SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2004 Buell XB12S

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
7Owner complaints

Model-year median: 3

1Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
7
20040
20053
2006
Compare all XB12S years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Exterior Lighting
5Electrical System
2

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 5 of 7 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Electrical System complaints

2 reports
Clear category filter
22,000 miles · Jul 21, 2006
Electrical System

WHILE RIDING MY 2004 BUELL XB12S MOTORCYCLE THOUGH THE ASM AMERICA, INC. PARKING LOT (3440 EAST UNIVERSITY DRIVE PHOENIX AZ 85034) AT APPROXIMATELY 11:00 AM THE ON 07-19-06 THE FOLLOWING OCCURRED. THE MOTORCYCLE LOST ALL POWER AND I COASTED TO A STOP INTO A PARKING SPOT: 1.RIDING THROUGH THE PARKING LOT AT ABOUT 5-10 MPH. 2…

Read full complaint

WHILE RIDING MY 2004 BUELL XB12S MOTORCYCLE THOUGH THE ASM AMERICA, INC. PARKING LOT (3440 EAST UNIVERSITY DRIVE PHOENIX AZ 85034) AT APPROXIMATELY 11:00 AM THE ON 07-19-06 THE FOLLOWING OCCURRED. THE MOTORCYCLE LOST ALL POWER AND I COASTED TO A STOP INTO A PARKING SPOT: 1.RIDING THROUGH THE PARKING LOT AT ABOUT 5-10 MPH. 2.THE MOTORCYCLE ENGINE STOPPED RUNNING. 3.THE MOTORCYCLE ELECTRICAL SYSTEM COMPLETELY FAILED AS IF THE MOTORCYCLE HAS BEEN TURNED OFF INCLUDING LOSS OF HORN, TURN SIGNALS, BRAKE LIGHTS, LICENSE PLATE LIGHT, REAR TAIL LIGHT, HEAD LIGHT, INSTRUMENT LIGHTS, WARNING LIGHTS, SPEEDOMETER AND TACHOMETER. 4.IF I HAD BEEN MERGING ONTO THE FREEWAY AT NIGHT I PROBABLY WOULD HAVE BEEN KILLED AS I WOULD HAVE HAD NO WAY TO SIGNAL I WAS LEAVING THE HIGHWAY! THE DEALER IS STILL INVESTIGATING WHY THE VEHICLE STOPPED RUNNING.

NHTSA ODI #10163064

Mileage unknown · Mar 5, 2004
Electrical System

I AM REPORTING A POTENTIALLY HAZARDOUS PROBLEM WITH MY 2004 BUELL XB12S MOTORCYCLE. I HAVE OBSERVED THIS SAME SITUATION ON ALL SIMILAR BIKES THAT I HAVE LOOKED AT. UNDER THE SEAT, THE ECM CABLE HARNESS RESTS AGAINST THE NEGATIVE BATTERY TERMINAL AND THERE ARE SIGNS OF ABRASION FROM VIBRATION.*AK

NHTSA ODI #10060544

Official recalls

1

03V494000 · Electrical System:horn

Dec 2, 2003

ON CERTAIN MOTORCYCLES, THE WIRE THAT PROVIDES POWER TO THE HORN, DUE TO MISROUTING, CAN BECOME FRAYED FROM CONTACT WITH THE HORN BRACKET MOUNTING BOLT. AS A RESULT, THE HORN WIRE MAY BECOME EXPOSED, AND WHEN THE HORN BUTTON IS PUSHED, EITHER THE HORN CIRCUIT FUSE OR THE KEY SWITCH FUSE CAN BLOW.

Consequence & remedy

Consequence: IF THE KEY SWITCH FUSE BLOWS, THE VEHICLE CAN STALL, WHICH COULD RESULT IN A CRASH. IF THE HORN FUSE BLOWS, THERE WILL BE A LOSS OF POWER TO THE HORN AND REAR BRAKE LIGHT.

Remedy: DEALERS WILL INSPECT AND CORRECT THE WIRE ROUTING, IF NECESSARY. OWNER NOTIFICATION BEGAN ON DECEMBER 23, 2003. OWNERS SHOULD CONTACT BUELL AT 1-414-342-4680.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.