IllustrationTHE WINDOW REGULATOR BROKE AND CAUSED THE WINDOW TO DROP INTO THE DOOR PANEL. THE REGULATOR, WINDOW CLIPS AND WINDOW REGULATOR MOTOR HAD TO BE REPLACED. BUICK REFUSED TO HONOR THE WARRANTY ON THESE PARTS. AS A RESULT, I PAID $200 FOR THE REPAIR. *TR
2002 Buick Rendezvous
Owner reports · Recalls · Investigations
More warning signs than most Rendezvous years
Owner complaints for the 2002 Buick Rendezvous are substantially higher than the model-year median of 138.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rendezvous years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
430–25K
6825–50K
9050–75K
7175–100K
75100–150K
31150K+
378 reports with mileage · 108 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports8 fire reports15 injury reports
What owners actually said
486 reportsTHE VEHICLE EXPERIENCED TOTAL ELECTRICAL FAILURE AND WOULD NOT START. THE CAR RADIO, DOOR LOCKS, AND INSTRUMENT PANEL WOULD REPEATEDLY LIGHT UP AND TURN OFF EVEN WITH THE KEY OUT OF THE IGNITION. THE BODY CONTROL MODULE HAD TO BE REPLACED. BUICK REFUSED TO HONOR THE WARRANTY ON THIS PART. AS A RESULT, I PAID $575 FOR THE REPAIR…
Read full complaint
THE VEHICLE EXPERIENCED TOTAL ELECTRICAL FAILURE AND WOULD NOT START. THE CAR RADIO, DOOR LOCKS, AND INSTRUMENT PANEL WOULD REPEATEDLY LIGHT UP AND TURN OFF EVEN WITH THE KEY OUT OF THE IGNITION. THE BODY CONTROL MODULE HAD TO BE REPLACED. BUICK REFUSED TO HONOR THE WARRANTY ON THIS PART. AS A RESULT, I PAID $575 FOR THE REPAIR. *TR
WATER PUMP FAILED AND CAUSE THE ENGINE TO OVERHEAT. BUICK REFUSED TO HONOR THE WARRANTY ON THIS PART. AS A RESULT, I PAID $575 FOR THE REPAIR. *TR
THE OIL PAN GASKET FAILED AND CAUSE AN OIL LEAK. BUICK FAILED TO HONOR THE WARRANTY ON THIS PART. AS A RESULT I PAID $670 TO REPAIR THE VEHICLE. *TR
ANTI-LOCK BRAKE SENSOR FAILED WHICH CAUSED EXCESSIVE MOVEMENT IN THE BRAKE PEDAL WHEN STOPPING. IN ADDITION, THIS SENSOR CAUSED THE TRACTION CONTROL SYSTEM TO DISENGAGE AND CREATED DIFFICULTY IN STOPPING THE VEHICLE. IN SOME INSTANCES THE BRAKE PEDAL WOULD DEPRESS ALL THE WAY TO THE FLOOR OF THE VEHICLE WHEN ATTEMPTING TO STOP. …
Read full complaint
ANTI-LOCK BRAKE SENSOR FAILED WHICH CAUSED EXCESSIVE MOVEMENT IN THE BRAKE PEDAL WHEN STOPPING. IN ADDITION, THIS SENSOR CAUSED THE TRACTION CONTROL SYSTEM TO DISENGAGE AND CREATED DIFFICULTY IN STOPPING THE VEHICLE. IN SOME INSTANCES THE BRAKE PEDAL WOULD DEPRESS ALL THE WAY TO THE FLOOR OF THE VEHICLE WHEN ATTEMPTING TO STOP. BUICK WOULD NOT HONOR THE WARRANTY ON THIS PART. AS A RESULT, I PAID $700 FOR THE REPAIR ON THIS PART. *TR
THE INTAKE MANIFOLD GASKET FAILED AND RESULTED IN COOLANT LEAKING AND THE ENGINE OVERHEATED ON MULTIPLE OCCASIONS. BUICK REFUSED TO HONOR THE WARRANTY FOR THE REPAIR TO THE INTAKE MANIFOLD GASKET. AS A RESULT, I PAID $950 FOR THE REPAIR TO THE VEHICLE. *TR
BOTH THE LEFT AND RIGHT AXLE BEARING AND HUB ASSEMBLY FAILED IN THE FIRST 10K MILES OF OWNERSHIP. BUICK REFUSED TO HONOR THE WARRANTY OF THESE PARTS. AS A RESULT, I PAID $1400 FOR THE REPAIR ON THESE PARTS. *TR
WE JUST BOUGHT A 2002 BUICK RENDEZVOUS. WE WERE FIRST TOLD THAT WE JUST NEEDED OUR FLUSHED. THE VEHICLE'S HOT COOLANT LIGHT WAS COMING ON AND THE TEMP GAUGE WAS INDICATING THAT THE VEHICLE WAS HOT. WE GOT THIS DONE AND WAS DRIVING IT HOME AND HAD THE SAME ISSUE. WE ARE NOW BEING TOLD THAT IT HAS A BLOWN HEAD GASKET. I DECIDED TO…
Read full complaint
WE JUST BOUGHT A 2002 BUICK RENDEZVOUS. WE WERE FIRST TOLD THAT WE JUST NEEDED OUR FLUSHED. THE VEHICLE'S HOT COOLANT LIGHT WAS COMING ON AND THE TEMP GAUGE WAS INDICATING THAT THE VEHICLE WAS HOT. WE GOT THIS DONE AND WAS DRIVING IT HOME AND HAD THE SAME ISSUE. WE ARE NOW BEING TOLD THAT IT HAS A BLOWN HEAD GASKET. I DECIDED TO RESEARCH ONLINE AND AM ASTOUNDED BY THE AMOUNT OF CONSUMERS THAT ARE HAVING THIS SAME ISSUE. SOME OF THEM ARE GETTING IT FIXED AND HAVING THE SAME ISSUE A FEW YEARS LATER. I AM REALLY FRUSTRATED AND FEEL THAT MY HANDS ARE TIED. WHAT IF I GET IT FIXED THIS TIME AND IN A FEW YEARS IT DOES IT AGAIN? I CAN NOT AFFORD TO KEEP PUTTING HUGE AMOUNTS OF MONEY INTO THIS VEHICLE. IF THIS IS SUCH A COMMON ISSUE WHY IS THERE NOT A RECALL? THIS IS NOT HOW GM SHOULD BE TREATING CONSUMERS. THEY NEED TO TAKE RESPONSIBILITY FOR A BAD PRODUCT. *TR
MY 2002 BUICK RENDEZVOUS HAD COMPLETE BRAKE FAILURE A FEW MONTHS AGO. LUCKILY I WAS ONLY TRAVELING ABOUT 10 MILES AN HOUR AND WAS WITHIN A MILE OF HOME. THE BRAKE LINE HAD RUSTED OUT. THIS CAR WAS STORED IN A GARAGE WHEN NOT DRIVEN AND HAS BEEN IN FLORIDA FOR TWO YEARS. THE BUICK DEALERSHIP IMPLIED THAT THIS IS JUST COMMON…
Read full complaint
MY 2002 BUICK RENDEZVOUS HAD COMPLETE BRAKE FAILURE A FEW MONTHS AGO. LUCKILY I WAS ONLY TRAVELING ABOUT 10 MILES AN HOUR AND WAS WITHIN A MILE OF HOME. THE BRAKE LINE HAD RUSTED OUT. THIS CAR WAS STORED IN A GARAGE WHEN NOT DRIVEN AND HAS BEEN IN FLORIDA FOR TWO YEARS. THE BUICK DEALERSHIP IMPLIED THAT THIS IS JUST COMMON WEAR AND TEAR. THERE WAS NO WARNING, AND NO REPAIR SHOP THAT DID WORK ON THE CAR EVER INDICATED THIS RUSTING OF THE BRAKE LINE WAS HAPPENING. CAR HAD ABOUT 100,000 MILES ON IT. I HAVE ALSO BEEN THROUGH THREE CONTROL MODULES, LUCKILY COVERED UNDER WARRANTY. ALSO, BECAUSE I GOT AN EXTENDED WARRANTY AT TIME OF PURCHASE, THE AIR CONDITIONING, THE HEAD GASKET AND VARIOUS OTHER PROBLEMS WERE COVERED. THIS 2002 MODEL DEFINITELY HAS SOME SPECIFIC AND EXPENSIVE AND DANGEROUS PROBLEMS. LATELY, IT'S CALMED DOWN. GREAT CAR FOR COMFORT, AND ROOMY FOR CARRYING HOUSEHOLD ITEMS. TOO BAD TOYOTA DIDN'T MAKE IT. *TR
WE PURCHASED THIS VEHICLE USED IN 2004, AND OVER THE PAST YEARS WE HAVE HAD TO REPLACE THE FOLLOWING: BOTH FRONT HUB ASSEMBLIES (WITH SPEED SENSORS), INTAKE MANIFOLD GASKET AND THE AIR CONDITIONER CONDENSER (ONE YEAR AGO). JUST WITHIN THE LAST 2 MONTHS WE HAVE HAD TO REPLACE THE FOLLOWING: TIE-ROD, RADIATOR, WATER PUMP, THERMOST…
Read full complaint
WE PURCHASED THIS VEHICLE USED IN 2004, AND OVER THE PAST YEARS WE HAVE HAD TO REPLACE THE FOLLOWING: BOTH FRONT HUB ASSEMBLIES (WITH SPEED SENSORS), INTAKE MANIFOLD GASKET AND THE AIR CONDITIONER CONDENSER (ONE YEAR AGO). JUST WITHIN THE LAST 2 MONTHS WE HAVE HAD TO REPLACE THE FOLLOWING: TIE-ROD, RADIATOR, WATER PUMP, THERMOSTAT, HEAD GASKET, AND THE INTAKE MANIFOLD GASKET AGAIN. THE VEHICLE ONLY HAS 86,000 MILES ON IT TO DATE. THE ONLY THING THAT WE HAD THE BUICK DEALER WORK ON WAS THE FRONT HUB ASSEMBLIES, THE REST OF THE WORK WAS PERFORMED BY TIRE DEALERSHIP, RADIATOR SHOP, AND AN AUTOMOTIVE REPAIR GARAGE. NOW, THE ABS LIGHT IS ON AGAIN MEANING THAT ONE OF THE FRONT HUB ASSEMBLIES ARE OUT (REPLACED BY BUICK THEMSELVES) AND OUR ANTI-LOCK BRAKES ARE NOT WORKING. AND, ALSO, THE AIR-BAG WARNING LIGHT IS ON. I HAVE NOTICED QUITE A LONG LIST OF COMPLAINTS OVER THE INTERNET CONCERNING ALL THE ABOVE PROBLEMS OTHERS HAVE HAD AS WELL WITH THIS MODEL BUICK WHICH LEADS ME TO BELIEVE THAT IT HAS BEEN AN ON-GOING PROBLEM OF WHICH BUICK WILL NOT DEAL WITH NOR STEP UP TO THEIR RESPONSIBILITY. I HAVE BEEN TOLD BY AUTO-REPAIRMEN THAT THEY HAVE HAD NUMEROUS CUSTOMERS COME IN WITH PROBLEMS WITH THE 3400 MODEL ENGINE. I HAVE CONTACTED BUICK CONCERNING THE AIR-BAG PROBLEM, AND THEY ACT AS THOUGH THEY HAVE NEVER HEARD OF ANY PROBLEMS AND DENY ANY RESPONSIBILITY TO LOOK INTO IT, EVEN THOUGH THEY HAVE ISSUED A RECALL ON THE AIR BAG INFLATOR FOR THIS YEAR, MAKE, AND MODEL, JUST NOT FOR MY VIN#. OVER THE YEARS THAT WE HAVE OWNED THIS VEHICLE WE HAVE INVESTED QUITE A SUM OF MONEY INTO REPAIRS ON THIS VEHICLE, AND IT HAS NEVER BEEN IN AN ACCIDENT! I BELIEVE THAT WITH ALL THE NHTSA SAFETY COMPLAINTS CONCERNING THE AIR BAGS SYSTEM, BUICK SHOULD BE HELD RESPONSIBLE! ALL THE OTHER UNIQUE PROBLEMS WITH THIS ENGINE HAVE BEEN REPAIRED BY US, AND IS TOO LATE TO EXPECT ANY HELP
Official recalls
207V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.