NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
378 reportsClear category filter64,000 miles · Jan 3, 2014
Steering
AS I BEGAN TO PULL OUT FROM PARKING LOT ONTO ROADWAY, THE STEERING WHEEL SUDDENLY LOCKED UP. I MANAGED TO BACK STRAIGHT DOWN THE HILL AND READ ABOUT THE ISSUE (IT WAS VERY EARLY IN THE MORNING). I TURNED THE CAR OFF AND RESTARTED. IT WORKED FINE. I'VE SINCE READ ABOUT THIS ISSUE ON SEVERAL BLOGS AND HAVE DISCOVERED THAT IS A REP…
Read full complaint
AS I BEGAN TO PULL OUT FROM PARKING LOT ONTO ROADWAY, THE STEERING WHEEL SUDDENLY LOCKED UP. I MANAGED TO BACK STRAIGHT DOWN THE HILL AND READ ABOUT THE ISSUE (IT WAS VERY EARLY IN THE MORNING). I TURNED THE CAR OFF AND RESTARTED. IT WORKED FINE. I'VE SINCE READ ABOUT THIS ISSUE ON SEVERAL BLOGS AND HAVE DISCOVERED THAT IS A REPEATING ISSUE. THANKFULLY I WASN'T IN THE MIDDLE OF RUSH-HOUR TRAFFIC. *TR
NHTSA ODI #10558317
29,900 miles · Dec 18, 2013
Steering
STEERING BECOMES DANGEROUSLY SLOPPY AND TWITCHY AT SPEEDS OVER 35MPH. CORRECTING THE STICKY STEERING CAUSES AN OVER-CORRECTION AND WEAVING ON THE HIGHWAY MAKING IT VERY DIFFICULT TO CONTROL THE VEHICLE. THIS IS A KNOWN PROBLEM BY THOUSANDS OF BMW OWNERS, YET NOTHING SEEMS TO BE IN THE WORKS TO ADDRESS. *TR
NHTSA ODI #10556487
23,000 miles · Nov 28, 2013
Steering
AS I WAS DRIVING ON THE HIGHWAY WHEN I HAD TO TURN DUE TO A CURVE IN THE ROAD, THE STEERING WOULD NOT RETURN TO CENTER. I HAD TO FORCE THE STEERING BACK TO CENTER. THIS ALMOST RESULTED IN A CRASH WITH ANOTHER CAR. THE STEERING IS VERY JERKY,, IT STICKS IN ONE SPOT. UNTIL YOU FORCE IT WHERE YOU NEED IT TO BE. THIS SAME PROBLEM H…
Read full complaint
AS I WAS DRIVING ON THE HIGHWAY WHEN I HAD TO TURN DUE TO A CURVE IN THE ROAD, THE STEERING WOULD NOT RETURN TO CENTER. I HAD TO FORCE THE STEERING BACK TO CENTER. THIS ALMOST RESULTED IN A CRASH WITH ANOTHER CAR. THE STEERING IS VERY JERKY,, IT STICKS IN ONE SPOT. UNTIL YOU FORCE IT WHERE YOU NEED IT TO BE. THIS SAME PROBLEM HAS NOW HAPPENED MANY TIMES AND IS GETTING WORSE. IT SEEMS TO HAPPEN MORE, THE HOTTER THE OUTSIDE TEMPERATURE IS. *TR
NHTSA ODI #10554058
222,000 miles · Nov 14, 2013
Steering
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL SEIZED AND BECAME DIFFICULT TO TURN WITHOUT WARNING. THE VEHICLE WAS LATER TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC INFORMED THE CONTACT THAT THE STEERING WHEEL WOULD NEED TO BE REPLACED. THE VEHICLE W…
Read full complaint
TL* THE CONTACT OWNS A 2004 BMW Z4. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL SEIZED AND BECAME DIFFICULT TO TURN WITHOUT WARNING. THE VEHICLE WAS LATER TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC INFORMED THE CONTACT THAT THE STEERING WHEEL WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 222,000.
NHTSA ODI #10552284
69,500 miles · Oct 31, 2013
Steering
SINCE I PURCHASED MY 2004 BMW Z4 ON MARCH 13, 2013 I HAVE EXPERIENCE VERY ANNOYING AND MORE IMPORTANTLY UNSAFE ISSUES WITH MY VEHICLES STEERING ESPECIALLY AT HIGH SPEEDS. AT FIRST I THOUGHT IT COULD HAVE BEEN THE ALIGNMENT BUT AFTER DOING EXTENSIVE RESEARCH ONLINE AND BMW FORUMS IT APPEARS THIS IS A COMMON PROBLEM FOR THE E85 (2…
Read full complaint
SINCE I PURCHASED MY 2004 BMW Z4 ON MARCH 13, 2013 I HAVE EXPERIENCE VERY ANNOYING AND MORE IMPORTANTLY UNSAFE ISSUES WITH MY VEHICLES STEERING ESPECIALLY AT HIGH SPEEDS. AT FIRST I THOUGHT IT COULD HAVE BEEN THE ALIGNMENT BUT AFTER DOING EXTENSIVE RESEARCH ONLINE AND BMW FORUMS IT APPEARS THIS IS A COMMON PROBLEM FOR THE E85 (2003-2005) BMW Z4 ROADSTERS. "NEED A NEW STEERING COLUMN TO FIX "STICKY STEERING" PROB WITH THE EPS @ $3,300. MY 2004 Z4 IS A "PLEASURE" CAR WITH 17,000 MILES. NOT A PLEASURE TO FIGHT THE STEERING ON THE ROAD." -TAKEN FROM ONE OF THE FORUMS. FORTUNATELY I HAVE ANOTHER VEHICLE I DRIVE DAILY AND DON'T HAVE TO COMMUTE DAILY IN THIS VEHICLE. HOWEVER WHEN I DO DRIVE IT IT'S DEFINITELY NOTICEABLE NOT ONLY BY ME BUT MY PASSENGERS, IT'S SCARY EVEN. I PURCHASED MY CAR WITH 69,500 MILES WHICH REALLY IS QUITE LOW CONSIDERING THE YEAR AND I AM VERY DISAPPOINTED TO FIND SOMETHING THAT HAS COST ME SO MUCH TO OBTAIN GIVES ME AN UNEASY FEELING EVERYTIME I DRIVE IT. WISH I COULD AFFORD TO HAVE THE PROBLEM FIXED BUT BEING A COLLEGE STUDENT I SIMPLY DON'T HAVE AN EXTRA $3,000+ TO SPARE TO SPEND TOWARDS THE REPAIR. ANYWAYS HOPING ENOUGH GRIEVANCES WILL BE FILED AND EVENTUALLY BMW WILL OWN UP TO THE PROBLEM AND BE WILLING TO WORK WITH ITS MANY UNHAPPY CUSTOMERS WHO ARE LITERALLY HAZARDS ON THE ROAD DUE TO THIS "STICKY STEERING" PROBLEMS AT HIGH SPEEDS. THANK YOU *TR
NHTSA ODI #10550433
65,000 miles · Sep 30, 2013
Steering
EPS(ELECTRIC POWER STEERING), DOES NOT FUNCTION PROPERLY. THE STEERING BINDS INTERMITTENTLY,AND ATTEMPTS TO CORRECT CAN THROW THE VEHICLE INTO ANOTHER LANE OR INTO A DANGEROUS SITUATION ON A CURVE. *TR
NHTSA ODI #10546325
69,265 miles · Sep 23, 2013
Steering
2004 BMW Z4 PURCHASED USED IN 2011 WITH JUST OVER 60K MILES ON THE ODOMETER. AT JUST UNDER 70K MILES THE DRIVER NOTICED STEERING SEEMED STIFF AND WHEN ENTERING A CURVE THE STEERING WHEEL WOULD FREEZE IN LOCKED POSITION UNTIL MANUALLY CORRECTED UPON WHICH TIME IT WOULD FEEL AS IF THE FRONT WHEELS WERE ON A PATCH OF BLACK ICE MOME…
Read full complaint
2004 BMW Z4 PURCHASED USED IN 2011 WITH JUST OVER 60K MILES ON THE ODOMETER. AT JUST UNDER 70K MILES THE DRIVER NOTICED STEERING SEEMED STIFF AND WHEN ENTERING A CURVE THE STEERING WHEEL WOULD FREEZE IN LOCKED POSITION UNTIL MANUALLY CORRECTED UPON WHICH TIME IT WOULD FEEL AS IF THE FRONT WHEELS WERE ON A PATCH OF BLACK ICE MOMENTARILY! OUTSIDE TEMPERATURE WAS ABOVE 80 DEGREES. DID A SEARCH ON THIS VEHICLE NO ACCIDENTS. HOWEVER IT WAS DISCOVERED MANY COMPLAINTS (242) ON THIS OR SIMILAR STEERING PROBLEMS. I CALLED BMW OF NORTH AMERICA AND SPOKE TO A PUBLIC RELATIONS REP. WHO INFORMED ME THAT BMW WAS UNAWARE OF ANY SUCH PROBLEMS WITH THIS YEAR MODEL STEERING. I REPLIED THAT THIS SEEMS ODD SINCE I HAD JUST LOOKED AT 17 PAGES OF SUCH PROBLEMS ON-LINE? I SCHEDULED AN APPOINTMENT WITH MY LOCAL DEALERSHIP AND ASKED TO SPEAK WITH AN EXPERIENCED TECHNICIAN CONCERNING THE PROBLEM. THE SERVICE MANAGER CHECKED WITH ONE OF THEIR TECHNICIANS! HE CONFIRMED THAT HE HAD SEEN THIS BEFORE AND THE STEERING COLUMN WOULD HAVE TO BE REPLACED. WHEN I PURCHASED THIS CAR I ALSO TRANSFERRED OVER AN EXTENDED WARRANTY AT A COST OF $1,000.00. SO I WILL ONLY BE OUT MY $100.00 DEDUCTIBLE. PARTS AND LABOR WILL BE IN EXCESS OF $4,000K IF A DEALERSHIP TECH IS AWARE OF SUCH PROBLEMS WITH A PARTICULAR MAKE OR MODEL YOU WOULD SURELY THINK THAT BMW OF NORTH AMERICA WOULD ALSO BE AWARE OF THE SAME SUCH FINDINGS! SOMETHING SMELLS AND ITS NOT GERMAN CHOCOLATE CAKE!
NHTSA ODI #10545069
39,700 miles · Aug 30, 2013
Steering
STEERING WAS STICKING AND FEELING FUNNY. SEEMED TO TAKE MORE FORCE TO TURN THE WHEEL. IT FELT MAGNETIC IN THE CENTER OR RIBBED LIKE. THEN IT WOULD SUDDENLY GO WHEN TURNING. HAD TO BE VERY CAREFUL. AFTER DOING RESEARCH I FIND THAT THE BMW Z4'S HAVE HAD PROBLEMS WITH STEERING COLUMNS IN THE 2003, 2004, 2005 AND SOME 2006 YEAR CARS…
Read full complaint
STEERING WAS STICKING AND FEELING FUNNY. SEEMED TO TAKE MORE FORCE TO TURN THE WHEEL. IT FELT MAGNETIC IN THE CENTER OR RIBBED LIKE. THEN IT WOULD SUDDENLY GO WHEN TURNING. HAD TO BE VERY CAREFUL. AFTER DOING RESEARCH I FIND THAT THE BMW Z4'S HAVE HAD PROBLEMS WITH STEERING COLUMNS IN THE 2003, 2004, 2005 AND SOME 2006 YEAR CARS. HAS TO DO WITH THE METAL WORM GEAR CLEARANCE IN THE NYLON COG GEAR BEING A POOR DESIGN. ON HOT DAYS THE CLEARANCE GOES TO ZERO MAKING THE GEARS TO TIGHT. ALSO NYLON ABSORBS MOISTURE AFTER A WHILE WHICH WOULD CAUSE THE NYLON GEAR TO INCREASE IN SIZE DECREASING THE CLEARANCE EVEN MORE. I JUST PURCHASED THIS CAR AND NOW AM SOMEWHAT AFRAID TO DRIVE IT OR LET MY FAMILY DRIVE IT. BMW HAS REPLACED MANY OF THESE. I HOPE MINE CAN BE REPLACED AS RIGHT NOW I'M NOT SURE WHAT MY RECOURSE MAY BE.
NHTSA ODI #10538034
23,000 miles · Aug 23, 2013
Steering
I HAVE A 2004 BMW Z4 WITH 32,000 MILES ON IT. I HAVE AN ISSUE WITH WHAT I WILL CALL STICKY STEERING. WHEN HOT, THE STEERING WHEEL WILL BIND AND REQUIRE EXTRA EFFORT TO MOVE, RESULTING IN OVER STEERING IN ORDER TO CORRECT THE STICKING. AT ALL SPEEDS THIS CAN BE DANGEROUS AND AT HIGHWAY SPEEDS THIS CAN BE PARTICULARLY DANGEROUS.…
Read full complaint
I HAVE A 2004 BMW Z4 WITH 32,000 MILES ON IT. I HAVE AN ISSUE WITH WHAT I WILL CALL STICKY STEERING. WHEN HOT, THE STEERING WHEEL WILL BIND AND REQUIRE EXTRA EFFORT TO MOVE, RESULTING IN OVER STEERING IN ORDER TO CORRECT THE STICKING. AT ALL SPEEDS THIS CAN BE DANGEROUS AND AT HIGHWAY SPEEDS THIS CAN BE PARTICULARLY DANGEROUS. *TR
NHTSA ODI #10536921
45,650 miles · Aug 19, 2013
Steering
IMMEDIATELY AFTER PURCHASING THIS VEHICLE WE NOTICED DIFFICULTY STEERING THE CAR. THE STEERING IS VERY STICKY AND ERRATIC. IT IS ACTUALLY SCARY TO DRIVE. HAS A TENDENCY TO VEER OFF AND POSSIBLY WRECK. I JUST HOPE IT DOES NOT TAKE X NUMBER OF ACCIDENTS/DEATHS FOR THE MANUFACTURE (WHO IS AWARE OF THE PROBLEM) TO FIX THIS UNAC…
Read full complaint
IMMEDIATELY AFTER PURCHASING THIS VEHICLE WE NOTICED DIFFICULTY STEERING THE CAR. THE STEERING IS VERY STICKY AND ERRATIC. IT IS ACTUALLY SCARY TO DRIVE. HAS A TENDENCY TO VEER OFF AND POSSIBLY WRECK. I JUST HOPE IT DOES NOT TAKE X NUMBER OF ACCIDENTS/DEATHS FOR THE MANUFACTURE (WHO IS AWARE OF THE PROBLEM) TO FIX THIS UNACCEPTABLE STEERING PROBLEM. MY PERSONAL RESEARCH HAS REVEALED THAT THERE ARE MANY MANY OWNERS OF THIS MAKE AND MODEL VEHICLE HAVE COMPLAINED TO THE MANUFACTURER ABOUT THIS EXACT SAME PROBLEM. IF ANY INFORMATION IS NEEDED OR IF YOU WISH FOR ME TO ELABORATE, PLEASE FEEL FREE TO EMAIL OR CALL ME. THANK YOU. *TR
NHTSA ODI #10536209
NHTSA investigations
2PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Illustration