THE VEHICLE HAS A SERIOUS STEERING PROBLEM. THE STEERING STICKS AND REQUIRES CONSTANT ADJUSTMENT FROM THE DRIVER TO CORRECT WHILE DRIVING. THE PROBLEM IS INTERMITTENT AND MAY APPEAR AT ANY TIME. THE TIME IT APPEARED, I WAS DRIVING ON THE HIGHWAY. THE CONDITION DID NOT EXIST AT FIRST BUT SUDDENLY AND WITHOUT WARNING THE STEER…
Read full complaint
THE VEHICLE HAS A SERIOUS STEERING PROBLEM. THE STEERING STICKS AND REQUIRES CONSTANT ADJUSTMENT FROM THE DRIVER TO CORRECT WHILE DRIVING. THE PROBLEM IS INTERMITTENT AND MAY APPEAR AT ANY TIME. THE TIME IT APPEARED, I WAS DRIVING ON THE HIGHWAY. THE CONDITION DID NOT EXIST AT FIRST BUT SUDDENLY AND WITHOUT WARNING THE STEERING WAS STUCK AS IF THE STEERING HAD A "DETENT". THE VEHICLE BEGAN TO DRIFT OUT OF LANE AND INTO THE LANE NEXT TO ME. THIS REQUIRED ME TO ABRUPTLY APPLY MORE FORCE TO THE STEERING WHEEL. EVENTUALLY THE STEERING BROKE FREE AND THE VEHICLE OVER COMPENSATED AND DRIFTED TO THE OTHER SIDE LANE. I IMMEDIATELY REDUCED SPEED TO THE MINIMUM ALLOWED ON THE HIGHWAY AND WAS ABLE TO SAFELY GET THE VEHICLE BACK HOME. I WAS FORTUNATE THAT NO OTHER VEHICLES WERE ON EITHER SIDE OF ME WHEN THIS OCCURRED, ELSE I WOULD HAVE SURELY COLLIDED WITH THEM BOTH. *TR
NHTSA ODI #10608209
44,000 miles · Jun 30, 2014
Steering
AFTER DRIVING MY Z4 ON A HOT AFTERNOON I NOTICE THE STEERING FEELING VERY NOTCHY. YOU HAD TO PUT IN A LOT OF FORCE TO GET THE WHEEL BACK TO WHERE YOU WANTED IT. THE NEXT MORNING IT WAS FINE. BUT I HAVE NOTICE ANY TIME THE CABIN TEMP GETS ABOVE 88 THE PROBLEM COMES BACK. IT PRODUCES A REAL JERKY FEELING IN THE WHEEL AND ITS VERY …
Read full complaint
AFTER DRIVING MY Z4 ON A HOT AFTERNOON I NOTICE THE STEERING FEELING VERY NOTCHY. YOU HAD TO PUT IN A LOT OF FORCE TO GET THE WHEEL BACK TO WHERE YOU WANTED IT. THE NEXT MORNING IT WAS FINE. BUT I HAVE NOTICE ANY TIME THE CABIN TEMP GETS ABOVE 88 THE PROBLEM COMES BACK. IT PRODUCES A REAL JERKY FEELING IN THE WHEEL AND ITS VERY UNNERVING TO DRIVE. *TR
NHTSA ODI #10607107
25,460 miles · Jun 18, 2014
Steering
DRIVING ON CURVY MOUNTAIN ROADS STEERING STICKS REQUIRING EXTRA FORCE TO STEER RESULTING IN OVER CORRECTION AND RUNNING OFF ONTO SHOULDER. WITHOUT A SHOULDER IN THE MOUNTAINS THIS IS A POTENTIAL SERIOUS ACCIDENT. *TR
NHTSA ODI #10604280
35,000 miles · Jun 10, 2014
Steering
WHEN I AM DRIVING AT ANY SPEED, MY STEERING WHEEL DOES NOT FEEL AS THOUGH IT IS MOVING SMOOTHLY, AS I WOULD EXPECT FROM A PRECISION-ENGINEERED BMW. IN FACT, IT STICKS TO THE POINT THAT IT WILL NOT MOVE UNLESS IT IS JERKED FORCEFULLY TO THE LEFT OR RIGHT. THIS JERKING IS NOT A BIG PROBLEM WHEN I AM DRIVING AT 20 TO 30 MILES PER H…
Read full complaint
WHEN I AM DRIVING AT ANY SPEED, MY STEERING WHEEL DOES NOT FEEL AS THOUGH IT IS MOVING SMOOTHLY, AS I WOULD EXPECT FROM A PRECISION-ENGINEERED BMW. IN FACT, IT STICKS TO THE POINT THAT IT WILL NOT MOVE UNLESS IT IS JERKED FORCEFULLY TO THE LEFT OR RIGHT. THIS JERKING IS NOT A BIG PROBLEM WHEN I AM DRIVING AT 20 TO 30 MILES PER HOUR. HOWEVER, WHEN I AM DRIVING ON A HIGHWAY AT 40 OR MORE MILES PER HOUR, THE STICKING OF THE STEERING WHEEL BECOMES A SERIOUS PROBLEM BECAUSE WHEN I JERK THE WHEEL AS HARD AS I HAVE TO IN ORDER TO UNSTICK THE STEERING, THE CAR SWERVES SO DRAMATICALLY THAT I COULD EASILY LOSE CONTROL OF THE CAR AND HIT ANOTHER CAR, ESPECIALLY IN RAIN OR OTHER PRECIPITATION, AND CAUSE PROPERTY, OR WORSE BODILY, DAMAGE TO OTHERS OR MYSELF. WHAT I FIND RIDICULOUS ABOUT THIS IS THAT I AM EXPECTED TO PAY $5K TO REPLACE THE STEERING COLUMN WITHOUT ANY GUARANTEE THAT THE REPLACEMENT PART WILL LAST ANY LONGER THAN THE ORIGINAL PART, AT WHICH TIME I WILL HAVE TO PAY $5K YET AGAIN. *TR
NHTSA ODI #10597483
49,281 miles · Jun 3, 2014
Steering
HAVE HAD THE CAR ABOUT 8 MONTHS. HAVE DRIVEN IT 268 MILES. TOOK THE CAR TO WORK 5/30/14. IT WAS FINE DRIVING IN THE MORNING. AFTER SITTING IN THE SUN ALL DAY, THE STEERING STUCK BADLY ON THE WAY HOME.IT FEELS LIKE YOU ARE RIDING ON A RAIL.HAVE TO KEEP MOVING STEERING WHEEL TO KEEP CAR GOING STRAIGHT. FEEL RESISTANCE IN STEERIN…
Read full complaint
HAVE HAD THE CAR ABOUT 8 MONTHS. HAVE DRIVEN IT 268 MILES. TOOK THE CAR TO WORK 5/30/14. IT WAS FINE DRIVING IN THE MORNING. AFTER SITTING IN THE SUN ALL DAY, THE STEERING STUCK BADLY ON THE WAY HOME.IT FEELS LIKE YOU ARE RIDING ON A RAIL.HAVE TO KEEP MOVING STEERING WHEEL TO KEEP CAR GOING STRAIGHT. FEEL RESISTANCE IN STEERING. I LOOKED ONLINE AND FOUND THIS IS A COMMON PROBLEM FOR 2003-2005 Z4'S. I WISH I KNEW THAT BEFORE I BOUGHT THE CAR. IT IS DANGEROUS. *TR
NHTSA ODI #10595919
Mileage unknown · May 28, 2014
Steering
STEERING IS VERY STICKY AND HARD TO STEER IN WARM WEATHER. *TR
NHTSA ODI #10594681
50,000 miles · Apr 9, 2014
Power TrainSteering
I OWN A SUSPECTED Z4 WITH A NHTSA REPORTED "STICKY STEERING" ISSUE I CAN TELL YOU A LITTLE MORE ABOUT IT. THE PROBLEM HAS NOTHING TO DO WITH THE BOOST. WHEN THE CAR GETS HOT (SUMMER HOT) THE STEERING GETS NOTCHY IN THAT WHEN YOU PUT THE CAR IN A SLIGHT TURN, LIKE CHANGING LANES OR GOING AROUND A SLIGHT CORNER, THE STEERING LITER…
Read full complaint
I OWN A SUSPECTED Z4 WITH A NHTSA REPORTED "STICKY STEERING" ISSUE I CAN TELL YOU A LITTLE MORE ABOUT IT. THE PROBLEM HAS NOTHING TO DO WITH THE BOOST. WHEN THE CAR GETS HOT (SUMMER HOT) THE STEERING GETS NOTCHY IN THAT WHEN YOU PUT THE CAR IN A SLIGHT TURN, LIKE CHANGING LANES OR GOING AROUND A SLIGHT CORNER, THE STEERING LITERALLY STICKS IN THAT POSITION CAUSING THE DRIVER TO APPLY OPPOSITE PRESSURE TO "BREAK" THE WHEEL LOOSE FROM THE TURN FOLLOWED BY ANOTHER STICK WHEREVER THE WHEEL IS BROUGHT BACK TO. PROBLEM IS THAT IT CAUSES MASSIVE OVER STEERING ISSUES AT HIGH SPEED UNLESS YOU ARE LOOKING FOR IT. EXTREMELY DANGEROUS AT HIGHWAY SPEEDS! BMW KNEW ABOUT IT AND RELEASED MULTIPLE PUMAS (THEIR EQUIVALENT OF A TSB) AND EVEN REDESIGNED THE SUSPECT COLUMN, BUT REFUSED TO REPLACE THE OLDER ONES OUT OF WARRANTY. THESE ARE $3000 BEFORE LABOR AND BMW HAS FLAT OUT TOLD ME THAT THEY WON'T COVER A SINGLE DOLLAR OF IT. I GUESS WE WILL SEE NHTSA FORCES THEIR HAND! I AM SCARED TO DEATH TO DRIVE THE VEHICLE I HAD TO JERK TO OUT OF ANOTHER LANE SEVERAL TIMES AND YOU MUST WORK EXTREMELY HARD TO KEEP IT STRAIGHT. PLEASE DO SOMETHING BEFORE SOMEONE GETS HURT. *TR
NHTSA ODI #10578571
67,926 miles · Apr 9, 2014
Steering
THE STEERING BECOMES "STICKY" WHEN THE WEATHER IS WARM. WHEN DRIVING STRAIGHT IT RESISTS TURNING AND ONCE TURNED TRIES TO STAY TURNED AND THE CAR TENDS TO VEER UNINTENTIONALLY. THE STEERING WILL NOT RETURN TO CENTER WHEN THE WHEEL IS RELEASED AND IT IS DIFFICULT TO STEER SMOOTHLY ON THE FREEWAY AND REQUIRES CONSTANT CORRECTION. …
Read full complaint
THE STEERING BECOMES "STICKY" WHEN THE WEATHER IS WARM. WHEN DRIVING STRAIGHT IT RESISTS TURNING AND ONCE TURNED TRIES TO STAY TURNED AND THE CAR TENDS TO VEER UNINTENTIONALLY. THE STEERING WILL NOT RETURN TO CENTER WHEN THE WHEEL IS RELEASED AND IT IS DIFFICULT TO STEER SMOOTHLY ON THE FREEWAY AND REQUIRES CONSTANT CORRECTION. WHEN IT IS COLD IT STEERS FINE AND TRAVELS DOWN THE FREEWAY PERFECTLY WITH NO HANDS ON THE STEERING WHEEL AND CORRECTIONS CAN BE MADE WITH ONLY TINY EFFORT. WHEN IT IS HOT AND STICKY IT TAKES BOTH HANDS AND A FAIR AMOUNT OF EFFORT TO STEER. THIS IS A DESIGN FLAW RESULTING IN A SAFETY ISSUE THAT BMW SHOULD FIX UNDER WARRANTY REGARDLESS OF AGE. *TR
NHTSA ODI #10578539
90,000 miles · Mar 31, 2014
Steering
THIS PROBLEM APPEARS WHEN THE OUTDOOR TEMPERATURE GETS ABOVE 70, OR MY VEHICLE SITS IN THE SUN ALL DAY. THERE IS A PROBLEM WITH THE STEERING AT ALL SPEEDS - THE STEERING WHEEL FEELS LIKE IT "STICKS" IN ONE POSITION AND I HAVE TO FORCE IT BACK IN THE OPPOSITE DIRECTION TO CORRECT THE COURSE I'M ON. THEN IT "STICKS" IN THAT POSI…
Read full complaint
THIS PROBLEM APPEARS WHEN THE OUTDOOR TEMPERATURE GETS ABOVE 70, OR MY VEHICLE SITS IN THE SUN ALL DAY. THERE IS A PROBLEM WITH THE STEERING AT ALL SPEEDS - THE STEERING WHEEL FEELS LIKE IT "STICKS" IN ONE POSITION AND I HAVE TO FORCE IT BACK IN THE OPPOSITE DIRECTION TO CORRECT THE COURSE I'M ON. THEN IT "STICKS" IN THAT POSITION AND I HAVE TO BE VERY VIGILANT WITH EVERY CURVE IN THE ROAD. IT SCARED ME LAST WEEK BECAUSE IT WAS THE WORST IT HAD BEEN SINCE IT FIRST BEGAN DOING THIS LAST YEAR. I LIVE IN THE FOOTHILLS OF CALIFORNIA AND CURVY ROADS ARE THE REASON I LOVE DRIVING MY Z4. LAST WEEK, THE STEERING PROBLEM SEEMED TO TAKE MORE ENERGY AND MORE CORRECTIONS TO FORCE THE WHEEL BACK IN THE DIRECTION I NEEDED THE CAR TO BE MOVING. WHEN THE WEATHER IS COOLER, THE STEERING IS PRECISE AND EFFORTLESS. I WAS SHOCKED TO HAVE TO DEAL WITH CORRECTING THE PATH OF THE VEHICLE NUMEROUS TIMES FOR EACH CURVE! IT WAS AN EXHAUSTING RIDE HOME; I DON'T FEEL SAFE WHEN THE CAR PERFORMS LIKE THIS. *TR
NHTSA ODI #10576056
51,000 miles · Feb 25, 2014
Steering
STEERING STICKS WHEN VEHICLE GETS HOT OR SITS IN THE SUN. *TR
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
2004 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration