NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
411 reports105,000 miles · Sep 10, 2014
Steering
THE STEERING ON THIS VEHICLE SEEMS TO STICK AT TIMES AND YOU HAVE TO JERK IT BACK TO CENTER TO KEEP IT IN LINE ON THE ROAD. ONCE IT STARTS, IT HAPPENS ALL THE TIME. I AM REAL CONCERNED ABOUT THE SAFETY OF DRIVING SINCE IT IS HARD SOMETIMES TO JERK IT BACK IN LINE OR STRAIGHT. THIS HAS BEEN HAPPENING FOR MANY MONTHS NOW AND I A…
Read full complaint
THE STEERING ON THIS VEHICLE SEEMS TO STICK AT TIMES AND YOU HAVE TO JERK IT BACK TO CENTER TO KEEP IT IN LINE ON THE ROAD. ONCE IT STARTS, IT HAPPENS ALL THE TIME. I AM REAL CONCERNED ABOUT THE SAFETY OF DRIVING SINCE IT IS HARD SOMETIMES TO JERK IT BACK IN LINE OR STRAIGHT. THIS HAS BEEN HAPPENING FOR MANY MONTHS NOW AND I AM VERY CONCERNED AND DON'T DRIVE IT AS MUCH NOW. *TR
NHTSA ODI #10632339
20,000 miles · Sep 9, 2014
Electrical SystemSteering
TL* THE CONTACT OWNS A 2004 BMW Z4. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE FAILURE OCCURRED SEVERAL TIMES. THE DEALER DETERMINED THAT THE VEHICLE EXPERIENCED AN ELECTRICAL FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2004 BMW Z4. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE FAILURE OCCURRED SEVERAL TIMES. THE DEALER DETERMINED THAT THE VEHICLE EXPERIENCED AN ELECTRICAL FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000. UPDATED 10/07/14*LJ UPDATED 3/23/2015 *JS
NHTSA ODI #10631969
19,000 miles · Sep 5, 2014
Steering
STEERING STICKS WHEN TEMPERATURE IS WARM. WHEN DRIVING HAVE TO PULL STEERING BACK TO CENTER WHEN STEERING EITHER LEFT OR RIGHT. USUALLY OCCURS ONCE TEMP IS ABOVE 75 DEGREES. DIFFICULT TO KEEP CAR ON ROAD, HAVE HAD MULTIPLE INSTANCES WHEN ALMOST WENT OFF THE ROAD. EXTREMELY DANGEROUS AND HAVE LIMITED MY DRIVING OF THIS VEHICLE DU…
Read full complaint
STEERING STICKS WHEN TEMPERATURE IS WARM. WHEN DRIVING HAVE TO PULL STEERING BACK TO CENTER WHEN STEERING EITHER LEFT OR RIGHT. USUALLY OCCURS ONCE TEMP IS ABOVE 75 DEGREES. DIFFICULT TO KEEP CAR ON ROAD, HAVE HAD MULTIPLE INSTANCES WHEN ALMOST WENT OFF THE ROAD. EXTREMELY DANGEROUS AND HAVE LIMITED MY DRIVING OF THIS VEHICLE DUE TO THE DANGER. *TR
NHTSA ODI #10630949
125,000 miles · Aug 4, 2014
Steering
WHILE DRIVING MY CAR I LOST CONTROL OF THE POWER STEERING AND IT FELT LIKE MY STEERING LOCKED. I WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD. I TURNED OFF THE CAR AND WAITED A BIT AFTER CHECKING UNDER THE HOOD TO SEE THAT I HAD GOOD POWER STEERING FLUID AND THE BELTS WERE GOOD. I TURNED ON THE CAR AGAIN AND STILL HAD NO POW…
Read full complaint
WHILE DRIVING MY CAR I LOST CONTROL OF THE POWER STEERING AND IT FELT LIKE MY STEERING LOCKED. I WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD. I TURNED OFF THE CAR AND WAITED A BIT AFTER CHECKING UNDER THE HOOD TO SEE THAT I HAD GOOD POWER STEERING FLUID AND THE BELTS WERE GOOD. I TURNED ON THE CAR AGAIN AND STILL HAD NO POWER STEERING. SINCE I WAS NOT FAR FROM HOME I CAREFULLY DROVE HOME FIGHTING MY STEERING ALL THE WAY. I CALLED MY LOCAL BMW DEALER THE FOLLOWING DAY AND THEY SAID THEY WERE AWARE OF THE ISSUE AND THE REPAIR WAS EXTREMELY COSTLY. I DID NOT REALIZE HOW AWARE THEY WERE UNTIL I FURTHER RESEARCHED THE ISSUE ON THE INTERNET AND WAS TOTALLY SHOCKED TO SEE HUNDREDS OF COMPLAINTS CONCERNING THE SAME EXACT ISSUE. COMPLAINTS THAT HAVE BEEN GOING ON FOR YEARS. I SAW REPORTS OF MULTIPLE ACCIDENTS. I CAN NOT BELIEVE THAT A RECALL WAS NEVER ISSUED ON THIS ITEM. IT IS ABSOLUTELY MIND BOGGLING THAT SUCH A DEFECT IS LEFT TO THE CONSUMER TO PAY WHEN IT IS CLEARLY A MANUFACTURER'S DEFECT. DOES A DEATH HAVE TO INCUR FOR A RECALL? AREN'T PREVENTATIVE MEASURES JUST AS IMPORTANT FROM THE NHTSA TO HELP AVOID FUTURE ACCIDENTS AND POSSIBLE INJURIES? *TR
NHTSA ODI #10618602
14,000 miles · Jul 29, 2014
Steering
THE STEERING WHEEL "STICKS" AT VARIOUS AND UNPREDICTABLE TIMES. IT WILL STICK AND RESIST GOING INTO A CURVE, THEN HOLD THE CAR IN THE CURVE AND NEED TO BE UNSTUCK TO BRING THE CAR OUT OF THE CURVE. THE STICKING IS NOT EXAGGERATED OR IMPOSSIBLE TO CORRECT, BUT SOME SMALL AMOUNT OF PRESSURE IS REQUIRED TO UNSTICK THE WHEEL FROM …
Read full complaint
THE STEERING WHEEL "STICKS" AT VARIOUS AND UNPREDICTABLE TIMES. IT WILL STICK AND RESIST GOING INTO A CURVE, THEN HOLD THE CAR IN THE CURVE AND NEED TO BE UNSTUCK TO BRING THE CAR OUT OF THE CURVE. THE STICKING IS NOT EXAGGERATED OR IMPOSSIBLE TO CORRECT, BUT SOME SMALL AMOUNT OF PRESSURE IS REQUIRED TO UNSTICK THE WHEEL FROM ITS DIRECTIONAL COURSE. BECAUSE IT HAPPENS AT UNPREDICTABLE TIMES IT IS UNSETTLING AND FEELS VERY UNSAFE ON CURVES OR WHEN MAKING LANE CHANGES. I'VE BROUGHT THE PROBLEM TO THE ATTENTION OF THE BMW DEALERSHIP ON SEVERAL OCCASIONS BUT THEY CLAIMED THEY COULDN'T DUPLICATE THE PROBLEM ON SEVERAL VISITS. ON THE MOST RECENT VISIT THE DEALERSHIP CONCEDED THE FAULTY STEERING COLUMN, BUT ARGUES THAT THE AGE OF THE VEHICLE MAKES IT INELIGIBLE FOR WARRANTY COVERAGE. I BELIEVE THAT FAULTY STEERING COLUMNS ARE A DOCUMENTED PROBLEM ON Z4 ROADSTERS FROM 2003 - 2005. THE CAR CURRENTLY HAS 22,500 MILES ON IT. CLASSIFYING THE PROBLEM AS RESULTING FROM AGE OR WEAR IS IRRESPONSIBLE. THE STEERING COLUMN WAS DESIGNED OR MANUFACTURED WITH THIS FAULT, AND BMW SHOULD CORRECT THE PROBLEM AT ITS EXPENSE BEFORE NEEDING TO RECORD ACCIDENTS OR INJURIES. *JS
NHTSA ODI #10617317
97,684 miles · Jul 22, 2014
Air Bags
MY PASSENGER-SIDE AIRBAG LITERALLY "EXPLODED" AS I WAS WALKING UP TO MY CAR THIS MORNING. OF COURSE, I DIDN'T REALIZE THAT WAS WHAT IT WAS UNTIL I UNLOCKED MY CAR AND OPENED THE DOOR. THE AIRBAG WAS EXPOSED AND THERE WAS "SMOKE" IN THE CAR. IT APPEARS WHAT HAPPENED IS THE EXACT REASON GIVEN FOR RECALLING THE 3 SERIES VEHICLES DU…
Read full complaint
MY PASSENGER-SIDE AIRBAG LITERALLY "EXPLODED" AS I WAS WALKING UP TO MY CAR THIS MORNING. OF COURSE, I DIDN'T REALIZE THAT WAS WHAT IT WAS UNTIL I UNLOCKED MY CAR AND OPENED THE DOOR. THE AIRBAG WAS EXPOSED AND THERE WAS "SMOKE" IN THE CAR. IT APPEARS WHAT HAPPENED IS THE EXACT REASON GIVEN FOR RECALLING THE 3 SERIES VEHICLES DUE TO THE TAKATA AIRBAG PROBLEM, THE REASON GIVEN ARE INCIDENTS SUCH AS THIS OCCUR IN FLORIDA AND PUERTO RICO DUE TO THE HIGH HEAT AND HUMIDITY. SEE USA TODAY ARTICLE: HTTP://WWW.USATODAY.COM/STORY/MONEY/CARS/2014/07/16/BMW-TAKATA-SHRAPNEL-NHTSA-RECALL/12729929/ !....UPDATED 07/31/14 *BF
NHTSA ODI #10615403
70,000 miles · Jul 17, 2014
Air Bags
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED ON THE PASSENGER SIDE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 09/02/14*LJ UPDATED 09/17/2014 *JS
NHTSA ODI #10611241
25,000 miles · Jul 15, 2014
Steering
ON DAYS OVER 75 DEGREES F, DURING HIGHWAY DRIVING, IF I TURN THE STEERING WHEEL SLIGHTLY AND RELEASE IT, STEERING DOES NOT RETURN TO TOP DEAD CENTER. INSTEAD, THE Z4 CONTINUES TO TURN ON IT'S OWN UNTIL I STEER THE CAR BACK TO A STRAIGHT LINE. THE STEERING WHEEL DOES NOT RETURN TO THE STRAIGHT-AHEAD POSITION WHEN I RELEASE IT. …
Read full complaint
ON DAYS OVER 75 DEGREES F, DURING HIGHWAY DRIVING, IF I TURN THE STEERING WHEEL SLIGHTLY AND RELEASE IT, STEERING DOES NOT RETURN TO TOP DEAD CENTER. INSTEAD, THE Z4 CONTINUES TO TURN ON IT'S OWN UNTIL I STEER THE CAR BACK TO A STRAIGHT LINE. THE STEERING WHEEL DOES NOT RETURN TO THE STRAIGHT-AHEAD POSITION WHEN I RELEASE IT. A GREAT DEAL OF STRENGTH IS REQUIRED TO STEER AT ALL WHEN THIS HAPPENS. POWER ASSIST DOES NOT SEEM TO WORK OVER 75F AND THE STEERING FEEL IS NOTCHY. ON COOL DAYS, THE STEERING IS FINE. THIS STEERING FAILURE HAS BEEN GOING ON FOR SEVERAL YEARS, IT IS GETTING WORSE AND IS NO LONGER SAFE. THE DEALER IS NOT HELPFUL. IT IS A US CAR AND I LIVE IN CANADA. I THOUGHT YOU WOULD WANT TO KNOW BECAUSE THERE IS A LOT OF DISCUSSION ABOUT THIS IN FORUMS. THE CARS ARE NOT SAFE TO DRIVE ON HOT DAYS. INTERIM SOLUTION IS: DON'T DRIVE MY Z4 ROADSTER ON HOT DAYS?! SO MUCH FOR THE ULTIMATE DRIVING MACHINE. *TR
NHTSA ODI #10610595
71,500 miles · Jul 12, 2014
Steering
IN WARM WEATHER HAS A STICKY STEERING PROBLEM AS IT SEEMS TO STICK WHEN YOU TRY AND TURN THE WHEEL. AND THAN RELEASES WITH PRESSURE AND THAN YOU OVER STEER. HAVE SEEN MANY PEOPLE HAVING SAME PROBLEM. ONLY TIME BEFORE THIS CAUSES AND ACCIDENT. *TR
NHTSA ODI #10610042
36,136 miles · Jul 10, 2014
Electrical System
JUST PURCHASED THIS CAR FROM A PRIVATE OWNER. DIDN'T NOTICE BUT THE PASSENGER SIDE DOOR WILL NOT UNLOCK BY EITHER USING THE KEY FOB OR THE CENTRAL LOCKING/UNLOCKING SWITCH INSIDE. DID A GOOGLE SEARCH AND FOUND THAT THE GM-5 BOARD NEEDS TO BE REPLACED. I ALSO HEARD THAT THIS GM-5 CAN CAUSE FAILURE ON OTHER FUNCTIONS WITH THE C…
Read full complaint
JUST PURCHASED THIS CAR FROM A PRIVATE OWNER. DIDN'T NOTICE BUT THE PASSENGER SIDE DOOR WILL NOT UNLOCK BY EITHER USING THE KEY FOB OR THE CENTRAL LOCKING/UNLOCKING SWITCH INSIDE. DID A GOOGLE SEARCH AND FOUND THAT THE GM-5 BOARD NEEDS TO BE REPLACED. I ALSO HEARD THAT THIS GM-5 CAN CAUSE FAILURE ON OTHER FUNCTIONS WITH THE CAR - WIPERS, LIGHTS ETC. THE CAR IS 10 YEARS OLD BUT ONLY HAS 36,000 MILES ON IT. THIS PART SHOULD NOT FAIL SO QUICKLY. *TR
NHTSA ODI #10609504
NHTSA investigations
2PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Illustration