The Electric Top Malfunctions because of fault design Behind the driver seat is a hydraulic cylinder that sits in a cabin. Water leaks into the cabin causing the hydraulics to go out. The cabin fills up with water, and submerges the pump. This is a major design flaw. It is common with all Z4 models 2003 - 2008. I have a roadst…
Read full complaint
The Electric Top Malfunctions because of fault design Behind the driver seat is a hydraulic cylinder that sits in a cabin. Water leaks into the cabin causing the hydraulics to go out. The cabin fills up with water, and submerges the pump. This is a major design flaw. It is common with all Z4 models 2003 - 2008. I have a roadster rental business, comprised specifically of the Z4 model. I can give you 4 different vehicles I own as an example. Plus I can quote every seller, that says the top does not work. If people are not aware of this it can lead to accidents, the claw hooks disengaging, unable to get the top up in a lightning storm, rain storm etc., I haven't seen any recalls on the tops. There are no warning lamps on the vehicle that indicate the top motor or its hydraulic cylinder are malfunctioning. Most of these tops quit working in the same year or a couple year after the car was purchased, from manufacturing date. My car, I have reported here, only has 75,000 Original miles.
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
2004 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration