2006 BMW Z4

THE CONVERTIBLE TOP FAILED 2011/30229 MILES, STILL UNDER CPO WARRANTY. THE DEALERSHIP ONLY TOPPED OFF THE HYDRAULIC FLUID AND CLAIMED NO LEAK FOUND. IT FAILED AGAIN 2014/45809 MILES. THIS TIME SEALS WERE REPLACED AND HYDRAULIC LINES. GOODWILL REPAIR WITH 50% OUT OF POCKET. IT FAILED AGAIN EARLIER THIS YEAR 2018/62112 MILES. THIS TIME I WAS QUOTED $2,938 TO $3,658. I HAD IT DIAGNOSED IN MAY AND WAS WAITING FOR AN ANSWER OF THE SERVICE MANAGER ABOUT BMW ASSISTING WITH THE REPAIR AND HAD NOT HEARD BACK. I INQUIRED AGAIN TWO DAYS AGO AND GOT A REPLY THAT BMW WOULD NOT PICK UP ANY OF THE REPAIR COST. IT APPEARS THAT IT WAS A SLOWLY DEVELOPING DEFECT. WHERE WOULD HAVE THE FLUID HAVE GONE AT THE FIRST REPAIR? ALSO DOING SOME RESEARCH TURNED UP A LOT OF THE SAME TROUBLE FOR OTHER OWNERS. APPARENTLY IT IS A DESIGN FLAW. WATER NOT DRAINING BECAUSE OF CLOGGING AND CONSEQUENTLY CAUSING DAMAGE TO THE HYDRAULIC SYSTEM.

STEERING IS EXTREMELY NOTCHY AND UNPREDICTABLE, ESPECIALLY ON HOT DAYS. WHEN IN MOTION, THE STEERING WHEEL REQUIRES FORCE TO TURN, AND SOMETIMES WILL TURN SLIGHTLY WITHOUT DRIVER INPUT. IT APPEARS THAT THE POWER ASSIST STEERING IS ACTUATING WHEN IT SHOULD NOT BE, CAUSING EITHER RESISTANCE TO STEERING INPUTS, OR APPLYING FORCE WHEN NO STEERING INPUT HAS BEEN APPLIED. WHEN THE ENGINE IS NOT RUNNING, OR AT VERY SLOW SPEEDS, NOISE CAN BE HEARD FROM THE POWER ASSIST MOTOR. IT ACTUATES WHEN NO STEERING INPUTS ARE BEING APPLIED. WHEN STEERING INPUTS ARE APPLIED, TOO MUCH RESISTANCE CAN BE FELT AND THE MOTOR MAKES ADDITIONAL NOISES. I PURCHASED THE CAR IN FEBRUARY OF 2016, AND THIS HAS BEEN HAPPENING SINCE APPROXIMATELY SPRING OF 2016. IT HAS BEEN GETTING PROGRESSIVELY WORSE.

DURING WEATHER ABOVE 80 DEGREES, THE STEERING BECOMES "TWITCHY" OR "NOTCHY," NO LONGER SMOOTH, BUT REQUIRING ADDITIONAL EFFORT TO TURN THE STEERING WHEEL, AT WHICH POINT, THE TIRES MOVE MORE THAN NEEDED, REQUIRING A STEERING ADJUSTMENT THE OPPOSITE DIRECTION. AT THE SAME TIME, THE CAR DOES NOT HOLD A "LINE" AS WELL, REQUIRING A SERIES OF SMALL LEFT AND RIGHT STEERING CORRECTIONS.

ON WARM DAYS THE STEERING ON MY 2006 BMW Z4 BECOMES UNRESPONSIVE AND UNPREDICTABLE. ON HOT DAYS IT IS DOWNRIGHT DANGEROUS. I HAVE READ IN MANY PLACES THAT THIS IS DUE TO A DESIGN DEFECT IN THE STEERING COLUMN. ONE SOURCE WHO IS AN ASE-CERTIFIED MASTER TECHNICIAN SAYS THAT THE "BMW Z4 STICKY STEERING IS RELATED TO A MANUFACTURING DEFECT, THAT HAS BEEN RECTIFIED AS OF 2007 AND UP. THERE IS A BEARING LOCATED IN THE MIDDLE OF THE STEERING COLUMN THAT IS NOT SEALED. WITH TIME AND WHEN HOT, THE LUBRICANT GETS DRY AND GUMS UP. TO MAKE MATTERS WORSE, THERE IS NOT A RACE FOR THE BEARING TO RIDE IN ' THE INNER RACE IS ACTUALLY THE STEERING SHAFT ITSELF, WHICH IS A POOR DESIGN". MY VEHICLE WAS BUILT IN 2006 AND HAS ONLY 54,000 MILES ON IT. BMW APPARENTLY WAS AWARE OF THIS PROBLEM AND CORRECTED IT THE FOLLOWING MODEL YEAR. THERE ARE MANY COMPLAINTS ON THE NHTSA WEBSITE ABOUT THE SAME PROBLEM, WHICH COULD GET WORSE OVER TIME. BMW SHOULD ISSUE A RECALL BEFORE SOMEONE GETS SERIOUSLY HURT.

TL* THE CONTACT OWNS A 2006 BMW Z4. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOISED THAT THE OCCUPANT PROTECTION MAT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REAPIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 13V564000 (AIR BAGS). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

MY CAR HAD APPROXIMATELY 65K MILES ON IT WHEN THE LIGHT ON THE DASHBOARD INDICATED AN ISSUE. IT WAS MANUFACTURED IN 08/06. READING FROM THE COMPUTER INDICATED A PASSENGER OCCUPANCY MAT FAILURE. BMW EXTENDED THE WARRANTY FOR 10 YEARS THROUGH MODEL YEAR 05 BUT WON'T DO ANYTHING FOR 2006. I CALLED BMW USA AND ESCALATED IT. THEY CALLED ME BACK AND STATED IT WILL NOT BE COVERED. I AM CONCERNED THAT THIS MAY PREVENT THE AIRBAG FROM OPERATING IN CASE OF A COLLISION FOR THE PASSENGER. THERE ARE MANY COMPLAINTS ABOUT THE 2006 MODEL OCCUPANCY MAT WITH THIS MY AND I THINK BMW SHOULD BE FORCED TO COVER THIS SAFETY HAZARD. THE CAR WAS PURCHASED FROM BMW DEALER AS A PRE-OWNED CERTIFIED CAR UNDER FULL WARRANTY. THE DEALER WOULD NOT ADDRESS REPAIRS UNDER THE CURRENT RECALLS. THIS SHOULD BE COVERED THE SAME WAY AS PREVIOUS MODEL YEAR Z4 VEHICLES. ACCORDING TO RECALL 13V-564 THIS SHOULD BE COVERED BUT BMW SAYS NO! HTTP://WWW-ODI.NHTSA.DOT.GOV/OWNERS/SEARCHRESULTS?REFURL=EMAIL&SEARCHTYPE=ID&TARGETCATEGORY=R&SEARCHCRITERIA.NHTSA_IDS=13V564