NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
302 reports69,000 miles · Mar 8, 2014
Electrical SystemEngineExterior Lighting
JUST AS THE CURRENT GM RECALL MY BUICK REGAL SUDDENLY LOSES ALL POWER WHILE DRIVING. THE 1ST TIME THIS OCCURRED I WAS ON THE INTERSTATE GOING 60 MPH AT NIGHT, 1ST ALL THE DASH LIGHTS FLASHED ON, THEN MY HEADLIGHTS, POWER STEERING, ALL ELECTRONICS AND ENGINE DIED! LUCKILY I WAS ABLE TO MAKE IT TO THE EMERGENCY LANE! ONCE, I WAS A…
Read full complaint
JUST AS THE CURRENT GM RECALL MY BUICK REGAL SUDDENLY LOSES ALL POWER WHILE DRIVING. THE 1ST TIME THIS OCCURRED I WAS ON THE INTERSTATE GOING 60 MPH AT NIGHT, 1ST ALL THE DASH LIGHTS FLASHED ON, THEN MY HEADLIGHTS, POWER STEERING, ALL ELECTRONICS AND ENGINE DIED! LUCKILY I WAS ABLE TO MAKE IT TO THE EMERGENCY LANE! ONCE, I WAS ABLE TO PULL MY FRIGHTENED SELF TOGETHER, THE CAR STARTED RIGHT BACK UP AND I WAS ABLE TO GET OFF THE INTERSTATE AND MAKE IT HOME VERY CAUTIOUSLY. IN THE DAYS FOLLOWING, I TESTED IT JUST DRIVING VERY CLOSE TO HOME AND CONTINUOUSLY HAD THE SAME PROBLEM, SOMEWHAT SEEMING TO OCCUR MORE OFTEN WHEN I USED MY TURN SIGNAL, THESE INCIDENCES OF TOTAL POWER FAILURE OCCURRED @ SPEEDS OF 0-35 MPH, SINCE I WAS UNWILLING TO PUT IT BACK ON THE INTERSTATE. WHEN PERFORMING A SIMPLE INTERNET SEARCH FOR A SOLUTION TO THIS PROBLEM, I QUICKLY FOUND THAT I WAS NOT THE ONLY TO HAVE THIS PROBLEM, SOME WITH A 1998 BUICK REGAL JUST AS MYSELF, AND OTHERS WITH A SIMILAR MAKE & MODEL (STILL GM) AND CLOSE TO THE SAME YEAR, WELL BEFORE 2003. AFTER TAKING THE CAR TO A MECHANIC & GETTING A NEW ALTERNATOR AND BLOWER MOTOR, THE CAR DIED YET AGAIN BEFORE I EVEN MADE IT OUT OF THE PARKING LOT. IT WAS SUGGESTED TO ME TO TRY THE NEW ALTERNATOR BEFORE REPLACING THE IGNITION AND RELATED PARTS WHICH ARE QUITE PRICEY ON THIS VEHICLE WHICH HAS 1 OF THOSE CHIPS IN THE KEY. THIS PROBLEM HAS YET TO BE SOLVED AND I WONDER IF THE CURRENT RECALL IS EVEN MORE OVERDUE THAN THOUGHT. PLEASE HELP! DO NOT WAIT UNTIL MYSELF, MY CHILDREN OR OTHERS SUFFER FATAL CONSEQUENCES! THIS VEHICLE IS NEW TO ME, HAS VERY LOW MILEAGE AND IS IN OTHERWISE IN GREAT CONDITION AND ALSO HAS A SATISFACTORY CARFAX REPORT. MY SINCEREST THANKS! *TR
NHTSA ODI #10567980
193,500 miles · Dec 31, 2013
Engine
WHEN I PUT MY TURN SIGNAL ON THE DASH WARNING LAMPS LIGHT UP AND THE VEHICLE ENGINE STOPPED RUNNING, THIS HAPPENED SEVERAL TIMES EVEN WHEN IN PARK, YOU TURN THE SIGNALS ON AND THE VEHICLE DIES, IF YOU CYCLE IT A COUPLE OF TIMES IT OPERATES FINE UNTIL THE VEHICLE IS SHUT OFF AND STANDING FOR A LITTLE WHILE THEN IT WILL START THE …
Read full complaint
WHEN I PUT MY TURN SIGNAL ON THE DASH WARNING LAMPS LIGHT UP AND THE VEHICLE ENGINE STOPPED RUNNING, THIS HAPPENED SEVERAL TIMES EVEN WHEN IN PARK, YOU TURN THE SIGNALS ON AND THE VEHICLE DIES, IF YOU CYCLE IT A COUPLE OF TIMES IT OPERATES FINE UNTIL THE VEHICLE IS SHUT OFF AND STANDING FOR A LITTLE WHILE THEN IT WILL START THE PROBLEM ALL OVER AGAIN. *TR
NHTSA ODI #10557962
208,104 miles · May 31, 2013
Air BagsCrash
I T- BONED A CAR. WHEN MY FRONT END HIT IT THE AIRBAGS WERE SET OFF. THE PASSENGER SIDE AIRBAG HAD WAY TOO MUCH CHARGE IN IT OCCURRING TO THE INSURANCE ADJUSTER. WHEN IT WENT OFF IT EXPLODED SO HARD AND FAST THAT THE TOP OF THE DASH FLIPPED UP AND SHATTERED THE WINDOW IN THAT SHAPE. THE REST OF THE WINDOW IS FINE BUT THIS REALLY…
Read full complaint
I T- BONED A CAR. WHEN MY FRONT END HIT IT THE AIRBAGS WERE SET OFF. THE PASSENGER SIDE AIRBAG HAD WAY TOO MUCH CHARGE IN IT OCCURRING TO THE INSURANCE ADJUSTER. WHEN IT WENT OFF IT EXPLODED SO HARD AND FAST THAT THE TOP OF THE DASH FLIPPED UP AND SHATTERED THE WINDOW IN THAT SHAPE. THE REST OF THE WINDOW IS FINE BUT THIS REALLY EXPLODED AND COULD HAVE KILLED SOMEONE IF THEY HAD BEEN IN THE FRONT SEAT WHEN THIS HAPPENED. *TR
NHTSA ODI #10514474
104,000 miles · Jan 1, 2013
Electrical System
THE CAR WENT COMPLETELY DEAD AFTER STOPPING AT THE BANK FOLLOWING 25 MINUTES OF DRIVING. THERE IS NO POWER, THE KEY IS LOCKED IN THE IGNITION, AND CANNOT BE JUMPSTARTED BY USING ANOTHER CAR. IT CAN JUMPSTART WITH A MACHINE AND RUN FOR A FEW MINUTES, AFTERWARDS IT INSTANTLY DIES AND LOCKS IN PLACE. THIS HAPPENED WHEN I WAS ON A R…
Read full complaint
THE CAR WENT COMPLETELY DEAD AFTER STOPPING AT THE BANK FOLLOWING 25 MINUTES OF DRIVING. THERE IS NO POWER, THE KEY IS LOCKED IN THE IGNITION, AND CANNOT BE JUMPSTARTED BY USING ANOTHER CAR. IT CAN JUMPSTART WITH A MACHINE AND RUN FOR A FEW MINUTES, AFTERWARDS IT INSTANTLY DIES AND LOCKS IN PLACE. THIS HAPPENED WHEN I WAS ON A REGULAR STREET, LUCKILY WITH NO TRAFFIC AT THE TIME. *TR
NHTSA ODI #10490626
254,000 miles · Oct 15, 2012
Suspension
TL* THE CONTACT OWNS A 1998 BUICK REGAL. THE CONTACT STATED THE REAR TRAIL MOUNT FRACTURED WHILE DRIVING 35 MPH. THE CONTACT HEARD A LOUD THUMPING NOISE, CAUSING THE VEHICLE TO SINK ON ONE SIDE. THE CONTACT THEN APPLIED THE BRAKES AND THE VEHICLE BECAME UNCONTROLLABLE. THE CONTACT THEN STOPPED THE VEHICLE AND NOTICED THE TIRE SE…
Read full complaint
TL* THE CONTACT OWNS A 1998 BUICK REGAL. THE CONTACT STATED THE REAR TRAIL MOUNT FRACTURED WHILE DRIVING 35 MPH. THE CONTACT HEARD A LOUD THUMPING NOISE, CAUSING THE VEHICLE TO SINK ON ONE SIDE. THE CONTACT THEN APPLIED THE BRAKES AND THE VEHICLE BECAME UNCONTROLLABLE. THE CONTACT THEN STOPPED THE VEHICLE AND NOTICED THE TIRE SEPARATION CAME FROM THE TRAILING MOUNT. THE VEHICLE WAS TAKEN TO THE CONTACT'S RESIDENCE AND WAS NOT TAKEN TO A MECHANIC OR A DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 254,000.
NHTSA ODI #10480109
160,000 miles · Aug 27, 2012
Steering
TL* THE CONTACT OWNS A 1998 BUICK REGAL. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE POWER STEERING FAILED. THE CONTACT MENTIONED THAT HE ATTEMPTED TO MAKE A LEFT TURN BUT HAD DIFFICULTY MANEUVERING THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY AS…
Read full complaint
TL* THE CONTACT OWNS A 1998 BUICK REGAL. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE POWER STEERING FAILED. THE CONTACT MENTIONED THAT HE ATTEMPTED TO MAKE A LEFT TURN BUT HAD DIFFICULTY MANEUVERING THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10472589
108,330 miles · Aug 2, 2012
Steering
TL* THE CONTACT OWNS A 1998 BUICK REGAL. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH IN A PARKING LOT, A LOUD NOISE EMITTED WHEN TURNING THE STEERING WHEEL. THE CONTACT WAS ABLE TO CONTINUE DRIVING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE RACK AND PINION WOULD NEED TO BE REPLACED. THE LO…
Read full complaint
TL* THE CONTACT OWNS A 1998 BUICK REGAL. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH IN A PARKING LOT, A LOUD NOISE EMITTED WHEN TURNING THE STEERING WHEEL. THE CONTACT WAS ABLE TO CONTINUE DRIVING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE RACK AND PINION WOULD NEED TO BE REPLACED. THE LOWER BEARING ASSEMBLY WAS REPLACED, BUT DID NOT CORRECT THE FAILURE. THERE WAS A RECALL RELATED TO THE DEFECT ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 03V527000 (STEERING:RACK AND PINION). THE VIN WAS INELIGIBLE UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,330.
NHTSA ODI #10468998
9,999,999 miles · Jul 19, 2012
EngineFire
THE VEHICLE WAS INVOLVED IN AN ENGINE COMPARTMENT FIRE. BUICK ADMITS THE RECALL BUT REFUSES TO REPAIR DAMAGE CAUSED BY FIRE. *TR
NHTSA ODI #10466619
Mileage unknown · Apr 4, 2012
Engine And Engine CoolingFire
I REC'D A RECALL NOTICE ON MY VEHICLE IN NOV. 2011 AND HAVE BEEN TRYING TO MAKE ARRANGEMENTS TO GET IT IN TO A DEALER TO HAVE THE RECALL FIXED WHEN THIS FIRE STARTED IN THE ENGINE COMPARTMENT WHILE I WAS ON MY WAY HOME FROM PICKING UP MY SON, AND MY DAUGHTER WAS IN THE VEHICLE AS WELL, I HAVE NO OTHER MEANS OF TRANSPORTATION TO …
Read full complaint
I REC'D A RECALL NOTICE ON MY VEHICLE IN NOV. 2011 AND HAVE BEEN TRYING TO MAKE ARRANGEMENTS TO GET IT IN TO A DEALER TO HAVE THE RECALL FIXED WHEN THIS FIRE STARTED IN THE ENGINE COMPARTMENT WHILE I WAS ON MY WAY HOME FROM PICKING UP MY SON, AND MY DAUGHTER WAS IN THE VEHICLE AS WELL, I HAVE NO OTHER MEANS OF TRANSPORTATION TO GET TO AND FROM WORK, AND MY WORK IS 30 MILES AWAY. IN CONTACTING GM THEY TOLD ME THAT THEY WILL ONLY FIX THE RECALL PART ANY OTHER DAMAGE WILL NOT BE COVERED, I DO NOT HAVE THE EXTRA MONEY TO FIX THIS VEHICLE AT THIS TIME AND I HAVE ALREADY MISSED 3 DAYS OF WORK, AND HAVE NO MORE PERSONAL PAID DAYS OFF TO TAKE. I AM THE MAIN BREADWINNER OF MY HOUSEHOLD AND MY HUSBAND IS USING A BORROWED VEHICLE TO GET BACK AND FORTH TO WORK AS WELL. I FEEL THAT IT IS TRULY UNFAIR GM CAN'T OR WONT HELP OUT A MOTHER OF 3 WITH FIXING THIS VEHICLE SO THAT I MAY CONTINUE TO PROVIDE FOR MY FAMILY. *TR
NHTSA ODI #10454075
181,000 miles · Dec 19, 2011
Electrical SystemExterior Lighting
1. RIGHT SIDE CORNERING LAMP IS INOPERATIVE DESPITE REPLACING BULB, SOCKET AND EVEN ENTIRE RIGHT SIDE HEADLAMP HOUSING ASSEMBLY WITH ALL NEW WIRING AND BULBS IN IT (NOT THE TURN SIGNAL BECAUSE THAT WORKS AND SO DO ALL HEADLIGHT FUNCTIONS I.E. HIGH/LOW BEAM). 2. WHEN ABOVE ISSUE STARTED CAR SUDDENLY STARTED SHUTTING OFF WHENEVER…
Read full complaint
1. RIGHT SIDE CORNERING LAMP IS INOPERATIVE DESPITE REPLACING BULB, SOCKET AND EVEN ENTIRE RIGHT SIDE HEADLAMP HOUSING ASSEMBLY WITH ALL NEW WIRING AND BULBS IN IT (NOT THE TURN SIGNAL BECAUSE THAT WORKS AND SO DO ALL HEADLIGHT FUNCTIONS I.E. HIGH/LOW BEAM). 2. WHEN ABOVE ISSUE STARTED CAR SUDDENLY STARTED SHUTTING OFF WHENEVER TURN SIGNALS WHERE USED WHEN PASSING OR TRYING TO ENTER HIGHWAY ON ENTRANCE RAMP REGARDLESS OF IF WE WERE SPEEDING UP OR SLOWING DOWN. IT HAS ALSO HAPPENED AT A COMPLETE STAND STILL WHILE LOCAL MECHANIC WAS INVESTIGATING COMPLAINT REGARDING ALL THE ABOVE AND HE IS STILL NOT ABLE TO FIND THE CAUSE. I AM AFRAID TO LET MY FAMILY RIDE IN THIS VEHICLE AND I AM AFRAID IT WILL COST US A FORTUNE TRYING TO FIGURE OUT WHAT IS CAUSING THIS UNSAFE ISSUE! *TR
NHTSA ODI #10440434
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Dec 17, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE VERTICAL HEAD LAMP ADJUSTING DEVICE MAY NOT BE CALIBRATED PROPERLY.
Consequence & remedy
Consequence: DRIVER VISIBILITY MAY BE IMPAIRED INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH AN OWNER'S MANUAL INSERT CONTAINING INSTRUCTIONS FOR OPTICALLY AIMING THE HEADLAMPS.
May 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.
Illustration