NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
271 reports89,000 miles · Jan 2, 2019
EngineFire
TL* THE CONTACT OWNED A 2012 BMW X5. WHILE DRIVING 65 MPH, THE ENGINE MALFUNCTION AND REDUCE SPEED WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PULL THE VEHICLE OFF THE ROADWAY AND IT CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT F…
Read full complaint
TL* THE CONTACT OWNED A 2012 BMW X5. WHILE DRIVING 65 MPH, THE ENGINE MALFUNCTION AND REDUCE SPEED WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PULL THE VEHICLE OFF THE ROADWAY AND IT CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT FACILITY. A FIRE REPORT WAS FILED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.
NHTSA ODI #11164582
131,000 miles · Jan 2, 2019
EngineFuel/propulsion SystemPower Train
ON AUGUST 7, 2018, I WAS TRAVELING ON INTERSTATE 95 IN MARYLAND (NORTH OF BALTIMORE) IN ROUTE TO NEW YORK STATE. DURING THE HIGHWAY DRIVE, MY BMW DRASTICALLY REDUCED SPEED TO 10 MILES PER HOUR AND THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. I HAD TO MOVE MY CAR TO A SAFE PLACE TO AVOID BEING HIT BY THE OTHER VEHICLES ON T…
Read full complaint
ON AUGUST 7, 2018, I WAS TRAVELING ON INTERSTATE 95 IN MARYLAND (NORTH OF BALTIMORE) IN ROUTE TO NEW YORK STATE. DURING THE HIGHWAY DRIVE, MY BMW DRASTICALLY REDUCED SPEED TO 10 MILES PER HOUR AND THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. I HAD TO MOVE MY CAR TO A SAFE PLACE TO AVOID BEING HIT BY THE OTHER VEHICLES ON THE HIGHWAY. I COULD NOT CONTINUE TO DRIVE MY CAR. AND, I WAS WORRIED ABOUT MY SAFETY AND WAS AT RISK DUE TO THE BMW CAR ISSUE. I CALLED AAA AND MY CAR WAS TOWED TO PASSPORT BMW IN SUITLAND, MARYLAND FOR REPAIR. ON AUGUST 8TH, PASSPORT EVALUATED MY CAR AND DIAGNOSED THE PROBLEM. I WAS INFORMED BY PASSPORT BMW THAT MY CAR ENGINE PROBLEM WAS DUE TO A FAULTY FUEL IGNITION SYSTEM WHICH HAD TO BE REPLACED. I APPROVED THIS OVER $570 REPAIR TO MY CAR. HOWEVER, WHEN I PICKED UP THE CAR, THE ENGINE LIGHT WAS STILL ON. AGAIN, I WAS CONCERNED SINCE MY CAR WAS REPAIRED BY BMW YET THE PROBLEM HAD NOT BEEN FIXED SINCE THE ENGINE LIGHT WAS STILL ON. I CONTACTED THE SERVICE ADVISOR TO INFORM HIM OF THE PROBLEM. HE APOLOGIZED AND REQUESTED THAT I BRING THE CAR BACK IN TO PASSPORT BMW ON THE NEXT DAY. THE NEXT DAY, I BROUGHT THE CAR IN TO PASSPORT BMW, I WAS INFORMED THAT THE CATALYTIC CONVERTER, AN ESTIMATED $3388 REPAIR, NEEDED TO BE REPLACED. MY CAR HAS BEEN IN FOR BMW SERVICE MAINTENANCE AND RECALL REPAIRS SEVERAL TIME. MY CAR WAS IN FOR MAINTENANCE SEVERAL TIMES AND WAS NOT ACCURATELY DIAGNOSED OR REPAIRED. THERE IS NO INDICATION THAT THE REPAIR DIAGNOSED ON AUGUST 8TH FIXED THE PROBLEM THAT CAUSED MY CAR TO STOP RUNNING ON THE HIGHWAY ON AUGUST 7TH. I PAID FOR THAT REPAIR IN AUGUST AND IT DID NOT FIX THE CHECK ENGINE PROBLEM AND WANT TO BE REIMBURSED FOR THIS EXPENSE. I AM CONCERNED ABOUT THE NUMEROUS REPAIRS TO MY BMW DESPITE THE FACT THAT MY CAR HAS BEEN SERVICED BY THE PASSPORT BMW SERVICE DEPARTMENT.
NHTSA ODI #11164436
117,500 miles · Dec 21, 2018
Engine
EGR COOLER FAILURE. EGR COOLER DEVELOPED, BOTH AN EXHAUST GAS LEAK AND CONTROL SPRING FAILURE. FAILURE WAS SEEN IN ENGINE CONTROL LIGHT AND LATER DIAGNOSED IN SECOND TRIP TO BMW DEALER. EXHAUST GAS LEAK IN ENGINE COMPARTMENT TO GREASE AIR SYSTEM IS PRIMARY ISSUE.
NHTSA ODI #11163042
66,000 miles · Dec 9, 2018
Engine
RECALL CAMPAIGN NUMBER 18V-336 ENGINE IDLER PULLEY BOLT SNAPPED WHILE DRIVING THROUGH TWISTING ROADS IN THE WET. LOSS OF POWER STEERING AND LOSS OF BATTERY CHARGE FROM THE ALTERNATOR ALSO THE BELT RUNS THE WATER PUMP SO THE ENGINE STARTED TO OVER HEAT BEFORE I COULD GET TO A SAFE PLACE TO PULL OFF THE ROAD.
NHTSA ODI #11157143
Mileage unknown · Dec 3, 2018
Unknown Or Other
BMW HAS OPENED A RECALL FOR MY VEHICLE AS OF MAY, 23 OF 2018 AND THE PARTS AREN'T AVAILABLE EVEN NOW. I HAVE CALLED THEM NUMEROUS TIMES WITH NO SUCCESS AT ALL. NOBODY NOWS WHEN THESE PARTS WILL BE AVAILABLE. I'M A RENT A CAR COMPANY OWNER AND THIS VEHICLE STAYS IN MY GARAGE AND COLLECTS DUST WITH NO REVENUE WHAT SO EVER. PLEA…
Read full complaint
BMW HAS OPENED A RECALL FOR MY VEHICLE AS OF MAY, 23 OF 2018 AND THE PARTS AREN'T AVAILABLE EVEN NOW. I HAVE CALLED THEM NUMEROUS TIMES WITH NO SUCCESS AT ALL. NOBODY NOWS WHEN THESE PARTS WILL BE AVAILABLE. I'M A RENT A CAR COMPANY OWNER AND THIS VEHICLE STAYS IN MY GARAGE AND COLLECTS DUST WITH NO REVENUE WHAT SO EVER. PLEASE HELP ME TO RESOLVE THIS ISSUE.
NHTSA ODI #11155537
65,000 miles · Nov 13, 2018
Power Train
TRANSMISSION PROBLEM, GEAR SELECTOR SOMETIMES WON'T SET IN PARK, SOMETIMES TRANSMISSION WILL GO INTO SAFE MODE RANDOMLY
NHTSA ODI #11151305
90,000 miles · Nov 12, 2018
Unknown Or Other
THIS WEEKEND I WAS DRIVING MY BMW ON THE EXPRESSWAY AND HEAR A LOUD POP. WHEN I LOOKED UP MY SUNROOF EXPLODED AND SCATTERED INTO SMALL PIECES. I WAS OUT OF TOWN AND ALL THE SCHERERVILLE DEALER TOLD ME IS TO CONTACT MY INSURANCE. THEY DIDN'T ACCOMMODATE ME AT ALL. NOTHING HIT MY CAR AND THE SAME SITUATION HAPPENED TO A RELATI…
Read full complaint
THIS WEEKEND I WAS DRIVING MY BMW ON THE EXPRESSWAY AND HEAR A LOUD POP. WHEN I LOOKED UP MY SUNROOF EXPLODED AND SCATTERED INTO SMALL PIECES. I WAS OUT OF TOWN AND ALL THE SCHERERVILLE DEALER TOLD ME IS TO CONTACT MY INSURANCE. THEY DIDN'T ACCOMMODATE ME AT ALL. NOTHING HIT MY CAR AND THE SAME SITUATION HAPPENED TO A RELATIVE IN HER BMW CAR LAST YEAR. THIS WAS A VERY SCARY SITUATION AND I WAS STUCK ALL WEEKEND OUT OF TOWN WITH A HOLE IN MY CAR. THE TEMPERED GLASS IS DEFECTIVE AND BMW NEEDS TO BE RESPONSIBLE.
NHTSA ODI #11150907
109,533 miles · Nov 8, 2018
Power Train
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE THE ENGINE WAS RUNNING, THE CONTACT HEARD AN ABNORMAL NOISE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 12V019000 (POWER TRAIN). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIA…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE THE ENGINE WAS RUNNING, THE CONTACT HEARD AN ABNORMAL NOISE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 12V019000 (POWER TRAIN). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND STATED THAT THE TORQUE CONVERTER WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED AND STATED THEY COULD NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 109,533.
NHTSA ODI #11150104
69,500 miles · Nov 5, 2018
Engine
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE THE VEHICLE WAS STATIONARY, THE ENGINE IDLER PULLEY BOLT FRACTURED. THE CONTACT STATED THAT THE RED BATTERY MALFUNCTION INDICATOR ILLUMINATED AND THE MESSAGE "CHARGING MALFUNCTION, BATTERY IS NOT RECHARGING" DISPLAYED. THE CONTACT ALSO STATED THAT THERE WAS A SUDDEN LOSS OF POWER STEERIN…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE THE VEHICLE WAS STATIONARY, THE ENGINE IDLER PULLEY BOLT FRACTURED. THE CONTACT STATED THAT THE RED BATTERY MALFUNCTION INDICATOR ILLUMINATED AND THE MESSAGE "CHARGING MALFUNCTION, BATTERY IS NOT RECHARGING" DISPLAYED. THE CONTACT ALSO STATED THAT THERE WAS A SUDDEN LOSS OF POWER STEERING ASSIST. THE CONTACT MANUALLY APPLIED SIGNIFICANT FORCE TO THE STEERING WHEEL AND WAS ABLE TO DRIVE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE PULLEY BOLT FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. FURTHERMORE, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V336000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND STATED THAT THERE WAS NO REMEDY FOR THE RECALL. THE CONTACT WAS REFERRED TO THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 69,500. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11149503
73,000 miles · Oct 27, 2018
Engine
WHILE DRIVING 65 MPH ON FREEWAY CAR REFUSED TO ACCELERATE FASTER THAN 60 MPH, WARNING THAT ENGINE WAS OVERHEATING AND TO DRIVE MODERATELY WAS DISPLAYED. LOUD BLOWING FROM ENGINE COMPARTMENT IN 10 SECOND INTERVALS. WATER PUMP AND THERMOSTAT NEED TO BE REPLACED, BUT DEALER CLAIMS OUR VEHICLE ISN'T COVERED UNDER ANY OF THE 3 RECEN…
Read full complaint
WHILE DRIVING 65 MPH ON FREEWAY CAR REFUSED TO ACCELERATE FASTER THAN 60 MPH, WARNING THAT ENGINE WAS OVERHEATING AND TO DRIVE MODERATELY WAS DISPLAYED. LOUD BLOWING FROM ENGINE COMPARTMENT IN 10 SECOND INTERVALS. WATER PUMP AND THERMOSTAT NEED TO BE REPLACED, BUT DEALER CLAIMS OUR VEHICLE ISN'T COVERED UNDER ANY OF THE 3 RECENTLY EXPANDED RECALLS AFFECTING OTHER 2012 X5 MODELS. ONLINE RESEARCH INDICATES THAT WATER PUMP FAILURES ARE CHRONIC WITH THIS MODEL AND "SOME" BMW REPAIR CENTERS ARE COVERING THE REPAIR AT 85% AS AN EXTENDED WARRANTY ON THE PART, BECAUSE OF THE INHERENT RISK OF FIRE.
NHTSA ODI #11143413
Official recalls
10Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Jan 10, 2017
BMW of North America, LLC (BMW) is recalling certain 2012 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain 2009 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, and X5 M vehicles, 2008-2009 X6 xDrive 35i, X6 xDrive50i, X6 M, and 2009 X5 xDrive35d vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, BMW is recalling certain 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, and 2008 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the front passenger air bag inflator or air bag module, free of charge. Interim letters were mailed March 2017. Owners will receive a second notice when remedy parts become available. Owners may contact BMW customer service at 1-800-525-7417.
Jun 13, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 VEHICLES EQUIPPED WITH A DIESEL ENGINE AND 2013 X5 AND X6 VEHICLES. DUE TO A MACHINING ERROR OF THE STEERING GEAR SURFACE, POWER STEERING FLUID MAY LEAK.
Consequence & remedy
Consequence: LEAKING POWER STEERING FLUID CAN SPRAY ONTO HOT EXHAUST PARTS, INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT, AND IF NECESSARY, REPLACE THE STEERING GEAR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 20, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jan 23, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 XDRIVE 35I SPORTS ACTIVITY VEHICLES, MANUFACTURED FROM DECEMBER 19, 2011, THROUGH DECEMBER 21, 2011. DUE TO A MANUFACTURING ERROR, ENGAGEMENT OF THE TRANSMISSIONS PARKING LOCK MAY NOT OCCUR EVEN IF THE P POSITION HAS BEEN SELECTED AND IS DISPLAYED.
Consequence & remedy
Consequence: IF THE DRIVER BELIEVES THAT THE TRANSMISSION IS IN PARK AND DOES NOT USE THE PARKING BRAKE, THE VEHICLE COULD ROLL AWAY AFTER EXITING THE VEHICLE INCREASING THE RISK OF A CRASH OR INJURY.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 2, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ18001 · Idler Pulley Bolt Failure
Opened Apr 18, 2018 · Closed Dec 1, 2018
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Additional source detail variants (3)
Steering
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist System
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Illustration