SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2008 Buick Enclave

Owner reports · Recalls · Investigations

More warning signs than most Enclave years

Owner complaints for the 2008 Buick Enclave are substantially higher than the model-year median of 69.

About this comparison →
536Owner complaints

Model-year median: 69

6Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
536
2008220
2009275
2010212
2011
Compare all Enclave years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Power Train
139Air Bags
113Steering
99Structure
77Electrical System
73
All reported categories
Engine
72Unknown Or Other
37Electronic Stability Control (esc)
22Visibility
22Vehicle Speed Control
17Engine And Engine Cooling
14Suspension
11Service Brakes
10Visibility/wiper
10Seats
9Fuel/propulsion System
8Seat Belts
6Exterior Lighting
5Service Brakes, Hydraulic
5Traction Control System
5Wheels
4Equipment
3Equipment Adaptive/mobility
3Fuel System, Gasoline
2Chest Clip, Buckle, Harness
1Latches/locks/linkages
1Service Brakes, Air
1Tires
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

452 reports with mileage · 84 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 139 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 113 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Steering. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

13 crash reports10 fire reports18 injury reports

Power Train complaints

139 reports
Clear category filter
104,000 miles · Dec 7, 2016
EnginePower Train

AT 90K MILES VEHICLE HAD CHECK ENGINE LIGHT ALONG WITH WARNING FOR STABILITRAK AND TRACTION CONTROL. LATER THAT DAY THE VEHICLE SHOOK AND STALLED AT A RED LIGHT. THE BUICK DEALER IDENTIFIED TIMINIG CHAIN AND TIMING ACTUATOR AS ISSUES. THESE PARTS WERE REPLACED UNDER AN EXTENDED WARRANTY THAT WE PURCHASED. AT 104K MILES THE CHEC…

Read full complaint

AT 90K MILES VEHICLE HAD CHECK ENGINE LIGHT ALONG WITH WARNING FOR STABILITRAK AND TRACTION CONTROL. LATER THAT DAY THE VEHICLE SHOOK AND STALLED AT A RED LIGHT. THE BUICK DEALER IDENTIFIED TIMINIG CHAIN AND TIMING ACTUATOR AS ISSUES. THESE PARTS WERE REPLACED UNDER AN EXTENDED WARRANTY THAT WE PURCHASED. AT 104K MILES THE CHECK ENGINE LIGHT IS ON AGAIN; THE DEALER SAYS IT IS THE SAME TIMING CHAIN THAT NEEDS TO BE REPLACE. BUT THIS GM NOR THE DEALER CAN EXPLAIN WHY THE TIMING CHAIN FAILED AFTER ONLY 14K MILES OF USE. TIMING CHAIN APPEARS TO BE AN ISSUE ON 2008 ENCLAVE EVEN THOUGH GM HAS REFUSED TO COVER THEM. ALSO IT APPEARS THE REPLACEMENT PARTS ARE NOT ANY BETTER.

NHTSA ODI #10930353

116,000 miles · Dec 1, 2016
Power Train

TL* THE CONTACT OWNS A 2008 BUICK ENCLAVE. WHILE DRIVING APPROXIMATELY 40 MPH AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS A CRACK IN THE WAVE PLATE, WHICH NEEDED TO BE REPAIRED OR THE TRANSMISSION NEEDED TO BE REPLAC…

Read full complaint

TL* THE CONTACT OWNS A 2008 BUICK ENCLAVE. WHILE DRIVING APPROXIMATELY 40 MPH AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS A CRACK IN THE WAVE PLATE, WHICH NEEDED TO BE REPAIRED OR THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 116,000.

NHTSA ODI #10929421

108,039 miles · Sep 21, 2016
Power Train

I HAVE FINANCED THIS 2008 BUICK ENCLAVE, WHICH I GOT IN FEBRUARY 2016. LOVE THE CAR AND ALL THE SPACE IT HAS. THAT WAS UNTIL TODAY! THIS WEEK AS I WAS LEAVING THE CAR WOULDN'T SHIFT INTO REVERSE. ONCE I GOT IT INTO NEUTRAL I WAS ABLE TO BACK DOWN THE INCLINE FROM THE CARPORT TO THE STREET. IT DID SHIFT INTO DRIVE, BUT WOULD …

Read full complaint

I HAVE FINANCED THIS 2008 BUICK ENCLAVE, WHICH I GOT IN FEBRUARY 2016. LOVE THE CAR AND ALL THE SPACE IT HAS. THAT WAS UNTIL TODAY! THIS WEEK AS I WAS LEAVING THE CAR WOULDN'T SHIFT INTO REVERSE. ONCE I GOT IT INTO NEUTRAL I WAS ABLE TO BACK DOWN THE INCLINE FROM THE CARPORT TO THE STREET. IT DID SHIFT INTO DRIVE, BUT WOULD ONLY GO ABOUT 25 MPH ON A BUSY HIGHWAY AND STAYED IN FIRST THE WHOLE TIME. I CONTACTED THE LOCAL CHEVY/GM DEALER AND HE SAID TO BRING IT IN. I COULDN'T BECAUSE I WAS AT WORK. THIS MORNING THE DEALER CALLED AGAIN AFTER BEING ASKED TO BY MY HUSBAND AND SENT A TECHNICIAN TO MY HOME. THE TECH CHECKED IT AND WROTE SOME CODES DOWN AND WENT BACK TO THE DEALERSHIP. THE DEALER THEN CALLED AND SAID IF I COULD GET THE CAR TO HIM HE WOULD HAVE THE TECH CHECK THE FUSES AND RELAYS. HE CHECKED THE CODES HE HAD PULLED AND CHECKED ALL FUSES AND RELAYS AND SAID THAT I NEEDED TO CONTACT A TRANSMISSION SHOP BECAUSE THE COMPUTER WAS NOT TALKING TO THE TRANSMISSION. ALL OF THIS AFTER AN ALMOST HOUR TRIP TO DRIVE 8 MILES TO THE DEALERSHIP AND DRIVE THAT SAME 8 MILES BACK HOME BECAUSE WE KEPT HAVING TO STOP ON THE SIDE OF THE ROAD AND STOP THE ENGINE AND THEN RESTART IT AGAIN ON THAT SAME BUSY HIGHWAY. WE HAD SEVERAL NEAR MISSES (PEOPLE DRIVING THE 65 MILE SPEED LIMIT NEARLY REAR ENDING US). SURELY THERE IS SOMETHING THAT CAN BE DONE TO MAKE SURE THIS DOESN'T HAPPEN TO ANYONE ELSE!

NHTSA ODI #10908590

105,000 miles · Sep 21, 2016
Power Train

WAVEPLATE DEBRIS IN SILINOID CAR JERKS FROM PARK TO DRIVE DOESN'T SHIFT WELL AT ALL

NHTSA ODI #10908519

90,000 miles · Sep 16, 2016
EnginePower Train

TL* THE CONTACT OWNS A 2008 BUICK ENCLAVE. WHILE DRIVING 20 MPH, THE TRANSMISSION MALFUNCTIONED AND THE CHECK ENGINE INDICATOR ILLUMINATED. IN ADDITION, THE VEHICLE WAS STUCK AT 3,500 RPMS AND THE VEHICLE SMELLED OF SMOKE AND BURNT METAL. THE CONTACT PULLED OVER TO THE RIGHT SHOULDER OF THE ROAD AND STOPPED THE VEHICLE. THE CONT…

Read full complaint

TL* THE CONTACT OWNS A 2008 BUICK ENCLAVE. WHILE DRIVING 20 MPH, THE TRANSMISSION MALFUNCTIONED AND THE CHECK ENGINE INDICATOR ILLUMINATED. IN ADDITION, THE VEHICLE WAS STUCK AT 3,500 RPMS AND THE VEHICLE SMELLED OF SMOKE AND BURNT METAL. THE CONTACT PULLED OVER TO THE RIGHT SHOULDER OF THE ROAD AND STOPPED THE VEHICLE. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND DRIVE AWAY. THE VEHICLE WAS TAKEN TO A DEALER TO BE REPAIRED, BUT THE DEALER COULD NOT DUPLICATE THE FAILURE. A TRANSMISSION CONTROL MODULE WAS REPLACED BASED ON THE DIAGNOSTIC TEST. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

NHTSA ODI #10907144

93,600 miles · Jul 22, 2016
Power Train

THE BUICK DEALER IS SAYING THE TIMING CHAIN(S) IS SLIPPING AND NEEDS REPLACEMENT AND THAT THE HEADS AND OR CAMS MAY ALSO REQUIRE REPLACEMENT. THE VEHICLE WENT INTO THE SHOP BECAUSE THE 2ND AND 5TH GEAR WAS NOT ENGAGING PROPERLY, THERE IS HESITATION IN THE TRANSMISSION/ENGINE. THE VEHICLE HAS 94,710 MILES. THE POWERTRAIN WAR…

Read full complaint

THE BUICK DEALER IS SAYING THE TIMING CHAIN(S) IS SLIPPING AND NEEDS REPLACEMENT AND THAT THE HEADS AND OR CAMS MAY ALSO REQUIRE REPLACEMENT. THE VEHICLE WENT INTO THE SHOP BECAUSE THE 2ND AND 5TH GEAR WAS NOT ENGAGING PROPERLY, THERE IS HESITATION IN THE TRANSMISSION/ENGINE. THE VEHICLE HAS 94,710 MILES. THE POWERTRAIN WARRANTY IS 5 YEARS OR 100,000 MILES. GM ISSUED AN EXTENDED WARRANTIES OF 10 YEARS AND 120,000 MILES FOR BOTH TRANSMISSION CLUTCH WAVE PLATE (3/5/R) AND FOR TIMING CHAIN SLIPPAGE. SO THEY ACKNOWLEDGE THEY HAVE THESE PROBLEMS WITH THE MATERIAL USED AND OR ENGINES. MY CONCERN IS THAT FOR THE TIMING CHAIN EXTENDED WARRANTY GM SKIPPED THE BUICK ENCLAVE 2008 YEAR MODEL AND COVER ONLY THE 2007 & 2009 YEAR MODELS AND THEY DO NOT WANT TO EXTEND THE COVERAGE TO COVER MY TIMING CHAIN REPLACEMENT. THIS IS NOT A NORMAL ROUTINE SERVICE ITEM PER THEIR BUICK ENCLAVE USER MANUAL. TIMING CHAIN SHOULD BE COVERED UNDER THE POWERTRAIN WARRANTY. I SHOULD NOT HAVE TO PAY FOR REPLACING THE TIMING CHAIN ON A VEHICLE WITH UNDER 100,000 MILES BECAUSE GM USED POORLY MANUFACTURED CHAINS. USUALLY METAL TIMING CHAINS LAST WELL BEYOND 100,000 MILES. I'VE NEVER REPLACED A CHAIN ON ANY OF MY VEHICLES PAST OR PRESENT. THIS IS A KNOWN DEFECT WITH THE GM TIMING CHAINS WHICH SHOULD BE COVERED. IF THE TIMING CHAINS BREAKS IT WILL CAUSE TREMENDOUS DAMAGE AND MAY CAUSE ME TO GET INTO A CATASTROPHIC ACCIDENT. THE DIAGNOSTIC CODES PROVIDED BY THE DEALER ARE AS FOLLOWS: P0011 INTAKE CMP B1 P0391 EXHAUST CMP B2 P0366 EXHAUST CMP B1 CHAINS NOISY DIAG DOC 08-06-01-011K REPAIR COST RANGE: $2,577 + TAX TO $5,231 +TAX DEPENDING ON WHETHER HEADS AND OR CAMS REQUIRE REPLACEMENT.

NHTSA ODI #10887856

77,827 miles · Jun 9, 2016
Power Train

TL* THE CONTACT OWNS A 2008 BUICK ENCLAVE. WHILE DRIVING 50 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. WHILE AT A STOP SIGN, THE FAILURE RECURRED. THE VEHICLE HAD TO BE SHIFTED INTO DIFFERENT GEARS FOR THE VEHICLE TO ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT …

Read full complaint

TL* THE CONTACT OWNS A 2008 BUICK ENCLAVE. WHILE DRIVING 50 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. WHILE AT A STOP SIGN, THE FAILURE RECURRED. THE VEHICLE HAD TO BE SHIFTED INTO DIFFERENT GEARS FOR THE VEHICLE TO ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,827.

NHTSA ODI #10873492

148,000 miles · Mar 5, 2016
EnginePower Train

MY 2008 BUICK ENCLAVE HAD THE TRANSMISSION GO OUT AT AT 135,000 AS WE WERE TRAVELING HOME FROM MY PARENTS HOUSE AND LEFT US STRANDED ABOUT 60 MILES FROM HOME. AFTER THIS HAPPENED I LOOKED ONLINE AND SEEN THAT THIS HAS BEEN A PROBLEM FOR OTHERS AS WELL. NOW AT 148,000 THE TIMING CHAIN IS STRETCHED AND CAUSED THE STABILITRACK AN…

Read full complaint

MY 2008 BUICK ENCLAVE HAD THE TRANSMISSION GO OUT AT AT 135,000 AS WE WERE TRAVELING HOME FROM MY PARENTS HOUSE AND LEFT US STRANDED ABOUT 60 MILES FROM HOME. AFTER THIS HAPPENED I LOOKED ONLINE AND SEEN THAT THIS HAS BEEN A PROBLEM FOR OTHERS AS WELL. NOW AT 148,000 THE TIMING CHAIN IS STRETCHED AND CAUSED THE STABILITRACK AND TRACTION CONTROL WARNING TO COME ON AND OFF, EVEN THOUGH THERE WAS NOTHING WRONG WITH THE TRACTION CONTROL. THIS CAUSES THE TRACTION CONTROL TO STOP WORKING WHEN IT IS FEBURARY IN MINNESOTA AND STILL HAVE SNOW AND ICE.

NHTSA ODI #10840055

105,000 miles · Mar 2, 2016
Power Train

TL* THE CONTACT OWNS A 2008 BUICK ENCLAVE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT SWITCH GEARS BEYOND THE SECOND GEAR AND WOULD NOT ACCELERATE BEYOND 30 MPH. IT WAS DIAGNOSED THAT THE WAVE PLATE INSIDE THE TRANSMISSION HAD MALFUNCTIONED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 105,000.

NHTSA ODI #10839531

124,276 miles · Jan 18, 2016
Power Train

WHILE TRAVELING ON A FLORIDA INTERSTATE AT EXPRESS WAY SPEEDS, THE TRANSMISSION JUST QUIT FUNCTIONING. I HAD JUST GONE OVER THE TOP OF A BRIDGE, LET UP ON THE THROTTLE, THAN PRESSED DOWN AGAIN TO MAINTAIN SPEED. THE ENGINE INCREASED RPM'S BUT I CONTINUED TO SLOW DOWN. THIS WAS WITH HEAVY TRAFFIC ON MY SIDE AND BEHIND ME. WHE…

Read full complaint

WHILE TRAVELING ON A FLORIDA INTERSTATE AT EXPRESS WAY SPEEDS, THE TRANSMISSION JUST QUIT FUNCTIONING. I HAD JUST GONE OVER THE TOP OF A BRIDGE, LET UP ON THE THROTTLE, THAN PRESSED DOWN AGAIN TO MAINTAIN SPEED. THE ENGINE INCREASED RPM'S BUT I CONTINUED TO SLOW DOWN. THIS WAS WITH HEAVY TRAFFIC ON MY SIDE AND BEHIND ME. WHEN I FOUND ROOM ENOUGH TO PULL OVER, I HAD SLOWED CONSIDERABLY CAUSING TRAFFIC TO SWERVE AROUND ME AND CAUSED PANIC BRAKING ON THEIR PART. BUICK MOTOR HAS A NOTICE OUT SAYING THEY WILL REPAIR AT NO CHARGE FOR 10 YEARS, OR 120,000 MILES. I HAD 124,276 MILES AND THEY HAVE REFUSED TO REIMBURSE ME. I CONSIDER THIS FEATURE TO BE A SAFETY ISSUE, AS THERE COULD HAVE BEEN A VERY SERIOUS ACCIDENT BECAUSE I NO LONGER HAD ANY CONTROL IN ORDER TO GET OUT OF THE WAY. IF THIS WERE TO HAPPEN ON A MULTILANE EXPRESS WAY, AND YOU WERE IN ONE OF THE CENTER LANES WITH HEAVY TRAFFIC, THE RESULT COULD VERY EASILY BE ACCIDENT/DEATH. I BELIEVE BUICK SHOULD BE FORCED TO RECALL BEFORE SERIOUS THINGS HAPPEN. THEY SHOULD ALSO BE FORCED TO PAY FOR THOSE THAT HAVE ALREADY HAD THE WORK DONE.

NHTSA ODI #10820773

Official recalls

6

21V782000 · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module

Oct 7, 2021

General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.

Air Bags:frontal

General Motors, LLC (GM) is recalling certain 2008-2017 Buick Enclave and 2013-2017 Chevrolet Traverse vehicles. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Dealers will replace the driver's air bag module, free of charge. Interim owner notification letters were mailed on November 3, 2021. Owner notification letters were mailed on January 10, 2022. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212349040.

15V415000 · Structure:body:hatchback/liftgate

Jun 30, 2015

General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.

Consequence & remedy

Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.

Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

14V118000 · Air Bags:side/window

Mar 17, 2014

General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.

Consequence & remedy

Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.

Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.

10V240000 · Electrical System

Jun 4, 2010

GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.

Consequence & remedy

Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.

Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

08V441000 · Electrical System

Aug 28, 2008

GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.

Consequence & remedy

Consequence: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

08V410000 · Visibility:windshield Wiper/washer:linkages

Aug 14, 2008

GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA08010 · NON-CRASH Engine Compartment Fires

Opened Jun 12, 2008 · Closed Sep 8, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Engine And Engine Cooling; Engine And Engine Cooling:engine; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Additional source detail variants (9)

Electrical SYSTEM:12V/24V/48V Battery

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring:front Underhood

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring:fuses And Circuit Breakers

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Electrical System:wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Engine And Engine Cooling:engine

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Engine And Engine Cooling

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Visibility:windshield Wiper/washer

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

Visibility:windshield Wiper/washer:switch/wiring

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.