IllustrationGENERAL MOTORS 3.4 LITER ENGINE FAILURE AT 83,000 MILES. FRONT HUB ASSEMBLY FAILURE DRIVER AND PASSENGER SIDE. *TR
2002 Buick Rendezvous
Owner reports · Recalls · Investigations
More warning signs than most Rendezvous years
Owner complaints for the 2002 Buick Rendezvous are substantially higher than the model-year median of 138.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rendezvous years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
430–25K
6825–50K
9050–75K
7175–100K
75100–150K
31150K+
378 reports with mileage · 108 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports8 fire reports15 injury reports
Suspension complaints
45 reportsAIR CONDITIONER WENT OUT AT 41,000 MILES---CAN'T AFFORD TO REPLACE FRONT WHEEL-BEARING WENT OUT AT 80,000---CAN'T AFFORD TO REPLACE INTAKE GASKET BLOWN AT 89,000---CAN'T AFFORD TO REPLACE. *TR
BUICK RENDEZVOUS 2002 FAILURE WITH BLOWN TRANSFER CASE & TRANSMISSION, MAIN EXHAUST PIPE LOOSE FROM HEAD, REAR END NOISE, PASSENGER DOOR STICKS. *TR
BEARINGS AND SENSOR ON ANTI LOCK WENT OUT. CAR STOPPING, LOCKING UP, NOT RE-STARTING. *TR
WHEEL BEARINGS NEED REPLACEMENT. FUEL PUMP WAS BAD. REPLACED TIRES AND BRAKES 3 TIMES SINCE I HAV E OWNED THE VEHICLE 2 YEARS. INTAKE MANIFOLD WAS LEAKING, CAUSING THE CAR TO BE SLUGGISH AND NOT START SOMETIMES. ABS LIGHTS CAME ON FREQUENTLY. THE CAR WAS A BIG NIGHTMARE. WISH I NEVER WOULD OF BOUGHT A BUICK RENDEZVOUS. …
Read full complaint
WHEEL BEARINGS NEED REPLACEMENT. FUEL PUMP WAS BAD. REPLACED TIRES AND BRAKES 3 TIMES SINCE I HAV E OWNED THE VEHICLE 2 YEARS. INTAKE MANIFOLD WAS LEAKING, CAUSING THE CAR TO BE SLUGGISH AND NOT START SOMETIMES. ABS LIGHTS CAME ON FREQUENTLY. THE CAR WAS A BIG NIGHTMARE. WISH I NEVER WOULD OF BOUGHT A BUICK RENDEZVOUS. *AK
I PURCHASED MY 2002 BUICK RENDEZVOUS CXL IN EARLY 2003. BY 2004 I HAD TO HAVE THE A/C CONDENSER REPLACED, THE SHOCKS & STRUTS REPLACED AND NUMEROUS PROBLEMS WITH THE A/C. THEN IN SUMMER OF 2006 THE CAR ENGINE STARTED MISFIRING AND THE CAR STALLED OUT WITH SMOKE COMING OUT OF THE HOOD, ETC. HAD IT TOWED TO BUICK, THEY SAID THE E…
Read full complaint
I PURCHASED MY 2002 BUICK RENDEZVOUS CXL IN EARLY 2003. BY 2004 I HAD TO HAVE THE A/C CONDENSER REPLACED, THE SHOCKS & STRUTS REPLACED AND NUMEROUS PROBLEMS WITH THE A/C. THEN IN SUMMER OF 2006 THE CAR ENGINE STARTED MISFIRING AND THE CAR STALLED OUT WITH SMOKE COMING OUT OF THE HOOD, ETC. HAD IT TOWED TO BUICK, THEY SAID THE ENGINE HAD A LEAK SOMEWHERE AND WATER LEAKED INTO THE OIL...HUH? ANYWAY, OF COURSE EVEN THOUGH I HAD THE EXTENDED WARRANTY, I WAS JUST OUT OF WARRANTY AND THEY REFUSED TO FIX IT. THE OPTION WAS TO REPLACE THE ENGINE FOR $6,000. THIS VEHICLE WAS ALREADY PAID OFF AND WORTH ABOUT $14K PRIOR TO THE ENGINE BLOWING UP. I ENDED UP SELLING IT FOR $3K. IS THIS NORMAL? I THINK NOT. I SUBMITTED MY CASE TO SEVERAL "LAWYER" CLAIMING TO SPECIALIZE IN THIS TYPE OF RIP OFF ACTIVITY BY CAR MANUFACTURERS BUT THEY SAID IT WASN'T WORTH IT TO THEM TO PURSUE IT. MAYBE IF SOMEONE HAD DIED IT WOULD BE WORTH MORE. I WOULD LIKE TO SEE BUICK AT LEAST ADMIT POOR MANUFACTURING AND REFUND ME SOME OF MY MONEY. I TOOK A LOSS OF $11K ON THIS VEHICLE. *JB
THREE SAFETY RELATED ISSUES WITH MY 2002 BUICK RENDEZVOUS CXL. THE ABS SENSORS FAILED WHICH WAS A DIFFICULT PROBLEM TO DIAGNOSE AS THE PROBLEM WAS ACTUALLY CAUSED BY WATER IN THE INSULATION TO THE SENSOR WIRING HARNESSES. I'M NOW BEING NOTIFIED OF A FRONT WHEEL BEARING PROBLEM THAT HAS NOT YET REACHED A FORMAL RECALL. SECOND …
Read full complaint
THREE SAFETY RELATED ISSUES WITH MY 2002 BUICK RENDEZVOUS CXL. THE ABS SENSORS FAILED WHICH WAS A DIFFICULT PROBLEM TO DIAGNOSE AS THE PROBLEM WAS ACTUALLY CAUSED BY WATER IN THE INSULATION TO THE SENSOR WIRING HARNESSES. I'M NOW BEING NOTIFIED OF A FRONT WHEEL BEARING PROBLEM THAT HAS NOT YET REACHED A FORMAL RECALL. SECOND ISSUE INVOLVES THE AWD REAR AXLE ASSEMBLY (DIFFERENTIAL). MOANING NOISES START IN THE REAR END, IN LOW SPEED TURNS SUCH AS PARKING LOT MANEUVERS. OCCURRENCE INCREASES IN SEVERITY AND FREQUENCY FAIRLY QUICKLY. THE REAR AXLE IS TO BE REPLACED BY THE DEALER UNDER MY EXTENDED WARRANTY. BUT I NOTICE THAT THIS IS NOT A RANDOM OR UNUSUAL PROBLEM WITH THIS YEAR/MODEL BUICK. I WOULD THINK THAT BOTH OF THESE ISSUES DUE TO THEIR RATE OF OCCURRENCE WOULD TRIGGER A FORMAL RECALL. WHY DOES THE REAR DRIVE AXLE CONTINUE TO FAIL? IF IT SHOULD FAIL CATASTROPHICALLY, WILL IT POSE A SAFETY ISSUE, ESPECIALLY IF HIGHWAY SPEEDS ARE INVOLVED AND THE VEHICLE BECOMES UNSTABLE? *NM
I HAVE HAD NOTHING BUT TROUBLE WITH THIS VEHICLE. I TOOK IT INTO THE DEALER THE OTHER DAY TO HAVE THE FRONT WHEEL BEARING REPLACE (PAID FOR BY GM) AND IN THE PROCESS, THE MECHANIC FOUND ANOTHER SERIOUS PROBLEM. I HAD BEEN HEARING A BANGING NOISE COMING FROM THE REAR END FOR A FEW MONTHS NOW. I JACKED THE REAR END OF THE CAR…
Read full complaint
I HAVE HAD NOTHING BUT TROUBLE WITH THIS VEHICLE. I TOOK IT INTO THE DEALER THE OTHER DAY TO HAVE THE FRONT WHEEL BEARING REPLACE (PAID FOR BY GM) AND IN THE PROCESS, THE MECHANIC FOUND ANOTHER SERIOUS PROBLEM. I HAD BEEN HEARING A BANGING NOISE COMING FROM THE REAR END FOR A FEW MONTHS NOW. I JACKED THE REAR END OF THE CAR UP AND COULDN'T FIND THE SOURCE OF THE NOISE. I WAS TOLD BY THE MECHANIC THAT IT IS THE RIGHT REAR KNUCKLE THAT WAS MAKING THE NOISE. WHEN THEY GOT IT ON THE RACK, THEY FOUND THAT THE TIRE IS MOVING FRONT TO BACK ABOUT 2 INCHES. I WAS TOLD THAT THIS IS A SERIOUS SAFETY ISSUE AND THAT I WILL NEED TO GET IT FIXED ASAP AT A COST OF ABOUT $750. I TOOK MY VEHICLE TO ANOTHER MECHANIC TO GET A SECOND OPINION. I GOT THE SAME DIAGNOSIS FROM THE SECOND MECHANIC WITH THE ADDITION OF "WE'VE NEVER SEEN ONE OF THESE GO BAD. YOU SHOULD NEVER HAVE TO REPLACE THIS PART" THEY WENT ON TO SAY THAT THEY DIDN'T WANT TO DO THIS WORK BECAUSE IT IS EXTREMELY LABOR INTENSIVE AND NOT THEIR SPECIALTY. I AM GOING TO TAKE IT TO A FRAME SPECIALIST AND HAVE THE WORK DONE THERE. DID I MENTION THAT I HAD TO REPLACE THE BODY CONTROL MODULE TWO WEEKS AGO?. *JB
DT*: THE CONTACT STATED THE VEHICLE'S FRONT WHEEL BEARINGS WENT BAD. THE WHEEL BEARINGS MADE A LOUD SOUND AND WERE REPLACED. THE REPLACEMENT WHEEL BEARINGS WERE ALSO DEFECTIVE AND HAD TO BE REPLACED.
I OWN A 2002 BUICK RENDEZVOUS. THIS VEHICLE HAS BEEN NOTHING BUT TROUBLE FOR ME SINCE THE GET GO (2004). I HAVE NUMEROUS AMOUNT OF PROBLEMS THAT ARE GOING ON WITH MY VEHICLE AS OTHER OWNERS. ALL OF THESE PROBLEMS STARTED AT OR AROUND 70000 MILES. THE EXTERIOR LIGHTS AND INTERIOR LIGHTS GO OFF WITH OUT WARNING AND FOR NO REAS…
Read full complaint
I OWN A 2002 BUICK RENDEZVOUS. THIS VEHICLE HAS BEEN NOTHING BUT TROUBLE FOR ME SINCE THE GET GO (2004). I HAVE NUMEROUS AMOUNT OF PROBLEMS THAT ARE GOING ON WITH MY VEHICLE AS OTHER OWNERS. ALL OF THESE PROBLEMS STARTED AT OR AROUND 70000 MILES. THE EXTERIOR LIGHTS AND INTERIOR LIGHTS GO OFF WITH OUT WARNING AND FOR NO REASON FOR SOMETIMES UP TO A MINUTE (AND THIS HAS HAPPENED AT NIGHTIME) "MAJOR SAFTEY ISSUE" NO ONE CAN TELL US WHY THE VEHICLE DOES THIS. THE NOISE THAT COMES FROM THE FRONT OF THE VEHICLE WHEN DRIVEN AT 45 MPH OR MORE IS OUTRAGIOUS...IT MAKES AN AWFUL HUMMING SOUND SO LOUD THAT THE RADIO CAN'T BE HEARD. THE VEHICLE ALSO WILL NOT START AT TIMES AS WELL...FOR NO PARTICULAR REASON AT ALL...NOTHING CAN BE FOUND WRONG WITH IT ALL!!! IT WILL STALL OR WILL NOT START AT ALL AFTER SEVERAL STARTS AND TURN OFFS. IT HAS ALSO DONE THIS ON INCLINES OR AFTER FILLING AT THE GAS STATION ONCE AS WELL. IF YOU GO BACK AND TRY TO START THE VEHICLE IN ABOUT A HALF HOUR IT WILL START...I FIGURED THIS OUT AFTER CALLING A TOW TRUCK SEVERAL TIMES...AND BY THE TIME THEY GOT TO ME..THEY TRIED TO START THE VEHICLE AND IT STARTED. THE VEHICLE BURNS A QURT OF OIL EVERY 3000 MILES OR SO. NOW MY BRAKES ARE TO THE FLOOR WHICH I HAVE RECENTLY HAD IT TO THE SHOP AGAIN AND THE MECHANIC HAS TOLD ME THAT MY BRAKES ARE FINE THAT I NEED MY ABS PUMP (MASTER CYLINDER) REPLACED IT IS LEAKING 800.00 +++ JUST FOR THE PART ALONE HMMMMM??? JUST ANOTHER ISSUE REPORTED LIKE ALL THE ABOVE FROM OTHER BUICK RENDEZVOUS 2002 OWNERS. OH AND ALSO MY DRIVER SIDE WINDOW REGULATOR HAS BROKE AND THAT WILL BE COSTING ME 450.00. PASSENGER SIDE DOOR DOES NOT SHUT CORRECTLY NOW AT ALL THE HINGES ARE MESSED UP ON THESE MODELS. THE DOOR GETS STUCK ALL THE TIME. ALL OF THESE PROBLEMS ARE PROBLEMS THAT OTHER BUICK RENDEZVOUS OWNERS OF THE 2002 MODELS ARE HAVING AND SOMETHING NEEDS TO BE DONE ABOUT IT ASAP. *JB
Official recalls
207V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.