IllustrationcHECK ENGINE LIGHT IS ON AND BASED ON THE CODE THERE IS A PROBLEM WITH THE ACTIVE GRILL SHUTTERS. i DID SOME RESEARCH AND SEEMS THIS IS A COMMON PROBLEM WHERE THE ACTUATOR MOTOR MAY BE THE PROBLEM
2020 BMW X5
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2020 BMW X5 do not stand out strongly from the model-year median of 100.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all X5 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 25 of 111 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports7 fire reports2 injury reports
What owners actually said
111 reportsThe front headlight enclosure repeatedly fogs because moisture gets inside. It has just happened again to us. This has been widely reported by BMW owners and is a significant safety issue that BMW has not addressed. In the interest of public safety BMW should recall and replace whatever defective parts cause the problem.
The contact owns a 2020 BMW X5. The contact stated that upon starting the vehicle, the check engine warning illuminated on the instrument panel. The vehicle was taken to the dealer, who diagnosed a failure with the active air flap controller. The vehicle was not repaired. The manufacturer was notified of the failure but referred…
Read full complaint
The contact owns a 2020 BMW X5. The contact stated that upon starting the vehicle, the check engine warning illuminated on the instrument panel. The vehicle was taken to the dealer, who diagnosed a failure with the active air flap controller. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 45,000.
Rear restraint system malfunction. BMW states it’s a faulty airbag that is not under warranty. Car has never been in an accident and only 4 years old so there should not have been any issues. It is a safety issue for passengers.
I was driving in the rain and I experienced an issue with a vehicle’s automatic safety systems that are designed to aid you from crashing and it would have been the proximate cause of my fatal accident had I not realized what was happening and stopped the system’s actions. The system kicked in when I touched the rumble strip wi…
Read full complaint
I was driving in the rain and I experienced an issue with a vehicle’s automatic safety systems that are designed to aid you from crashing and it would have been the proximate cause of my fatal accident had I not realized what was happening and stopped the system’s actions. The system kicked in when I touched the rumble strip with my front left tire but I brought it back before the system could because it detected the event and created a countering event to correct my mistake, hence begins the issue. When the car veered right it didn’t need to so I had to counter that movement to keep from hitting the car next to me. The car then detected this and created another event that I again corrected before the system could. This created a situation now where the systems working together were creating events to correct events it didn’t need to do because the systems when working together now had a response time to real world events slower than mine and it couldn’t stop itself from doing this solely due to a lack of processing power. In less than 2 seconds I went from driving straight to fighting a car that put me into a horizontal “death wobble” that would have caused my car to spin either clockwise or counterclockwise at some point had I panicked and slammed on the brakes, which is what most people would have done in this situation, but I knew better. I realized what was happening immediately and I stopped it by simply keeping the steering wheel centered straight ahead forcefully until the safety systems caught up and cleared all the events. I am giving you the short version because the system in the first 1-2 seconds made, created, and stacked at least 5 of these events as I fought to correct them until the vehicle’s body roll and “death wobble” stopped and I was able to drive straight again. The wet roadways and rain only made it worse. This is a huge problem and may cause so many fatal accidents that I can’t even imagine, as I a retired policer this
The contact owns a 2020 BMW X5. The contact stated that the PUSH to START button was inoperable. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the control sensor for the start button to be replaced. The vehicle was repaired. The manufact…
Read full complaint
The contact owns a 2020 BMW X5. The contact stated that the PUSH to START button was inoperable. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the control sensor for the start button to be replaced. The vehicle was repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 40,800.
I have received two malfunction alerts two months apart for both driver and passenger airbags. The first dealership reset the fault codes and the second different dealership found 4 faults and reset it as well. I learned from the second dealership that the airbag sensors sit below the cup holders, secured by a screw in each cup …
Read full complaint
I have received two malfunction alerts two months apart for both driver and passenger airbags. The first dealership reset the fault codes and the second different dealership found 4 faults and reset it as well. I learned from the second dealership that the airbag sensors sit below the cup holders, secured by a screw in each cup on the bottom base of the housing. They removed the rubber bottom portion of the cup holder and noticed there was liquid reside and the screw appeared rusted. They believe the water may have leaked through the screw and ruined the airbag sensors. If this was true, they mentioned the airbags would not work properly and I would be responsible to pay for the work performed to correct the issue since they consider this a outside influence and not covered by my warranty. I mentioned that this a a huge safety concern, a terrible design flaw, and no where in the owners manual does it warn owners of the potential safety concerns of using cup holders that seat above the airbag sensors. I contacted BMW public relations, filed a complaint, and they have heard of this complaint before and advised different safety teams would see my compliant and wait for a callback.
BMW front cup holders have hole in bottom and it allows condensation/liquid to migrate through bottom to air bag sensor located directly underneath cup holders. Consumers are at risk of air bags going off unintentionally and/or not going off at all. Sensor should not be directly under a cup holder and/or the cup holder should …
Read full complaint
BMW front cup holders have hole in bottom and it allows condensation/liquid to migrate through bottom to air bag sensor located directly underneath cup holders. Consumers are at risk of air bags going off unintentionally and/or not going off at all. Sensor should not be directly under a cup holder and/or the cup holder should not have a hole directly above safety sensor. BMW design defect. Consumers are having to pay out of pocket for sensor to be replaced as it is not covered under warranty. Additionally, there is a pending class action lawsuit that has been filed and documentation of this being a problem over several BMW models is well documented in forums, etc. on the internet.
WHILE PARKING THE VEHICLE IN A HEAD-ON PARKING SPOT, THE CAR SUDDENLY ACCELERATED WITHOUT WARNING AND HIT A WALL. THE CAR THEN WENT INTO REVERSE AND SPED UP RAPIDLY UNTIL IT HIT A CONCRETE PATIO ON THE OTHER SIDE OF THE PARKING LOT. THE BRAKE PEDAL WAS DEPRESSED WITH SUBSTANTIAL FORCE THE ENTIRE TIME THE VEHICLE WAS MOVING BUT…
Read full complaint
WHILE PARKING THE VEHICLE IN A HEAD-ON PARKING SPOT, THE CAR SUDDENLY ACCELERATED WITHOUT WARNING AND HIT A WALL. THE CAR THEN WENT INTO REVERSE AND SPED UP RAPIDLY UNTIL IT HIT A CONCRETE PATIO ON THE OTHER SIDE OF THE PARKING LOT. THE BRAKE PEDAL WAS DEPRESSED WITH SUBSTANTIAL FORCE THE ENTIRE TIME THE VEHICLE WAS MOVING BUT THE VEHICLE WOULD NOT STOP MOVING. THE BRAKES DID NOT ENGAGE. I DO NOT RECALL HOW THE CAR WENT FROM DRIVE TO REVERSE. FORTUNATELY, THERE WERE NO PEOPLE OR CARS IN THE PARKING LOT AT THE TIME OF THE INCIDENT. THE AUTO BODY SHOP THAT CURRENTLY HAS POSSESSION OF THE VEHICLE COULD NOT FIND ANYTHING WRONG WITH THE COMPUTER/ELECTRICAL SYSTEMS IN THE VEHICLE NOR WERE THEY ABLE TO RECREATE THE INCIDENT. I DO NOT KNOW HOW THOROUGH THEY LOOKED FOR PROBLEMS. BMW HAS BEEN NOTIFIED AND HOPEFULLY THEY WILL SEND A CREW TO INVESTIGATE. THE CAR IS CURRENTLY AT THE AUTO BODY SHOP BUT MY INSURANCE GOMPANY, GEICO, WILL HAVE THE CAR TOWED TO ONE OF THEIR FACILITIES IN A COUPLE OF DAYS. THE CAR HAS BEEN DEEMED A TOTAL LOSS DUE TO ALL OF THE DAMAGE. I HAVE BEEN HAVING ELECTRONICS ISSUES WITH THE CAR SINCE PURCHASE IN JUNE 2020, HOWEVER, THEY HAVE BEEN RELATED TO THE ENTERTAINMENT AND COMMUNICATION SYSTEMS. IN HINDSIGHT, I REALIZE THAT I HAD TWO OTHER INSTANCES IN THE PAST WITH SUDDEN ACCELERATION WITH THIS CAR. I THOUGHT NOTHING OF IT AT THE TIME BUT THEY MAY BE RELATED TO THIS LATEST INCIDENT.
squeaking and grinding in steering column, overheated steering column to the touch. Took to local BMW and was informed it was an issue with steering rack (after two visits there) and part has to be ordered and replaced.
Official recalls
1125V644000 · Electrical System:starter Assembly
Sep 25, 2025
BMW of North America, LLC (BMW) is recalling certain 2020 340I, X6, 2020-2025 840I, 2020-2022 740LI, 2019-2020 X7, and X5 vehicles. After repeated attempts, the starter motor may overheat from an electrical overload.
Consequence & remedy
Consequence: An overheated starter motor can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.
Remedy: Dealers will replace the engine starter, free of charge. This recall includes vehicles repaired under recall 24V576 and those owners will need to have their vehicle repaired again. Owner notification letters were mailed February 9, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 17, 2025.
24V576000 · Electrical System:starter Assembly; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
Aug 1, 2024
BMW of North America, LLC is recalling certain 2019-2020 X5, X7, 2020 3 Series Sedan, X6, 2020-2021 7 Series Sedan, 2020 8 Series Convertible, 8 Series Coupe, and 2020 8 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. In the event the starter motor fails, repeated attempts to start the vehicle can cause the starter motor to overheat from an electrical overload.
Consequence & remedy
Consequence: A starter motor that overheats can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed September 27, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
BMW of North America, LLC is recalling certain 2019-2020 X5, X7, 2020 3 Series Sedan, X6, 2020-2021 7 Series Sedan, 2020 8 Series Convertible, 8 Series Coupe, and 2020 8 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. In the event the starter motor fails, repeated attempts to start the vehicle can cause the starter motor to overheat from an electrical overload.
Consequence: A starter motor that overheats can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed September 27, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Electrical System:starter Assembly
BMW of North America, LLC is recalling certain 2019-2020 X5, X7, 2020 3 Series Sedan, X6, 2020-2021 7 Series Sedan, 2020 8 Series Convertible, 8 Series Coupe, and 2020 8 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. In the event the starter motor fails, repeated attempts to start the vehicle can cause the starter motor to overheat from an electrical overload.
Consequence: A starter motor that overheats can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.
Remedy: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed September 27, 2024. Owners may contact BMW customer service at 1-800-525-7417.
22V267000 · Visibility:sun/moon Roof Assembly
Apr 20, 2022
BMW of North America, LLC (BMW) is recalling certain 2022 4 Series Gran Coupe (430i, 430i xDrive, M440i xDrive); 2019-2022 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M; 2021-2022 X5 xdrive45e; 2020-2022 X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6M and 2019-2023 X7 xDrive40i, X7 xDrive50i, X7 M50i, X7 xDrive60i, X7 M60i, X7M, Alpina XB7 vehicles. The roof function control unit may be programmed incorrectly, allowing the sunroof to close without the key fob present inside the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."
Consequence & remedy
Consequence: A sunroof that closes without the key fob present inside the vehicle can increase the risk of injury.
Remedy: Dealers will reprogram the roof function control unit, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact BMW customer service at 1-800-525-7417.
21V096000 · Back Over Prevention: Sensing System: Camera; Back Over Prevention:software
Feb 19, 2021
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Back Over Prevention:software
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Back Over Prevention: Sensing System: Camera
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
Remedy: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
21V062000 · Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:hydraulic
Feb 10, 2021
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence & remedy
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:hydraulic
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Service Brakes, Hydraulic
BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.
Consequence: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.
20V678000 · Suspension:front:control Arm
Nov 4, 2020
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, xDrive40i, X5 M50i, X5M, X7 xDrive40i, X7 M50i, X6 xDrive40i, X6 M50i and X6M vehicles and 2021 X5 xDrive45e vehicles. The weld between the front axle support and the right front control arm bearing bracket may separate.
Consequence & remedy
Consequence: If the weld between the front axle support and the right front control arm bearing bracket separates, vehicle handling and control may be affected, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front axle support, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
20V528000 · Exterior Lighting:headlights
Sep 1, 2020
BMW of North America, LLC (BMW) is recalling certain 2020-2021 X5 sDrive40i, xDrive40i, xDrive50i, X5 M50i, X5M, X6 sDrive40i, xDrive40i, X6 M50i, X6M, X7 M50i and 2021 X5 xDrive45e vehicles. The headlamps may allow a blue light to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Oncoming drivers may be confused by the blue light of approaching vehicles, which could potentially increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the headlamps and, if necessary, replace them, free of charge. The recall began October 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.
20V465000 · Electrical System:starter Assembly; Power Train:automatic Transmission
Aug 7, 2020
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive 40i, X5 xDrive 40i and one X7 xDrive 40i vehicle. The starter motor may have an extra bolt that could potentially fall into the transmission housing and cause an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the starter motor for the extra bolt, removing it if necessary. Dealers will also inspect the starter for damage, and check if the bolt has fallen into the transmission housing, replacing any damaged parts as necessary. All repairs will be performed free of charge. The recall began on October 2, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Electrical System:starter Assembly
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive 40i, X5 xDrive 40i and one X7 xDrive 40i vehicle. The starter motor may have an extra bolt that could potentially fall into the transmission housing and cause an engine stall.
Consequence: An engine stall increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the starter motor for the extra bolt, removing it if necessary. Dealers will also inspect the starter for damage, and check if the bolt has fallen into the transmission housing, replacing any damaged parts as necessary. All repairs will be performed free of charge. The recall began on October 2, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Power Train:automatic Transmission
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive 40i, X5 xDrive 40i and one X7 xDrive 40i vehicle. The starter motor may have an extra bolt that could potentially fall into the transmission housing and cause an engine stall.
Consequence: An engine stall increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the starter motor for the extra bolt, removing it if necessary. Dealers will also inspect the starter for damage, and check if the bolt has fallen into the transmission housing, replacing any damaged parts as necessary. All repairs will be performed free of charge. The recall began on October 2, 2020. Owners may contact BMW customer service at 1-800-525-7417.
20V434000 · Steering; Steering:column
Jul 28, 2020
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X5 sDrive40i, X5 xDrive40i and X5 xDrive50i vehicles and 2020 X6M vehicles. The steering column shaft bearing plate may not have been properly attached to the vehicle, allowing it to loosen.
Consequence & remedy
Consequence: A loose bearing plate can affect the vehicle's handling and control, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the steering column shaft bearing plate and properly attach or replace it, as necessary, free of charge. BMW telephoned owners and all of the vehicles have been remedied. No owner notification letter is necessary. Please contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Steering:column
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X5 sDrive40i, X5 xDrive40i and X5 xDrive50i vehicles and 2020 X6M vehicles. The steering column shaft bearing plate may not have been properly attached to the vehicle, allowing it to loosen.
Consequence: A loose bearing plate can affect the vehicle's handling and control, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the steering column shaft bearing plate and properly attach or replace it, as necessary, free of charge. BMW telephoned owners and all of the vehicles have been remedied. No owner notification letter is necessary. Please contact BMW customer service at 1-800-525-7417.
Steering
BMW of North America, LLC (BMW) is recalling certain 2019-2020 X5 sDrive40i, X5 xDrive40i and X5 xDrive50i vehicles and 2020 X6M vehicles. The steering column shaft bearing plate may not have been properly attached to the vehicle, allowing it to loosen.
Consequence: A loose bearing plate can affect the vehicle's handling and control, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the steering column shaft bearing plate and properly attach or replace it, as necessary, free of charge. BMW telephoned owners and all of the vehicles have been remedied. No owner notification letter is necessary. Please contact BMW customer service at 1-800-525-7417.
19V684000 · Back Over Prevention: Sensing System: Camera
Sep 27, 2019
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Consequence & remedy
Consequence: The lack of an image in the back-up camera display increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
19V631000 · Steering:rack And Pinion:rack
Aug 28, 2019
BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, X5 xDrive40i, X5 M50i, X7 xDrive40i and X7 M50i vehicles. The steering rack pinion teeth may break under load, resulting in a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control increases risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the steering rack, free of charge. The recall began August 21, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.