AIRBAG LIGHT STAYS ON ALL THE TIME. THIS HAPPENED THE FIRST TIME IN NOVEMBER 1999. DEALERSHIP ANALYZED THE FAULT ON THEIR COMPUTER AND SAID IT WAS A PROBLEM WITH THE DRIVER'S SIDE SEATBELT RECEPTICLE. THIS WAS REPLACED UNDER WARRANTY. IN JUNE OF 2001, AIRBAG LITE CAME ON AGAIN. DEALERSHIP DIAGNOSED THE PROBLEM AS A SHORT IN…
Read full complaint
AIRBAG LIGHT STAYS ON ALL THE TIME. THIS HAPPENED THE FIRST TIME IN NOVEMBER 1999. DEALERSHIP ANALYZED THE FAULT ON THEIR COMPUTER AND SAID IT WAS A PROBLEM WITH THE DRIVER'S SIDE SEATBELT RECEPTICLE. THIS WAS REPLACED UNDER WARRANTY. IN JUNE OF 2001, AIRBAG LITE CAME ON AGAIN. DEALERSHIP DIAGNOSED THE PROBLEM AS A SHORT IN THE DRIVER'S SIDE SEATBELT RECEPTACLE. REPLACEMENT COST IS $266.00. I SAID THEY REPLACED THE SAME PART A YEAR AND A HALF AGO. THE SAID THE WARRANTY ON PARTS IS ONE YEAR. I CALLED BMW OF NORTH AMERICA AND REQUESTED HELP WITH THE REPAIR. THEY SAID THE PARTS WARRANTY IS ONE YEAR. I SAID IT'S A MAJOR SAFETY COMPONENT OF THE VEHICLE AND ITS BEEN REPLACED ONCE ALREADY. THERE'S OBVIOUSLY A PROBLEM WITH THE PART THEY MANUFACTURE. WITHOUT THE SENSOR IN THE SEATBELT RECEPTACLE FUNCTIONING, THE AIRBAG WILL NOT DEPLOY IN A CRASH. THEY REPLIED, PARTS WARRANTY IS ONE YEAR.*AK
NHTSA ODI #748070
Mileage unknown · Nov 20, 2000
Air Bags
AIR BAG LIGHT ON. BROUGHT TO BMW CHARGED $80 TO DIAGNOSE, SAW INTERNET OTHER OWNERS SAME PROBLEM / THEN FOUNDOUT THERE IS A SERVICE BULLITEN
NHTSA ODI #736637
Mileage unknown · May 17, 2000
Air Bags
REQUESTING AN ON/OFF AIR BAG SWITCH
NHTSA ODI #9000795
Mileage unknown · Jan 3, 2000
Air BagsCrashInjury
NO DEPLOYMENT OF AIR BAG DURING ACCIDENT WHICH RESULTED IN SUBSTANTIAL FRONTAL DAMAGE. CONSUMER SUSTAINED INJURIES TO ARM, WRIST AND LOWER BACK. NLM
NHTSA ODI #550196
Mileage unknown · Oct 2, 1998
Air BagsElectrical SystemExterior LightingFireInjury
AFTER VEHICLE WAS VACUUMED IT WOULD NOT START; THE VEHICLE WAS PUSHED TO THE SIDE AND THE DRIVER TURNED THE KEY AGAIN TO START IT, AND A PUFF OF SMOKE CAME FROM THE STEERING COLUMN. THE DRIVER QUICKLY TRIED TO TURN THE KEY TO THE OFF POSITION,THEN THE LIGHTS DIMMED. THE KEY BECAME IMMOVABLE IN THE START POSITION, AND SMOKE BEGAN…
Read full complaint
AFTER VEHICLE WAS VACUUMED IT WOULD NOT START; THE VEHICLE WAS PUSHED TO THE SIDE AND THE DRIVER TURNED THE KEY AGAIN TO START IT, AND A PUFF OF SMOKE CAME FROM THE STEERING COLUMN. THE DRIVER QUICKLY TRIED TO TURN THE KEY TO THE OFF POSITION,THEN THE LIGHTS DIMMED. THE KEY BECAME IMMOVABLE IN THE START POSITION, AND SMOKE BEGAN TO POUR FROM ALL THE VENTS. STUNNED, THE DRIVER OPENED THE DOOR TO RUN FROM THE VEHICLE, BUT THE AIR BAG DEPLOYED AND KNOCKED THE DRIVER UNCONSCIOUS. THE DRIVER WAS PULLED FROM THE VEHICLE AND REVIVED IN TIME TO GET THE NEGATIVE BATTERY TERMINAL DISCONNECTED. EMS ATTENDED TO THE DRIVER'S INJURIES.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 BMW Z3 Problems, Complaints & Recalls | Skip That Year
Illustration