TL* THE CONTACT OWNS A 1996 BUICK RIVIERA. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, THERE WAS A STRONG GASOLINE ODOR. THE CONTACT NOTICED THAT THE FUEL TANK WAS FRACTURED FROM EXCESSIVE CORROSION CAUSING FUEL TO LEAK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 68,000. UPDATED 8//1/14*CN …
Read full complaint
TL* THE CONTACT OWNS A 1996 BUICK RIVIERA. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, THERE WAS A STRONG GASOLINE ODOR. THE CONTACT NOTICED THAT THE FUEL TANK WAS FRACTURED FROM EXCESSIVE CORROSION CAUSING FUEL TO LEAK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 68,000. UPDATED 8//1/14*CN THE CONSUMER STATED THE TANK WAS PLASTIC WITH A METAL RING BONDED TO THE TANK, WITH A METAL LOCK RING THAT HELD THE FUEL PUMP IN PLACE. BOTH METAL RINGS WERE COMPLETELY RUSTED, TO THE POINT THEY WERE CRUMBLING AND FLAKING. UPDATED 08/26/14
NHTSA ODI #10594863
140,000 miles · Nov 9, 2009
Fuel System, GasolineFire
TL* THE CONTACT OWNS A 1996 BUICK RIVIERA. WHILE DRIVING APPROXIMATELY 45 MPH THE ENGINE STARTED HESITATING. HE PULLED OVER TO THE SIDE OF THE ROAD, AND NOTICED AN ENGINE COMPARTMENT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A SALVAGE CENTER. THE VEHICLE WAS COMP…
Read full complaint
TL* THE CONTACT OWNS A 1996 BUICK RIVIERA. WHILE DRIVING APPROXIMATELY 45 MPH THE ENGINE STARTED HESITATING. HE PULLED OVER TO THE SIDE OF THE ROAD, AND NOTICED AN ENGINE COMPARTMENT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A SALVAGE CENTER. THE VEHICLE WAS COMPLETELY DESTROYED . THE CAUSE OF FAILURE HAS NOT BEEN DETERMINED AT THIS TIME. ALTHOUGH HE EXPERIENCED AN IDENTICAL FAILURE, HE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL CAMPAIGN ID NUMBER 96V116000 (FUEL SYSTEM, GASOLINE:FUEL) . THE FAILURE AND CURRENT MILEAGES WERE 140,000.
NHTSA ODI #10291539
120,000 miles · Jun 5, 2008
Fuel System, Gasoline
FUEL SMELL WHEN TANK IS FULL. REMOVED ACCESS COVER FOR FUEL PUMP MODULE FOUND WELL FOR MODULE FILLED WITH DIRT OVER TOP OF MODULE. CLEAN OUT DIRT FOUND METAL RING TO HOLD MODULE IN ROTTED OFF TANK THERE WAS NOTHING HOLDING FUEL PUMP MODULE IN TANK IF CAR ROLLED OVER. FUEL CAN RUN OUT LOOKS LIKE A BAD HAZARD. *TR
NHTSA ODI #10230002
131,451 miles · Mar 10, 2008
Fuel System, Gasoline
TL*THE CONTACT OWNS A 1996 BUICK RIVIERA. THE CONTACT IS EXPERIENCING A FUEL AND A WATER LEAK. THE DEALER STATED THAT THE FUEL INJECTOR NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 150,000. UPDATED 04-08-08 *BF
NHTSA ODI #10220677
123,800 miles · Mar 7, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED THERE WAS AN ODOR OF FUEL IN THE VEHICLE. THE CONTACT TOOK THE SHROUD OFF OF THE ENGINE AND DETERMINED THE PLASTIC FUEL LINE HAD A HOLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE THE FUEL LINE WAS REPLACED WITH A HIGH PRESSURE HOSE. UPDATED 3/22/2006 - THE VEHICLE STALLED WHILE DRIV…
Read full complaint
DT*: THE CONTACT STATED THERE WAS AN ODOR OF FUEL IN THE VEHICLE. THE CONTACT TOOK THE SHROUD OFF OF THE ENGINE AND DETERMINED THE PLASTIC FUEL LINE HAD A HOLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE THE FUEL LINE WAS REPLACED WITH A HIGH PRESSURE HOSE. UPDATED 3/22/2006 - THE VEHICLE STALLED WHILE DRIVING AND THAT WHEN THE CONSUMER OPEN THE HOOD AND SAY THE MIST OF FUEL BEING SPRAYED ONTO THE HOT ENGINE. THE RUBBER FUEL LINE WAS REPLACED WITH A HIGH PRESSURE RUBBER LINE AT AND INDEPENDENT SHOP. *NM
NHTSA ODI #10152100
Mileage unknown · May 15, 1996
Fuel System, Gasoline
TOP OF THE GAS TANK SPLIT, RESULTING IN A LARGE GAS SPILL, ALMOST CAUSING A FIRE. *AK
A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
THESE VEHICLES WERE ASSEMBLED WITH A MALFUNCTION ALARM, LIGHTING AND LOCKING (MALL) MODULE THAT CAN CONTAIN A DAMAGED CAPACITOR. IF THE CAPACITOR IS DAMAGED, THE "KEY IN THE IGNITION" WARNING CHIME AND THE DRIVER SEAT BELT UNBUCKLED WARNING CHIME AND INDICATOR LAMP MAY NOT WORK. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION" AND FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." IN ADDITION, OTHER CHIME REMINDER FUNCTIONS, INTERIOR LIGHTING CONTROLS, AND POWER DOOR LOCKING FEATURES ARE ALSO AFFECTED.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE; THE DRIVER MAY NOT BE AWARE THAT THE KEY WAS LEFT IN THE IGNITION OR THAT THE SAFETY BELT WAS NOT BUCKLED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, REPLACE THE MALL MODULE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE99059 · Rear Seat Belt Retractor
Opened Sep 15, 1999 · Closed Feb 22, 2000
Status: closed (inferred from source dates) · Seat Belts:rear/other
COMPLAINTS GENERALLY STATED THAT ONE OR BOTH OUTBOARD REAR SEAT BELTS DO NOT RETRACT AT ALL AND ARE USELESS.IT IS EVIDENT THAT THE SEAT BELTS DO NOT PROVIDE ANY TENSION AND HAVE EXCESS SLACK.THE RETRACTOR ASSEMBLY HAS A PLASTIC COVER NEXT TO THE RETRACTOR RETURN SPRING.ACCORDING TO GENERAL MOTORS (GM), HEAT MAY SOFTEN, WARP AND DEFLECT THE PLASTIC SPRING COVER ALLOWING THE RETURN SPRING TO DISENGAGE THROUGH AND JAM IN THE SPRING COVER ACCESS HOLE RENDERING THE RETURN SPRING NONFUNCTIONAL.TO ELIMANATE THE PROBLEM, GM CHANGED THE SPRING COVER MATERIAL AND ACCESS HOLE AT THE BEGINNING OF PRODUCTION OF MODEL YEAR (MY) 1996 BUICK RIVIERA AND OLDSMOBILE AURORA VEHICLES.BOTH COMPLAINTS AND WARRANTY CLAIMS HAVE DECLINED SIGNIFICANTLY FROM MY 1995 SUBJECT VEHICLES TO MY 1996 VEHICLES.
1996 Buick Riviera Problems, Complaints & Recalls | Skip That Year
Illustration