INTAKE MANIFOLD FAILED WATER LEAKED INTERNALLY INTO COMBUSTION CHAMBER CAUSING HYDROLOCKING OF ENGINE. UPON RESEARCHING CAUSATIVE ACTIONS I FIND THAT GENERAL MOTORS IS AWARE OF THIS DEFECT AND HAS REDESIGNED THE FAULTY PARTS BUT DISAVOW ANY CULPABILITY EVEN THOUGH A CONSCIENTIOUS OWNER WHO PROPERLY MAINTAINS THE VEHICLE CANNOT…
Read full complaint
INTAKE MANIFOLD FAILED WATER LEAKED INTERNALLY INTO COMBUSTION CHAMBER CAUSING HYDROLOCKING OF ENGINE. UPON RESEARCHING CAUSATIVE ACTIONS I FIND THAT GENERAL MOTORS IS AWARE OF THIS DEFECT AND HAS REDESIGNED THE FAULTY PARTS BUT DISAVOW ANY CULPABILITY EVEN THOUGH A CONSCIENTIOUS OWNER WHO PROPERLY MAINTAINS THE VEHICLE CANNOT KNOW WHAT IS TRANSPIRING INSIDE A COMPOSITE MATERIALS INTAKE MANIFOLD,MANY HAVE BEEN KNOWN TO BURST INTO A FIRE AND DESTROY THE VEHICLES. ONE WOULD TEND TO BELIEVE THIS TO BE A SIGNIFICANT SAFETY THREAT THAT SHOULD BE ADDRESSED IN A RECALL TO REPLACE THIS RECOGNIZED FAILURE OF SIGNIFICANT NUMBERS,I THAT WOULD WARRANT MANUFACTURERS REPLACEMENT TO PROVIDE SAFE TRANSPORTATION. BY THE GRACE OF GOD I NOTED THE VEHICLE ACTING UP AND RETURNED HOME JUST AS THE ENGINE QUIT AND NOW IS HYDROLOCKING DUE TO COOLANT FILLING COMBUSTION CYLINDERS.
NHTSA ODI #10956086
46,000 miles · Mar 22, 2013
Fuel/propulsion System
TL* THE CONTACT OWNS A 1997 BUICK LASABRE. THE CONTACT STATED THAT THE INTAKE MANIFOLD WAS CRACKED CAUSING THE OIL TO LEAK INTO THE RADIATOR. THE ENGINE RAN ROUGH AND BACKFIRED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THE UPPER INTAKE MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED WHO STATED…
Read full complaint
TL* THE CONTACT OWNS A 1997 BUICK LASABRE. THE CONTACT STATED THAT THE INTAKE MANIFOLD WAS CRACKED CAUSING THE OIL TO LEAK INTO THE RADIATOR. THE ENGINE RAN ROUGH AND BACKFIRED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THE UPPER INTAKE MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED WHO STATED THERE WAS A RECALL NHTSA CAMPAIGN NUMBER: 96V116000 (FUEL SYSTEM, GASOLINE) BUT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 46,000 AND THE CURRENT MILEAGE WAS 49,000.
A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
THESE VEHICLES WERE ASSEMBLED WITH ONE OR MORE INCORRECT SAFETY BELT AND/OR SAFETY BELT BUCKLE ENDS. THIS DOES NOT CONFORM WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF AN INCORRECT PART IS USED, THE BELT MAY NOT LATCH PROPERLY, INCREASING THE RISK OF INJURY TO THE OCCUPANT SHOULD A VEHICLE CRASH OCCUR.
Remedy: DEALERS WILL INSPECT ALL FRONT AND REAR SAFETY BELT LATCH ENDS AND SAFETY BELT BUCKLES FOR CORRECT PARTS AND REPLACE ANY INCORRECT PARTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
1997 Buick Lesabre Problems, Complaints & Recalls | Skip That Year
Illustration