NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
72 reportsClear category filter130,000 miles · Jun 26, 2018
EngineInjury
THE VEHICLE WILL RANDOMLY LOOSE POWER OR COMPLETELY SHUT OFF WHILE DRIVING IT, NO MATTER WHAT SPEED OR WHAT CONDITION. A WARNING ON THE DASH SAYS THAT POWER WAS REDUCED, ALMOST LIKE A SAFETY OR GOVERNOR. IT RANDOMLY DOES IT, THE LOCKS WILL CLICK BACK AND FORTH BETWEEN UNLOCK AND LOCK AND IT WILL SOMETIMES COMPLETELY DIE OR JUS…
Read full complaint
THE VEHICLE WILL RANDOMLY LOOSE POWER OR COMPLETELY SHUT OFF WHILE DRIVING IT, NO MATTER WHAT SPEED OR WHAT CONDITION. A WARNING ON THE DASH SAYS THAT POWER WAS REDUCED, ALMOST LIKE A SAFETY OR GOVERNOR. IT RANDOMLY DOES IT, THE LOCKS WILL CLICK BACK AND FORTH BETWEEN UNLOCK AND LOCK AND IT WILL SOMETIMES COMPLETELY DIE OR JUST BE IN LIMP MODE SO YOU HAVE NO CONTROL. THIS HAS HAPPENED WHILE GOING 75 DOWN THE INTERSTATE WITH HEAVY TRAFFIC, ALMOST CAUSING A WRECK A FEW TIMES. IT WILL ALSO HAPPEN AT LOWER SPEEDS OR AROUND TURNS ETC.
NHTSA ODI #11103981
89,655 miles · Apr 6, 2018
Engine
THIS VEHICLE WITH 89000 MILES HAS JUST BEEN DIAGNOSED WITH A STRETCHED TIMING CHAIN PROBLEM, AND WE HAVE BEEN QUOTED A PRICE OF $2800 TO EFFECT A REPAIR THAT OBVIOUSLY SHOULD HAVE BEEN A RECALL. AT THIS MOMENT THERE HAS NOT BEEN A CATASTROFIC FAILURE WHICH WOULD NECESSITATE AN ENGINE REPLACEMENT . WE THINK THAT IT IS UNCONSCION…
Read full complaint
THIS VEHICLE WITH 89000 MILES HAS JUST BEEN DIAGNOSED WITH A STRETCHED TIMING CHAIN PROBLEM, AND WE HAVE BEEN QUOTED A PRICE OF $2800 TO EFFECT A REPAIR THAT OBVIOUSLY SHOULD HAVE BEEN A RECALL. AT THIS MOMENT THERE HAS NOT BEEN A CATASTROFIC FAILURE WHICH WOULD NECESSITATE AN ENGINE REPLACEMENT . WE THINK THAT IT IS UNCONSCIONABLE THAT GM KNOWING OF THIS FAILURE HASN'T REACHED OUT TO THE VICTIMS AND OFFERED A SOLUTION TO THI BURDENING PROBLEM FOR FOLKS WHO CAN'T AFFORD TO REPAIR THEIR VEHICLE THAT IS NECESSARILY DEPENDED UPON. IT LOOKS TO US THAT A CLASS ACTION SUIT IS IN ORDER TO FORCE GM TO FIX THEIR MISTAKES. IT IS GALLING TO NOTE THAT LOTS OF OLDER FOLKS HAVE TRIED TO STAY LOYAL TO U.S. MANUFACTURERS HAVE BEEN MISPLACING THEIR LOYALTIES. THE SUIT AGAINST THE SATURN VUE TRANSMISSION SHOULD BE A GOOD EXAMPLE TO FOLLOW. ANYONE AGREE?
NHTSA ODI #11083608
80,000 miles · Mar 26, 2018
Engine
VEHICLE HESITATION WHILE ACCELERATING. CHECK ENGINE LIGHT COMES ON. CODE WAS P0008 REQUIRING NEW TIMING CHANIS TO BE INSTALLED FOR $3,200. VEHICLE ONLY HAS 80K MILES ON IT
NHTSA ODI #11081316
80,000 miles · Mar 9, 2018
Engine
TL* THE CONTACT OWNS A 2010 BUICK ENCLAVE. WHILE DRIVING AT AN UNDISCLOSED SPEED, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED OF A FAULT CODE FOR THE ENGINE CONTROL MODULE (P0008). THE CONTACT WAS ALSO INFORMED THAT THE TIMING BELT WAS…
Read full complaint
TL* THE CONTACT OWNS A 2010 BUICK ENCLAVE. WHILE DRIVING AT AN UNDISCLOSED SPEED, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED OF A FAULT CODE FOR THE ENGINE CONTROL MODULE (P0008). THE CONTACT WAS ALSO INFORMED THAT THE TIMING BELT WAS ALSO A FACTOR IN THE FAILURE. THE VEHICLE WAS TAKEN TO RICK HENDRICK BUICK GMC (3244 COMMERCE AVE NW, DULUTH, GA 30096, (770) 954-8718); HOWEVER, THE MECHANIC AND SERVICE DEPARTMENT WERE VERY EVASIVE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #11078292
73,000 miles · Mar 5, 2018
Engine
ON JANUARY 9, 2018, WHILE WAITING AT A STOP LIGHT ON THE CITY STREET, AS I PROCEEDED THROUGH THE TRAFFIC LIGHT MY VEHICLE CUT OFF. I HAD TO HAVE MY VEHICLE TOWED HOME WHICH WAS THE CLOSEST DESTINATION. MY 2010 BUICK ENCLAVE HAS BEEN LOOKED AT JIM MURPHY BUICK AND WEST HERR CHEVY AND BOTH DEALERSHIPS CONCLUDED THE SAME PROBLEM.…
Read full complaint
ON JANUARY 9, 2018, WHILE WAITING AT A STOP LIGHT ON THE CITY STREET, AS I PROCEEDED THROUGH THE TRAFFIC LIGHT MY VEHICLE CUT OFF. I HAD TO HAVE MY VEHICLE TOWED HOME WHICH WAS THE CLOSEST DESTINATION. MY 2010 BUICK ENCLAVE HAS BEEN LOOKED AT JIM MURPHY BUICK AND WEST HERR CHEVY AND BOTH DEALERSHIPS CONCLUDED THE SAME PROBLEM. THE PROBLEM WITH THIS VEHICLE IS THE TIMING CHAIN. MY VEHICLE IS NO LONGER WORKING, I NEED TO REPLACE THE ENGINE DUE TO THE MALFUNCTION OF THE TIMING CHAIN. WHEN SEEKING A RECONDITIONED ENGINE, THE RESPONSE I'VE GOTTEN FROM AUTO PART/ENGINE DEALERS IS THAT THERE HAVE BEEN REPEATED PROBLEMS WITH THE TIMING CHAIN ON THOSE ENGINES FOR 2010 BUICK ENCLAVE MODELS AND THAT THE TIMING CHAIN WAS NOT BUILT TO LAST LONG. BUT, THE RECONDITIONED ENGINES TIMING CHAIN IS NOW UPGRADED TO THE NEW GM SPECS.
NHTSA ODI #11076193
85,000 miles · Feb 22, 2018
EngineSteeringUnknown Or Other
STEERING: SEEMS VAGUE WHEN IN MOTION AT HIGHWAY SPEED. OTHER: REAR TAILGATE OPENS WHILE DRIVING, SITTING STILL W/O THE KEY IN THE IGNITION. CONTACTED GM AND CUSTOMER SERVICE TOLD ME IT WAS MY PROBLEM NOT THEIRS. ENGINE: SOUNDS LIKE A MEATGRINDER ON COLD START UP, IF THE ENGINE FAILS WILL LOOSE STEERING, BRAKES AND POSSIBLY CONTR…
Read full complaint
STEERING: SEEMS VAGUE WHEN IN MOTION AT HIGHWAY SPEED. OTHER: REAR TAILGATE OPENS WHILE DRIVING, SITTING STILL W/O THE KEY IN THE IGNITION. CONTACTED GM AND CUSTOMER SERVICE TOLD ME IT WAS MY PROBLEM NOT THEIRS. ENGINE: SOUNDS LIKE A MEATGRINDER ON COLD START UP, IF THE ENGINE FAILS WILL LOOSE STEERING, BRAKES AND POSSIBLY CONTROL OF THE VEHICLE.
NHTSA ODI #11074287
52,000 miles · Feb 14, 2018
Engine
2010 MODEL WITH APPROX. 52K MILES. VEHICLE HESITATES WHEN ACCELERATING AND ENGINE LIGHT RECENTLY CAME ON. HAD IT CHECKED AND IT IS A STRETCHED OUT TIMING CHAIN. VEHICLE MANUFACTURED IN 08/09 PER MFT. STICKER ON DOOR. REPAIRS ARE VERY EXPENSIVE. THERE IS A 10YR/120K MILE EXTENDED POWER TRAIN WARRANTY ON THE 2009 MODEL, BUT DOES…
Read full complaint
2010 MODEL WITH APPROX. 52K MILES. VEHICLE HESITATES WHEN ACCELERATING AND ENGINE LIGHT RECENTLY CAME ON. HAD IT CHECKED AND IT IS A STRETCHED OUT TIMING CHAIN. VEHICLE MANUFACTURED IN 08/09 PER MFT. STICKER ON DOOR. REPAIRS ARE VERY EXPENSIVE. THERE IS A 10YR/120K MILE EXTENDED POWER TRAIN WARRANTY ON THE 2009 MODEL, BUT DOES NOT APPEAR TO APPLY TO 2010 MODEL. HESITATION ISSUE CAUSING SAFETY ISSUES.
NHTSA ODI #11072922
120,000 miles · Feb 14, 2018
Engine
THIS ENGINE HAS A TIMING CHAIN ISSUE THAT FORCED A 2009 N 2008 RECALL. THE 2010 IS THE SAME ENGINE WITH THE SAME ISSUE. IN FACT THE 3.6L V6 ENGINE ON ALL MODELS SHOULD BE LOOKED INTO. THE REPAIR COST IS OVER $2000
NHTSA ODI #11072833
189,000 miles · Feb 7, 2018
EngineService BrakesTraction Control System
TL* THE CONTACT OWNS A 2010 BUICK ENCLAVE. WHILE DRIVING 50 MPH, THE VEHICLE EXPERIENCED A LOSS OF ENGINE POWER. ALSO, THE CHECK ENGINE, TRACTION CONTROL, AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS OPERABLE AFTER BEING MANUALLY RESTARTED. THE VEHICLE WAS TAKEN TO BIG LAKE AUTOMOTIVE (19868 172ND ST NW, BIG LAKE, MN)…
Read full complaint
TL* THE CONTACT OWNS A 2010 BUICK ENCLAVE. WHILE DRIVING 50 MPH, THE VEHICLE EXPERIENCED A LOSS OF ENGINE POWER. ALSO, THE CHECK ENGINE, TRACTION CONTROL, AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS OPERABLE AFTER BEING MANUALLY RESTARTED. THE VEHICLE WAS TAKEN TO BIG LAKE AUTOMOTIVE (19868 172ND ST NW, BIG LAKE, MN), BUT THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 189,000.
NHTSA ODI #11071538
136,636 miles · Feb 1, 2018
Engine
TL* THE CONTACT OWNS A 2010 BUICK ENCLAVE. WHEN THE CONTACT STARTED THE VEHICLE, IT STALLED AND WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN NEEDED TO BE REPLACED AND COULD POTENTIALLY DAMAGE THE ENGINE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS C…
Read full complaint
TL* THE CONTACT OWNS A 2010 BUICK ENCLAVE. WHEN THE CONTACT STARTED THE VEHICLE, IT STALLED AND WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN NEEDED TO BE REPLACED AND COULD POTENTIALLY DAMAGE THE ENGINE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND WAS UNABLE TO PROVIDE ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 136,636.
NHTSA ODI #11066499
Official recalls
6Oct 7, 2021
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.
Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration