Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
3125–50K
2750–75K
2475–100K
20100–150K
11150K+
133 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports4 fire reports5 injury reports
What owners actually said
158 reports
112,000 miles · Nov 9, 2012
Electrical System
AFTER DRIVING FOR A APPROXIMATELY ONE HOUR AT 65-70 MPH ON THE INTERSTATE THE SPEEDOMETER READING DROPS OFF FROM 70 EVENTUALLY DOWN TO 0 MPH. UPON STOPPING AND RESTARTING THE ENGINE AT A REST STOP THE SPEEDOMETER RETURNS TO AN ACCURATE READING FOR A SHORT WHILE. I RELIED ON MY GARMIN GPS TO GIVE ME A SPEED APPROXIMATION WHEN T…
Read full complaint
AFTER DRIVING FOR A APPROXIMATELY ONE HOUR AT 65-70 MPH ON THE INTERSTATE THE SPEEDOMETER READING DROPS OFF FROM 70 EVENTUALLY DOWN TO 0 MPH. UPON STOPPING AND RESTARTING THE ENGINE AT A REST STOP THE SPEEDOMETER RETURNS TO AN ACCURATE READING FOR A SHORT WHILE. I RELIED ON MY GARMIN GPS TO GIVE ME A SPEED APPROXIMATION WHEN THE SPEEDOMETER WENT OUT COMPLETELY. RELYING ON A ACCURATE SPEEDOMETER IS A CRITICAL SAFETY ISSUE ESPECIALLY AT NIGHT. WITHOUT THE GPS GIVING ME A SPEED READING IT WOULD BE NEXT TO IMPOSSIBLE TO JUDGE A SAFE SPEED IN THE DARKNESS ON A ROAD ILLUMINATED ONLY BY MY HEADLIGHTS. THIS DEFECT MUST BE SIMILAR TO OTHER MODELS IN THE GM FAMILY, TRAILBLAZER AND ENVOY. IF ONE PERSON WERE TO RELY ON THIS FAULTY SPEEDOMETER THEY MIGHT THINK THEY WERE DRIVING 40 WHEN IN ACTUALITY THEY COULD BE DRIVING IN EXCESS OF 70. *TR
NHTSA ODI #10483792
105,000 miles · Sep 25, 2012
VisibilityFire
TL* THE CONTACT OWNS A 2004 BUICK RAINER. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE OFF AND REMOVING THE KEY FROM THE IGNITION, THE ENGINE BLOWER CONTINUED RUNNING. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS DETERMINED THAT THE WIRES FOR THE HEATER BLOWER WERE BURNED OUT. THE MECHANIC ADVISED THE CONTACT THAT THE F…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RAINER. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE OFF AND REMOVING THE KEY FROM THE IGNITION, THE ENGINE BLOWER CONTINUED RUNNING. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS DETERMINED THAT THE WIRES FOR THE HEATER BLOWER WERE BURNED OUT. THE MECHANIC ADVISED THE CONTACT THAT THE FAILURE COULD HAVE CAUSED THE VEHICLE TO CATCH ON FIRE. THE CONTACT THEN SPOKE TO THE DEALER AND WAS TOLD THAT THERE WERE NO RECALLS FOR THE ISSUE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 105,000.
NHTSA ODI #10476982
83,000 miles · Aug 10, 2012
Electrical SystemFire
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, SHE SMELLED AN ODOR OF BURNING WIRES. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE DEALER WAS NOTIFIED AND AN APPOINTMENT WAS SCHEDULED TO HAVE THE VEHICLE EXAMINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, SHE SMELLED AN ODOR OF BURNING WIRES. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE DEALER WAS NOTIFIED AND AN APPOINTMENT WAS SCHEDULED TO HAVE THE VEHICLE EXAMINED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000. UPDATED 10/10/12 *CN
1) FUEL GAUGE - THE FUEL GAUGE HAS DONE A 180, THE NEEDLE IS NOW UPSIDE DOWN. AND DOESN'T WORK REALLY. I SEARCHED THE INTERNET AND FOUND OUT THE THERE IS A RECALL ON 2005- 2007 BUICK RAINIERS BUT NOT ON MY 2004. MAYBE WITH MY COMPLAINT, MAYBE IT WILL INCLUDE 2004 MODELS. 2) DRIVES DOOR LOCK - THE CAR KEY WILL NO LONGER OPEN…
Read full complaint
1) FUEL GAUGE - THE FUEL GAUGE HAS DONE A 180, THE NEEDLE IS NOW UPSIDE DOWN. AND DOESN'T WORK REALLY. I SEARCHED THE INTERNET AND FOUND OUT THE THERE IS A RECALL ON 2005- 2007 BUICK RAINIERS BUT NOT ON MY 2004. MAYBE WITH MY COMPLAINT, MAYBE IT WILL INCLUDE 2004 MODELS. 2) DRIVES DOOR LOCK - THE CAR KEY WILL NO LONGER OPEN THE CAR DOOR. I CAN ONLY OPEN THE DOOR WITH THE REMOTE BUTTON. *TR
NHTSA ODI #10467527
72,153 miles · Jun 5, 2012
Electrical System
GOING DOWN THE ROAD SPEEDOMETER STUCK AT 120. *TR
NHTSA ODI #10460731
130,000 miles · Apr 17, 2012
Seat Belts
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN A PASSENGER BECAME STUCK IN THE REAR PASSENGER SEAT. THE SEAT BELT SEIZED AND WOULD NOT RELEASE THE PASSENGER. THE CONTACT HAD TO CUT THE SEAT BELT TO RELEASE THE PASSENGER. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE, BUT WAS UNABLE …
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN A PASSENGER BECAME STUCK IN THE REAR PASSENGER SEAT. THE SEAT BELT SEIZED AND WOULD NOT RELEASE THE PASSENGER. THE CONTACT HAD TO CUT THE SEAT BELT TO RELEASE THE PASSENGER. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE, BUT WAS UNABLE TO DIAGNOSE THE FAILURE. AN AUTHORIZED DEALER WAS NOTIFIED AND A NEW SEAT BELT WAS ORDERED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10455555
Mileage unknown · Mar 22, 2012
Electrical System
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER MALFUNCTIONED AND THE SPEEDOMETER FAILED. IN ADDITION, THE ABS WARNING LIGHT WAS ILLUMINATED WHENEVER THE VEHICLE WAS STARTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THE CONTACT THAT THE ABS SENSOR AND INSTRUMENT P…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER MALFUNCTIONED AND THE SPEEDOMETER FAILED. IN ADDITION, THE ABS WARNING LIGHT WAS ILLUMINATED WHENEVER THE VEHICLE WAS STARTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THE CONTACT THAT THE ABS SENSOR AND INSTRUMENT PANEL WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS UNKNOWN.
NHTSA ODI #10452686
90,000 miles · Mar 18, 2012
Electrical System
GAUGES DON'T FUNCTION RIGHT. SPEEDO READS TOO FAST, TOO SLOW OR NOT AT ALL, FUEL GAUGE READS TWICE AS FULL. NEEDLE PEGGED TO STOP AS IS THE OIL GAUGE NEEDLE. BUYING THIS WAS THE BIGGEST MISTAKE EVER MADE. *TR
NHTSA ODI #10452094
32,985 miles · Feb 10, 2012
Electrical System
DASHBORAD GAUGES DO NOT KEEP AN ACCURATE ACCOUNT OF RPM'S AS WELL AS SPEED. THE BATTERY GAUGE JUST STARTED BEING INACCURATE JANUARY 2012. *TR
NHTSA ODI #10447388
54,000 miles · Jan 28, 2012
Electrical System
2004 BUICK RAINIER- INSTRUMENT PANEL - SPEEDOMETER, TEMPERATURE, FUEL AND OIL PRESSURE GAUGES ALL STARTED WORKING INTERMITTENTLY AND PROVIDING FALSE READINGS (120MPH AT DEAD STOP WITH ENGINE OFF, TEMP IN RED ZONE AT START UP). THIS APPEARS TO BE ALL TO COMMON OF AN ISSUE WITH GM TRUCKS/SUVS OF THIS ERA AND NEEDS TO BE ADDRESSED …
Read full complaint
2004 BUICK RAINIER- INSTRUMENT PANEL - SPEEDOMETER, TEMPERATURE, FUEL AND OIL PRESSURE GAUGES ALL STARTED WORKING INTERMITTENTLY AND PROVIDING FALSE READINGS (120MPH AT DEAD STOP WITH ENGINE OFF, TEMP IN RED ZONE AT START UP). THIS APPEARS TO BE ALL TO COMMON OF AN ISSUE WITH GM TRUCKS/SUVS OF THIS ERA AND NEEDS TO BE ADDRESSED VIA RECALL. THE PROBLEM IS NOW GETTING PROGRESSIVELY WORSE. *TR
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2004 Buick Rainier Problems, Complaints & Recalls | Skip That Year
Illustration