TL* THE CONTACT OWNS A 2003 BMW Z4. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, VARIOUS WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE BEGAN TO ACCELERATE INDEPENDENTLY WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. THE VEHICLE BEGAN TO VEER SIDE TO SIDE AND AS A RESULT, AN ONCOMING VEHICLE ON THE LEFT …
Read full complaint
TL* THE CONTACT OWNS A 2003 BMW Z4. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, VARIOUS WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE BEGAN TO ACCELERATE INDEPENDENTLY WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. THE VEHICLE BEGAN TO VEER SIDE TO SIDE AND AS A RESULT, AN ONCOMING VEHICLE ON THE LEFT LANE CRASHED INTO THE CONTACT'S REAR DRIVER SIDE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS TOWED TO A JUNKYARD. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10852919
50,100 miles · Jun 9, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 2003 BMW Z4. WHILE DRIVING 3 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT COASTED THE VEHICLE TO A PARKING SPOT AND ATTEMPTED TO RESTART THE VEHICLE. THE VEHICLE WOULD IDLE BUT IF HE DEPRESSED THE ACCELERATOR PEDAL, IT WOULD STALL AGAIN. THE FAILURE OCCURRED TWICE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE…
Read full complaint
TL*THE CONTACT OWNS A 2003 BMW Z4. WHILE DRIVING 3 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT COASTED THE VEHICLE TO A PARKING SPOT AND ATTEMPTED TO RESTART THE VEHICLE. THE VEHICLE WOULD IDLE BUT IF HE DEPRESSED THE ACCELERATOR PEDAL, IT WOULD STALL AGAIN. THE FAILURE OCCURRED TWICE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT CALLED THE MANUFACTURER AND WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 50,100.
NHTSA ODI #10335451
7,600 miles · Nov 28, 2003
Vehicle Speed Control
NOTE: THIS IS MY SECOND COMPLAINT FOR THE SAME PROBLEM.... WHEN COMING TO A STOP AT A TRAFFIC SIGNAL, MY CAR BEGAN TO REV UNCONTOLLABLY AT SPEEDS SO HIGH I THOUGH THE ENGINE WOULD BLOW. AS HAPPENED THE FIRST TIME, I PRESSED AS HARD AS I COULD SO AS NOT TO LUNGE FORWARD. I SHUT THE ENGINE OFF BUT UPON STARTING, IT WAS STILL OUT…
Read full complaint
NOTE: THIS IS MY SECOND COMPLAINT FOR THE SAME PROBLEM.... WHEN COMING TO A STOP AT A TRAFFIC SIGNAL, MY CAR BEGAN TO REV UNCONTOLLABLY AT SPEEDS SO HIGH I THOUGH THE ENGINE WOULD BLOW. AS HAPPENED THE FIRST TIME, I PRESSED AS HARD AS I COULD SO AS NOT TO LUNGE FORWARD. I SHUT THE ENGINE OFF BUT UPON STARTING, IT WAS STILL OUT OF CONTROL. I DON'T KNOW WHAT IT WAS THAT STOPPED THIS PROBLEM AS ONE GETS PRETTY MUCH PANICKED WHEN ONE CAN'T CONTROL THE SITUATION. *AK
NHTSA ODI #10047706
4,800 miles · Aug 21, 2003
Engine And Engine CoolingService Brakes, HydraulicVehicle Speed Control
DRIVING ON THE INTERSTATE IN MY JUNE 2003 PRODUCTION BMW Z4 3.0I ROADSTER. THE CAR SUDDENLY DIES AT 65 MPH. THE "EML" LIGHT COMES ON, BRAKE LIGHTS COME ON, RPM NEEDLE SURGES, THROTTLE IS UNRESPONSIVE, AND THE FOOT BRAKES ARE FROZEN AND CANNOT BE DEPRESSED. I WAS BARELY ABLE TO SWERVE OFF THE INTERSTATE, ACROSS THE SERVICE ROA…
Read full complaint
DRIVING ON THE INTERSTATE IN MY JUNE 2003 PRODUCTION BMW Z4 3.0I ROADSTER. THE CAR SUDDENLY DIES AT 65 MPH. THE "EML" LIGHT COMES ON, BRAKE LIGHTS COME ON, RPM NEEDLE SURGES, THROTTLE IS UNRESPONSIVE, AND THE FOOT BRAKES ARE FROZEN AND CANNOT BE DEPRESSED. I WAS BARELY ABLE TO SWERVE OFF THE INTERSTATE, ACROSS THE SERVICE ROAD, AND INTO A PARKING LOT WHERE I HAD TO USE THE HAND BRAKES TO GET THE CAR TO STOP COMPLETELY.*AK
NHTSA ODI #10033253
5,095 miles · Aug 10, 2003
Vehicle Speed Control
I WAS APPROACHING A TRAFFIC SIGNAL AND I HAD TO STOP. I BEGAN EASING UP ON THE BRAKE PEDAL AS THE CAR WAS COMING TO A STOP. IT WAS THEN THAT I REALIZED I WAS HAVING TO PRESS HARDER ON THE BRAKE PEDAL AS THE CAR WAS NOT MAINTAINING THE SLOW SPEED I WAS EXPECTING. HAVING REACHED THE POINT AT WHICH I HAD TO STOP, I FOUND MYSELF P…
Read full complaint
I WAS APPROACHING A TRAFFIC SIGNAL AND I HAD TO STOP. I BEGAN EASING UP ON THE BRAKE PEDAL AS THE CAR WAS COMING TO A STOP. IT WAS THEN THAT I REALIZED I WAS HAVING TO PRESS HARDER ON THE BRAKE PEDAL AS THE CAR WAS NOT MAINTAINING THE SLOW SPEED I WAS EXPECTING. HAVING REACHED THE POINT AT WHICH I HAD TO STOP, I FOUND MYSELF PRESSING QUITE HARD ON THE BRAKE PEDAL. I IMMEDIATELY PUT THE CAR INTO NEUTRAL AND NOTICED THE TACHOMETER READING 3,500 TO 4,000 RPM'S. I BELIEVE IT WAS MY TAPPING ON THE GAS PEDAL THAT GOT THE CAR TO REV AT THE NORMAL RPM'S FOR A CAR THAT IS A STATIONARY POSITION, HOWEVER, THIS HAPPENED SO FAST AND CAUGHT ME OFF GUARD, THAT PERHAPS THE PROBLEM FIXED ITSELF AND IT WASN'T MY TAPPING ON THE GAS PEDAL. *NLM
NHTSA ODI #10031217
5,396 miles · Jun 2, 2003
Vehicle Speed ControlCrash
ENGINE SURGED THEN REVVED UNCONTROLLABLLY AFTER STARTUP. CONTINUED TO SURGE AND IDLE WITH RPM ALTERNATING BETWEEN 0 - 2500 RPM THE ACCELORATOR WAS UNRESPONSIVE.*AK AFTER STARTUP THE CAR SURGED FORWARD. DAMANGE TO FRONT BUMBER AND CRACKED LIGHT RESULTED. DEFECTIVE PART: BAD THROTTLE HOUSING, REPLACED ENGINE THROTTLE (R6…
Read full complaint
ENGINE SURGED THEN REVVED UNCONTROLLABLLY AFTER STARTUP. CONTINUED TO SURGE AND IDLE WITH RPM ALTERNATING BETWEEN 0 - 2500 RPM THE ACCELORATOR WAS UNRESPONSIVE.*AK AFTER STARTUP THE CAR SURGED FORWARD. DAMANGE TO FRONT BUMBER AND CRACKED LIGHT RESULTED. DEFECTIVE PART: BAD THROTTLE HOUSING, REPLACED ENGINE THROTTLE (R6385) DEFECT CODE 15 540 712
ON CERTAIN PASSENGER VEHICLES, INCOMPATIBLE ELECTRONIC AIR BAG SYSTEM PROCESSORS MAY HAVE BEEN INSTALLED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AIR BAG DEPLOYMENT MAY NOT OCCUR, INCREASING THE RISK OF INJURIES TO THE DRIVER AND/OR FRONT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE AIR BAG SYSTEM PROCESSORS. THE RECALL BEGAN JUNE 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, UNDER CERTAIN ENVIRONMENTAL CONDITIONS, A VAPOR LOCK IN THE FUEL PUMP COULD OCCUR CAUSING THE ENGINE TO STALL. IF THIS WERE TO HAPPEN, THE ENGINE WOULD NOT BE ABLE TO BE RESTARTED FOR APPROXIMATELY 15 TO 20 MINUTES.
Consequence & remedy
Consequence: IF STALLING WERE TO OCCUR, THE DRIVER WOULD BE UNABLE TO MAINTAIN VEHICLE SPEED OR ACCELERATE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A RESISTOR IN THE ELECTRICAL LINE POWERING THE FUEL PUMP IN ORDER TO PREVENT AN OCCURRENCE OF VAPOR LOCK. THE RECALL BEGAN MAY 11, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN VEHICLES EQUIPPED WITH 18" TIRES, IT IS POSSIBLE THAT THE TIRE HAS BEEN DAMAGED DURING THE MOUNTING PROCESS TO THE RIM.
Consequence & remedy
Consequence: CONSEQUENTLY, A LOSS OF TIRE PRESSURE, OR A TIRE FAILURE, COULD OCCUR. DEPENDING ON TRAFFIC CONDITIONS AND THE DRIVER'S REACTIONS, THIS COULD LEAD TO A CRASH.
Remedy: DEALERS WILL UNSEAT THE TIRE FROM ITS RIM, INSPECT FOR ANY DAMAGE, AND THEN RESEAT THE TIRE TO ITS RIM. IF INSPECTION REVEALS THAT A FRONT TIRE HAS INCURRED DAMAGE DURING THE MOUNTING PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 14, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES, THE CONNECTION OF THE SAFETY BELT BUCKLE TO THE STEEL ROPE OF THE TENSIONER DOES NOT MEET BMW SPECIFICATIONS. IN SEVERE FRONTAL CRASHES, THIS CONNECTION CAN DETACH.
Consequence & remedy
Consequence: IF THE CONNECTION DETACHES, THE PROTECTION PROVIDED BY THE SAFETY BELT IS LIKELY TO BE IMPAIRED, AND SERIOUS INJURIES TO THE DRIVER AND/OR FRONT PASSENGER COULD OCCUR THAT MIGHT OTHERWISE BE MITIGATED.
Remedy: DEALERS WILL INSPECT BOTH FRONT SAFETY BELT TENSIONER AND BUCKLE ASSEMBLIES, AND IF NECESSARY, REPLACE THESE PARTS. OWNER NOTIFICATION BEGAN MARCH 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10020 · Sticky Steering
Opened Jun 28, 2010 · Closed Jun 28, 2011
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Additional source detail variants (3)
Steering
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:column
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
Steering:electric Power Assist System
ODI has evaluated the sticky steering condition, which included reviews of complaints and warranty claims, interviews and surveys of owners of complaint vehicles, road tests of complaint vehicles, and a review of BMW's engineering and test data.ODI found the sticky steering condition does not result in a significant steering effort, thus the impact on the driver's ability to control the vehicle does not appear to be significant.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.See the attached report for additional information.In addition, during this investigation, ODI became aware of allegations of failure or loss of electric power-assisted steering on the subject vehicles.As a result, ODI is separately reviewing this issue to determine whether additional agency action is needed.
2003 BMW Z4 Problems, Complaints & Recalls | Skip That Year
Illustration