NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
34 reportsClear category filter30,000 miles · Aug 8, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT RECEIVED BUICK RECALL NOTICE NUMBER 07035 OR NHTSA CAMPAIGN ID NUMBER 08V118000 REGARDING THE GASKET ON HIS VEHICLE. HE TOOK THE VEHICLE TO THE DEALER AND THEY REPAIRED THE FIRST GASKET. THE CONTACT STATED THAT THE SECOND GASKET IS EXPERIENCING THE SAME FAILURE; HOWEVER, THE…
Read full complaint
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT RECEIVED BUICK RECALL NOTICE NUMBER 07035 OR NHTSA CAMPAIGN ID NUMBER 08V118000 REGARDING THE GASKET ON HIS VEHICLE. HE TOOK THE VEHICLE TO THE DEALER AND THEY REPAIRED THE FIRST GASKET. THE CONTACT STATED THAT THE SECOND GASKET IS EXPERIENCING THE SAME FAILURE; HOWEVER, THE DEALER DOES NOT WANT TO MAKE THE REPAIR. HE CALLED GM TO FILE A COMPLAINT AND THEY REFERRED HIM TO NHTSA. CURRENTLY, THE GASKET IS LEAKING AND DRIPPING DOWN ONTO THE EXHAUST MANIFOLD. THE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #10237501
78,892 miles · Apr 24, 2008
Engine And Engine Cooling
DEALER SAYS LOWER INTAKE MANIFOLD LEAKING. REPAIRED AT 61,549 MI. DEALER SAYS LOWER INTAKE COOLANT BYPASS IS LEAKING, AS IS, THE VALVE COVER GASKETS. CLAIMS THERE HAVE BEEN ENGINE FIRES AND THAT GM HAS A RECALL ,BUT NOT A REMEDY FOR THE PROBLEM, AS OF YET. REPAIRED GASKETS AT 78,892 MI., TOTAL COST FOR BOTH 1,600.00. 1. ONE WOU…
Read full complaint
DEALER SAYS LOWER INTAKE MANIFOLD LEAKING. REPAIRED AT 61,549 MI. DEALER SAYS LOWER INTAKE COOLANT BYPASS IS LEAKING, AS IS, THE VALVE COVER GASKETS. CLAIMS THERE HAVE BEEN ENGINE FIRES AND THAT GM HAS A RECALL ,BUT NOT A REMEDY FOR THE PROBLEM, AS OF YET. REPAIRED GASKETS AT 78,892 MI., TOTAL COST FOR BOTH 1,600.00. 1. ONE WOULD THINK AFTER BUILDING CARS FOR 50 YRS. THAT A HEAD GASKET COULD LAST 200,000 MI. 2. MY GASKET LASTED 17,000 MILES BETWEEN REPAIRS. THE LEAKING GASKETS ARE A DIRECT CAUSE OF THE ENGINE FIRES. THE OIL LEAKS DOWN ON TOP OF THE EXHAUST MANIFOLD AND BINGO, "FIRE". THEY SAY THEY HAVE TO COME UP WITH A BETTER HEAT SHIELD "DUH". I BOUGHT THE CAR BASED ON CONSUMER REPORTS. I'VE HAD OTHER PROBLEMS TOO. I JUST WONDER IF GM WILL STEP UP AND REIMBURSE ME. *TR
NHTSA ODI #10225595
65,870 miles · Apr 17, 2008
Engine And Engine CoolingFire
DRIVING THE CAR TO THE SHOPPING MALL THERE WAS NOTHING OUT OF THE ORDINARY, NO SMELL, NO NOISE. ABOUT 15 MINUTES LATER I REMEMBERED I FORGOT SOMETHING IN THE CAR AND WENT OUT TO RETRIEVE IT WHEN I SAW FIRE TRUCKS. THERE WERE FLAMES SHOOTING OUT 10 FEET HIGH OF A CAR, THINKING POOR FOOL, THEN REALIZING THAT FOOL WAS ME! IT WAS M…
Read full complaint
DRIVING THE CAR TO THE SHOPPING MALL THERE WAS NOTHING OUT OF THE ORDINARY, NO SMELL, NO NOISE. ABOUT 15 MINUTES LATER I REMEMBERED I FORGOT SOMETHING IN THE CAR AND WENT OUT TO RETRIEVE IT WHEN I SAW FIRE TRUCKS. THERE WERE FLAMES SHOOTING OUT 10 FEET HIGH OF A CAR, THINKING POOR FOOL, THEN REALIZING THAT FOOL WAS ME! IT WAS MY 2001 REGAL. THE CAR WAS TORCHED TO THE INSIDE DASH BOARD. WITNESSES STATED SPARKS WERE COMING FROM UNDER THE FRONT LEFT, WHEN IT BURST INTO FLAMES. NEEDLESS TO SAY THE CAR IS TOAST. NEVER, EVER ANY WARNING, NO DASH LIGHTS INDICATING A PROBLEM, AND IT ONLY HAD 65K MILES ON IT. MY SON HAS A 92 TOYOTA WITH OVER 200K, BET THAT WON'T EVER CATCH FIRE! *TR
NHTSA ODI #10224787
118,357 miles · Mar 13, 2008
Engine And Engine Cooling
MY WIFE WENT OUT TO START THE VEHICLE AFTER IT HAD BEEN SITTING FOR 2-3 DAYS IN 0-20 DEGREE TEMPERATURES. UPON TURNING THE IGNITION SWITCH SHE HEARD A LOUD EXPLOSION SOUND, SAW THE HOOD BULGE, AND SAW SMOKE BILLOW OUT FROM THE SIDES. SHE IMMEDIATELY REMOVED KEY, EXITED THE VEHICLE, AND ASKED ME TO COME OUT TO THE VEHICLE. UPON O…
Read full complaint
MY WIFE WENT OUT TO START THE VEHICLE AFTER IT HAD BEEN SITTING FOR 2-3 DAYS IN 0-20 DEGREE TEMPERATURES. UPON TURNING THE IGNITION SWITCH SHE HEARD A LOUD EXPLOSION SOUND, SAW THE HOOD BULGE, AND SAW SMOKE BILLOW OUT FROM THE SIDES. SHE IMMEDIATELY REMOVED KEY, EXITED THE VEHICLE, AND ASKED ME TO COME OUT TO THE VEHICLE. UPON OPENING THE HOOD WE FOUND PIECES OF THE HEAT SHIELD, AND PLASTIC INTAKE MANIFOLD SCATTERED THROUGH THE ENGINE COMPARTMENT, ALONG WITH THE OIL FILL CAP, WHICH HAD BEEN BLOWN OFF. *TR
NHTSA ODI #10221055
225,000 miles · Jan 4, 2008
Engine And Engine CoolingFire
VEHICLE HAS A 3.8 LITER SUPER CHARGED ENGINE. PARKED CAR AFTER DRIVING APPROXIMATELY 70 MILES WITH NO NOTICEABLE PROBLEM. ABOUT FIFTEEN MINUTES LATER, I SAW SMOKE COMING FROM UNDER THE HOOD. THE ENGINE COMPARTMENT WAS ENGULFED. THE VEHICLE IS A TOTAL LOSS. THE CAR WAS NOT RUNNING AND THEIR WAS NO INDICATION OF SMOKE/FIRE…
Read full complaint
VEHICLE HAS A 3.8 LITER SUPER CHARGED ENGINE. PARKED CAR AFTER DRIVING APPROXIMATELY 70 MILES WITH NO NOTICEABLE PROBLEM. ABOUT FIFTEEN MINUTES LATER, I SAW SMOKE COMING FROM UNDER THE HOOD. THE ENGINE COMPARTMENT WAS ENGULFED. THE VEHICLE IS A TOTAL LOSS. THE CAR WAS NOT RUNNING AND THEIR WAS NO INDICATION OF SMOKE/FIRE WHEN I TURNED IT OFF. *CN
NHTSA ODI #10213722
Mileage unknown · May 3, 2007
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT STATED THAT THE ENGINE FAILED WHEN ACTIVATING THE TURN SIGNALS AND SLOWING DOWN TO MAKE A TURN. THE VEHICLE WILL RESTART AFTER A FEW MINUTES HAVE PASSED. THE FAILURE BEGAN IN APRIL 2007 , AND WAS NOW OCCURRING MORE FREQUENTLY. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN…
Read full complaint
TL*THE CONTACT OWNS A 2001 BUICK REGAL. THE CONTACT STATED THAT THE ENGINE FAILED WHEN ACTIVATING THE TURN SIGNALS AND SLOWING DOWN TO MAKE A TURN. THE VEHICLE WILL RESTART AFTER A FEW MINUTES HAVE PASSED. THE FAILURE BEGAN IN APRIL 2007 , AND WAS NOW OCCURRING MORE FREQUENTLY. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN. *AK
NHTSA ODI #10189625
84,000 miles · Feb 1, 2007
Engine And Engine CoolingService Brakes, HydraulicSuspension
AT ABOUT 80,000 MILES GRINDING NOISE IN RIGHT FRONT WHEEL DEVELOPED, REPLACED BRAKES AND ROTORS FOUND THE RIGHT FRONT WHEEL BEARING WAS BAD AND HAD TO HAVE IT REPLACED . AT ABOUT 84,000 MILES THE LIFTERS WERE MAKING A TICKING NOISE THAT SOUNDED LIKE A HELICOPTER, REPLACED THE LIFTERS AT A COST OF $1600 THIS WAS JUST ONE MONTH A…
Read full complaint
AT ABOUT 80,000 MILES GRINDING NOISE IN RIGHT FRONT WHEEL DEVELOPED, REPLACED BRAKES AND ROTORS FOUND THE RIGHT FRONT WHEEL BEARING WAS BAD AND HAD TO HAVE IT REPLACED . AT ABOUT 84,000 MILES THE LIFTERS WERE MAKING A TICKING NOISE THAT SOUNDED LIKE A HELICOPTER, REPLACED THE LIFTERS AT A COST OF $1600 THIS WAS JUST ONE MONTH AFTER THE FINAL PAYMENT OF THE 5 YEAR LOAN ONE MONTH AFTER THE LIFTERS WERE REPLACED THE ENGINE SEIZED UP NEEDED TO BE TOWED AND I'M TOLD THAT THE MAIN BEARING HAS GONE BAD AND THE ENGINE NEEDS TO BE REPLACED OR REBUILT. *NM
NHTSA ODI #10181358
76,000 miles · Sep 22, 2005
Electrical SystemEngine And Engine Cooling
2001 BUICK REGAL LS. I LOST ALL VACUUM TO BRAKES AND STEERING. ENGINE DIED. TOOK IT TO C_SPECK MOTORS IN SUNNYSIDE, WA FOR INVESTIGATION. THEY FOUND THAT THE INTAKE COVER, WHICH IS EITHER PLASTIC OR FIBERGLASS HAD A HOLE ABOUT 1 1/2 INCH IN DIAMETER BURNT THROUGH JUST BEHIND THE AIR INTAKE HOSE. ON TOP OF THE HOLE IS A WIRING H…
Read full complaint
2001 BUICK REGAL LS. I LOST ALL VACUUM TO BRAKES AND STEERING. ENGINE DIED. TOOK IT TO C_SPECK MOTORS IN SUNNYSIDE, WA FOR INVESTIGATION. THEY FOUND THAT THE INTAKE COVER, WHICH IS EITHER PLASTIC OR FIBERGLASS HAD A HOLE ABOUT 1 1/2 INCH IN DIAMETER BURNT THROUGH JUST BEHIND THE AIR INTAKE HOSE. ON TOP OF THE HOLE IS A WIRING HARNESS THAT HAS THE FLEX BURNT THROUGH AND THE WIRING HARNESS TAPE IS BURNT THROUGH. WIRES APPEAR TO BE OK. IT COULD HAVE CAUSED AN ACCIDENT AND OR CAUGHT FIRE.*JB
NHTSA ODI #10137266
43,000 miles · Sep 6, 2005
Engine And Engine CoolingFire
I RETURNED HOME FROM A SHORT TRIP TO THE STORE ON 9/3/05, TURNED OFF THE CAR, AND PARKED MY 2001 BUICK REGAL GS IN THE DRIVEWAY. ABOUT 5-10 MINUTES LATER, MY HUSBAND SAID HE SMELLED SOMETHING BURNING. HE LOOKED OUT THE FRONT DOOR, AND SMOKE AND FLAMES WERE COMING FROM UNDER THE HOOD OF THE CAR. I CALLED 911, AND MY HUSBAND AT…
Read full complaint
I RETURNED HOME FROM A SHORT TRIP TO THE STORE ON 9/3/05, TURNED OFF THE CAR, AND PARKED MY 2001 BUICK REGAL GS IN THE DRIVEWAY. ABOUT 5-10 MINUTES LATER, MY HUSBAND SAID HE SMELLED SOMETHING BURNING. HE LOOKED OUT THE FRONT DOOR, AND SMOKE AND FLAMES WERE COMING FROM UNDER THE HOOD OF THE CAR. I CALLED 911, AND MY HUSBAND ATTEMPTED TO CONTAIN THE FLAMES UNTIL THE FIRE DEPARTMENT ARRIVED. THE ENGINE TRIED TO START, ON ITS OWN, WHILE IT WAS BURNING. THE CAR RADIO CAME ON. THE ENGINE WAS ENGULFED IN FLAMES WHEN THE FIRE DEPARTMENT ARRIVED. THE CAR APPEARS TO BE A TOTAL LOSS. IN ADDITION, THE HEAT FROM THE FLAMES MELTED THE VINYL SIDING ON MY HOUSE, INASMUCH AS THE CAR WAS PARKED IN FRONT OF THE GARAGE NEXT TO THE HOUSE. *NM
NHTSA ODI #10135483
Mileage unknown · May 16, 2005
Engine And Engine CoolingVehicle Speed Control
2001 BUICK REGAL EXPERIENCED STALLING . *MR THE VEHICLE ALSO EXPERIENCED SUDDEN ACCELERATION. THE SERVICE DEALER WAS UNABLE TO FIND THE PROBLEM. *SC *JB
NHTSA ODI #10121526
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Apr 6, 2001
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH SUNVISOR LOCATED AIR BAG LABELS, FAIL TO CONFORM TO FEDERAL MOTOR VEHICLES SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE A MESSAGE AREA LESS THAN 30 CM WHICH DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.
Remedy: GM WILL MAIL A NEW BILINGUAL AIR BAG LABEL WITH INSTALLATION INSTRUCTIONS. HOWEVER, THE CUSTOMER MAY BRING THE LABEL TO THEIR DEALER FOR INSTALLATION FREE OF CHARGE. OWNER NOTIFICATION BEGAN MAY 4, 2001. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT OLDSMOBILE AT 1-800-442-6537 OR BUICK AT 1-800-521-7300.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration