Steering. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports2 fire reports1 injury reports

Exterior Lighting complaints

2 reports

Clear category filter

82,976 miles · Jul 21, 2015

Exterior Lighting

Read full complaint

DRIVER SIDE LOW BEAM HEADLIGHT QUIT WORKING WHEN IGNITION WAS TURNED ON. HEADLIGHT WAS WORKING FINE WHEN THE VEHICLE WAS PARKED. BLOWN LIGHT INDICATOR ON INSTRUMENT CLUSTER APPEARED. WHEN CHANGING OUT THE LIGHT I DISCOVERED ALL THE WIRES INSIDE THE HEADLIGHT ENCLOSURE WERE DAMAGED DUE TO HEAT. ALL OF THE WIRES INSULATION WAS DRY ROTTED , SECTIONS OF THE INSULATION BROKEN OFF OF THE WIRES AND SHORTED OUT TOGETHER. I HAVE MANY YEARS OF VEHICLE WIRING TROUBLESHOOTING AND DESIGN. THE WIRES IN THE HEADLIGHTS DO NOT HAVE THE APPROPRIATE JACKET RATING FOR THE HEADLIGHT LOCATION WHERE THEY WERE INSTALLED BY BMW. I BELIEVE THE HEAT FROM THE HEADLIGHTS DRIED OUT AND MADE THE WIRE JACKET BRITTLE. AFTER INVESTIGATION OF THE LEFT HEADLIGHT HOUSING BOTH HEADLIGHTS REQUIRE THE INTERNAL HARNESS OF EACH HEADLIGHT TO BE REPLACED DUE TO HEAT AND DRY ROT. THE SHORTING OF THE WIRES ONLY BLEW MY HEADLIGHT BULB AND NOT THE FUSE IN THE SYSTEM. THIS COULD BE THE REASON FOR THE OTHER PERSONS COMPLAINED ABOUT THEIR HEADLIGHTS TURNING ON AND OFF WHILE DRIVING. IF LEFT UNCHECKED THIS COULD CAUSE OTHER PROBLEMS IN THE CARS ELECTRICAL SYSTEM AND BE DANGEROUS IF THE LIGHTS SHORTED OUT DURING A NIGHT DRIVE.

NHTSA ODI #10735607

49,000 miles · Jun 21, 2013

Exterior Lighting

TL* THE CONTACT OWNS A 2007 BMW Z4. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS WOULD FLICKER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 49,000. *TR

NHTSA ODI #10521087

Official recalls

22V119000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Mar 2, 2022

BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Consequence & remedy

Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.

Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.

17V683000 · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Oct 30, 2017

BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Consequence & remedy

Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.

Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.