NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
132 reports29,000 miles · May 27, 2014
Air Bags
GM RECALL 14030 STATES IN THE EVENT OF A CRASH, THE SIAB, FRONT CENTER AIRBAG, IF EQUIPPED, AND/OR SEAT BELT PRETENSIONERS MAY NOT DEPLOY INCREASING THE RISK OF INJURY TO THE DRIVER OR FRONT PASSENGER. PARTS ARE NOT CURRENTLY AVAILABLE. GM IS PRECLUDING DEALERS FORM ALLOWING TEST DRIVES OR SALE OF ANY NEW OR USED ENCLAVE UNTIL T…
Read full complaint
GM RECALL 14030 STATES IN THE EVENT OF A CRASH, THE SIAB, FRONT CENTER AIRBAG, IF EQUIPPED, AND/OR SEAT BELT PRETENSIONERS MAY NOT DEPLOY INCREASING THE RISK OF INJURY TO THE DRIVER OR FRONT PASSENGER. PARTS ARE NOT CURRENTLY AVAILABLE. GM IS PRECLUDING DEALERS FORM ALLOWING TEST DRIVES OR SALE OF ANY NEW OR USED ENCLAVE UNTIL THE RECALL IS RESOLVED. NOTWITHSTANDING THE NOTICE AND THE FAILURE TO REPAIR BUICK CUSTOMER SERVICE SAYS CARS ARE SAFE TO DRIVE AND REFUSES TO PROVIDE ANY COMPENSATION TO CURRENT OWNERS SUCH AS MYSELF TO PARK THE CAR UNTIL THE SAFETY ISSUE IS RESOLVED AND ALLOW FOR ALTERNATE TRANSPORTATION. SO THEY ARE TELLING ME MY CAR HAS AN INCREASED INJURY RISK THEY ARE TELLING ME IT IS BEING RECALLED THEY ARE TELLING ME THEY DO NOT HAVE THE PARTS TO FIX IT THEY ARE PRECLUDING DEALERS FROM LETTING ANYONE DRIVE THEM AND PRECLUDING SALE BUT TELLING ME THE CAR IS SAFE NOT WITHSTANDING THE NOTICE THAT SAYS IT IS NOT. REPLACEMENT VEHICLE SHOULD BE PROVIDED OF FUNDS TO PAY FOR RENTAL PROVIDED SO THE CAR CAN BE PARKED UNTIL THEY CAN ADDRESS THE RECALL. *TR
NHTSA ODI #10594317
34,794 miles · May 20, 2014
Fuel System, GasolineFuel System, Other
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT ON SEVERAL OCCASIONS THE FUEL GAUGE INDICATOR WOULD DISPLAY INACCURATE FUEL LEVELS AND CAUSE THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE FUEL GAUGE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANU…
Read full complaint
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT ON SEVERAL OCCASIONS THE FUEL GAUGE INDICATOR WOULD DISPLAY INACCURATE FUEL LEVELS AND CAUSE THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE FUEL GAUGE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WERE 34,794.
NHTSA ODI #10592796
36,900 miles · Apr 18, 2014
Electrical SystemFuel System, GasolineService Brakes
TWICE IN THE LAST 30 DAYS OUR ENCLAVE WAS SHOWING LOW ON GAS (USUALLY NOT AN ISSUE) BUT BOTH TIMES THE CAR SPUTTERED TO A STOP. ONCE IT QUIT I LOST ALL POWER STEERING AND BRAKING. EVEN AFTER I PUT GAS IN THE CAR, THE KEY WOULD NOT MOVE SO I WAS UNABLE TO START THE CAR WITHOUT A JUMP. CAR WAS TOWED TO DEALERSHIP. THEY WERE UNABLE…
Read full complaint
TWICE IN THE LAST 30 DAYS OUR ENCLAVE WAS SHOWING LOW ON GAS (USUALLY NOT AN ISSUE) BUT BOTH TIMES THE CAR SPUTTERED TO A STOP. ONCE IT QUIT I LOST ALL POWER STEERING AND BRAKING. EVEN AFTER I PUT GAS IN THE CAR, THE KEY WOULD NOT MOVE SO I WAS UNABLE TO START THE CAR WITHOUT A JUMP. CAR WAS TOWED TO DEALERSHIP. THEY WERE UNABLE TO RECREATE THE ISSUE ALTHOUGH THEY WERE UNABLE TO EXPLAIN WHY THE KEY WOULD LOCK UP IN THE IGNITION. ACCORDING TO BUICK EVERYTHING CHECKED OUT FINE. BASED ON WHAT WE ARE HEARING ON THE NEWS, THIS ISSUE SEEMS VERY SIMILAR TO THE COBALT ISSUE. THANK YOU. *TR
NHTSA ODI #10583576
33,098 miles · Apr 7, 2014
Electrical SystemEngineSteering
MY CAR HAS HAD TO BE TOWED TWICE DUE TO FAILURE TO START. IT WILL CRANK THEN THE ENGINE LIGHT WILL COME ON AND WILL NOT CRANK ANYMORE. HAS BEEN AT SHOP TWO TIMES EACH TIME A WEEK WITH NO ANSWER TO WHY. *TR
NHTSA ODI #10577833
23,083 miles · Mar 21, 2014
Air BagsElectrical SystemSeat Belts
HELLO, PROBLEM: FRONT PASSENGER SIDE SEAT BELT ALARMS WITH LESS THAN 5 POUNDS OF WEIGHT ON THE SEAT. FACTS: I OWN A 2012 BUICK ENCLAVE. I HAD A SERVICE CLINIC APPOINTMENT WITH STERLING MCCALL BUICK AT THE SW FREEWAY IN HOUSTON, TEXAS. A FEW DAYS BEFORE THE APPOINTMENT THE SEAT BELT ALARM WOULD DING WHEN MY PURSE AND …
Read full complaint
HELLO, PROBLEM: FRONT PASSENGER SIDE SEAT BELT ALARMS WITH LESS THAN 5 POUNDS OF WEIGHT ON THE SEAT. FACTS: I OWN A 2012 BUICK ENCLAVE. I HAD A SERVICE CLINIC APPOINTMENT WITH STERLING MCCALL BUICK AT THE SW FREEWAY IN HOUSTON, TEXAS. A FEW DAYS BEFORE THE APPOINTMENT THE SEAT BELT ALARM WOULD DING WHEN MY PURSE AND IPAD WAS ON THE SEAT. I WEIGHED THE ITEMS THEY WEIGH 4.8 POUNDS. THIS IS THE SECOND TIME I HAVE HAD THIS ISSUE. THEY REPLACED THE MODULE ABOUT 45 DAYS AGO. OUTCOME: I WAS FORWARDED GM SERVICE NOTICE DOCUMENT ID 31202743/#08-09-41-0071. I COULD NOT BELIEVE THIS NOTICE. I AM NOT TO PUT ANY ELECTRONIC DEVICES OR LARGE DRINKS IN THE FRONT OF THE CAR. REALLY? THERE IS A USB IN THE DASH COMPARTMENT OF THE SUV (WITHOUT A NOTCH FOR THE CORD - ROLLING MY EYES) AND GM THINKS THERE WILL NOT BE AN ELECTRONIC DEVICE IN THE FRONT SEAT? AND A LARGE DRINK? I REALLY DON'T GET THE LARGE DRINK THING. THAT IS HILARIOUS. MY DEALERSHIP GAVE ME A SEAT BELT EXTENDER TO KEEP THE THING FROM DINGING CONSTANTLY. OPINION: I THINK THE MODULE UNDER SEAT IS SO FREQUENTLY DEFECTIVE THAT GM HAS WRITTEN THIS NOTICE TO UNBURDENED THE CORPORATION OF FURTHER WARRANTY WORK. THEY CAN'T PUT A PIECE OF ALUMINUM FOIL UNDER THE SEAT TO SHIELD THIS MODULE FROM INTERFERENCE? OF COURSE I DON'T KNOW HOW YOU COULD SHIELD IT FROM THE LARGE DRINK THREAT, BOUNTY PAPER TOWELS? MY CONCERN IS IF THERE IS AN ELECTRONIC DEVICE IN THE POCKET OR LAP OR AT THE FEET OF A PASSENGER WILL THE AIR BAGS DEPLOY? *TR
NHTSA ODI #10574081
Mileage unknown · Mar 14, 2014
Visibility/wiperInjury
TL * THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT THE HEATER WAS ACTIVATED AND OVERHEATED, CAUSING THIRD-DEGREE BURNS TO THE CONTACT'S FOOT. THE VEHICLE WAS INSPECTED BUT THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMAT…
Read full complaint
TL * THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT THE HEATER WAS ACTIVATED AND OVERHEATED, CAUSING THIRD-DEGREE BURNS TO THE CONTACT'S FOOT. THE VEHICLE WAS INSPECTED BUT THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10569357
8,000 miles · Nov 15, 2013
Electrical System
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE TURN SIGNALS FAILED TO EMIT A CLICKING NOISE WHEN ENGAGED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TWICE WHERE THE RADIO AND INSTRUMENT PANEL WERE REPLACED AT DIFFERENT TIMES. THE …
Read full complaint
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE TURN SIGNALS FAILED TO EMIT A CLICKING NOISE WHEN ENGAGED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TWICE WHERE THE RADIO AND INSTRUMENT PANEL WERE REPLACED AT DIFFERENT TIMES. THE FAILURE PERSISTED AFTER EACH REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 8,000.
NHTSA ODI #10552412
20,000 miles · Jun 6, 2013
StructureInjury
WHEN I EXIT THE VEHICLE AND CLOSE THE DOOR, THE DESIGN OF THE DOOR IS SO IT CUTS MY LEG. I HAVE CUT THE LEG THREE TIMES IN THE ONE YEAR I HAVE OWNED THE VEHICLE, EACH TIME DRAWING BLOOD THROUGH MATERIAL. THE DOOR IS DESIGNED WHERE THE BOTTOM CORNER PROTRUDES ABOUT THREE INCHES FROM THE STRAIGHT EDGE OF THE DOOR, THE DOOR CURV…
Read full complaint
WHEN I EXIT THE VEHICLE AND CLOSE THE DOOR, THE DESIGN OF THE DOOR IS SO IT CUTS MY LEG. I HAVE CUT THE LEG THREE TIMES IN THE ONE YEAR I HAVE OWNED THE VEHICLE, EACH TIME DRAWING BLOOD THROUGH MATERIAL. THE DOOR IS DESIGNED WHERE THE BOTTOM CORNER PROTRUDES ABOUT THREE INCHES FROM THE STRAIGHT EDGE OF THE DOOR, THE DOOR CURVES OUT. SO WHEN I CLOSE THE DOOR, THAT EDGE EXTENDS PAST THE DOOR AND CUTS MY LEG. THIS IS A DESIGN FLAW WITH THE DOOR AND SHOULD BE CORRECTED. I AM TIRED OF SCARING MY LEG. *TR
NHTSA ODI #10515579
Mileage unknown · Apr 25, 2013
Air Bags
I HAVE BOUGHT A BUICK ENCLAVE 2012 THE FIX AIR BAG SIGN IS ON ALL THE TIME I WENT TO FIX IT TO THE DEALER BUT STILL IT'S NOT FIXED. *TR
NHTSA ODI #10509502
30,000 miles · Apr 9, 2013
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE OF THE CONTACTS VEHICLE AND ALL OF THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE LEFT LEG AND ARM. THE FRONT PASSENGER SUSTAINED INJURIES TO THE HEAD, BACK AND SHOU…
Read full complaint
TL* THE CONTACT OWNS A 2012 BUICK ENCLAVE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT PASSENGER SIDE OF THE CONTACTS VEHICLE AND ALL OF THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE LEFT LEG AND ARM. THE FRONT PASSENGER SUSTAINED INJURIES TO THE HEAD, BACK AND SHOULDERS. THE REAR DRIVER'S SIDE PASSENGER SUSTAINED NECK INJURIES, AS WELL AS UPPER AND LOWER BACK INJURIES. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS TOWED TO AN INDEPENDENT SHOP HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 30,000. *TR UPDATED 6/18/13 *CN UPDATED 07/11/2013 *JS
NHTSA ODI #10505682
Official recalls
6Oct 7, 2021
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration