IllustrationCAR SHUTS DOWN WITH NO WARNING , HAD 1500 DOLLAR POWER TRAIN WORK . THE CAR ALMOST CAUSED ME TO BE KILLED DUE TO CAR RUNNING NO ENGINE LIGHT AND COMPLETELY SHUT DOWN AS IF YOU TURNED THE OFF. HWY 287 GOING 65
2005 Buick Rainier
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Buick Rainier do not stand out strongly from the model-year median of 91.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rainier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1525–50K
2150–75K
1375–100K
19100–150K
5150K+
82 reports with mileage · 21 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports3 injury reports
What owners actually said
103 reportsON THE EVENING OF 9/5/2015 I WAS DRIVING MY 2005 BUICK RAINIER WHEN THE LOW BEAM HEADLIGHTS WENT OUT. I WAS ABLE TO DRIVE TO A SAFE LOCATION USING MY HIGH BEAM HEADLIGHTS. WHEN INSPECTED BY MY LOCAL BUICK DEALER (FERMAN BUICK) IT WAS FOUND THAT RELAY 46 (HEADLAMP DRIVER MODULE) HAD BURNED UP AND DAMAGED ADDITIONAL FUSES AND RE…
Read full complaint
ON THE EVENING OF 9/5/2015 I WAS DRIVING MY 2005 BUICK RAINIER WHEN THE LOW BEAM HEADLIGHTS WENT OUT. I WAS ABLE TO DRIVE TO A SAFE LOCATION USING MY HIGH BEAM HEADLIGHTS. WHEN INSPECTED BY MY LOCAL BUICK DEALER (FERMAN BUICK) IT WAS FOUND THAT RELAY 46 (HEADLAMP DRIVER MODULE) HAD BURNED UP AND DAMAGED ADDITIONAL FUSES AND RELAYS. THE ENTIRE FUSE BOX HAD TO BE REPLACED DUE TO THE DAMAGE. THIS CASE HAS BEEN REPORTED TO GM (#8-1567980379). GM CURRENTLY HAS MULTIPLE YEARS OF BUICK RAINIER UNDER RECALL FOR THIS EXACT PROBLEM, SO I'M HOPING THEY EXPAND THE RECALL TO COVER 2005.
MY SPEEDOMETER IS NOT SHOWING THE ACCURATE SPEED. THE NEEDLE SHOOTS TO 100-120MPH, WHEN I AM ONLY DOING 65 MPH. WHEN I TURN THE TRUCK OFF IT WILL SIT AT 60MPH OR STAY ON 120MPH. I HAVE TO TURN THE TRUCK OFF AND ON TO RESET THE SPEEDOMETER. THE OIL GAUGE JUST STOPPED WORKING. ALSO MY HEADLIGHTS FLICKER WHILE I AM DRIVING. THE PRO…
Read full complaint
MY SPEEDOMETER IS NOT SHOWING THE ACCURATE SPEED. THE NEEDLE SHOOTS TO 100-120MPH, WHEN I AM ONLY DOING 65 MPH. WHEN I TURN THE TRUCK OFF IT WILL SIT AT 60MPH OR STAY ON 120MPH. I HAVE TO TURN THE TRUCK OFF AND ON TO RESET THE SPEEDOMETER. THE OIL GAUGE JUST STOPPED WORKING. ALSO MY HEADLIGHTS FLICKER WHILE I AM DRIVING. THE PROBLEM WITH THE SPEEDOMETER HAS BEEN AN ONGOING ISSUE.
WHILE DRIVING MY SPEEDOMETER WILL READ 120MPH WHEN IN FACT I'M ONLY DOING 65MPH. IT'LL STAY STUCK AT 60 AND 120MPH WHEN THE TRUCK IS TURNED OFF. I HAVE TO TURN THE ENGINE OFF AND ON TO RESET IT BACK TO 0. ONE DAY IT WORKS FINE, NEXT DAY IT'S READING INCORRECTLY. MY OIL GAUGE JUST STOPPED WORKING ALL TOGETHER. MY HEADLIGHTS ALSO …
Read full complaint
WHILE DRIVING MY SPEEDOMETER WILL READ 120MPH WHEN IN FACT I'M ONLY DOING 65MPH. IT'LL STAY STUCK AT 60 AND 120MPH WHEN THE TRUCK IS TURNED OFF. I HAVE TO TURN THE ENGINE OFF AND ON TO RESET IT BACK TO 0. ONE DAY IT WORKS FINE, NEXT DAY IT'S READING INCORRECTLY. MY OIL GAUGE JUST STOPPED WORKING ALL TOGETHER. MY HEADLIGHTS ALSO FLICKER WHILE I'M DRIVING.
TL* THE CONTACT OWNS A 2005 BUICK RAINIER. WHILE AT A TRAFFIC LIGHT, THE DOOR LOCKS STARTED TO LOCK AND UNLOCK RAPIDLY WITHOUT WARNING. AFTER THE LIGHT CHANGED, THE VEHICLE FAILED TO ACCELERATE AND THEN STALLED. THE VEHICLE RESTARTED AND RESUMED NORMAL OPERATION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT …
Read full complaint
TL* THE CONTACT OWNS A 2005 BUICK RAINIER. WHILE AT A TRAFFIC LIGHT, THE DOOR LOCKS STARTED TO LOCK AND UNLOCK RAPIDLY WITHOUT WARNING. AFTER THE LIGHT CHANGED, THE VEHICLE FAILED TO ACCELERATE AND THEN STALLED. THE VEHICLE RESTARTED AND RESUMED NORMAL OPERATION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 103,000. THE VIN WAS NOT AVAILABLE.MA 09/25 UPDATED 11/27/2017*CN
WHILE DRIVING THE LOCKS START UNLOCKING AND LOCKING MULTIPLE TIMES, WHILE THIS IS HAPPENING THE GEAR SHIFT INDICATOR ON THE DASH GOES FROM DRIVE TO PARK. THIS ALSO HAPPENED ON MAY 30,2015 AND JUNE 1,2015. I NOTICED THERE HAS BEEN A RECALL ON THE 2006-2007 MODEL IT WOULD SEEM THAT A PROBLEM LIKE THIS WOULD BE LOOKED AT IN ALL MO…
Read full complaint
WHILE DRIVING THE LOCKS START UNLOCKING AND LOCKING MULTIPLE TIMES, WHILE THIS IS HAPPENING THE GEAR SHIFT INDICATOR ON THE DASH GOES FROM DRIVE TO PARK. THIS ALSO HAPPENED ON MAY 30,2015 AND JUNE 1,2015. I NOTICED THERE HAS BEEN A RECALL ON THE 2006-2007 MODEL IT WOULD SEEM THAT A PROBLEM LIKE THIS WOULD BE LOOKED AT IN ALL MODELS.
PASSENGER DOOR PANEL CAUGHT ON FIRE WHEN THE CARE WASN'T USED FOR OVER 15 HOURS. THE WINDOW AND DOOR LOCKS WEREN'T WORKING ON THAT SIDE AND THE WINDOW WAS UP PRIOR TO THE FIRE. THE FIRE CAUSED THE WINDOW TO DROP DOWN AND A PASSING TOW TRUCK THANKFULLY SAW THE FLAMES.
TL* THE CONTACT OWNS A 2005 BUICK RAINER. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW PANEL FAILED TO OPERATE. ALSO, THE CONTACT STATED THAT THERE WAS A BURNING ODOR INSIDE THE VEHICLE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2005 BUICK RAINER. THE CONTACT STATED THAT THE DRIVER SIDE WINDOW PANEL FAILED TO OPERATE. ALSO, THE CONTACT STATED THAT THERE WAS A BURNING ODOR INSIDE THE VEHICLE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000.
TL*THE CONTACT OWNS A 2005 BUICK RAINIER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS WOULD INTERMITTENTLY OPERATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
TL* THE CONTACT OWNS A 2005 BUICK RAINER. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE ABNORMALLY LOWERED TO THE GROUND. AS A RESULT, THE VEHICLE BOUNCED WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR COMPRESSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MAN…
Read full complaint
TL* THE CONTACT OWNS A 2005 BUICK RAINER. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE ABNORMALLY LOWERED TO THE GROUND. AS A RESULT, THE VEHICLE BOUNCED WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR COMPRESSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 121,000.
Official recalls
105V035000 · Visibility:windshield
Feb 3, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD URETHANE BEAD MAY NOT HAVE ADHERED TO THE BODY IN CERTAIN AREAS DURING THE CURE PROCESS.
Consequence & remedy
Consequence: IF A CRASH OCCURS, THE WINDSHIELD MAY NOT BE RETAINED, INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD FREE OF CHARGE. THE RECALL BEGAN ON MARCH 10, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
PE11014 · Fuel Level Gauge System Failure
Opened Apr 25, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
Additional source detail variants (2)
Fuel System, Other
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
Fuel System, Other:storage:fuel Gauge System
The office of defects investigations (ODI) analyzed complaint data provided by General Motors (GM) as well as complaints submitted to ODI from consumers.In total, there were 5,089 unique reports indicating an inaccurate fuel level reading while driving.General Motors stated that this condition occurs when the contacts of the fuel sensor wear prematurely.Most of the complaints indicated an empty fuel gauge reading after filling the tank.Less than 10 percent of theODI complaints involved an engine stall incident.During this investigation, GM developed a remedy procedure and issued special coverage bulletin instructing dealers to install a new design fuel level sensor.The bulletin was sent to dealers on August 10, 2011 and the owner letter mailing began on August 15, 2011.See the investigative file for copies of GM's bulletin and owner letter.This preliminary evaluation is closed.
DP10001 · Fuel Level Gauge System Failure
Opened Jan 7, 2010 · Closed May 23, 2011
Status: closed (inferred from source dates) · Fuel System, Other; Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Additional source detail variants (2)
Fuel System, Other
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.
Fuel System, Other:storage:fuel Gauge System
The Office of Defects Investigation has received 668 complaints alleging inaccurate fuel gauge reading while driving in model year 2005-07 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, and Saab 9-7x vehicles.Of the 668 complaints, 58 incidents were alleged to result in a vehicle stall.Of the 58 stalling incidents, 43 complaints reported stalling because the fuel level reading indicated more fuel availability than what is actually in the fuel tank. One complaint alleged a vehicle crash after the vehicle stalled while exiting the interstate, became disabled, and was struck from behind.Summarily, the complaints show an apparent increasing trend, with most complaints received within the past year.A Preliminary Evaluation has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.