NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
36 reportsClear category filter130,000 miles · Mar 24, 2010
Engine And Engine CoolingFire
TL* THE CONTACT OWNS A 1996 BUICK REGAL LE. THE CONTACT STATED THERE WAS AN UNUSUAL LOUD EXPLOSION IMMEDIATELY AFTER THE VEHICLE WAS STARTED. SHE OPENED THE HOOD TO FURTHER INVESTIGATE AND WAS EXHUMED WITH THICK SMOKE EMITTING FROM THE ENGINE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE TOP …
Read full complaint
TL* THE CONTACT OWNS A 1996 BUICK REGAL LE. THE CONTACT STATED THERE WAS AN UNUSUAL LOUD EXPLOSION IMMEDIATELY AFTER THE VEHICLE WAS STARTED. SHE OPENED THE HOOD TO FURTHER INVESTIGATE AND WAS EXHUMED WITH THICK SMOKE EMITTING FROM THE ENGINE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE TOP MANIFOLD MELTED. THE MECHANIC REPLACED THE MANIFOLD, INJECTORS, SENSOR WIRES, PCV VALVES, AND HOSES. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE APPROXIMATE CURRENT MILEAGE WAS 130,000.
NHTSA ODI #10321739
113,048 miles · Feb 26, 2010
Engine And Engine CoolingFire
ON ENGINE START, LOUD EXPLOSION IN ENGINE COMPARTMENT. INSPECTION REVELED ENGINE COVER BROKEN, UPPER INTAKE MANIFOLD (PLENUM) SPLIT IN TWO PIECES. SMELL OF GAS, BROKEN VACUUM AND FUEL LINES. MUST REPLACE UPPER INTAKE MANIFOLD, FUEL RAIL, 2 INJECTORS, VARIOUS LINES. OLD PARTS ARE AVAILABLE. *TR
NHTSA ODI #10314670
90,000 miles · May 24, 2009
Engine And Engine CoolingFuel System, Gasoline
VEHICLE BACK FIRE THROUGH THE INTAKE AND SMOKE ROLLS OUT FROM UNDER THE HOOD WHEN TRYING TO START THE VEHICLE, NORMALLY START GOOD AFTER SITTING OVER NIGHT, BUT GO TO START IT AGAIN IT WILL BACK FIRE OR THE ENGINE IDLE IS VERY ERRATIC BEFORE IT WILL SMOOTH OUT. I REPLACE SPARK PLUG, SPARK PLUG WIRES, CAM SENSOR, PCV VALVE, FUEL …
Read full complaint
VEHICLE BACK FIRE THROUGH THE INTAKE AND SMOKE ROLLS OUT FROM UNDER THE HOOD WHEN TRYING TO START THE VEHICLE, NORMALLY START GOOD AFTER SITTING OVER NIGHT, BUT GO TO START IT AGAIN IT WILL BACK FIRE OR THE ENGINE IDLE IS VERY ERRATIC BEFORE IT WILL SMOOTH OUT. I REPLACE SPARK PLUG, SPARK PLUG WIRES, CAM SENSOR, PCV VALVE, FUEL FILTER CHECK BATTERY CONNECTION. *TR
NHTSA ODI #10269816
78,117 miles · Dec 26, 2008
Engine And Engine CoolingFuel System, Gasoline
TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT NOTICED THAT THE VEHICLE SPORADICALLY EXPERIENCED A NO-START CONDITION. THERE WAS ALSO A BACKFIRE THAT OCCURRED WHEN THE VEHICLE WAS STARTED. THE UPPER INTAKE MANIFOLD FAILED PRIOR TO THE UPPER INTAKE MANIFOLD. THE DEALER STATED THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN…
Read full complaint
TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT NOTICED THAT THE VEHICLE SPORADICALLY EXPERIENCED A NO-START CONDITION. THERE WAS ALSO A BACKFIRE THAT OCCURRED WHEN THE VEHICLE WAS STARTED. THE UPPER INTAKE MANIFOLD FAILED PRIOR TO THE UPPER INTAKE MANIFOLD. THE DEALER STATED THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 96V116000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM). THE CONTACT WOULD NOT ASSUME RESPONSIBILITY FOR THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 78,117. UPDATED 02/05/09. *LJ COOLANT WAS FOUND IN THE OIL WHEN REPAIRS WERE MADE ON THE MANIFOLD. UPDATED 02/10/09. *JB
NHTSA ODI #10252849
186,000 miles · May 23, 2007
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT'S VEHICLE CAUGHT FIRE AFTER BEING PARKED FOR APPROXIMATELY FIFTEEN MINUTES. THE CURRENT AND FAILURE MILEAGES WERE 186,000. UPDATED 02-01-08. *KB UPDATED 02/19/10. *LJ UPDATED 09/2810*JB
NHTSA ODI #10191601
87,000 miles · Dec 16, 2006
Engine And Engine Cooling
I BOUGHT A USED CAR IN BOARDMAN, OHIO AREA AND I NOW HAVE A 1490.00 REPAIR BILL AFTER SALESMAN TOLD ME IT WAS CHECKED OUT. THEY REPLACED A BURNED OUT BULB WITH ANOTHER BURNED OUT BULB WHICH I CAN PROVE. I NEED HELP TO STOP THIS PRACTICE. *JB
NHTSA ODI #10176299
29,050 miles · Mar 25, 2005
Electrical SystemEngine And Engine CoolingFuel System, GasolineFire
AFTER TURNING THE IGNITION TO START THE VEHICLE THERE WAS AN EXPLOSION, THE ENGINE WAS ON FIRE. THE FIRE DEPARTMENT WAS CALLED, AND THE FIRE WAS EXTINGUISHED. THIS VEHICLE WAS NOT INCLUDED IN THE INTAKE MANIFOLD NHTSA RECALL 96V116000. *AK THE EGR VALVE WAS INOPERATIVE AND ON ANOTHER OCCASION THE VEHICLE HAD TO BE JUMP STA…
Read full complaint
AFTER TURNING THE IGNITION TO START THE VEHICLE THERE WAS AN EXPLOSION, THE ENGINE WAS ON FIRE. THE FIRE DEPARTMENT WAS CALLED, AND THE FIRE WAS EXTINGUISHED. THIS VEHICLE WAS NOT INCLUDED IN THE INTAKE MANIFOLD NHTSA RECALL 96V116000. *AK THE EGR VALVE WAS INOPERATIVE AND ON ANOTHER OCCASION THE VEHICLE HAD TO BE JUMP STARTED. *SC *JB
NHTSA ODI #10112868
105,310 miles · Dec 21, 2004
Engine And Engine Cooling
ANTI FREEZE LEAKED INSIDE THE ENGINE DUE TO FAULTY INTAKE MANIFOLD GASKETS WHICH WERE MADE OF PLASTIC. THIS HAPPENED FREQUENTLY, EVEN AFTER ANTIFREEZE WAS REFILLED. *AK FUMES FROM THE ANTIFREEZE OIL MIXTURE WERE ENTERING THE CABIN OF THE VEHICLE FROM THE ENGINE. *NM
NHTSA ODI #10099875
181,000 miles · Nov 11, 2004
Engine And Engine CoolingFire
VEHICLE WOULD NOT START, IT WAS TOWED TO REPAIR SHOP SAT FOR ABOUT 24 HOURS, WHEN TRYING TO START IT THE INTAKE MANIFOLD EXPLODED.
NHTSA ODI #10098682
51,278 miles · Nov 8, 2004
Engine And Engine Cooling
WHILE ATTEMPTING TO START THE VEHICLE THE CONSUMER HEARD AN EXPLOSION. *NM A HOLE WAS DISCOVERED BLOWN THROUGH THE INTAKE MANIFOLD AND A CRACK WAS DISCOVERED A CRACK IN THE DUST COVER. THE CONSUMER REQUESTED REIBURSEMENT. *SC
NHTSA ODI #10101434
NHTSA investigations
6EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA99026 · Inadvertent Air Bag Deployment
Opened Aug 31, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
EA96023 · Inappropriate Air Bag Deployment
Opened Sep 27, 1996 · Closed Feb 13, 1998
Status: closed (inferred from source dates) · Air Bags
THE FAILURE RATE (1.25/100K) ON THIS ISSUE IS LOW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITURE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO CLOSELY MONITOR THIS ISSUE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
Illustration