NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
184 reports130,000 miles · Oct 30, 2009
Electrical SystemWheels
TL* THE CONTACT OWNS A 2000 BUICK REGAL. WHILE ATTEMPTING TO ACCELERATE AT 70 MPH THE SPEED WOULD NOT INCREASED. NEXT THE VEHICLE BEGAN TO LOOSE POWER.. THE VEHICLE HAS NOT BEEN INSPECTED BY A DEALER. THE CURRENT AND FAILURE MILEAGES WERE 130000. UPDATED 12/07/09 *BF THE CONSUMER STATED WHEN SHE TURNED ON HER TURN SIGNAL …
Read full complaint
TL* THE CONTACT OWNS A 2000 BUICK REGAL. WHILE ATTEMPTING TO ACCELERATE AT 70 MPH THE SPEED WOULD NOT INCREASED. NEXT THE VEHICLE BEGAN TO LOOSE POWER.. THE VEHICLE HAS NOT BEEN INSPECTED BY A DEALER. THE CURRENT AND FAILURE MILEAGES WERE 130000. UPDATED 12/07/09 *BF THE CONSUMER STATED WHEN SHE TURNED ON HER TURN SIGNAL TO PASS ANOTHER VEHICLE, ALL THE LIGHTS ON THE DASH STARTED FLASHING AND THE VEHICLE STARTED TO LOOSE POWER. THE CONSUMER GOT OFF AT THE NEXT EXIT AND WHEN SHE MADE A TURN, THE VEHICLE CUT OFF. ALSO EVERY MONTH THE LOW PRESSURE TIRE LIGHT ILLUMINATED. ONE OF THE TIRES WAS EXTREMELY LOW. THE CONSUMER WAS INFORMED THE REASON THE TIRE WAS LOOSING AIR WAS BECAUSE OF THE RIMS. UPDATED 12/09/09.
NHTSA ODI #10290368
137,000 miles · Oct 16, 2009
Electrical System
I WAS DRIVING ON THE HIGHWAY AND TURNED MY BLINKER ON TO PASS A VEHICLE WHEN THE CAR SHUT THE POWER OFF AND ON TO THE GAS.WHILE I DID THAT THE ALL THE LIGHTS ON MY DASH WERE BLINKING WHEN I TURNED BACK IN TO THE OTHER LANE I HAD TURNED MY BLINKER BACK ON. STARTED DOING IT AGAIN. I GOT TO AN EXIT TO TURN AROUND TO GO HOME SO I TU…
Read full complaint
I WAS DRIVING ON THE HIGHWAY AND TURNED MY BLINKER ON TO PASS A VEHICLE WHEN THE CAR SHUT THE POWER OFF AND ON TO THE GAS.WHILE I DID THAT THE ALL THE LIGHTS ON MY DASH WERE BLINKING WHEN I TURNED BACK IN TO THE OTHER LANE I HAD TURNED MY BLINKER BACK ON. STARTED DOING IT AGAIN. I GOT TO AN EXIT TO TURN AROUND TO GO HOME SO I TURNED MY BLINKER BACK ON AND THE CAR SHUT DOWN ON MY WHILE I WAS TURNING A SHARPE CORNER. SO I HAD NO POWER STEERING. I STARTED IT BACK UP BUT WHEN I GOT DOWN THE ROAD I HAD TO TURN AGAIN SO I TURNED MY BLINKER ON AND IT HAD DID IT AGAIN. I NOTICED I HAD TO TURN MY HAZARDS ON TO GET HOME, AND WHEN I DID THAT THEY LIGHTS DIDN'T BLINK ON THE DASH. I MADE IT HOME AND CHECKED ALL THE FUSES BUT THAT WASN'T THE PROBLEM. I CAN'T START MY CAR NOW AND THE LIGHTS STILL BLINK ON THE DASH EVEN WHEN THE KEY IS JUST ON THE ON POSITION. *TR
NHTSA ODI #10288713
106,000 miles · Sep 16, 2009
Electrical System
9/12/09 DIES AND WILL NOT RESTART. 9/14/09 PARTS THAT NEEDED REPLACED ARE STARTER AND BATTERY. PROBLEM IS STILL THERE. CAR WILL ONLY TURN OVER (RUN) WHEN THE HEAD LIGHTS ARE ON (NOT IN THE AUTO MODE) AND IF TURNED OFF THE CAR DIES AND EVERY LIGHT ON DASH IS ELIMINATED AND FLASHING. THEN WHEN BLINKERS ARE USED WHILE DRIVING THE M…
Read full complaint
9/12/09 DIES AND WILL NOT RESTART. 9/14/09 PARTS THAT NEEDED REPLACED ARE STARTER AND BATTERY. PROBLEM IS STILL THERE. CAR WILL ONLY TURN OVER (RUN) WHEN THE HEAD LIGHTS ARE ON (NOT IN THE AUTO MODE) AND IF TURNED OFF THE CAR DIES AND EVERY LIGHT ON DASH IS ELIMINATED AND FLASHING. THEN WHEN BLINKERS ARE USED WHILE DRIVING THE MOTOR DIES. THIS HAPPENS EVERY TIME THE CAR IS DRIVEN (AFTER 9/14/09). ON BLOGS OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM AND REPLACED IGNITION SWITCH. *TR
NHTSA ODI #10284232
70,000 miles · Sep 5, 2009
Electrical System
2000 BUICK REGAL W/AUTOMATIC...AFTER ABOUT 3 YRS INTERMITTENT PROBLEM "KEY CAPTURE"...PARK, TURN OFF IGNITION AND SOMETIMES CANNOT REMOVE KEY AND CANNOT MOVE WHEEL TO LOCATE ANTI-THEFT STEERING WHEEL LOCK DETENT...REPEATED RESTART / MOVING OF AUTO / IGNITION OFF ...FINALLY RELEASES KEY !!...LOSS OF ELECTRICAL POWER CAUSES STEERI…
Read full complaint
2000 BUICK REGAL W/AUTOMATIC...AFTER ABOUT 3 YRS INTERMITTENT PROBLEM "KEY CAPTURE"...PARK, TURN OFF IGNITION AND SOMETIMES CANNOT REMOVE KEY AND CANNOT MOVE WHEEL TO LOCATE ANTI-THEFT STEERING WHEEL LOCK DETENT...REPEATED RESTART / MOVING OF AUTO / IGNITION OFF ...FINALLY RELEASES KEY !!...LOSS OF ELECTRICAL POWER CAUSES STEERING WHEEL LOCK !!!...IF BATTERY IS DISCHARGED, ATTEMPT AT START CAUSES KEY TO BE "CAPTURED,"...CANNOT BE REMOVED WITHOUT "BOOST."...THE LATTER INDICATES ESSENTIALLY FAULTY DESIGN...APPARENTLY NOBODY CHECKED WHAT WOULD HAPPEN WITH DEAD BATTERY, LOSS OF AUTO ELECTRICAL POWER, OR LOSS OF ELECTRICAL POWER AT STEERING WHEEL ANTI-THEFT LOCKING SYSTEM..."THEFT SETUP"...CAN SET DOOR LOCKS AND EXIT VEHICLE, BUT "CAPTURED KEY" CAN BE USED TO START ENGINE AND VEHICLE CAN BE DRIVEN AWAY !!!..APPARENTLY THIS IS NO LONGER A SIMPLE MECHANICAL DETENT, BUT A SOLENOID SYSTEM...SO-CALLED "FAIL SAFE" IS IN "WRONG DIRECTION" !!!...OUGHT TO FAIL INTO NON-LOCKING...THIS SYSTEM IS IRRITATING AT MINIMUM, BUT CAN EASILY BE A TERRIBLE SAFETY HAZARD WHEN VEHICLE IS IN MOTION...DEALER MAINTAINED "NEVER HEARD OF PROBLEM."..PAST JUNE ARRIVED IN FARGO, ND FOR OVERNIGHT...TOOK DOZEN RESTARTS / MOVES / STOPS BEFORE KEY "RELEASED" !!!...LOCAL DEALER FAMILIAR WITH PROBLEM...CONNECTOR CORROSION AT SHIFT CONSOLE...UNITIZED ASSEMBLY, ENTIRE CONSOLE SUB-ASSEMBLY REPLACEMENT AT $780 !!!...TECH "LOADED" CONNECTOR WITH SILICONE "IGNITION GREASE" TO FORESTALL RECURRENCE...DON'T KNOW EXTENT (YEARS AND VEHICLES) GM IS USING THIS SYSTEM...(ASIDE OPINION)...DEALER DENIAL OF PROBLEM AND NO ISSUANCE OF DEFECT WARNING OPENS UP A POTENTIALLY HELLISH LEGAL LIABILITY CAMPAIGN... *TR
NHTSA ODI #10282980
117,000 miles · Jul 22, 2009
Engine And Engine CoolingFire
MY SON WAS DRIVING WHEN HE NOTICED SMOKE FROM UNDER THE HOOD. HE PULLED OVER AND FLAMES ENGULFED THE FRONT OF THE CAR . IT WAS A TOTAL LOSS. AL HIS BELONGINGS WERE INSIDE AS HE WAS MOVING TO COLLEGE. I RECEIVED A RECALL FOR THIS MATTER IN THE MAIL. VIN # AND REASON MATCHES MY CAR. I HAD LIABILITY INSURANCE ONLY SO I LOST EVERYTH…
Read full complaint
MY SON WAS DRIVING WHEN HE NOTICED SMOKE FROM UNDER THE HOOD. HE PULLED OVER AND FLAMES ENGULFED THE FRONT OF THE CAR . IT WAS A TOTAL LOSS. AL HIS BELONGINGS WERE INSIDE AS HE WAS MOVING TO COLLEGE. I RECEIVED A RECALL FOR THIS MATTER IN THE MAIL. VIN # AND REASON MATCHES MY CAR. I HAD LIABILITY INSURANCE ONLY SO I LOST EVERYTHING. I HAD TO PAY FOR THE PARKING LOT DAMAGE ALSO. MY SON WAS NOT INJURED THANKS TO HIS QUICK THINKING AND GOD. I PAID $3000.00 FOR THE CAR. WE STILL TRUST G.M. BUT WOULD LIKE THEM TO ADDRESS THIS MATTER WITH ME. THANK YOU, *TR
NHTSA ODI #10277895
Mileage unknown · Jul 16, 2009
Engine And Engine Cooling
CONSUMER IS REQUESTING REIMBURSEMENT FOR THE REPAIR WORK PERFORMED ON HER 2000 BUICK REGAL - SAFETY RECALL 09047. *NJ THE CONSUMER RECEIVED A SAFETY RECALL LETTER IN THE MAIL. SHE TOOK THE VEHICLE TO THE DEALER FOR THE RECALL ON MAY 18, 2009. ON MAY 27, 2009 THE VEHICLE STALLED AND ALMOST CAUSED AN ACCIDENT. THE VEHICLE STARTE…
Read full complaint
CONSUMER IS REQUESTING REIMBURSEMENT FOR THE REPAIR WORK PERFORMED ON HER 2000 BUICK REGAL - SAFETY RECALL 09047. *NJ THE CONSUMER RECEIVED A SAFETY RECALL LETTER IN THE MAIL. SHE TOOK THE VEHICLE TO THE DEALER FOR THE RECALL ON MAY 18, 2009. ON MAY 27, 2009 THE VEHICLE STALLED AND ALMOST CAUSED AN ACCIDENT. THE VEHICLE STARTED UP AGAIN AFTER A 5 MINUTE REST. THE NEXT DAY, THE VEHICLE STALLED 4 SEPARATE TIMES WHILE DRIVING, THE LAST STALL TOOK A WAIT OF 20 MINUTES. THE CONSUMER TOOK THE VEHICLE BACK SINCE THE VEHICLE STARTED STALLING AFTER THE SAFETY RECALL WAS PERFORMED. THE CONSUMER WAS TOLD A NEW IGNITION SWITCH WAS NEEDED, BUT DECLINED THE REPAIRS. THE CONSUMER WENT TO HER PERSONAL MECHANIC TO HAVE THE VEHICLE INSPECTED. THE MECHANIC STATED THE ENGINE WIRING AND IGNITION WERE ALL OK. THE MECHANIC DID FIND 2 PLUG WIRE SEPARATORS ON THE FRONT OF THE ENGINE AND SPARK PLUG WIRES WERE ROUTED WRONG, HE ALSO FOUND THE BATTERY WAS INSTALLED ON ELECTRICAL WIRES LEADING TO THE FUSE PANEL. THE MECHANIC EXPLAINED TO THE CONSUMER THAT THE SPARK PLUG CAPS WERE REPLACED AND RE-ROUTED INCORRECTLY, AND THE SPARK PLUG SEPARATOR WIRES WERE ALL MIXED UP, WHICH CAUSED THE SPARK PLUGS TO MISFIRE RESULTING IN THE VEHICLE STALLING. THE CONSUMER IS REQUESTING REIMBURSEMENT ON THE GROUNDS THAT THE MECHANIC SHOULD HAVE BEEN MORE CAREFUL AND DID THE REPLACEMENT CORRECTLY WHEN PERFORMING THE RECALL. *JB
NHTSA ODI #10277729
Mileage unknown · Jun 18, 2009
Engine And Engine CoolingFire
2000 BUICK REGAL WAS A TOTAL LOSS DUE TO AN ENGINE FIRE. *NJ THE CONSUMER WAS INFORMED THE VEHICLE HAD AN OIL LEAK, BUT WHEN HE CONTACTED ANOTHER REPAIR FACILITY, HE WAS TOLD A THOROUGH INSPECTION HAD BEEN DONE AND THERE WAS NOTHING WRONG WITH THE VEHICLE. SEVERAL MONTHS LATER, THE CONSUMER NEEDED A SMOG CERTIFICATE TO REGIST…
Read full complaint
2000 BUICK REGAL WAS A TOTAL LOSS DUE TO AN ENGINE FIRE. *NJ THE CONSUMER WAS INFORMED THE VEHICLE HAD AN OIL LEAK, BUT WHEN HE CONTACTED ANOTHER REPAIR FACILITY, HE WAS TOLD A THOROUGH INSPECTION HAD BEEN DONE AND THERE WAS NOTHING WRONG WITH THE VEHICLE. SEVERAL MONTHS LATER, THE CONSUMER NEEDED A SMOG CERTIFICATE TO REGISTER HIS VEHICLE, HE TOOK THE VEHICLE TO THE REPAIR SHOP AND LEFT IT. A FEW DAYS LATER HE RECEIVED A CALL TELLING HIM TO COME TO THE SHOP. WHEN THE CONSUMER ARRIVED THERE WERE BURN MARKS ON THE HOOD OF HIS VEHICLE. THE SHOP INFORMED HIM WHEN THEY PERFORMED THE SMOG TEST A FIRE BROKE OUT UNDER THE HOOD AND THEY STATED THE VEHICLE WAS A TOTAL LOSS. THE CONSUMER RECEIVED A RECALL NOTICE 1 YEAR AFTER THE FIRE. *JB
NHTSA ODI #10274511
107,000 miles · May 13, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2000 BUICK REGAL. IN APRIL OF 2009, THE CONTACT NOTICED OIL LEAKS IN HER VEHICLE AND SMELLED A BURNING ODOR. SHE TOOK THE VEHICLE TO A MECHANIC, WHO STATED THAT THE VALVE COVER GASKET NEEDED TO BE REPLACED. IN MAY OF 2009, SHE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000. THE CONTACT …
Read full complaint
TL*THE CONTACT OWNS A 2000 BUICK REGAL. IN APRIL OF 2009, THE CONTACT NOTICED OIL LEAKS IN HER VEHICLE AND SMELLED A BURNING ODOR. SHE TOOK THE VEHICLE TO A MECHANIC, WHO STATED THAT THE VALVE COVER GASKET NEEDED TO BE REPLACED. IN MAY OF 2009, SHE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000. THE CONTACT FELT THAT THE SPARK PLUG REMEDY WOULD BE INSUFFICIENT BECAUSE THE OIL COULD STILL LEAK ONTO ANOTHER COMPONENT AND CAUSE A FIRE. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR THE RECALL REPAIR; HOWEVER, AN APPOINTMENT WAS SCHEDULED. THE CURRENT MILEAGE WAS 110,023 AND FAILURE MILEAGE WAS APPROXIMATELY 107,000.
NHTSA ODI #10268663
100,000 miles · Mar 18, 2009
Engine And Engine Cooling
2000 BUICK REGAL STALLS WHILE DRIVING MY 2000 BUICK REGAL HAS DIED MULTIPLE TIMES IN THE LAST WEEK AS I WAS DRIVING. THE ENGINE QUITS IN AS LITTLE AS FIVE MINUTES, BUT MIGHT TAKE LONGER, AND ALWAYS HAPPENS AS I AM DECELERATING (FOOT OFF THE ACCELERATOR, APPLYING BRAKE). CRANKING CAUSES THE ENGINE TO FIRE, BUT NOT ENOUGH TO K…
Read full complaint
2000 BUICK REGAL STALLS WHILE DRIVING MY 2000 BUICK REGAL HAS DIED MULTIPLE TIMES IN THE LAST WEEK AS I WAS DRIVING. THE ENGINE QUITS IN AS LITTLE AS FIVE MINUTES, BUT MIGHT TAKE LONGER, AND ALWAYS HAPPENS AS I AM DECELERATING (FOOT OFF THE ACCELERATOR, APPLYING BRAKE). CRANKING CAUSES THE ENGINE TO FIRE, BUT NOT ENOUGH TO KEEP RUNNING. IT MIGHT TAKE UP TO TWENTY TRIES TO GET IT RUNNING AGAIN. EN ROUTE TO MY MECHANIC, DRIVING SLOWLY AND GENTLY, THE CAR WOULD NOT STALL. THE MECHANIC ROAD TESTED THE CAR, AND MADE IT STALL. INITIALLY, ERROR CODES P0300, P0463, P1096, P0103 AND P0128 WERE READ. THE OLDER BATTERY WAS REPLACED AND THE POSITIVE CABLE SERVICED. THE ECM WAS REPROGRAMMED (COST: $100!), AND THE REGAL RAN WELL FOR A DAY. SHORTLY THEREAFTER, IT BEGAN DYING AS BEFORE, AND WAS RETURNED TO THE SHOP. SINCE THEN, IT HAS BEEN IN HIS SHOP FOR FOUR DAYS, ENGINE IDLING WITH TEST EQUIPMENT ATTACHED. WHEN IT DIES, IT STARTS UP IMMEDIATELY, AND NO ERROR CODES ARE PRESENT. HE IS AT A LOSS. *TR
NHTSA ODI #10262365
Mileage unknown · Mar 14, 2009
Engine And Engine Cooling
MY CAR IS OVERHEATING AND LEAKING EXCESSIVE DEXCOOL FROM THE INTAKE MANIFOLD GASKETS AND COOLANT ELBOW. WESTLUND BUICK GMC, BUICK, PONTIAC IN SEATTLE, WA HAS DIAGNOSED THE INTAKE MANIFOLD GASKETS AND THE COOLANT ELBOW HAVE GONE BAD. A CUSTOMER SERVICE REPRESENTATIVE AT BUICK CUSTOMER SERVICE HAS INFORMED ME THAT THERE IS A VIN…
Read full complaint
MY CAR IS OVERHEATING AND LEAKING EXCESSIVE DEXCOOL FROM THE INTAKE MANIFOLD GASKETS AND COOLANT ELBOW. WESTLUND BUICK GMC, BUICK, PONTIAC IN SEATTLE, WA HAS DIAGNOSED THE INTAKE MANIFOLD GASKETS AND THE COOLANT ELBOW HAVE GONE BAD. A CUSTOMER SERVICE REPRESENTATIVE AT BUICK CUSTOMER SERVICE HAS INFORMED ME THAT THERE IS A VIN SPECIFIC RECALL ON THIS ISSUE. BUICK CUSTOMER SERVICE HAS VERIFIED MY VIN IS NOT PART OF THAT RECALL BUT I FEEL THAT MY VEHICLE SHOULD BE INCLUDED SINCE IT IS THE SAME MAKE, MODEL, AND YEAR OF OTHER VEHICLES INCLUDED IN THE RECALL. *TR
NHTSA ODI #10261821
Official recalls
8Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Apr 6, 2001
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH SUNVISOR LOCATED AIR BAG LABELS, FAIL TO CONFORM TO FEDERAL MOTOR VEHICLES SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE A MESSAGE AREA LESS THAN 30 CM WHICH DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.
Remedy: GM WILL MAIL A NEW BILINGUAL AIR BAG LABEL WITH INSTALLATION INSTRUCTIONS. HOWEVER, THE CUSTOMER MAY BRING THE LABEL TO THEIR DEALER FOR INSTALLATION FREE OF CHARGE. OWNER NOTIFICATION BEGAN MAY 4, 2001. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT OLDSMOBILE AT 1-800-442-6537 OR BUICK AT 1-800-521-7300.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Jun 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE CLAMP THAT SECURES THE FLEXIBLE FUEL FILL HOSE TO THE METAL FILL TUBE MAY BE LOOSE AND COULD SEPARATE.
Consequence & remedy
Consequence: THIS COULD CAUSE FUEL LEAKAGE EXCEEDING THE PERMISSIBLE AMOUNT.
Remedy: DEALERS WILL INSPECT THE FUEL HOSE FILL NECK CLAMP AND, IF NECESSARY, REPOSITION AND TIGHTEN THE CLAMP.
May 17, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH REAR DRUM BRAKES. THE BOLT HEAD(S) ON THE REAR SPINDLE ROD CAN SEPARATE.
Consequence & remedy
Consequence: THE REAR WHEEL CAN SHIFT, CAUSING REAR STEERING OF THE VEHICLE. THE DRIVER COULD LOSE CONTROL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE REAR SPINDLE BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
Illustration