NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
140 reports126,046 miles · Sep 2, 2013
Vehicle Speed Control
I WAS TRAVELING NORTHBOUND ON US 495 IN SECOND LANE FROM RIGHT GETTING READY TO EXIT TO ROUTE 7 AND TRAVEL WEST TOWARDS LEESBURG WHEN SUDDENLY THE CAR ACCELERATED UNCONTROLLABLY. THE ENGINE WAS RACING. I TRIED EVERYTHING TO AVOID OTHER TRAFFIC AND STOP OR SLOW DOWN THE CAR WHILE TURNING THE AUTO TO THE ADJACENT LANE. THIS INCL…
Read full complaint
I WAS TRAVELING NORTHBOUND ON US 495 IN SECOND LANE FROM RIGHT GETTING READY TO EXIT TO ROUTE 7 AND TRAVEL WEST TOWARDS LEESBURG WHEN SUDDENLY THE CAR ACCELERATED UNCONTROLLABLY. THE ENGINE WAS RACING. I TRIED EVERYTHING TO AVOID OTHER TRAFFIC AND STOP OR SLOW DOWN THE CAR WHILE TURNING THE AUTO TO THE ADJACENT LANE. THIS INCLUDES SHIFTING THE AUTOMATIC TRANSMISSION TO NEUTRAL AND PARK, APPLYING BRAKES, APPLYING EMERGENCY BRAKES AND FINALLY SHUTTING OFF THE ENGINE. THE AUTO MOVED TO THE RIGHT LANE AND FINALLY CAME TO A STOP WITH LITTLE CONTROL OF STEERING. I WAITED FOR A FEW MINUTES AND STARTED THE ENGINE AGAIN AND SHIFTED INTO FIRST GEAR TO GET AWAY FROM TRAFFIC. AUTO STARTED UP AGAIN BUT ENGINE NO LONGER RACED. I SHIFTED INTO THIRD AND WAS ABLE TO MAKE IT HOME SAFELY ABOUT 6 MILES AWAY IN A NORMAL MANNER.ITS BEEN A GREAT CAR, AND THIS HAS NEVER HAPPENED BEFORE. *JS
NHTSA ODI #10538415
105,214 miles · Jul 27, 2013
Structure
CAR WENT FOR ITS OIL CHANGE AND WE WERE INFORMED TO STOP DRIVING THE CAR NOW DO NOT DRIVE IT AN INCH. THE FRONT SUB FRAME IS RUSTED AND BROKE THIS HOLDS THE FRONT SUSPENSION AND ENGINE. *TR
NHTSA ODI #10532167
101,200 miles · Apr 18, 2013
Electrical SystemExterior Lighting
WHEN I TURNED ON THE LEFT TURN, THE LAMP ON THE INSTRUMENT PANEL HAD STOPPED BLINKING AND STAYED ON, EVEN WHEN THE SWITCH WAS IN THE NEUTRAL POSITION. RIGHT-TURN WORKED FINE. THE NEXT DAY I COULD NOT START MY CAR, THE BATTERY WAS COMPLETELY DEAD. I WAS LATE FOR AN IMPORTANT MEETING. LATER I FOUND OUT THAT WHEN THE ENGINE IS …
Read full complaint
WHEN I TURNED ON THE LEFT TURN, THE LAMP ON THE INSTRUMENT PANEL HAD STOPPED BLINKING AND STAYED ON, EVEN WHEN THE SWITCH WAS IN THE NEUTRAL POSITION. RIGHT-TURN WORKED FINE. THE NEXT DAY I COULD NOT START MY CAR, THE BATTERY WAS COMPLETELY DEAD. I WAS LATE FOR AN IMPORTANT MEETING. LATER I FOUND OUT THAT WHEN THE ENGINE IS OFF AND THE KEY REMOVED FROM THE IGNITION, ALL THE LIGHTS ON THE LEFT SIDE OF THE CAR CONTINUED TO BURN, AND THAT WAS THE CAUSE BATTERY DISCHARGE. I STARTED RESEARCHING MY PROBLEM ON THE INTERNET AND FOUND OUT THAT MANY PEOPLE FACED THE EXACT SAME PROBLEM. YOU CAN CHECK GOOGLE ASKING 'SIGNAL FLASHER PROBLEM BUICK PARK AVENUE 1999' , 'LEFT TURN ALWAYS ON BUICK PARK AVENUE 1999' ETC. ACCORDING MY ESTIMATION, AT LEAST THOUSAND PEOPLE MET THIS PROBLEM THE CULPRIT IS 'TURN SIGNAL HAZARD FLASHER UNIT'. IT IS OBVIOUS THAT THIS UNIT HAS A BUILT FACTORY DEFECTS AND IT IS DANGEROUS, THIS UNIT UNNECESSARILY MISLEADS OTHER DRIVERS, AND IS RESPONSIBLE FOR HAZARD FLASHING. I BELIEVE THAT GM SHOULD REPLACE THIS UNIT AT ALL BUICK PARK AVENUE 1997-2005. FACTORY DEFECT IS OBVIOUS AND THE BUYER DOES NOT HAVE TO SUFFER BECAUSE OF THE SHORTCOMINGS OF ENGINEERS. PLEASE REPLACE MY TURN SIGNAL HAZARD FLASHER UNIT FOR FREE. *TR
NHTSA ODI #10508728
85,000 miles · Sep 11, 2012
Fuel/propulsion SystemFire
TL* THE CONTACT OWNS A 1999 BUICK PARK AVENUE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V090000 (FUEL SYSTEM, GASOLINE:DELIVERY). SHORTLY THEREAFTER THE ENGINE EXPLODED, CAUSING MASSIVE DAMAGE TO THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND STATED THAT SINCE THE RECALL REPAIR HAD BEEN …
Read full complaint
TL* THE CONTACT OWNS A 1999 BUICK PARK AVENUE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 04V090000 (FUEL SYSTEM, GASOLINE:DELIVERY). SHORTLY THEREAFTER THE ENGINE EXPLODED, CAUSING MASSIVE DAMAGE TO THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND STATED THAT SINCE THE RECALL REPAIR HAD BEEN COMPLETED AND THEY USED AFTER MARKET PARTS, THEY WERE NOT LIABLE FOR THE DAMAGES OR THE FAILURE. THE FAILURE AND THE CURRENT MILEAGES WERE 85,000.
NHTSA ODI #10475049
99,000 miles · Mar 30, 2011
Fuel System, GasolineFire
I OWN A 1999 BUICK PK AVE. ON FEB 27, 2011 I HAD TO MOVE VEHICLE TO PLOW SNOW. LOW BATTERY, ATTACH BOOSTER PACK AND TRIED TO START AGAIN. THERE WAS A LOUD BACKFIRE. APPARENTLY THE PLENUM HAD BURST KNOCKING OFF FUEL LINE AND I FOUND MY VEHICLE TO BE ON FIRE. AFTER PUTTING OUT FIRE I CONTACTED MY INS CO, WHO ADVISED ME THAT THIS …
Read full complaint
I OWN A 1999 BUICK PK AVE. ON FEB 27, 2011 I HAD TO MOVE VEHICLE TO PLOW SNOW. LOW BATTERY, ATTACH BOOSTER PACK AND TRIED TO START AGAIN. THERE WAS A LOUD BACKFIRE. APPARENTLY THE PLENUM HAD BURST KNOCKING OFF FUEL LINE AND I FOUND MY VEHICLE TO BE ON FIRE. AFTER PUTTING OUT FIRE I CONTACTED MY INS CO, WHO ADVISED ME THAT THIS DAMAGE WAS AN EXACT DESCRIPTION OF A GM RECALL-TSB#03054B- AND I SHOULD CONTACT THEM. GM ADVISED ME THAT THE RECALL WAS DONE PREVIOUSLY. I WOULD HAVE THOUGHT THAT THIS PROBLEM WOULD NOT HAVE HAPPENED IF THE SUPPOSED REPAIR WAS ACTUALLY DONE AND THE REPLACEMENT PARTS WERE NOT ALSO FAULTY. I FEEL GM SHOULD BE RESPONSIBLE. I HAVE SAVED ALL PARTS AND AM REQUESTING AN INVESTIGATION INTO THIS MATTER. ANOTHER VEHICLE IN MY SAME AREA ALSO HAS THE SAME CONDITION AND FIRE - HIS CAR WAS BURNT UP. SOMETHING IS DEFINITELY WRONG AND I AM HOPING THERE WILL BE ANOTHER INVESTIGATION. EITHER IN THE REPAIR PARTS IF USED OR THE DEALERSHIPS REPAIR HABITS CONFIRMING THAT NO FRAUD WAS COMMITTED BY SAID DEALERSHIP. *TR
NHTSA ODI #10393740
100,000 miles · Mar 18, 2011
Fuel System, GasolineFire
TL* THE CONTACT OWNS A 1999 BUICK PARK AVENUE. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN THE DRIVEWAY WHEN IT BACKFIRED AND A FIRE STARTED FROM UNDER THE HOOD. THE FIRE WAS EXTINGUISHED BY THROWING SNOW ON THE MOTOR. THERE WERE NO INJURIES AND A FIRE REPORT WA FILED. THE VEHICLE WAS TOWED TO A LOCAL BODY SHOP WHO ADVISE…
Read full complaint
TL* THE CONTACT OWNS A 1999 BUICK PARK AVENUE. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN THE DRIVEWAY WHEN IT BACKFIRED AND A FIRE STARTED FROM UNDER THE HOOD. THE FIRE WAS EXTINGUISHED BY THROWING SNOW ON THE MOTOR. THERE WERE NO INJURIES AND A FIRE REPORT WA FILED. THE VEHICLE WAS TOWED TO A LOCAL BODY SHOP WHO ADVISED THAT THE DELPHI PRESSURE REGULATOR HAD LEAKED GAS ONTO THE MOTOR AND AS THE KEY WAS TURNED, IT STARTED A SPARK. THE VEHICLE THEN BACKFIRED CAUSING THE FIRE TO ERUPT UNDER THE HOOD OF THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V090000 (FUEL SYSTEM, GASOLINE: DELIVERY) BUT COULD NOT CONFIRM IF THE VEHICLE WAS INCLUDED IN THE RECALL. THE MANUFACTURER WAS CONTACTED AND ADVISED THE WOULD BE IN CONTACT WITH HIM WITHIN SEVEN TO TEN DAYS. THE CONTACTS INSURANCE COMPANY WAS HANDLING THE BODY DAMAGES. THE FAILURE MILEAGE WAS 100,000. UPDATED 04/15/11*LJ UPDATED 1/13/2012 *LN
NHTSA ODI #10390568
62,000 miles · Nov 16, 2010
Steering
STEERING CONSISTENTLY VIBRATES AT LOW SPEED AND PARKING SPEEDS CONCERN FOR LOSS OF STEERING AT HIGHER SPEEDS TSB 990232007 NHTSA 608376 REPAIRED BY TSB DIRECTION ON 11-16-2010 BECAUSE OF GREATER EXPENSE OF HOSES AND LABOR FOR REPAIR, IT SHOULD BE A RECALL ITEM. *TR
NHTSA ODI #10365954
Mileage unknown · Jul 16, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1999 BUICK PARK AVENUE. WHEN THE CONTACT STARTED THE IGNITION, HE SMELLED A STRONG BURNING ODOR INSIDE THE PASSENGER COMPARTMENT. IN ADDITION, OIL WAS LEAKING FROM THE ENGINE COMPARTMENT ONTO THE GROUND. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE HAS NOT BEEN REPAIRED. THE …
Read full complaint
TL*THE CONTACT OWNS A 1999 BUICK PARK AVENUE. WHEN THE CONTACT STARTED THE IGNITION, HE SMELLED A STRONG BURNING ODOR INSIDE THE PASSENGER COMPARTMENT. IN ADDITION, OIL WAS LEAKING FROM THE ENGINE COMPARTMENT ONTO THE GROUND. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 41,281.
NHTSA ODI #10277018
134,000 miles · Jul 11, 2009
Steering
MY WIFE CAME HOME AND STATED THIS CAR WAS DRIVING WOBBLY AND MAKING A NOISE.I INSPECTED VEHICEL AND FOUND THE FOLLOWING. VEHICLE STEERING RACK SEPERATED FROM CRADLE..FIRST NOTICED LOUD NOISE WHEN STEERING ROTATED LOCK TO LOCK..VISUAL INSPECTION COULD SEE TIE ROD CONTACTING RIGHT SIDE UNIBODY RAIL...CLOSER INSPECTION FOUND CASTI…
Read full complaint
MY WIFE CAME HOME AND STATED THIS CAR WAS DRIVING WOBBLY AND MAKING A NOISE.I INSPECTED VEHICEL AND FOUND THE FOLLOWING. VEHICLE STEERING RACK SEPERATED FROM CRADLE..FIRST NOTICED LOUD NOISE WHEN STEERING ROTATED LOCK TO LOCK..VISUAL INSPECTION COULD SEE TIE ROD CONTACTING RIGHT SIDE UNIBODY RAIL...CLOSER INSPECTION FOUND CASTING OR RACK HOUSING CRACKED AND SEPERATED FROM IT'S MOUNTING POINT ON RIGHT SIDE..THIS ALLOWED STEERING RACK TO LIFT UP AND BIND AGAINST RIGHT RAIL OR VEHICLE INNER STRUCTURE...LOSS OF STEERING AND CONTROL WHEN ATTEMPTING TO STEER VEHICLE.
NHTSA ODI #10276418
164,376 miles · May 3, 2009
Engine And Engine CoolingFire
1999 BUICK PARK AVE V6=3800 3 8L SHOT FIRE APX. 6 FEET PER FIREMEN ON DUTY THAT WITNESSED THIS. THE MOTOR SHOOK. UPPER INTAKE, INTAKE SET, VALVE COVER SET, PCV, OIL PRESSURE SWITCH, BOTH CONVERTERS AND STILL NOT FIXED. *TR
NHTSA ODI #10267590
NHTSA investigations
4EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA00002 · Front Shoulder Belt Malfunction
Opened Jan 6, 2000 · Closed May 2, 2000
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
Illustration