ENGINE INJECTOR FAILURE. *BF THE CONSUMER HAS 5 INJECTORS ON THE VEHICLE AND SO FAR ONLY 1 HAS FAILED. THE CONSUMER BELIEVED THAT EVENTUALLY THE REMAINING INJECTORS WILL HAVE TO REPLACED. THE CONSUMER THE MANUFACTURER KNEW ABOUT THE PROBLEM FOR YEARS AS FAR AS 1994. THE INJECTOR PROBLEM HAS CAUSED ANOTHER SAFETY ISSUE SUCH …
Read full complaint
ENGINE INJECTOR FAILURE. *BF THE CONSUMER HAS 5 INJECTORS ON THE VEHICLE AND SO FAR ONLY 1 HAS FAILED. THE CONSUMER BELIEVED THAT EVENTUALLY THE REMAINING INJECTORS WILL HAVE TO REPLACED. THE CONSUMER THE MANUFACTURER KNEW ABOUT THE PROBLEM FOR YEARS AS FAR AS 1994. THE INJECTOR PROBLEM HAS CAUSED ANOTHER SAFETY ISSUE SUCH AS ENGINE HESITATION WHEN THE GAS PEDAL WAS DEPRESSED AND THE ENGINE DOES NOT WANT TO MOVE FOR A NUMBER OF SECONDS UNTIL THE PEDAL IS ALMOST FLOORED. *JB
NHTSA ODI #10096884
Mileage unknown · May 27, 2003
Fuel System, Gasoline
FUEL IS LEAKING UNDER THE VEHICLE. PLEASE PROVIDE DETAILS.*AK
NHTSA ODI #10021578
Mileage unknown · Oct 7, 1999
Fuel System, Gasoline
THE VEHICLE HAS A LEAKING HIGH PRESSURE FUEL LINE . THE DEALER HAS BEEN NOTIFIED. *AK
NHTSA ODI #850164
Mileage unknown · Nov 8, 1996
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
ENGINE LOOSES POWER, REPLACE SEVERAL PARTS, PROM AND VAC HOSE/INJECTOR.
THESE VEHICLES WERE ASSEMBLED WITH REAR OUTBOARD SAFETY BELT ANCHORAGES THAT MAY NOT WITHSTAND THE REQUIRED LOAD. THIS DOES NOT COMPLY WITH FMVSS NO.210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN A COLLISON, STRESS CAN CAUSE THE ATTACHMENT METAL TO TEAR AND ALLOW THE ANCHORAGE TO SEPARATE FROM THE BODY OF THE VEHICLE. THE SAFETY BELT MAY NOT PROTECT AN OCCUPANT IN THE EVENT OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE EXISTING ANCHOR BOLTS WITH A NEW SHOULDER BOLT AND THREAD LOCKING ADHESIVE. ADDITIONALLY, NOISE CONTROL PATCHES WILL BE APPLIED AT EACH ANCHORAGE.
THE RIGHT HAND SPINDLE NUT WAS NOT PROPERLY TIGHTENED DURING ASSEMBLY. THIS CAN CAUSE PREMATURE WHEEL BEARING FAILURE AND OVER TIME, THE SPINDLE CAN FRACTURE.
Consequence & remedy
Consequence: THIS WOULD CAUSE THE WHEEL TO SEPARATE FROM THE AXLE AND RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE TORQUE ON THE RIGHT HAND FRONT SPINDLE NUT. IF THE SPINDLE NUT IS UNDERTORQUED THE DEALER WILL REPLACE THE RIGHT HAND FRONT WHEEL BEARING ASSEMBLY AND THE SPINDLE NUT WILL BE REPLACED.
WATER INTRUSION CAN CAUSE A SHORT CIRCUIT IN THE POWER DOOR LOCK ASSEMBLY.
Consequence & remedy
Consequence: A SHORT CIRCUIT IN THE POWER DOOR LOCK ASSEMBLY CAN RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE POWER DOOR LOCK RELAY AND ANY CORRODED TERMINALS. IN ADDITION, THE NEW RELAY WILL BE RELOCATED TO AN AREA WHERE WATER INTRUSION IS LESS LIKELY.
IN THE EVENT OF A PRIMARY ACCELERATOR CONTROL SPRING FAILURE, THE SECONDARY (BACK-UP) ACCELERATOR CONTROL RETURN SPRING WILL NOT RETURN THE THROTTLE TO THE FULLY CLOSED POSITION, AS REQUIRED BY FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEM."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: LOSS OF THROTTLE CONTROL COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE SECONDARY THROTTLE RETURN SPRING.
DURING ASSEMBLY, WATER MAY HAVE ENTERED THE ACCELERATOR CONTROL CABLE CONDUIT CAUSING IT TO DEVELOP A HIGH EFFORT AND/OR BINDING CONDITION IN VERY COLD WEATHER.
Consequence & remedy
Consequence: HIGH EFFORT OR BINDING CONDITIONS CAUSE LOSS OF NORMALTHROTTLE CONTROL OR THE THROTTLE MAY NOT RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED. IF THIS WERE TO OCCUR WHILE THE VEHICLE IS IN MOTION, A VEHICLE CRASH COULD OCCUR.
Remedy: THE DEALER WILL PURGE THE THROTTLE CABLE OF ANY INTERNALLY TRAPPED WATER, IF IT IS PRESENT.
THE CRUISE CONTROL CABLE MAY SEPARATE FROM THE CONDUIT END FITTING WHILE ENGAGED AND ACCELERATOR CONTROL COULD BE LOST.
Consequence & remedy
Consequence: LOSS OF ACCELERATOR CONTROL MAY NOT REDUCE ENGINE SPEEDTO A LEVEL ANTICIPATED BY THE DRIVER. ALTHOUGH THE VEHICLE CAN STILL BE STOPPEDWITH THE SERVICE BRAKE, LOSS OF ACCELERATOR CONTROL COULD RESULT IN A VEHICLECRASH WITHOUT PRIOR WARNING.
Remedy: REPLACE THE CRUISE CONTROL CABLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1994 Buick Century Problems, Complaints & Recalls | Skip That Year
Illustration