NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
246 reports120,000 miles · May 14, 2009
Power Train
TL*THE CONTACT OWNS A 1999 BUICK REGAL. THE VEHICLE WAS PURCHASED WITH A FAULTY TRANSMISSION. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE TRANSMISSION HAD PREVIOUSLY BEEN REPLACED PRIOR TO HIM PURCHASING THE VEHICLE. FOUR YEARS LATER, THE TRANSMISSION FAILED AGAIN AND CAUSES THE VEHICLE TO JERK WHILE I…
Read full complaint
TL*THE CONTACT OWNS A 1999 BUICK REGAL. THE VEHICLE WAS PURCHASED WITH A FAULTY TRANSMISSION. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE TRANSMISSION HAD PREVIOUSLY BEEN REPLACED PRIOR TO HIM PURCHASING THE VEHICLE. FOUR YEARS LATER, THE TRANSMISSION FAILED AGAIN AND CAUSES THE VEHICLE TO JERK WHILE IN FIRST AND SECOND GEARS. LATELY, THE VEHICLE HAS BECOME DIFFICULT TO DRIVE DUE TO THE JERKING AND SLIPPING. THE CURRENT AND FAILURE MILEAGES WERE 120,000.
NHTSA ODI #10268759
132,000 miles · May 13, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1999 BUICK REGAL. THE CONTACT PLACED OIL IN HIS VEHICLE AND TWO DROPS LANDED ON THE MANIFOLD, WHICH CAUSED AN IMMEDIATE FIRE. HE WAS ABLE TO EXTINGUISH THE FIRE WITH A HOSE. THE VEHICLE WAS OPERATING AFTER THE FAILURE, BUT EMITTED A BURNING SMELL WHEN THE ENGINE WAS STARTED. THE DAY BEFORE THE FAILURE, …
Read full complaint
TL*THE CONTACT OWNS A 1999 BUICK REGAL. THE CONTACT PLACED OIL IN HIS VEHICLE AND TWO DROPS LANDED ON THE MANIFOLD, WHICH CAUSED AN IMMEDIATE FIRE. HE WAS ABLE TO EXTINGUISH THE FIRE WITH A HOSE. THE VEHICLE WAS OPERATING AFTER THE FAILURE, BUT EMITTED A BURNING SMELL WHEN THE ENGINE WAS STARTED. THE DAY BEFORE THE FAILURE, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 09V116000 AND SCHEDULED A REPAIR APPOINTMENT. HE SPOKE WITH THE DEALER AND ASKED IF THE ODOR WAS A SYMPTOM OF THE RECALL, BUT THE DEALER STATED THAT IT ONLY OCCURRED WHEN THE ENGINE WAS RUNNING. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 132,000. UPDATED 06/27/09 *BF THE VEHICLE CAUGHT ON FIRE DUE TO OIL DRIPPING ON THE EXHAUST MANIFOLD WHEN THE VEHICLE WAS OFF. UPDATED 06/24/09.*JB
NHTSA ODI #10268601
Mileage unknown · May 12, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1999 BUICK REGAL. IN 2008, THE CONTACT'S VEHICLE CAUGHT FIRE UNDER THE HOOD AT A SCHOOL. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE WIRING UNDERNEATH THE DASHBOARD AND HOOD WERE ALL BURNED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS REPAIRED. RECENTLY, SHE REC…
Read full complaint
TL*THE CONTACT OWNS A 1999 BUICK REGAL. IN 2008, THE CONTACT'S VEHICLE CAUGHT FIRE UNDER THE HOOD AT A SCHOOL. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE WIRING UNDERNEATH THE DASHBOARD AND HOOD WERE ALL BURNED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS REPAIRED. RECENTLY, SHE RECEIVED A RECALL NOTICE FOR GM RECALL NUMBER 90047 AND NHTSA CAMPAIGN ID NUMBER 09V116000 (ENGINE AND ENGINE COOLING ON THE ENGINE). THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN. UPDATED 07/14/09. *LJ UPDATED 07/15/09.*JB
NHTSA ODI #10268472
47,000 miles · Feb 22, 2009
Visibility
THE WINDOW REGULATOR JUST FAILED YESTERDAY ON MY 1999 BUICK REGAL- ONLY 47K MILES- WE HAVE REPLACED 3 OTHER WINDOW REGULATORS ON PONTIAC GRAND AM VEHICLES IN THE LAST 3 YEARS. THIS IS NOT A CHEAP REPAIR- OVER $500 FOR EACH WINDOW! I SEE THERE ARE LOTS OF PEOPLE ONLINE COMPLAINING ABOUT THE SAME THING. BUICK AND GM SHOULD BE H…
Read full complaint
THE WINDOW REGULATOR JUST FAILED YESTERDAY ON MY 1999 BUICK REGAL- ONLY 47K MILES- WE HAVE REPLACED 3 OTHER WINDOW REGULATORS ON PONTIAC GRAND AM VEHICLES IN THE LAST 3 YEARS. THIS IS NOT A CHEAP REPAIR- OVER $500 FOR EACH WINDOW! I SEE THERE ARE LOTS OF PEOPLE ONLINE COMPLAINING ABOUT THE SAME THING. BUICK AND GM SHOULD BE HELD ACCOUNTABLE FOR FAULTY MECHANISMS AND THERE SHOULD BE SOME COMPENSATION FOR REPEATED FAILUES SUCH AS THESE. I WILL NOT BUY AMERICAN MADE CARS AGAIN WITH A HISTORY OF FAILURES LIKE THESE. *TR
NHTSA ODI #10259595
Mileage unknown · Nov 19, 2008
Engine And Engine CoolingFire
ON MY WAY TO THE HOSPITAL I STOPPED BY THE GAS STATION AND FILLED UP. AFTER THAT I LEFT TO GO TO THE HOSPITAL, I PARKED AND WENT INSIDE. NOT EVEN 5 MINUTES AFTER I GOT INSIDE, MY CAR CAUGHT FIRE. THE HOSPITAL SECURITY AND POLICE WERE TRYING TO EXTINGUISH IT BEFORE THE FIRE TRUCK ARRIVED TO KEEP FROM SPREADING TO THE OTHER CARS. …
Read full complaint
ON MY WAY TO THE HOSPITAL I STOPPED BY THE GAS STATION AND FILLED UP. AFTER THAT I LEFT TO GO TO THE HOSPITAL, I PARKED AND WENT INSIDE. NOT EVEN 5 MINUTES AFTER I GOT INSIDE, MY CAR CAUGHT FIRE. THE HOSPITAL SECURITY AND POLICE WERE TRYING TO EXTINGUISH IT BEFORE THE FIRE TRUCK ARRIVED TO KEEP FROM SPREADING TO THE OTHER CARS. THANKFULLY IT DIDN'T. THE FIRE GOT WORST AND ENGULFED THE ENTIRE FRONT OF THE CAR WITH FLAMES, THE FIRE DEPT. MANAGED TO PUT THE FIRE OUT BUT NOT BEFORE THE CAR WAS BADLY DAMAGED. FIRE DEPT STATED THAT IT STARTED IN THE ENGINE DEPT. WAITING ON TOW TRUCK TO TOW CAR OFF. COULDN'T SAVE ANYTHING. BUT A COUPLE ITEMS IN THE TRUNK. I GOT HOME A LITTLE LATER AND SAW THAT I HAD A LETTER FOR A RECALL. STATING THAT ENGINE COMPONENT OR PARTS CAN CAUSE FIRES. THE FACT OF THE MATTER IS. I GOT THE RECALL LETTER TO LATE. I NEED THIS TAKEN CARE OF IMMEDIATELY. OR A NEW CAR. *TR
NHTSA ODI #10249297
63,000 miles · Aug 4, 2008
Engine And Engine CoolingFire
I DROVE MY 99 BUICK REGAL TO WORK, PARKED, WENT INSIDE, STARTED ANSWERING EMAIL. WAS INFORMED BY CO WORKERS THAT MY CAR WAS BURNING. MY CAR WAS ENGULFED IN FLAMES IN MINUTES. *TR
NHTSA ODI #10236938
Mileage unknown · Jul 21, 2008
Engine And Engine CoolingEquipment
MY WIFE TOOK MY 1999 BUICK REGAL GS TO THE DEALERSHIP TO ADDRESS RECALL 07035. MY CAR WAS IN PERFECT WORKING ORDER AND RUNNING SMOOTHLY. UPON RETURN OF MY VEHICLE, THE A/C NO LONGER WORKED, THE A/C CONTROL PANEL NO LONGER WORKED, AND THE CAR WAS MISSING WHEN GOING UP HILL AND THE ENGINE TROUBLE LIGHT IS NOW CONTINUOUSLY FLASHING…
Read full complaint
MY WIFE TOOK MY 1999 BUICK REGAL GS TO THE DEALERSHIP TO ADDRESS RECALL 07035. MY CAR WAS IN PERFECT WORKING ORDER AND RUNNING SMOOTHLY. UPON RETURN OF MY VEHICLE, THE A/C NO LONGER WORKED, THE A/C CONTROL PANEL NO LONGER WORKED, AND THE CAR WAS MISSING WHEN GOING UP HILL AND THE ENGINE TROUBLE LIGHT IS NOW CONTINUOUSLY FLASHING. MY WIFE WAS IN A VERY RURAL AREA AND I HAD TO GET IN MY TRUCK TO FOLLOW HER HOME. RECALL REPAIR FOR 07035 HAS VIRTUALLY MADE MY CAR INOPERABLE AND THE DEALERSHIP SAYS IT IS NOTHING THEY DID. YOU DON'T HAVE TO BE A MECHANIC TO KNOW THEY DID SOMETHING WRONG WHEN THE CAR GOES IN WORKING PERFECTLY AND COMES OUT WITH SO MANY PROBLEMS. WHAT CAN YOU DO REGARDING THE DEALERSHIP, OR GENERAL MOTORS TO MAKE MY CAR SAFE AGAIN AND OPERATING SAFELY FOR MY WIFE. *TR
NHTSA ODI #10235083
84,000 miles · Jul 17, 2008
Service Brakes, Hydraulic
MY WIFE SAID THE BRAKES FELT "FUNNY". BUT NO RED WARNING LIGHT SHOWED. I WENT TO DRIVE THE CAR TO SEE WHAT THE PROBLEM WAS. WHEN I STARTED THE ENGINE AND PUSHED THE BRAKE, THE PEDDLE WENT ALL THE WAY TO THE FLOOR AND THE BRAKE FLUID DRAINED OUT IN A PUDDLE UNDER THE CAN - THEN THE RED WARNING LIGHT WENT ON. PRIOR TO THIS, THERE …
Read full complaint
MY WIFE SAID THE BRAKES FELT "FUNNY". BUT NO RED WARNING LIGHT SHOWED. I WENT TO DRIVE THE CAR TO SEE WHAT THE PROBLEM WAS. WHEN I STARTED THE ENGINE AND PUSHED THE BRAKE, THE PEDDLE WENT ALL THE WAY TO THE FLOOR AND THE BRAKE FLUID DRAINED OUT IN A PUDDLE UNDER THE CAN - THEN THE RED WARNING LIGHT WENT ON. PRIOR TO THIS, THERE WAS NO INDICATION OF A BRAKE PROBLEM. IF WE HAD BEEN DRIVING, WE WOULD HAVE HAD AN ACCIDENT. THE CAR WAS TOWED TO THE DEALER, WHO IS NOW MAKING REPAIRS. I CONTACTED GM TO COMPLAIN ABOUT THE CATASTROPHIC NATURE OF THIS BRAKE FAILURE -THEY WILL NOT ACCEPT ANY RESPONSIBILITY. I AM CONCERNED THAT THIS IS LIKELY TO HAPPEN TO OTHER BUICK OWNERS WILL SERIOUS NEGATIVE RESULTS. *TR
NHTSA ODI #10234647
Mileage unknown · Jul 11, 2008
Seat Belts
REAR SEAT BELTS MALFUNCTION-CANNOT INSERT BUCKLE IN TWO OUT OF THREE BELTS. *TR
NHTSA ODI #10234007
98,700 miles · Jul 9, 2008
Suspension
TL*THE CONTACT OWNS A 1999 BUICK REGAL. THE CONTACT NOTICED THAT THE FRONT END OF THE VEHICLE WOULD MOVE INCONSISTENTLY WITH THE REST OF THE VEHICLE. THE FAILURE OCCURRED WHILE DRIVING AT ANY SPEED. THE DEALER STATED THAT THE FRONT SWAY BAR FAILED AND NEEDED TO BE REPLACED. THE CONTACT HAS BEEN WAITING THREE MONTHS TO HAVE T…
Read full complaint
TL*THE CONTACT OWNS A 1999 BUICK REGAL. THE CONTACT NOTICED THAT THE FRONT END OF THE VEHICLE WOULD MOVE INCONSISTENTLY WITH THE REST OF THE VEHICLE. THE FAILURE OCCURRED WHILE DRIVING AT ANY SPEED. THE DEALER STATED THAT THE FRONT SWAY BAR FAILED AND NEEDED TO BE REPLACED. THE CONTACT HAS BEEN WAITING THREE MONTHS TO HAVE THE VEHICLE REPAIRED BECAUSE THE PARTS ARE ON NATIONWIDE BACK ORDER. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE FAILURE MILEAGE WAS 98,700 AND CURRENT MILEAGE WAS 108,000.
NHTSA ODI #10233666
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 10, 2004
CERTAIN PASSENGER VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES DO NOT MEET THE OVERHEAD SIGN ILLUMINATION REQUIREMENTS.
Consequence & remedy
Consequence: LESS ILLUMINATION MAY REDUCE THE ABILITY OF THE DRIVER TO READ OVERHEAD SIGNS WHEN DRIVING AT NIGHT.
Remedy: DEALERS WILL INSTALL NEW LOW BEAM HEADLAMP BULBS IN BOTH OF THE HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080. NOTE: IF THE BULB NEEDS REPLACEMENT IN THE FUTURE, GM BULB NUMBER 89024715 IS AVAILABLE FROM A DEALER, OR THE EQUIVALENT SYLVANIA BULB IS 9006HP, WITH ORANGE LETTERING ON THE BULB.
Dec 17, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE VERTICAL HEAD LAMP ADJUSTING DEVICE MAY NOT BE CALIBRATED PROPERLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY MAY BE IMPAIRED INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH AN OWNER'S MANUAL INSERT CONTAINING INSTRUCTIONS FOR OPTICALLY AIMING THE HEADLAMPS.
Jul 9, 1999
SOME OF THESE VEHICLES WITH THE KEY IN THE "ON" POSITION, EXHIBIT A CONDITION IN WHICH THE ANTILOCK BRAKE SYSTEM (ABS) MOTOR SHORTS TO ITS CASE AND GROUNDS THROUGH A FLEXIBLE BRAKE FLUID PIPE.
Consequence & remedy
Consequence: THIS SHORT CAN CAUSE EXTREME HEATING OF THE FLEXIBLE BRAKE PIPE WHERE IT CAN MELT A NEARBY FLEXIBLE PLASTIC FUEL HOSE, WHICH COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A GROUND CABLE FROM THE ELECTRONIC BRAKE CONTROL MODULE (EBCM) TO THE ENGINE COMPARTMENT BODY RAIL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
Illustration