NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
105 reports36,400 miles · Nov 28, 2025
Power Train
The contact owns a 2021 BMW X5. The contact stated that while driving at various speeds, there was an abnormal grinding and clanking sound coming from the front end of the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that the front differential was faulty and needed to be replaced. The vehicle was r…
Read full complaint
The contact owns a 2021 BMW X5. The contact stated that while driving at various speeds, there was an abnormal grinding and clanking sound coming from the front end of the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that the front differential was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 36,400.
NHTSA ODI #11701920
Mileage unknown · Nov 8, 2025
EnginePower TrainVehicle Speed Control
The vehicle shakes at low speeds with a jolt and vibration when turning. When I pressed the accelerator from a standstill, the gas pedal broke off from its floor mounted bracket.
NHTSA ODI #11698378
55,000 miles · Oct 22, 2025
Electrical SystemEngine And Engine Cooling
The contact owns a 2021 BMW X5. The contact stated that upon starting the vehicle, there was an abnormal sputtering sound coming from the vehicle. After several attempts, the vehicle was able to start. The vehicle was taken to the dealer, where it was diagnosed with starter failure. The contact was provided with the following DT…
Read full complaint
The contact owns a 2021 BMW X5. The contact stated that upon starting the vehicle, there was an abnormal sputtering sound coming from the vehicle. After several attempts, the vehicle was able to start. The vehicle was taken to the dealer, where it was diagnosed with starter failure. The contact was provided with the following DTC: 0012240600. The vehicle was not repaired due to the cost. The contact stated that the failure persisted. Upon further investigation, the contact associated the failure with NHTSA Campaign Number: 24V576000 (ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING). However, the VIN was not included. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 55,000.
NHTSA ODI #11695040
40,000 miles · Oct 16, 2025
Engine And Engine Cooling
The contact owns a 2021 BMW X5. The contact stated that while driving at an undisclosed speed, the coolant warning light illuminated with the message "Coolant Dangerously Low - Fill Right Away" displayed on the instrument panel. The message was displayed on several occasions. The vehicle was taken to a dealer where the dealer di…
Read full complaint
The contact owns a 2021 BMW X5. The contact stated that while driving at an undisclosed speed, the coolant warning light illuminated with the message "Coolant Dangerously Low - Fill Right Away" displayed on the instrument panel. The message was displayed on several occasions. The vehicle was taken to a dealer where the dealer discovered coolant leaking from the bottom of the vehicle and diagnosed that the water pump needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was no longer under warranty. The failure mileage was approximately 40,000. The VIN was not available.
NHTSA ODI #11693874
Mileage unknown · Oct 15, 2025
Unknown Or Other
What component or system failed or malfunctioned, and is it available for inspection upon request? The engine/transmission mounts were diagnosed by Sterling BMW (Newport Beach, CA) as “sagging” and in need of replacement at only 38,437 miles. The components remain on the vehicle and are available for inspection. How was your s…
Read full complaint
What component or system failed or malfunctioned, and is it available for inspection upon request? The engine/transmission mounts were diagnosed by Sterling BMW (Newport Beach, CA) as “sagging” and in need of replacement at only 38,437 miles. The components remain on the vehicle and are available for inspection. How was your safety or the safety of others put at risk? If engine mounts are in fact deteriorating prematurely, the drivetrain may shift during operation, affecting vehicle stability, steering alignment, and braking response. This could cause a sudden loss of control and create a hazard to occupants and other drivers. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Sterling BMW performed the inspection on October 2, 2025, and documented the issue in their inspection report, listing “motor mounts are sagging” under “Needs Immediate Attention,” with an estimated repair cost of $2,301.12. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? BMW of North America was contacted on October 15, 2025. They verbally denied warranty coverage, refused to provide a written response, and did not investigate further. The issue has not been independently inspected by police or insurance representatives. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No dashboard warning lights or messages appeared. The issue was only reported by the dealer during the October 2, 2025 service visit. I have not experienced noticeable vibration, noise, or performance changes that would typically indicate failed mounts. This raises concern that the diagnosis may either indicate a premature defect or an unnecessary upsell.
NHTSA ODI #11693718
Mileage unknown · Oct 8, 2025
Power Train
The front differential on my BMW failed at just 47,000 miles. There were no warning lights—only a faint grinding noise that gradually worsened. After inspection, the dealership confirmed the failure and quoted $9,000 for replacement. In speaking with other BMW owners, I’ve discovered this issue isn’t isolated. Many have experie…
Read full complaint
The front differential on my BMW failed at just 47,000 miles. There were no warning lights—only a faint grinding noise that gradually worsened. After inspection, the dealership confirmed the failure and quoted $9,000 for replacement. In speaking with other BMW owners, I’ve discovered this issue isn’t isolated. Many have experienced front differential failures around the 50,000-mile mark, suggesting a troubling pattern. This raises serious concerns about the reliability of this component and whether BMW is adequately addressing what appears to be a recurring problem.
NHTSA ODI #11692077
Mileage unknown · Sep 29, 2025
Power Train
Around September, 2025 several small puddles was under the vehicle. Made an appointment with BMW to have a 2021, X5 inspected. The BMW dealership technicians diagnosed the problem as a Water pump -Engine coolant. There was no previous warning messages notifying a problem with the vehicle cooling system. Vehicle total mileage was…
Read full complaint
Around September, 2025 several small puddles was under the vehicle. Made an appointment with BMW to have a 2021, X5 inspected. The BMW dealership technicians diagnosed the problem as a Water pump -Engine coolant. There was no previous warning messages notifying a problem with the vehicle cooling system. Vehicle total mileage was around 58,000 miles at the time of problem found.Cost of damage was over $2,000 to fix at dealership.
NHTSA ODI #11690421
Mileage unknown · Sep 23, 2025
Power TrainSteering
Steering the vehicle in a low gear causes the vehicle to tremble or shudder. The dealership identified the problem to be the transfer case fluid. In manufacturing, BMW put a fluid which did not meet the specifications of the vehicle. The transfer case fluid is documented in the manual of BMW X5 M50i (2021) to be something which …
Read full complaint
Steering the vehicle in a low gear causes the vehicle to tremble or shudder. The dealership identified the problem to be the transfer case fluid. In manufacturing, BMW put a fluid which did not meet the specifications of the vehicle. The transfer case fluid is documented in the manual of BMW X5 M50i (2021) to be something which does not require replacement in the lifetime of the vehicle. I raised this issue when the vehicle was under warranty, but the dealership ignored the issue. After the warranty period was over (62,000 miles), the dealer recommended that I replace the fluid to fix the shudder issue. It is a very well known issue, and there is a service bulletin issued to the dealerships to deal with this particular case (SIB 27 02 20). After the fluid replacement, the issue went away. This issue is widely known by the dealership, and it is a safety issue. I had to pay for the fluid replacement, and I believe BMW should have recalled this issue to replace the fluid for ALL X5s manufactured in 2020 and 2021. This is a safety issue.
NHTSA ODI #11689259
Mileage unknown · Sep 23, 2025
EnginePower Train
Component Failed: Water pump (engine cooling system) - Part has been superseded by BMW with upgraded version, indicating manufacturer awareness of defect. Failed component retained and available for inspection upon request. Safety Risk: Complete water pump failure at 56,611 miles created immediate risk of catastrophic engine ove…
Read full complaint
Component Failed: Water pump (engine cooling system) - Part has been superseded by BMW with upgraded version, indicating manufacturer awareness of defect. Failed component retained and available for inspection upon request. Safety Risk: Complete water pump failure at 56,611 miles created immediate risk of catastrophic engine overheating and potential engine seizure while driving. BMW-certified mechanic warned that driving vehicle even short distances could result in total engine failure, creating risk of: Sudden loss of power on highways/intersections Engine fire from overheating Being stranded in dangerous locations/conditions Complete loss of steering assist if engine stops Confirmation: BMW-certified independent mechanic (formerly employed by BMW) confirmed water pump failure and identified it as "common B58 engine issue." BMW dealer (Silver Spring) immediately quoted exact repair cost of $2,300, indicating familiarity with this failure pattern. Mechanic documented that BMW has superseded the original part with an upgraded design, suggesting manufacturer acknowledgment of defect. Inspection Status: Failed part preserved by mechanic with full documentation including BMW's superseded part number from their system. Vehicle not inspected by BMW due to dealer network failure - three dealers failed to respond, one took 5+ hours to return call, none could provide service in reasonable timeframe. Warning Signs: No prior warning symptoms. Failure was sudden and catastrophic. Temperature gauge spiked without warning during normal driving conditions. No previous cooling system issues or warning lights. Regular maintenance performed per BMW specifications. Additional Pattern Evidence: Research reveals extensive documentation of identical B58 engine water pump failures between 40,000-60,000 miles across multiple BMW models (X5, X3, 3-series, 5-series) on owner forums. BMW's decision to supersede the part without issuing a recall suggests they are aware of the defect.
NHTSA ODI #11689062
Mileage unknown · Sep 19, 2025
Air BagsSeat BeltsSeats
Described by BMW as a "malfunctioning passenger restraint system", the sensor detecting weight in the seats is faulty without any external factors. The safety of both minors and adults is placed at risk when a system like this malfunctions, either keeping the airbag on or off. The automatically-adjusting seatbelt is also affec…
Read full complaint
Described by BMW as a "malfunctioning passenger restraint system", the sensor detecting weight in the seats is faulty without any external factors. The safety of both minors and adults is placed at risk when a system like this malfunctions, either keeping the airbag on or off. The automatically-adjusting seatbelt is also affected by this. There was a warning message for this displayed.
NHTSA ODI #11688338
Official recalls
12Apr 20, 2022
BMW of North America, LLC (BMW) is recalling certain 2022 4 Series Gran Coupe (430i, 430i xDrive, M440i xDrive); 2019-2022 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M; 2021-2022 X5 xdrive45e; 2020-2022 X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6M and 2019-2023 X7 xDrive40i, X7 xDrive50i, X7 M50i, X7 xDrive60i, X7 M60i, X7M, Alpina XB7 vehicles. The roof function control unit may be programmed incorrectly, allowing the sunroof to close without the key fob present inside the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence & remedy
Consequence: A sunroof that closes without the key fob present inside the vehicle can increase the risk of injury.
Remedy: Dealers will reprogram the roof function control unit, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Mar 10, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i, X5 xDrive50i, X5 M50i, X5 xDrive45e, 2021 X7 xDrive40i, X7 M50i, and XB7 vehicles. The head restraints on the second-row outer seats may be the incorrect type for the vehicle.
Consequence & remedy
Consequence: In the event of a crash, the head restraints could detach, and increase the risk of injury.
Remedy: BMW will notify owners, and dealers will inspect the head restraints, and replace them as necessary, free of charge. The recall began May 3, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Feb 19, 2021
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Back Over Prevention:software
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Back Over Prevention: Sensing System: Camera
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Feb 18, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence & remedy
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Additional source detail variants (2)
Service Brakes, Hydraulic:critical Fasteners
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Service Brakes, Hydraulic:foundation Components:disc
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Feb 10, 2021
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence & remedy
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:hydraulic
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Service Brakes, Hydraulic
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Jan 29, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i, X5 xDrive40i, X5M, X5 xDrive45e, X6 sDrive40i, X6 xDrive40i, X7 xDrive40i, X7 M50i vehicles. The steering column shaft's universal joint connection may not have been tightened to specifications, and can become loose.
Consequence & remedy
Consequence: A loose steering column shaft universal joint connection can affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect and, depending upon the inspection, either the bolt will be replaced and tightened to specifications, or the steering column shaft, universal joint, and bolt will be replaced and tightened to specifications, free of charge. The recall began March 30, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Dec 9, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 M340i xDrive, M440i xDrive Coupe, 530i, 530i xDrive, 540i, 540i xDrive, 740Li, 740Li xDrive, 840i Gran Coupe, 840i xDrive Gran Coupe, X5 sDrive40i, X5 xDrive40i, X6 sDrive40i, X6 xDrive40i, and X7 xDrive40i vehicles. The connection between the 48-Volt battery and the starter-generator may not have been assembled properly, which can cause increased electrical resistance at the connections.
Consequence & remedy
Consequence: Increased electrical resistance can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect the connection between the 48-Volt battery and the starter-generator assembly, replacing it if necessary, free of charge. The recall is expected to begin April 12, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Nov 4, 2020
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, xDrive40i, X5 M50i, X5M, X7 xDrive40i, X7 M50i, X6 xDrive40i, X6 M50i and X6M vehicles and 2021 X5 xDrive45e vehicles. The weld between the front axle support and the right front control arm bearing bracket may separate.
Consequence & remedy
Consequence: If the weld between the front axle support and the right front control arm bearing bracket separates, vehicle handling and control may be affected, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front axle support, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Sep 30, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 530e, 530e xDrive, 530e iPerformance and X3 xDrive30e and MINI Cooper Countryman All4 SE, 2020 BMW i8, and 2021 330e, 330e xDrive, 745Le xDrive and X5 xDrive45e vehicles. Debris may have entered one or more of the hybrid battery cells during their production.
Consequence & remedy
Consequence: The debris could result in a short-circuit, increasing the risk of fire or injury.
Remedy: BMW will inspect and, if necessary, replace the battery module free of charge. The remedy is currently being developed. Until the remedy is completed, drivers are instructed to not charge their vehicles. Drivers are instructed to not drive in manual mode, sport mode, and to not use the shift paddles. Owners were notified of the safety risk October 23, 2020. The recall began November 24, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Sep 1, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 X5 sDrive40i, xDrive40i, xDrive50i, X5 M50i, X5M, X6 sDrive40i, xDrive40i, X6 M50i, X6M, X7 M50i and 2021 X5 xDrive45e vehicles. The headlamps may allow a blue light to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Oncoming drivers may be confused by the blue light of approaching vehicles, which could potentially increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the headlamps and, if necessary, replace them, free of charge. The recall began October 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Aug 18, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence & remedy
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Electrical SYSTEM:12V/24V/48V Battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Aug 14, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 X6 (sDrive40i, xDrive40i and M50i) and X5 (sDrive40i, xDrive40i and M50i) vehicles equipped with certain Pirelli tires. The tires may have a damaged inner layer, possibly resulting in a rapid loss of pressure while the vehicle is moving.
Consequence & remedy
Consequence: A rapid loss of tire pressure while the vehicle is moving can affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW has notified all of the affected owners, and dealers will replace the defective tires, free of charge. BMW has contacted owners by telephone and those owners have had their cars remedied. Owner notification letters will not be sent. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration