NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
30 reportsClear category filter100,000 miles · Nov 6, 2018
Air BagsSteeringUnknown Or OtherInjury
PURCHASED THIS CAR SPRING 2017 PAID IN FULL TO PRIOR OWNER. ASKED PRIOR OWNER WHEN TEST DROVE CAR HOW COME ALL THE SERVICE LIGHTS UP AND INCLUDING AIR BAG WARNING LIGHT ON DASH COLLUM ARE LIT UP? OWNERS RESPONSE "NOT SURE BUT HAS BEEN LIKE THAT FOR AS LONG AS CAN REMEMBER WE DON'T THINK YOU SHOULD WORRY?" A WEEK LATER NOTICE THE…
Read full complaint
PURCHASED THIS CAR SPRING 2017 PAID IN FULL TO PRIOR OWNER. ASKED PRIOR OWNER WHEN TEST DROVE CAR HOW COME ALL THE SERVICE LIGHTS UP AND INCLUDING AIR BAG WARNING LIGHT ON DASH COLLUM ARE LIT UP? OWNERS RESPONSE "NOT SURE BUT HAS BEEN LIKE THAT FOR AS LONG AS CAN REMEMBER WE DON'T THINK YOU SHOULD WORRY?" A WEEK LATER NOTICE THE CAR WANTS TO ACCELERATE ON ITS OWN? JUST BOLTS ON MY MOM AND I ? WITHIN THAT MONTH BOTH PASSENGER RIGHT SIDE DOORS FRONT & BACK POWER WINDOWS WILL NO LONGER WORK AT ALL? STEERING WHEEL STARTS MAKING A HORRIBLE SOUND AND SMELL CHECK STEERING FLUID EMPTY REPLACED FLUID ONLY TO FIND OUT IT JUST POOR'S OUT STEERING WILL LOCK UP AND CAN'T DRIVE MOST DAYS? NOTICE SAME ISSUE WITH RADIATOR? MY FAR WORSE EXPERIENCE WITH THIS CAR WAS NOT KNOWING HOW HEAVY THE TRUNK WAS AS WELL AS NOT KNOWING IT WILL FALL BACK SHUT ON OWN? THIS HAPPENED TO ME UNLOADING GROCERIES ONE DAY CRASHING DOWN ON MY HEAD SHOULDERS AND MID BACK PINNING ME INSIDE TRUNK DAZED AND HURT UNTIL MY SON SAW ME TRAPPED AND PULLED TRUNK OFF MY BODY? SHOULD OF WENT TO THE E.R. WAS IN ASTRONOMICAL AMOUNT OF PAIN BUT DIDN'T HAVE MEDICAL INSURANCE SO TREATED MYSELF AT HOME? TOOK 2 MONTH'S BEFORE BRUISING AND SWELLING FINALLY WENT DOWN ? CUT ON MY HEAD TOOK LONGER TO HEAL? THIS HAS ACCURED MORE THAN ONCE AND I'M ABSOLUTELY TERRIFIED TO GO NEAR THE TRUNK AT ALL NOW WITHOUT MY SON TO HELP ME? INTERIOR LIGHT WILL STAY ON UP TO AN HOUR AFTER STARTING AND DRIVING THE CAR MAKING NIGHT DRIVING DANGEROUSLY DIFFICULT AND FEARFUL! PASSENGER FRONT SEAT HAS NEVER WORKED CAN'T ADJUST SEATING AT ALL DUE TO IT BEING POWER SEATS? I'M TERRIFIED EVERY TIME I GET INTO MY CAR WORRIED IT'S GOING TO MALFUNCTION RESULTING IN HURTING MY FAMILY AND I OR ANYONE THAT COULD BE INVOLVED IN AN ACCIDENT CAUSED BY THIS MONSTER OF A CAR? PLEASE HELP ME? THIS CAR IS SCARY
NHTSA ODI #11149585
194,985 miles · Dec 15, 2015
Fuel/propulsion SystemSteeringStructure
VEHICLE INTERIOR LIGHTING DOES NOT WORK IN PARK, DRIVE OR WHEN LIGHTS TURNED ON, CLUSTER, GEAR INDICATOR, CLIMATE DISPLAY, RADIO LIGHTING DOES NOT WORK AT ALL, WHEN DRIVING AT NIGHT & WINDOWS FOG UP I HAVE A HARD TIME FINDING THE TEMP. BUTTONS WHILE SEEING SAFELY OUT WINDSHIELD. MY SON PULLED OUT CLUSTER, NOTICED MISSING RESIST…
Read full complaint
VEHICLE INTERIOR LIGHTING DOES NOT WORK IN PARK, DRIVE OR WHEN LIGHTS TURNED ON, CLUSTER, GEAR INDICATOR, CLIMATE DISPLAY, RADIO LIGHTING DOES NOT WORK AT ALL, WHEN DRIVING AT NIGHT & WINDOWS FOG UP I HAVE A HARD TIME FINDING THE TEMP. BUTTONS WHILE SEEING SAFELY OUT WINDSHIELD. MY SON PULLED OUT CLUSTER, NOTICED MISSING RESISTORS ARE THE CAUSE. DRIVER SIDE LEATHER HEATED SEAT GETS TOO HOT WHEN SWITCHED ON, FEAR IT COULD LEAD TO FIRE. REAR STRUT SNAPPED FROM RUST/AGE. SON REPLACED BOTH REAR STRUTS, NOTICED THE STRUT TO FRAME WAS RUSTING OUT WHERE THE WELDS HAVE BEEN MADE & WAS NOT SUPPORTING THE VEHICLES WEIGHT PROPERLY. IF THESE GIVE OUT, THE REAR OF THE CAR WILL DROP & LOOSE CONTROL OF VEHICLE, POSSIBLY PUNCTURING THE FUEL TANK CAUSING LEAK/FIRE WHILE STEERING WHILE IS PARKED OR IN MOTION, MOVING STEERING WHEEL 9 TO 3 O'CLOCK POSITION IS A VERY LOUD THUD. HEADLIGHT COMBO SWITCH HAS FAILED RESULTING OF LOSING HEADLIGHTS, INTERIOR LIGHTS. LEAKS OIL, PUDDLES OF OIL NEAR PLENUM & TOP OF MOTOR. ITS ALWAYS LEAKED SINCE OWNING IT. FUEL LEAK INSIDE OF ENGINE BAY. MY SON HAS RECENTLY DISCOVERED A FUEL LEAK ONCE THE MOTOR IS SHUT OFF. IT APPEARS IT IS THE BACK FUEL RAIL RETURN LINE QUICK DISCONNECT FITTING THAT IS LEAKING GAS ONCE THE MOTOR IS SHUT OFF, REALIZED THE PROBLEM WHEN I SHUT MY CAR OFF, 5 MINS LATER I STARTED IT & COULD SMELL GASOLINE FROM THE HEAT VENTS. SHUT IT OFF. OPENED HOOD, STRONG ORDER OF GAS PRESENT. REMOVED PLASTIC TOP ENGINE COVER & A VERY STRONG SMELL PRESENT. TRACED THE FUEL LINES & FOUND GASOLINE DRIPPING OUT OF THE REAR FUEL RAIL ONTO THE MOTOR. SON IS REPLACING THE O RINGS IN THE QUICK CONNECT TO CORRECT THE PROBLEM. AFTER GOOGLING THIS IS A COMMON PROBLEM ON W-BODYS & HAS CAUSED THE VEHICLES TO START A FIRE BUT HAS NOT BEEN RECALLED. CAN PROVIDE PICTURES TAKEN OF THE LEAK IF CONTACTED
NHTSA ODI #10810429
98,157 miles · Jul 12, 2015
Electrical SystemEngineSteering
I WAS DRIVING MY 2000 BUICK REGAL COMING BACK FROM WORK, AS I WAS DRIVING AND ABOUT READY TO GO INTO A STEEP TURN, MY STEREO SYSTEM FIRST COMPLETELY SHUT OFF, THEN EVERYTHING ELSE IN MY CAR FAILED AS WELL, ENGINE, POWER STEERING, ETC. I WAS BARELY ABLE TO GET IT TO THE SIDE OF THE ROAD AND WHEN I TRIED TO RESTART IT, IT BARELY T…
Read full complaint
I WAS DRIVING MY 2000 BUICK REGAL COMING BACK FROM WORK, AS I WAS DRIVING AND ABOUT READY TO GO INTO A STEEP TURN, MY STEREO SYSTEM FIRST COMPLETELY SHUT OFF, THEN EVERYTHING ELSE IN MY CAR FAILED AS WELL, ENGINE, POWER STEERING, ETC. I WAS BARELY ABLE TO GET IT TO THE SIDE OF THE ROAD AND WHEN I TRIED TO RESTART IT, IT BARELY TURNED OVER. CLEARLY THERE IS AN ELECTRICAL PROBLEM IN THESE VEHICLES AND MY CAR HASN'T EVEN REACHED 100,000 MILES EVEN.
NHTSA ODI #10733437
41,500 miles · Oct 25, 2014
Electrical SystemEngineSteering
I WAS DRIVING ON A ROAD AT ABOUT 35 MPH, I SIGNALED TO TURNED RIGHT AND MY VEHICLE WENT DEAD(THE ENGINE STOPPED-NO STEERING OR BRAKES.) FORTUNATELY,NO ONE WAS DRIVING BEHIND ME. I CAME TO A HALT AND TRIED STARTING THE ENGINE MULTIPLE TIMES, BUT ALL THAT HAPPENED WAS THE DASHBOARD LIGHTS WOULD FLASH. FINALLY, I TRIED MOVING TH…
Read full complaint
I WAS DRIVING ON A ROAD AT ABOUT 35 MPH, I SIGNALED TO TURNED RIGHT AND MY VEHICLE WENT DEAD(THE ENGINE STOPPED-NO STEERING OR BRAKES.) FORTUNATELY,NO ONE WAS DRIVING BEHIND ME. I CAME TO A HALT AND TRIED STARTING THE ENGINE MULTIPLE TIMES, BUT ALL THAT HAPPENED WAS THE DASHBOARD LIGHTS WOULD FLASH. FINALLY, I TRIED MOVING THE TURN SIGNAL UP AND DOWN AND IT STARTED! SINCE THEN THIS HAS HAPPENED MULTIPLE TIMES. THIS SHOULD NOT HAPPEN ON A LOW MILEAGE CAR OR ANY CAR! I HAVE ALMOST GOTTEN INTO MULTIPLE ACCIDENTS! *TR
NHTSA ODI #10649961
110,000 miles · May 11, 2014
Electrical SystemSteering
ON OR AROUND OCTOBER 2013, I STARTED EXPERIENCING DIFFICULTY IN TURN IGNITION SWITCH OFF AND REMOVING KEY. NOW ITS WORSEN WHERE I SPEND ANYWHERE 5 MINS. TO 15 MIN TRYING TO REMOVE THE KEY. ONLY WAY I CAN DO THAT IS BY TURNING THE STEERING WHEEL OR MOVING THE GEAR SELECTOR BACK AN FORTH TILL IT DECIDES IT RELEASE THE KEY.I THOUG…
Read full complaint
ON OR AROUND OCTOBER 2013, I STARTED EXPERIENCING DIFFICULTY IN TURN IGNITION SWITCH OFF AND REMOVING KEY. NOW ITS WORSEN WHERE I SPEND ANYWHERE 5 MINS. TO 15 MIN TRYING TO REMOVE THE KEY. ONLY WAY I CAN DO THAT IS BY TURNING THE STEERING WHEEL OR MOVING THE GEAR SELECTOR BACK AN FORTH TILL IT DECIDES IT RELEASE THE KEY.I THOUGHT IT MIGHT HAVE BEEN THE ANTI-THEFT IN COLUMN THAT WAS LOCKING UP. I'M SCHEDULED TO HAVE A NEW IGNITION INSTALLED AFTER REPLACING THE OLD KEY WITH A NEW KEY. I LIKE TO MAKE SURE THIS IS COVERED BEFORE I SINK ANYMORE MONEY INTO IT. I DEPEND ON THE CAR TO MAKE TO DOCTOR APPOINTMENTS AND SUCK I OFTEN AM LATE FOR BECAUSE I"M IN THE PARKING LOT PLAYING SPIN THE WHEEL. THE OTHER FACTOR IS STEERING WHEEL GET EXTREMELY HOT WHEN DRIVING AT TIMES. WHERE I HAVE TO PUT ON GLOVES TO DRIVE. I REPLACED ALL THE LIGHT BULBS IN THE SOCKET LAST YEAR ALL BUT THE RIGHT FRONT TURN SIGNAL WORKS. THEY TELL ME IT POSSIBLY COULD BE THE MODULE. AGAIN, I DON'T HAVE THE FUNDS TO DO EXTREME CAR REPAIRS. OR REIMBURSE ME FOR THE COSTS WHICH IS THE RIGHT THING TO DO. *TR
NHTSA ODI #10587661
Mileage unknown · Apr 23, 2014
Electrical SystemExterior LightingSteering
THERE ARE MULTIPLE PROBLEMS WITH THIS VEHICLE. ONE OF MY MAIN COMPLAINTS IS THE STEERING WHEEL IS BECOMING VERY WARM TO THE TOUCH. NEXT, THE KEY GETS STUCK IN THE SWITCH AND WILL NOT COME OUT, CAUSING THE BATTERY TO RUN DOWN. ALSO, THE SIGNAL LIGHTS HAVE GONE OUT AND ARE NOT REPAIRABLE AND THE ELECTRICAL WINDOWS HAVE GONE OUT…
Read full complaint
THERE ARE MULTIPLE PROBLEMS WITH THIS VEHICLE. ONE OF MY MAIN COMPLAINTS IS THE STEERING WHEEL IS BECOMING VERY WARM TO THE TOUCH. NEXT, THE KEY GETS STUCK IN THE SWITCH AND WILL NOT COME OUT, CAUSING THE BATTERY TO RUN DOWN. ALSO, THE SIGNAL LIGHTS HAVE GONE OUT AND ARE NOT REPAIRABLE AND THE ELECTRICAL WINDOWS HAVE GONE OUT DUE TO RUSTING AND ARE NOT REPAIRABLE. *TR
NHTSA ODI #10584484
137,000 miles · Mar 2, 2013
Engine And Engine CoolingFuel/propulsion SystemSteering
2000 REGAL BUICK WITH LOW MILEAGE DIDN'T PASS NH STATE INSPECTION BECAUSE OF CODE P0440 EVAPORATION EMISSION CONTROL SYSTEM. WHEN LOOKING AT GM RECALL THERE WERE 248 OTHER 2000 BUICK RECALLS WITH THE SAME ISSUE REPORTED TO GENERAL MOTORS.THIS CODE HAS TO DO WITH THE FUEL SYSTEM, GAS LINES AND STORAGE TANK AND CAN BE VERY DANGER…
Read full complaint
2000 REGAL BUICK WITH LOW MILEAGE DIDN'T PASS NH STATE INSPECTION BECAUSE OF CODE P0440 EVAPORATION EMISSION CONTROL SYSTEM. WHEN LOOKING AT GM RECALL THERE WERE 248 OTHER 2000 BUICK RECALLS WITH THE SAME ISSUE REPORTED TO GENERAL MOTORS.THIS CODE HAS TO DO WITH THE FUEL SYSTEM, GAS LINES AND STORAGE TANK AND CAN BE VERY DANGEROUS AND CATCH THE CAR ON FIRE.I DID CALL GM AND FILED A CLAIM BUT THEY REALLY DON'T CARE.ALSO THERE IS A STEERING/SUSPENSION STEERING LINKAGE FREE PLAY. WHEN DOING RESEARCH ON THIS THERE WAS A RECALL (76128) AND 979 PEOPLE ALSO REPORTED THIS ISSUE. *TR
NHTSA ODI #10501015
Mileage unknown · Jan 25, 2009
Steering
EXPERIENCE AN INTERMITTENT LOSS OF POWER STEERING ASSIST WHEN MAKING LEFT TURNS,USUALLY AT LOW SPEEDS. WHEN TRYING TO TURN LEFT OUT OF A PARKING SPACE EXPERIENCE HIGHER RESISTANCE OR IN A FEW CASES ASSISTS TOWARDS THE RIGHT. IF THIS HAPPENS WHILE THE VEHICLE IS MOVING, A CRASH COULD RESULT. *TR
NHTSA ODI #10256266
26,729 miles · Nov 5, 2007
Air BagsEngine And Engine CoolingSteering
TL*THE CONTACT OWNS A 2000 BUICK REGAL. THE CONTACT WAS UNABLE TO STEER THE VEHICLE AND IT WAS TOWED TO THE GARAGE. THE BELT AND PUMP WERE REPLACED. THE FAILURE RECURRED AND THE DEALER REPLACED THE STEERING RACK ASSEMBLY AT THE COST OF $475.57. THE THIRD TIME, THE CONTACT NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. TH…
Read full complaint
TL*THE CONTACT OWNS A 2000 BUICK REGAL. THE CONTACT WAS UNABLE TO STEER THE VEHICLE AND IT WAS TOWED TO THE GARAGE. THE BELT AND PUMP WERE REPLACED. THE FAILURE RECURRED AND THE DEALER REPLACED THE STEERING RACK ASSEMBLY AT THE COST OF $475.57. THE THIRD TIME, THE CONTACT NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. THE DEALER DIAGNOSED THE CAUSE OF THE FAILURE AS AN OIL LEAK. THEY REPLACED THE SEAL PUMP AND HOSES AT THE COST OF $588.98. THE CURRENT MILEAGE WAS 41,286 AND FAILURE MILEAGE WAS 26,729. UPDATED 12/12/2007 *BF THE DEALER STATED AIR BAG LIGHT ON. UPDATED 12/12/07 *TR
NHTSA ODI #10207935
50,000 miles · Jul 6, 2007
Steering
TL*THE CONTACT OWNS A 2000 BUICK REGAL. WHILE DRIVING 35 MPH, THE CONTACT HAD DIFFICULTY TURNING THE STEERING WHEEL TO THE LEFT. THE FAILURE OCCURRED INTERMITTENTLY. THE MECHANIC STATED THAT THE CAUSE OF FAILURE WAS THE COLD WEATHER. THE FAILURE BECAME PROGRESSIVELY WORSE IN THE WINTER. THE MECHANIC STATED THAT THE RACK AND…
Read full complaint
TL*THE CONTACT OWNS A 2000 BUICK REGAL. WHILE DRIVING 35 MPH, THE CONTACT HAD DIFFICULTY TURNING THE STEERING WHEEL TO THE LEFT. THE FAILURE OCCURRED INTERMITTENTLY. THE MECHANIC STATED THAT THE CAUSE OF FAILURE WAS THE COLD WEATHER. THE FAILURE BECAME PROGRESSIVELY WORSE IN THE WINTER. THE MECHANIC STATED THAT THE RACK AND PINION FAILED ON THE DRIVER SIDE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THERE WAS A LEAN WITH THE POWER STEERING SHORT RACK. AS OF JULY 6, 2007, THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE IS 65,000 AND FAILURE MILEAGE WAS 50,000. THE CONSUMER STATED DEALER REFUSED TO ADMIT THERE WAS A DEFECT BUT THE VEHICLE WAS NEVER INSPECTED BY THE DEALER. THE CONSUMER STATED TOOK THE VEHICLE TO ANOTHER DEALER TO BE REPAIRED AND THE CONSUMER HAS THE ORIGINAL PART. UPDATED 09/05/07 *TR
NHTSA ODI #10195488
Official recalls
8Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Apr 6, 2001
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH SUNVISOR LOCATED AIR BAG LABELS, FAIL TO CONFORM TO FEDERAL MOTOR VEHICLES SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE A MESSAGE AREA LESS THAN 30 CM WHICH DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.
Remedy: GM WILL MAIL A NEW BILINGUAL AIR BAG LABEL WITH INSTALLATION INSTRUCTIONS. HOWEVER, THE CUSTOMER MAY BRING THE LABEL TO THEIR DEALER FOR INSTALLATION FREE OF CHARGE. OWNER NOTIFICATION BEGAN MAY 4, 2001. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT OLDSMOBILE AT 1-800-442-6537 OR BUICK AT 1-800-521-7300.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Jun 16, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE CLAMP THAT SECURES THE FLEXIBLE FUEL FILL HOSE TO THE METAL FILL TUBE MAY BE LOOSE AND COULD SEPARATE.
Consequence & remedy
Consequence: THIS COULD CAUSE FUEL LEAKAGE EXCEEDING THE PERMISSIBLE AMOUNT.
Remedy: DEALERS WILL INSPECT THE FUEL HOSE FILL NECK CLAMP AND, IF NECESSARY, REPOSITION AND TIGHTEN THE CLAMP.
May 17, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH REAR DRUM BRAKES. THE BOLT HEAD(S) ON THE REAR SPINDLE ROD CAN SEPARATE.
Consequence & remedy
Consequence: THE REAR WHEEL CAN SHIFT, CAUSING REAR STEERING OF THE VEHICLE. THE DRIVER COULD LOSE CONTROL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE REAR SPINDLE BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
Illustration