NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
21 reportsClear category filter150,471 miles · Apr 15, 2019
Exterior Lighting
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE HEADLIGHTS TURNED OFF INTERMITTENTLY WITHOUT WARNING. THE CONTACT STATED THAT THE HEADLIGHTS REMAINED OFF FOR APPROXIMATELY SIX MINUTES. WHEN THE LIGHTS TURNED BACK ON, THE LIGHTING WAS DIM. THE VEHICLE WAS TAKEN TO J.D. BYRIDER (5101 NEW BERN AVE, RALEIGH, N…
Read full complaint
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE HEADLIGHTS TURNED OFF INTERMITTENTLY WITHOUT WARNING. THE CONTACT STATED THAT THE HEADLIGHTS REMAINED OFF FOR APPROXIMATELY SIX MINUTES. WHEN THE LIGHTS TURNED BACK ON, THE LIGHTING WAS DIM. THE VEHICLE WAS TAKEN TO J.D. BYRIDER (5101 NEW BERN AVE, RALEIGH, NC 27610) WHERE THEY REPLACED THE REPLACED THE HEADLIGHT DRIVER MODULE ON TWO DIFFERENT OCCASIONS, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,471.
NHTSA ODI #11196567
116,400 miles · Apr 26, 2018
Exterior Lighting
HEADLIGHTS FAIL INTERMITTENTLY WHILE DRIVING. WHILE DRIVING LAST NIGHT THE LOW BEAM HEADLIGHTS WENT OUT. THE HIGH BEAMS STILL WORKED. THIS IS ABOUT THE SIXTH TIME THIS HAS HAPPENED. I CHANGED OUT THE HEADLIGHT RELAY JUST BEFORE THIS OCCURRED AS I HAD SEEN A RECALL ON 2006 AND 2007 RAINIERS SHOWING THIS AS THE PROBLEM. AFTER…
Read full complaint
HEADLIGHTS FAIL INTERMITTENTLY WHILE DRIVING. WHILE DRIVING LAST NIGHT THE LOW BEAM HEADLIGHTS WENT OUT. THE HIGH BEAMS STILL WORKED. THIS IS ABOUT THE SIXTH TIME THIS HAS HAPPENED. I CHANGED OUT THE HEADLIGHT RELAY JUST BEFORE THIS OCCURRED AS I HAD SEEN A RECALL ON 2006 AND 2007 RAINIERS SHOWING THIS AS THE PROBLEM. AFTER A SHORT TIME THE HIGH BEAMS ALSO WENT OUT. I PARKED AND TURNED THE ENGINE OFF FOR A WHILE AND WHEN I RESTARTED THE HIGH BEAMS WERE WORKING AGAIN BUT NOT THE LOW BEAMS. I WAS DOING A COMBINATION OF STREET AND HIGHWAY DRIVING AND IT APPEARS TO BE UNRELATED TO ANY ROAD CONDITIONS AS THIS HAS HAPPENED ON BOTH HIGHWAYS AND CITY STREETS.
NHTSA ODI #11090229
200,000 miles · Dec 22, 2017
Exterior Lighting
LOW BEAM HEADLIGHTS FAILURE BOTH AT THE SAME TIME. OCCURRED ON TWO SEPARATE OCCASIONS. FIRST TIME A YEAR OR SO AGO, LOW BEAM RELAY REPLACED BY BEST RECOLLECTION
NHTSA ODI #11056167
114,000 miles · Jul 22, 2017
Exterior LightingVisibility/wiper
LOW BEAMS ON LIGHTING GOES OUT FOR NO APPARENT REASON. THIS HAS HAPPENED TWO TIMES IN THE LAST TWO WEEKS. DEALERSHIP SAYS THEY JUST CAN'T FIND ANYTHING WRONG. ALTHOUGH THEY HAD ANOTHER VEHICLE THERE WITH SAME PROBLEM. THIS SEEMS TO BE A RECURRING PROBLEM WITH GM SUV'S. MY 1994 GMC DID THE SAME THING AND I HEARD REPORTS OF OTHER…
Read full complaint
LOW BEAMS ON LIGHTING GOES OUT FOR NO APPARENT REASON. THIS HAS HAPPENED TWO TIMES IN THE LAST TWO WEEKS. DEALERSHIP SAYS THEY JUST CAN'T FIND ANYTHING WRONG. ALTHOUGH THEY HAD ANOTHER VEHICLE THERE WITH SAME PROBLEM. THIS SEEMS TO BE A RECURRING PROBLEM WITH GM SUV'S. MY 1994 GMC DID THE SAME THING AND I HEARD REPORTS OF OTHER GMC'S DOING THE SAME THING. NOT GOOD ON INTERSTATES AT NIGHT.
NHTSA ODI #11010081
Mileage unknown · Aug 20, 2016
Electrical SystemElectronic Stability Control (esc)Exterior Lighting
I TRIED TO GET MY CAR INSPECTED TODAY IN VIRGINIA BUT IT FAILED DUE TO THE DUMMY LIGHTS ON IN THE DASH BOARD ABS AND BRAKE. THE DEALER COULD NOT COMM WITH COMP BUT CHANGED THE FUSE FOR THE CIG LIGHTER THEN THE CODES READ EBCM MODULE FAULT.. IN 2014 MY RUNNING HEADLIGHTS WOULD JUST GO OUT.. NO LIGHTS UNTIL I PUT ON HIGH BEAMS I …
Read full complaint
I TRIED TO GET MY CAR INSPECTED TODAY IN VIRGINIA BUT IT FAILED DUE TO THE DUMMY LIGHTS ON IN THE DASH BOARD ABS AND BRAKE. THE DEALER COULD NOT COMM WITH COMP BUT CHANGED THE FUSE FOR THE CIG LIGHTER THEN THE CODES READ EBCM MODULE FAULT.. IN 2014 MY RUNNING HEADLIGHTS WOULD JUST GO OUT.. NO LIGHTS UNTIL I PUT ON HIGH BEAMS I HAVE HAD THEM WORKED ON AND CHANGED BUT STILL BURN OUT
NHTSA ODI #10897381
110,000 miles · Jul 10, 2016
Exterior Lighting
AFTER HEADLIGHTS ARE ON FOR A LONG TIME THEY WILL GO OFF.
NHTSA ODI #10883858
160,000 miles · Aug 19, 2015
Exterior Lighting
TL* THE CONTACT OWNS A 2004 BUICK RAINIER. WHILE DRIVING AT 50 MPH, THE HEADLIGHTS FAILED TO ILLUMINATE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10749810
95,000 miles · Jun 4, 2015
Electrical SystemExterior Lighting
HAVE NOTICED AFTER A HEAVY AND DRIVING RAIN THAT THE ELECTRICAL SYSTEMS ACTS UP. WE CALL IT CRAZY CAR! ALL THE DASH LIGHTS BLINK & FLASH, BELLS DING AND GAUGES FLUCTUATE WHILE THE VEHICLE IS AT REST AND ON THE MOVE. WE SHUT THE ENGINE OFF, SIT FOR A MINUTE AND RESTART ONLY TO GET THE SAME THING. THAT MAY HAPPEN FOR THE ENTIRE …
Read full complaint
HAVE NOTICED AFTER A HEAVY AND DRIVING RAIN THAT THE ELECTRICAL SYSTEMS ACTS UP. WE CALL IT CRAZY CAR! ALL THE DASH LIGHTS BLINK & FLASH, BELLS DING AND GAUGES FLUCTUATE WHILE THE VEHICLE IS AT REST AND ON THE MOVE. WE SHUT THE ENGINE OFF, SIT FOR A MINUTE AND RESTART ONLY TO GET THE SAME THING. THAT MAY HAPPEN FOR THE ENTIRE RIDE DURATION OR WE MAY GET NO DASH LIGHTS AT ALL. IT APPEARS TO ME THAT THERE IS A SHORT OR A MOISTURE THAT CREATES THIS HAPPENING BECAUSE AFTER A FEW DAYS OF GOOD SUNNY WEATHER WHERE THE WATER HAS EVAPORATED FROM THE ROADWAYS, OUR BELOVED RAINER COMES BACK TO NORMAL. WE STILL EXPERIENCE THE DIMMING OF THE HEADLIGHTS AS WE ARE DRIVING AT NIGHT WHEN WE ARE CRUISING WITH NO GAS PEDAL APPLICATION AT AROUND THE 32 MPH MARKING WHICH IS RATHER ANNOYING AS OTHER DRIVERS FEEL AS IF WE ARE FLASHING THEM. WE SEE A DOWN SURGE IN THE BATTERY GAUGE DROP FOR 14 VOLTS TO 11 VOLTS AND THEN COME BACK UP. SOMETIMES THIS CAN HAPPEN ONCE OR TWICE DURING A 10 MILE RIDE OR AS MANY AS 50! WE WONDER, WHEN, OH, WHEN WILL GM PAY ATTENTION TO THESE COMPLAINTS OR ARE WE JUST TALKING INTO THE WIND?
NHTSA ODI #10723414
80,000 miles · Feb 10, 2015
Exterior Lighting
TL*THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE LOW BEAM HEADLIGHT SOCKET MELTED CAUSING THE LIGHT TO SHAKE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HEAD LAMP MODULE NEEDED TO BE REPLACED, ALONG WITH REPLACEMENT OF THE LIGHT. THE …
Read full complaint
TL*THE CONTACT OWNS A 2004 BUICK RAINIER. THE CONTACT STATED THAT THE LOW BEAM HEADLIGHT SOCKET MELTED CAUSING THE LIGHT TO SHAKE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HEAD LAMP MODULE NEEDED TO BE REPLACED, ALONG WITH REPLACEMENT OF THE LIGHT. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V755000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #10682590
121,000 miles · Jul 15, 2013
Electrical SystemExterior Lighting
THIS IS MY SECOND COMPLAINT RISING FROM THE SAME ISSUE, I OWN TWO 2004 BUICK RAINIER'S AND THEY BOTH HAVE HAD AN ISSUE WITH THE LOW BEAM HEADLAMP BULB AND CONNECTOR BEING MELTED DUE TO POOR CONNECTION. THIS IS A COSTLY REPAIR SINCE THE GM PARTS CATALOG DOES NOT LIST A REPLACEMENT CONNECTOR, THEY WOULD RATHER SELL THE ENTIRE HEAD…
Read full complaint
THIS IS MY SECOND COMPLAINT RISING FROM THE SAME ISSUE, I OWN TWO 2004 BUICK RAINIER'S AND THEY BOTH HAVE HAD AN ISSUE WITH THE LOW BEAM HEADLAMP BULB AND CONNECTOR BEING MELTED DUE TO POOR CONNECTION. THIS IS A COSTLY REPAIR SINCE THE GM PARTS CATALOG DOES NOT LIST A REPLACEMENT CONNECTOR, THEY WOULD RATHER SELL THE ENTIRE HEADLAMP ASSEMBLY. THE FIRST COMPLAINT OCCURRED ON MY OTHER RAINIER NOW THIS ONE. NO HEADLAMP IS A SAFETY CONCERN, AND DUE TO THE WIRING OVERHEATING AND MELTING COULD BE A POTENTIAL FIRE HAZARD.*TR
NHTSA ODI #10524983
NHTSA investigations
3RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration