO SCARED TO TAKE IT ON TRIPS OR FIELD TRIPS THINKING THAT IT WILL HAPPEN AGAIN ON THE EXPRESS WAY LIKE IT DID TO OTHER TERAZZA OWNERS. WE LEASED IT SO I CAN'T GET RID OF IT. INSTEAD I MAKE A HUGE PAYMENT EVERY MONTH ON A LEMON. *JB
NHTSA ODI #10156952
13,444 miles · Apr 14, 2006
Latches/locks/linkagesPower Train
DT*: THE CONTACT STATED THE AUTOMATIC SLIDING DOOR LOCKED BY ITSELF AND WOULD NOT OPEN BY THE KEY OR POWER CONTROLS. THE VEHICLE WAS SEEN BY A DEALER FOR REPLACEMENT OF THE POWER DOOR LOCK MOTOR. ALTHOUGH THE DOOR LOCK PROBLEM WAS CORRECTED, THE DOOR RATTLED WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE IS CURRENTLY AWAITING …
Read full complaint
DT*: THE CONTACT STATED THE AUTOMATIC SLIDING DOOR LOCKED BY ITSELF AND WOULD NOT OPEN BY THE KEY OR POWER CONTROLS. THE VEHICLE WAS SEEN BY A DEALER FOR REPLACEMENT OF THE POWER DOOR LOCK MOTOR. ALTHOUGH THE DOOR LOCK PROBLEM WAS CORRECTED, THE DOOR RATTLED WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE IS CURRENTLY AWAITING FURTHER INSPECTION BY THE DEALER. *AK UPDATED 5/10/2006 - THE VEHICLE ROLLED BACK WHILE ON HILLS. *NM
NHTSA ODI #10155387
Mileage unknown · Apr 10, 2006
Latches/locks/linkages
2005 BUICK TERRAZA LEFT SLIDING DOOR WOULD NOT OPEN EITHER ELECTRONICALLY OR MANUALLY. DOOR LATER OPENED WHILE VEHICLE WAS IN MOTION. *TS THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES BUT THEY WERE UNABLE TO FIND THE CAUSE OF THE PROBLEM. THEY DID UPDATE THE SLIDING DOOR MODULE PER SERVICE BULLETIN 05-08-64-013 BUT THAT…
Read full complaint
2005 BUICK TERRAZA LEFT SLIDING DOOR WOULD NOT OPEN EITHER ELECTRONICALLY OR MANUALLY. DOOR LATER OPENED WHILE VEHICLE WAS IN MOTION. *TS THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES BUT THEY WERE UNABLE TO FIND THE CAUSE OF THE PROBLEM. THEY DID UPDATE THE SLIDING DOOR MODULE PER SERVICE BULLETIN 05-08-64-013 BUT THAT DID NOT CORRECT THE PROBLEM. *NM
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Buick Terraza Problems, Complaints & Recalls | Skip That Year
Illustration