IllustrationFRONT PASSENGER SEATBELT LOCKS- SOMETIMES UNUSABLE -RATCHETT ASSEMBLY- DEALER REPLACED 3 X - STILL NOT WORKING -DEALER &BMW MANUF CLAIM NOTHING THEY CAN DO ABOUT IT????? OTHER OWNERS HAVE SAME COMPLAINT. *AK
1996 BMW Z3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 BMW Z3 do not stand out strongly from the model-year median of 30.
About this comparison →How this year compares
Owner complaints by model year
Compare all Z3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 30 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seats. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports2 injury reports
What owners actually said
30 reportsTHE BMW Z3 HIT ANOTHER CAR DIRECTLY IN THE SIDE ; THIS WAS A FRONTAL COLLISION BY THE BMW. THE DRIVER WAS WEARING HER SAFETY BELT, BUT HE AIRBAG DID NOT DEPLOY
HAD A HEAD-ON COLLISION AND AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED SOME INJURIES. *AK
ELECTRICAL TYPE SMOKE IS SEEN UNDERNEATH STEERING COLUMN. DEALER NOTED PROBLEM WAS A FUSE. PROBLEM HAS NOT STOPPED. DEALER THEN NOTED A FAULTY INSTRUMENT PANEL. PROBLEM REMAINS. *AK
VEHICLE IN MOTION, PASSENGER 'S SEAT BELT WOULD LOCK UP. WOULD RETRACT, BUT NOT RELEASE. WORKED ON IT FOR 5-10 MINUTES BEFORE MOVING. TOOK TO DEALER & INFORMED MECHANISM NEEDED REPLACING. SEAT BELT RELEASING OR RETRACTING STILL EXISTS. *AK
FUEL GAUGE FAILED.
VEHICLE IS DIFFICULT TO HANDLE BECAUSE THE REAR SUSPENSION IS LOOSE WHEN TURNING OR GOING OVER BUMPS AT 50 MPH.
FOG LIGHT INOPERATIVE.
VALVE SEATS NOT ROUND, RESULTING IN PISTON RINGS NOT SEATING. *AK
CONSUMER REARENDED SOMONE AND BOTH AIR BAG DIDN'T DEPLOY . PLEASE DESCRIBE . *AK
Official recalls
197V131000 · Vehicle Speed Control
Aug 19, 1997
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.