NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
271 reports50,000 miles · Dec 12, 2017
Power Train
I HAVE A 2012 BMW X5 WITH ABOUT 70K MILES ON IT. ABOUT 12-18 MONTHS AGO, I STARTED NOTICING ISSUES WITH SHUDDER/SHAKE WHEN TURNING AT LOW SPEEDS. I MENTIONED IT TO BMW SERVICE BUT THEY TOLD ME THAT THEY DON'T SEE ANY ISSUES. ABOUT 4-5 MONTHS BACK WHEN I COMPLAINED AGAIN, THIS TIME THEY TOLD ME THAT THERE IS AN ISSUE. THE ISSUE I…
Read full complaint
I HAVE A 2012 BMW X5 WITH ABOUT 70K MILES ON IT. ABOUT 12-18 MONTHS AGO, I STARTED NOTICING ISSUES WITH SHUDDER/SHAKE WHEN TURNING AT LOW SPEEDS. I MENTIONED IT TO BMW SERVICE BUT THEY TOLD ME THAT THEY DON'T SEE ANY ISSUES. ABOUT 4-5 MONTHS BACK WHEN I COMPLAINED AGAIN, THIS TIME THEY TOLD ME THAT THERE IS AN ISSUE. THE ISSUE IS WITH THE TRANSFER CASE. THEY SAID IT'S A VERY EXPENSIVE REPAIR AND TOLD ME THE ORIGINAL PARTS+LABOR RUNS AT OVER $7,000 BUT I CAN GET A REFURBISHED PART AT AROUND $3,200. FOR A VEHICLE LIKE BMW, I DIDN'T EXPECT IT TO HAVE SUCH MAJOR ISSUES SOON AFTER THE WARRANTY ENDED. I DID SOME RESEARCH AND I SEE SO MANY INDIVIDUALS REPORTING THE EXACT SAME ISSUES WITH BMW X5 IN THAT TIME RANGE. I HOPE BMW WILL ACCEPT THE PROBLEM AND ISSUE A SAFETY RECALL FOR IT SO WE, THE CUSTOMERS, DON'T HAVE TO PAY FOR SUCH A MAJOR ISSUE WITH THE CAR. AFTER THIS EXPERIENCE, I HAVE DECIDED NOT TO BUY ANYMORE BMWS AND HAVE BEEN RECOMMENDING THE SAME TO OTHERS.
NHTSA ODI #11054269
Mileage unknown · Dec 4, 2017
Fuel/propulsion System
HESITATION STARTING THE CAR, DIAGNOSIS BY DEALER WAS FUEL PUMP FAILING. MILEAGE WAS 65,000. COST TO REPAIR 1500.00. I SEE THERE WAS A RECALL FOR MODEL YEARS 2008-2011.
NHTSA ODI #11052216
55,000 miles · Nov 29, 2017
Engine
I WAS DRIVING ON THE HIGHWAY WITH A POSTED SPEED LIMIT OF 70 MPH WITH MY FAMILY ON A ROAD TRIP. THE CHECK ENGINE LIGHT CAME ON AND SAID ENGINE IS OVERHEATTED AND POWER IS REDUCED. WHEN I TRIED TO PRESS DOWN ON THE GAS, THE CAR WOULD NOT GO FASTER. TRAFFIC WAS A BIT HEAVY AND I WAS GOING 70 MPH WITH TRAFFIC BEHIND ME. IT WAS NERV…
Read full complaint
I WAS DRIVING ON THE HIGHWAY WITH A POSTED SPEED LIMIT OF 70 MPH WITH MY FAMILY ON A ROAD TRIP. THE CHECK ENGINE LIGHT CAME ON AND SAID ENGINE IS OVERHEATTED AND POWER IS REDUCED. WHEN I TRIED TO PRESS DOWN ON THE GAS, THE CAR WOULD NOT GO FASTER. TRAFFIC WAS A BIT HEAVY AND I WAS GOING 70 MPH WITH TRAFFIC BEHIND ME. IT WAS NERVE WRECKING TO SLOW DOWN (BECAUSE THE CAR ISN'T PRODUCING ANY POWER BECAUSE THE ENGINE IS OVERHEATTED) DUE TO PHYSICS AND NEEDING TO PULL OVER TO THE SIDE OF A BUSY HIGHWAY. WHEN I TOOK THE CAR TO THE MECHANIC, THEY TOLD ME THE WATER PUMP HAS FAILED. MY CAR ONLY HAS 55K MILES ON IT.
NHTSA ODI #11051265
57,200 miles · Nov 24, 2017
Engine
LAST SATURDAY 11/11/2017, WE AS A FAMILY (ME, MY WIFE AND MY 6 YEAR OLD CHILD), STARTED TO GO ON A 3 HOUR DRIVE FROM OUR HOME TO TELIMENA STATE PARK TO WATCH FOR THE FALL FOLIAGE COLORS THROUGH THE BEAUTIFUL TELIMENA NATIONAL SCENIC BYWAY IN ARKANSAS. IT IS PART OF A HUGE OUACHITA NATIONAL FOREST. LITTLE DID WE KNOW THAT WE ARE …
Read full complaint
LAST SATURDAY 11/11/2017, WE AS A FAMILY (ME, MY WIFE AND MY 6 YEAR OLD CHILD), STARTED TO GO ON A 3 HOUR DRIVE FROM OUR HOME TO TELIMENA STATE PARK TO WATCH FOR THE FALL FOLIAGE COLORS THROUGH THE BEAUTIFUL TELIMENA NATIONAL SCENIC BYWAY IN ARKANSAS. IT IS PART OF A HUGE OUACHITA NATIONAL FOREST. LITTLE DID WE KNOW THAT WE ARE FIRST TIMERS AND WE DID NOT ANTICIPATE OUR T-MOBILE CELL PHONE SIGNALS WILL QUIT ON US. EVERYTHING WAS GOING GOOD UNTIL A POINT WHERE MY ENGINE ALMOST QUIT ON ME WITH A WARNING MESSAGE "ENGINE IS NOW WORKING AT A REDUCED SPEED AND ADVISED TO SEE NEAREST BMW DEALER", WE WERE ON A SPEED OF ABOUT 60MPH AND THE CAR DOES NOT ACCELERATE ALL OF A SUDDEN, IT WAS EXTREMELY EXTREMELY SCARY AND TERRIFYING. WITH ALL THE TRAFFIC, WE BARELY MANAGED TO DIVERT A POTENTIAL ACCIDENT AND PULLED OVER TO THE SIDE AND SHUT DOWN THE CAR. WE MANAGED TO SURVIVE THE SUDDEN ENGINE QUITTING ON US ON A SPEEDY ROAD. THIS IS EXTREMELY LIFE THREATENING. WE DID NOT HAVE OUR CELL PHONE SIGNAL AND WE WERE STRANDED FOR SOME HELP FOR ABOUT 4 HOURS. WE DID NOT WANT TO TAKE CHANCES DRIVING THIS CAR AND DO ANOTHER LIFE THREATENING EXPERIENCE. WE MANAGED TO GET SOME HELP AND GET OUT OF THERE. NEXT DAY WITH SOME HELP, I MANAGED TO DRIVE THE CAR SLOWLY BY MYSELF AND A FRIEND FOLLOWING ME. WE MADE IT TO THE DEALERSHIP IN BMW PLANO. RECENTLY I HAD A RECALL WORK DONE WITH BMW PLANO ON 10/30-11/1 FOR 3 ITEMS. FRONT AIRBAG, FRONT DRIVESHAFT, MASS AIRFLOW SENSOR. YESTERDAY THEY RETURNED THE CAR MENTIONING THAT THE ISSUE IS POSSIBLY RELATED TO OTHER UNRELATED ITEMS. (1) CHARGE PIPE NEAR THROTTLE BODY IS CRACKED / TORN / LEAKED.. CHARGE PIPE CODES SEEN DURING SMOKE TESTING I BOUGHT THIS CAR ON 30TH DEC 2016 WHEN THE MILEAGE ON THE CAR WAS AROUND 48000 MILES AND IT WAS WORKING FINE UP UNTIL THIS LIFE THREATENING AND TERRIFYING SITUATION NOW AT CURRENT MILEAGE OF 57000 MILES.
NHTSA ODI #11048198
57,200 miles · Nov 24, 2017
Unknown Or Other
EGR COOLER AT FRONT OF ENGINE IS LEAKING EXHAUST. EXHAUST DIESEL SMELL IS COMING IN SIDE THE CABIN. DRIVER AND PASSENGERS SMELLING DIESEL EXHAUST. DETERIORATING HEALTH OF FAMILY ADULTS AND KIDS. UNSAFE. NUMEROUS COMPLAINTS ARE ALREADY FOUND ONLINE. REACHED OUT TO BMW NORTH AMERICA CUSTOMERREALTIONS@BMWUSA.COM AND THEY WONT COVER…
Read full complaint
EGR COOLER AT FRONT OF ENGINE IS LEAKING EXHAUST. EXHAUST DIESEL SMELL IS COMING IN SIDE THE CABIN. DRIVER AND PASSENGERS SMELLING DIESEL EXHAUST. DETERIORATING HEALTH OF FAMILY ADULTS AND KIDS. UNSAFE. NUMEROUS COMPLAINTS ARE ALREADY FOUND ONLINE. REACHED OUT TO BMW NORTH AMERICA CUSTOMERREALTIONS@BMWUSA.COM AND THEY WONT COVER IT. 2012 BMW X5 XDRIVE35D 57200 MILES ON CAR. THIS IS UNSAFE CAR. DIESEL SMELL INSIDE CAR IS BAD. MY EMAIL [XXX] PHONE [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11048195
89,000 miles · Nov 20, 2017
Engine
2012 BMW X5 XDRIVE50I PURCHASED 10-25-2014 AS CERTIFIED PRE-OWNED FROM BMW OF AUSTIN WITH 54,554 MILES AND EXTENDED WARRANTY TO 8-1-17 OR 100,000 MILES. ALL SERVICE WORK AND MAINTENANCE PERTAINING TO ENGINE DONE AT BMW OF AUSTIN ON TIME AS SCHEDULED. NUMEROUS RECALL WORK PERFORMED UNDER WARRANTY. NUMEROUS ISSUES WITH ENGINE HESI…
Read full complaint
2012 BMW X5 XDRIVE50I PURCHASED 10-25-2014 AS CERTIFIED PRE-OWNED FROM BMW OF AUSTIN WITH 54,554 MILES AND EXTENDED WARRANTY TO 8-1-17 OR 100,000 MILES. ALL SERVICE WORK AND MAINTENANCE PERTAINING TO ENGINE DONE AT BMW OF AUSTIN ON TIME AS SCHEDULED. NUMEROUS RECALL WORK PERFORMED UNDER WARRANTY. NUMEROUS ISSUES WITH ENGINE HESITATION DURING ACCELERATION REPORTED TO DEALER, INVESTIGATED BY DEALER, AND SUPPOSEDLY "FIXED" BY DEALER. PROBLEMS WITH ENGINE HESITATION AT ACCELERATION PERSISTED. PROBLEM REPORTED TWICE TO DEALER THE LAST MONTH OF ELIGIBLE WARRANTY ALONE ALONG WITH STATEMENT THAT ENGINE WAS BURNING THROUGH AN EXCESSIVE ABOUT OF BMW SUPPLIED SYNTHETIC OIL (ON 7/5/17 AND AGAIN ON 7/21/17). ENGINE FINALLY SEIZED ENTIRELY ON 10/25/17 AT 89,000 MILES WHILE DRIVING AT 50 MPH AND WAS TOWED TO BMW OF AUSTIN. SERVICE REP STATED THEY COULD NOT GET THE ENGINE STARTED AND REQUESTED APPROVAL TO CRACK OPEN THE ENGINE COMPARTMENT TO INVESTIGATE. THE WORK WAS APPROVED AND HE SAID THERE WAS "UNUSUAL AND SEVERAL SCORING ON THE NUMBER 6 CYLINDER THAT WOULD REQUIRE REPLACING THE ENGINE." THIS TYPE OF CATASTROPHIC ENGINE FAILURE IS NOT USUAL FOR A WELL MAINTAINED ENGINE. THE NUMEROUS RECALLS ON THIS VEHICLE ARE SUSPECT IN THE EARLY ENGINE FAILURE. THE KNOWN DEFECTS IN MATERIAL PARTS ASSOCIATED WITH THE FRONT DRIVE SHAFT BEING THE MOST SUSPECT. TO DATE, BMW USA IS ONLY WILLING TO OFFER $5000 TOWARDS REPAIR OR TRADE IN (NOW ONLY WORTH $2500 DUE TO NON-FUNCTIONING ENGINE). I STRONGLY BELIEVE THIS ISSUE SHOULD BE HANDLED UNDER THE 10 YEAR/120000 MILE EXTENDED WARRANTY PROVIDED BY BMW FOR REPAIRS RELATED TO THE AFOREMENTIONED RECALLS. THEY DISAGREE.
NHTSA ODI #11047501
75,000 miles · Nov 14, 2017
Power Train
AT 75K MILES MY BMW X5 BEGAN SHUTTERING WHILE MAKING SHARP, SLOW TURNS. I THOUGHT IT WAS THE NEW TIRES WE PUT ON. THEN THE STUTTERING HAPPENED WHEN COMING TO A STOP, AS WELL. TOOK IT TO THE DEALERSHIP WHERE IT HAS BEEN SERVICED ALL ALONG AND THEY SAID THE TRANSFER CASE NEEDS TO BE REPLACED. REALLY, AT 75K MILES. WHEN I WENT…
Read full complaint
AT 75K MILES MY BMW X5 BEGAN SHUTTERING WHILE MAKING SHARP, SLOW TURNS. I THOUGHT IT WAS THE NEW TIRES WE PUT ON. THEN THE STUTTERING HAPPENED WHEN COMING TO A STOP, AS WELL. TOOK IT TO THE DEALERSHIP WHERE IT HAS BEEN SERVICED ALL ALONG AND THEY SAID THE TRANSFER CASE NEEDS TO BE REPLACED. REALLY, AT 75K MILES. WHEN I WENT ONLINE TO RESEARCH THE ITEM I FOUND THAT THE PREVIOUS YEAR MODEL WAS A RECALL. OBVIOUSLY, BMW DID NOT FIX THE ITEM ON THE 2012 THAT I OWN. A FAULTY TRANSFER CASE IN THE X5 CAN CAUSE LOSS OF DRIVE AND THIS CAN CAUSE SERIOUS INJURIES OR DEATH IF THE OCCUPANTS ARE ON A FREEWAY OR IN AN INTERSECTION ETC WHERE THEY ARE STUCK. WHAT WOULD IT TAKE FOR SOMEONE TO LOOK AT THIS ISSUE AND HOLD THE MANUFACTURERS ACCOUNTABLE.
NHTSA ODI #11045924
Mileage unknown · Nov 2, 2017
Air Bags
TAKATA RECALL NHTSA RECALL 16V071 HAS STATUS THAT REMEDY PARTS ARE AVAILABLE. DESPITE OF THIS, MY LOCAL BMW DEALER (PETER PAN BMW IN SAN MATEO, CALIFORNIA) SAYS PARTS ARE NOT AVAILABLE AND THAT IT STILL WILL TAKE SEVERAL MONTHS DUE TO PARTS BEING SHIPPED FROM EUROPE. I DON'T FIND IT ACCEPTABLE THAT BMW IS DELAYING SUCH REP…
Read full complaint
TAKATA RECALL NHTSA RECALL 16V071 HAS STATUS THAT REMEDY PARTS ARE AVAILABLE. DESPITE OF THIS, MY LOCAL BMW DEALER (PETER PAN BMW IN SAN MATEO, CALIFORNIA) SAYS PARTS ARE NOT AVAILABLE AND THAT IT STILL WILL TAKE SEVERAL MONTHS DUE TO PARTS BEING SHIPPED FROM EUROPE. I DON'T FIND IT ACCEPTABLE THAT BMW IS DELAYING SUCH REPAIRS AND WOULD EXPECT BMW TO USE EXPEDITED SHIPPING SOLUTIONS TO COMPLETE THIS CRITICAL FIX. *CN
NHTSA ODI #11042826
140,000 miles · Oct 31, 2017
EngineSteering
TL* THE CONTACT OWNS A 2012 BMW X5. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING REVERSED, THE STEERING WHEEL SEIZED AND DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO FAULKNER BMW LOCATED AT: 1530 MANHEIM PIKE, LANCASTER, PA 17601, (717) 569-4269, TO BE DIAGNOSED. THE CONTACT STATED THAT THE IDLER PULLEY BOLT FRACTURED …
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING REVERSED, THE STEERING WHEEL SEIZED AND DIFFICULT TO MANEUVER. THE VEHICLE WAS TOWED TO FAULKNER BMW LOCATED AT: 1530 MANHEIM PIKE, LANCASTER, PA 17601, (717) 569-4269, TO BE DIAGNOSED. THE CONTACT STATED THAT THE IDLER PULLEY BOLT FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V550000 (STEERING, ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #11041551
Mileage unknown · Oct 28, 2017
Air Bags
TAKATA RECALL (THIS IS MORE OF A CONCERN AND REQUEST FOR HELP RATHER THAN AN INCIDENT. I WAS DIRECTED TO THIS WEBSITE BY THE RECALL NOTICE. NO OTHER INSTRUCTIONS OTHER THAN THE URL WERE GIVEN) I LIVE ON GALVESTON ISLAND IN TEXAS, SOUTH OF HOUSTON. IT IS ONE OF THE HOTTEST, MOST HUMID PLACES IN THE US. MY PASSENGER SIDE AIRB…
Read full complaint
TAKATA RECALL (THIS IS MORE OF A CONCERN AND REQUEST FOR HELP RATHER THAN AN INCIDENT. I WAS DIRECTED TO THIS WEBSITE BY THE RECALL NOTICE. NO OTHER INSTRUCTIONS OTHER THAN THE URL WERE GIVEN) I LIVE ON GALVESTON ISLAND IN TEXAS, SOUTH OF HOUSTON. IT IS ONE OF THE HOTTEST, MOST HUMID PLACES IN THE US. MY PASSENGER SIDE AIRBAG WAS RECALLED IN MARCH OF 2017. DESPITE REPEATED REQUESTS TO BMW, THEY STILL WILL NOT REPLACE THE RECALLED AIRBAG. I AM CONCERNED BECAUSE IN APRIL 2016, NOT FAR FROM WHERE I LIVE, A 17 YEAR OLD GIRL WAS KILLED BY SHRAPNEL FROM HER AIRBAG IN A CRASH THAT SHE OTHERWISE WOULD HAVE WALKED AWAY FROM.
NHTSA ODI #11040761
Official recalls
10Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Jan 10, 2017
BMW of North America, LLC (BMW) is recalling certain 2012 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain 2009 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, and X5 M vehicles, 2008-2009 X6 xDrive 35i, X6 xDrive50i, X6 M, and 2009 X5 xDrive35d vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, BMW is recalling certain 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, and 2008 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the front passenger air bag inflator or air bag module, free of charge. Interim letters were mailed March 2017. Owners will receive a second notice when remedy parts become available. Owners may contact BMW customer service at 1-800-525-7417.
Jun 13, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 VEHICLES EQUIPPED WITH A DIESEL ENGINE AND 2013 X5 AND X6 VEHICLES. DUE TO A MACHINING ERROR OF THE STEERING GEAR SURFACE, POWER STEERING FLUID MAY LEAK.
Consequence & remedy
Consequence: LEAKING POWER STEERING FLUID CAN SPRAY ONTO HOT EXHAUST PARTS, INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT, AND IF NECESSARY, REPLACE THE STEERING GEAR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 20, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jan 23, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 XDRIVE 35I SPORTS ACTIVITY VEHICLES, MANUFACTURED FROM DECEMBER 19, 2011, THROUGH DECEMBER 21, 2011. DUE TO A MANUFACTURING ERROR, ENGAGEMENT OF THE TRANSMISSIONS PARKING LOCK MAY NOT OCCUR EVEN IF THE P POSITION HAS BEEN SELECTED AND IS DISPLAYED.
Consequence & remedy
Consequence: IF THE DRIVER BELIEVES THAT THE TRANSMISSION IS IN PARK AND DOES NOT USE THE PARKING BRAKE, THE VEHICLE COULD ROLL AWAY AFTER EXITING THE VEHICLE INCREASING THE RISK OF A CRASH OR INJURY.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 2, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ18001 · Idler Pulley Bolt Failure
Opened Apr 18, 2018 · Closed Dec 1, 2018
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Additional source detail variants (3)
Steering
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist System
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Illustration