NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
36 reportsClear category filterMileage unknown · Sep 13, 2026
Electrical System
The starter motor malfunctioned, which then prevented the car from starting when it was hot. It could only be started after it had completely cooled down. Additionally, the fault code indicated that there was a problem with the starter motor. I also noticed that there was a similar recall before, so I'm wondering if this one mig…
Read full complaint
The starter motor malfunctioned, which then prevented the car from starting when it was hot. It could only be started after it had completely cooled down. Additionally, the fault code indicated that there was a problem with the starter motor. I also noticed that there was a similar recall before, so I'm wondering if this one might also pose a risk of fire.
NHTSA ODI #11763905
Mileage unknown · Sep 8, 2026
Electrical System
The contact owns a 2021 BMW X5. The contact stated that the AC was inoperable. The vehicle was taken to a dealer and an independent mechanic on several occasions to repair the AC; however, the failure reoccurred after each repair. The AC was not replaced. The contact believed that the issue was caused by Hybrid system.
NHTSA ODI #11762762
Mileage unknown · Sep 4, 2026
Back Over PreventionElectrical System
Vehicle: 2021 BMW X5 xDrive40i (G05) Mileage: 54,423 miles Component: Central Information Display (CID)/ MGU (Media Graphics Unit) Head Unit Safety Defect: The CID intermittently goes completely blank without warning. When this occurs, the backup camera is unavailable, creating a safety hazard when reversing. Navigation, radio,…
Read full complaint
Vehicle: 2021 BMW X5 xDrive40i (G05) Mileage: 54,423 miles Component: Central Information Display (CID)/ MGU (Media Graphics Unit) Head Unit Safety Defect: The CID intermittently goes completely blank without warning. When this occurs, the backup camera is unavailable, creating a safety hazard when reversing. Navigation, radio, Apple CarPlay, and vehicle settings are also unavailable. Failure History/Diagnosis: The first failure occurred about one month ago while I was reversing. After several hard resets and leaving the vehicle unused for two days, the display began working again. The failure occurred again yesterday when my spouse started the vehicle. I took it to Bobby Rahal BMW of South Hills, PA. The BMW technician confirmed that the head unit (MGU) and RAM (Receiver Audio Module) are not communicating. The technician also found corrosion on the head-unit power connector and inside the head unit, suggesting moisture intrusion and/or an internal electrical short. The dealer recommended replacing the head unit, with the part costing over $4,000, plus labor and additional diagnosis to identify the source of the leak/moisture causing the corrosion. Inspection: The defect was inspected and confirmed by the BMW dealer. The failed component is available for inspection upon request. There were no police or insurance inspections. Warning Signs: There were no warning lights or messages before either failure. The display simply went blank. The failure is intermittent and unpredictable. Safety Concern: The CID can suddenly fail during operation, including while reversing, causing loss of the backup camera and other critical functions. Corrosion inside the head unit and on its power connector raises concern about a recurring moisture-intrusion or electrical/design defect. I request that NHTSA investigate whether this is a recurring safety defect affecting BMW X5 G05 vehicles and determine whether a recall or corrective action is warranted.
NHTSA ODI #11762076
49,000 miles · Aug 24, 2026
Electrical SystemEngineEngine And Engine Cooling
The contact owns a 2021 BMW X5. The contact stated that the vehicle failed to immediately start. The vehicle started later. The engine and a yellow warning light flashed on the instrument panel. Upon research, the contact located the German Federal Motor Transport Authority (Kraftfahrt-Bundesamt), for KBA Reference Number: 16131…
Read full complaint
The contact owns a 2021 BMW X5. The contact stated that the vehicle failed to immediately start. The vehicle started later. The engine and a yellow warning light flashed on the instrument panel. Upon research, the contact located the German Federal Motor Transport Authority (Kraftfahrt-Bundesamt), for KBA Reference Number: 16131R, which was associated with the starter motor. The contact stated that the failure was associated with NHTSA Campaign Number: 24V576000 (Electrical System, Engine and Engine Cooling) and 25V644000 (Electrical System). The vehicle was taken to an independent mechanic who determined that the failure was associated with the starter motor, which was replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was informed that there was no recall on the VIN associated with the failure. The failure mileage was approximately 49,000.
NHTSA ODI #11759048
Mileage unknown · Aug 9, 2026
Electrical System
The drivetrain warning light came on shortly after I started the vehicle. I noticed acceleration issues both while driving on side streets and on the freeway. I took the X5 45e into the repair center the day after the notice came on especially given the experience on the freeway, which happened during rush hour traffic. Upon ins…
Read full complaint
The drivetrain warning light came on shortly after I started the vehicle. I noticed acceleration issues both while driving on side streets and on the freeway. I took the X5 45e into the repair center the day after the notice came on especially given the experience on the freeway, which happened during rush hour traffic. Upon inspection, I was told the starter was beginning to fail and that while there had been a recall on starters on many other BMW models, it did not include the X5 45e. BMW advised I replace the starter immediately due to safety, which cost $2,600. Two weeks later, the same drivetrain light has come on and the X5 is back at the service center for diagnosis.
NHTSA ODI #11755801
Mileage unknown · Aug 5, 2026
Electrical System
Auto Start/Stop button needs to be pressed three times to start the vehicle.
NHTSA ODI #11754934
Mileage unknown · May 15, 2026
Electrical SystemEnginePower Train
2021 BMW X5 xDrive45e PHEV, built October 2020 by BMW AG (Germany). In-service Oct 28, 2021. Vehicle intermittently shows "Drivetrain Malfunction — you can continue driving" warning. DME scan reveals 5 fault codes, all for the conventional 12V pinion starter: 21A50A — Pinion starter: timeout occurred several times in succes…
Read full complaint
2021 BMW X5 xDrive45e PHEV, built October 2020 by BMW AG (Germany). In-service Oct 28, 2021. Vehicle intermittently shows "Drivetrain Malfunction — you can continue driving" warning. DME scan reveals 5 fault codes, all for the conventional 12V pinion starter: 21A50A — Pinion starter: timeout occurred several times in succession 21A511 — Pinion starter: timeout 21611A — Pinion starter: starting torque could not be built up; high counter torque and/or undervoltage 216119 — Pinion starter: line break in starter control (KL50/KL30) 216115 — Pinion starter: attempt to start with blocked starter detected 21A50A and 216115 are protected memory codes that cannot be cleared by standard OBD-II tools. The main 12V AGM battery was replaced and registered; codes continue to recur. This signature matches the B58 pinion starter defect addressed in NHTSA Recall 24V-576 (Aug 2024) and 25V644 (Nov 2025, physical starter replacement). The vehicle's German manufacture date falls inside the production windows of KBA recalls 15630R, 15632R, and 15633R — all covering X5 G05 for short-circuit and fire risk from starter relay corrosion or inadequate mounting. BMW AG has issued an ADAC advisory not to leave affected vehicles running unattended after starting. BMW NA Customer Relations was contacted. Initial verbal response: U.S. recalls don't apply because the xDrive45e PHEV uses a different starter than non-hybrid B58 vehicles. However, codes 216115 and 216119 only exist on vehicles equipped with a conventional pinion starter — confirming this vehicle has the same component. The subsequent written denial pivoted to warranty expiration without addressing the technical or recall-scope questions. Filing so the field record reflects this defect signature for future U.S. recall scope expansion analysis.
NHTSA ODI #11738107
47,600 miles · Mar 5, 2026
Electrical System
The contact owns a 2021 BMW X5. The contact stated that while starting the vehicle, the Push to Start button failed to function as intended. After several attempts, the vehicle started. The drivetrain warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed, and determined that the starter had f…
Read full complaint
The contact owns a 2021 BMW X5. The contact stated that while starting the vehicle, the Push to Start button failed to function as intended. After several attempts, the vehicle started. The drivetrain warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed, and determined that the starter had failed and needed to be replaced. The dealer informed the contact to cease driving the vehicle due to safety concerns. The vehicle was not yet repaired. The vehicle remained at the dealer unrepaired. The manufacturer was notified of the failure. The failure mileage was 47,600.
NHTSA ODI #11722339
30,000 miles · Feb 23, 2026
Electrical System
The contact owns a 2021 BMW X5. The contact stated that while driving at an undisclosed speed on the highway, the vehicle shut off. The vehicle was pulled off to the side of the road, but failed to restart after several attempts. The vehicle was towed to a local dealer, where it was diagnosed with starter failure. The dealer ref…
Read full complaint
The contact owns a 2021 BMW X5. The contact stated that while driving at an undisclosed speed on the highway, the vehicle shut off. The vehicle was pulled off to the side of the road, but failed to restart after several attempts. The vehicle was towed to a local dealer, where it was diagnosed with starter failure. The dealer referenced NHTSA Campaign Number: 20V761000 (ELECTRICAL SYSTEM); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 30,000.
NHTSA ODI #11719875
Mileage unknown · Feb 11, 2026
Electrical System
the vehicle delays to start and will not recognize that key is in the vehicle. the starter button has to be pushed three times until the vehicle recognizes the key is in the vehicle. the vehicle was inspected at a BMW dealership and no codes or errors were found. battery is still good but possible issues with the starter.
NHTSA ODI #11717419
Official recalls
12Apr 20, 2022
BMW of North America, LLC (BMW) is recalling certain 2022 4 Series Gran Coupe (430i, 430i xDrive, M440i xDrive); 2019-2022 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M; 2021-2022 X5 xdrive45e; 2020-2022 X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6M and 2019-2023 X7 xDrive40i, X7 xDrive50i, X7 M50i, X7 xDrive60i, X7 M60i, X7M, Alpina XB7 vehicles. The roof function control unit may be programmed incorrectly, allowing the sunroof to close without the key fob present inside the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence & remedy
Consequence: A sunroof that closes without the key fob present inside the vehicle can increase the risk of injury.
Remedy: Dealers will reprogram the roof function control unit, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact BMW customer service at 1-800-525-7417.
Mar 10, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i, X5 xDrive50i, X5 M50i, X5 xDrive45e, 2021 X7 xDrive40i, X7 M50i, and XB7 vehicles. The head restraints on the second-row outer seats may be the incorrect type for the vehicle.
Consequence & remedy
Consequence: In the event of a crash, the head restraints could detach, and increase the risk of injury.
Remedy: BMW will notify owners, and dealers will inspect the head restraints, and replace them as necessary, free of charge. The recall began May 3, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Feb 19, 2021
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Back Over Prevention:software
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Back Over Prevention: Sensing System: Camera
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Feb 18, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence & remedy
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Additional source detail variants (2)
Service Brakes, Hydraulic:critical Fasteners
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Service Brakes, Hydraulic:foundation Components:disc
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i and X5 xDrive40i vehicles. The right front brake disc may have been assembled with incorrect fasteners, which over time, could result in the front brake disc becoming loose.
Consequence: A loose brake disc could affect vehicle handling and control, and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the right front brake disc and replace it if necessary, along with the unaffected left side brake disc, free of charge. There are no owner vehicles affected; therefore, owner notification is not necessary and, as such, a planned owner notification date is not entered into the recall schedule. Owners may contact BMW's customer service at 1-800-525-7417.
Feb 10, 2021
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence & remedy
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:hydraulic
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Service Brakes, Hydraulic
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Jan 29, 2021
BMW of North America, LLC (BMW) is recalling certain 2021 X5 sDrive40i, X5 xDrive40i, X5M, X5 xDrive45e, X6 sDrive40i, X6 xDrive40i, X7 xDrive40i, X7 M50i vehicles. The steering column shaft's universal joint connection may not have been tightened to specifications, and can become loose.
Consequence & remedy
Consequence: A loose steering column shaft universal joint connection can affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect and, depending upon the inspection, either the bolt will be replaced and tightened to specifications, or the steering column shaft, universal joint, and bolt will be replaced and tightened to specifications, free of charge. The recall began March 30, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Dec 9, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 M340i xDrive, M440i xDrive Coupe, 530i, 530i xDrive, 540i, 540i xDrive, 740Li, 740Li xDrive, 840i Gran Coupe, 840i xDrive Gran Coupe, X5 sDrive40i, X5 xDrive40i, X6 sDrive40i, X6 xDrive40i, and X7 xDrive40i vehicles. The connection between the 48-Volt battery and the starter-generator may not have been assembled properly, which can cause increased electrical resistance at the connections.
Consequence & remedy
Consequence: Increased electrical resistance can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect the connection between the 48-Volt battery and the starter-generator assembly, replacing it if necessary, free of charge. The recall is expected to begin April 12, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Nov 4, 2020
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, xDrive40i, X5 M50i, X5M, X7 xDrive40i, X7 M50i, X6 xDrive40i, X6 M50i and X6M vehicles and 2021 X5 xDrive45e vehicles. The weld between the front axle support and the right front control arm bearing bracket may separate.
Consequence & remedy
Consequence: If the weld between the front axle support and the right front control arm bearing bracket separates, vehicle handling and control may be affected, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front axle support, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Sep 30, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 530e, 530e xDrive, 530e iPerformance and X3 xDrive30e and MINI Cooper Countryman All4 SE, 2020 BMW i8, and 2021 330e, 330e xDrive, 745Le xDrive and X5 xDrive45e vehicles. Debris may have entered one or more of the hybrid battery cells during their production.
Consequence & remedy
Consequence: The debris could result in a short-circuit, increasing the risk of fire or injury.
Remedy: BMW will inspect and, if necessary, replace the battery module free of charge. The remedy is currently being developed. Until the remedy is completed, drivers are instructed to not charge their vehicles. Drivers are instructed to not drive in manual mode, sport mode, and to not use the shift paddles. Owners were notified of the safety risk October 23, 2020. The recall began November 24, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Sep 1, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 X5 sDrive40i, xDrive40i, xDrive50i, X5 M50i, X5M, X6 sDrive40i, xDrive40i, X6 M50i, X6M, X7 M50i and 2021 X5 xDrive45e vehicles. The headlamps may allow a blue light to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Oncoming drivers may be confused by the blue light of approaching vehicles, which could potentially increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the headlamps and, if necessary, replace them, free of charge. The recall began October 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Aug 18, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence & remedy
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Electrical SYSTEM:12V/24V/48V Battery
BMW of North America, LLC (BMW) is recalling certain 2021 330e and X5 xDrive45e, 2020-2021 X3 xDrive30e, and 2020 MINI Countryman SE ALL4 vehicles. Loose welding beads may form a conductive path between the hybrid battery cells which could lead to a short-circuit.
Consequence: A short-circuited hybrid battery may increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will inspect and, if necessary, replace the battery modules, free of charge. BMW issued owners an interim notification on October 16, 2020. Although potentially affected BMW owners received interim owner notification letters, all potentially affected BMW owner vehicles have been remedied; therefore, BMW Final owner notification letters will not be necessary. Owners may contact BMW customer service at 1-800-525-7417.
Aug 14, 2020
BMW of North America, LLC (BMW) is recalling certain 2021 X6 (sDrive40i, xDrive40i and M50i) and X5 (sDrive40i, xDrive40i and M50i) vehicles equipped with certain Pirelli tires. The tires may have a damaged inner layer, possibly resulting in a rapid loss of pressure while the vehicle is moving.
Consequence & remedy
Consequence: A rapid loss of tire pressure while the vehicle is moving can affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW has notified all of the affected owners, and dealers will replace the defective tires, free of charge. BMW has contacted owners by telephone and those owners have had their cars remedied. Owner notification letters will not be sent. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration