NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
92 reportsClear category filter59,800 miles · Aug 9, 2017
Engine
TL* THE CONTACT OWNS A 2012 BMW X5. UPON STARTING THE VEHICLE AND WHILE DRIVING, THE LOW COOLANT LEVEL WARNING INDICATOR ILLUMINATED. THE CONTACT ADDED COOLANT TO THE VEHICLE, BUT THE WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO GLOBAL IMPORTS BMW (500 INTERSTATE N PKWY, ATLANTA, GA 303369 (800) 294-1853) WHE…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. UPON STARTING THE VEHICLE AND WHILE DRIVING, THE LOW COOLANT LEVEL WARNING INDICATOR ILLUMINATED. THE CONTACT ADDED COOLANT TO THE VEHICLE, BUT THE WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO GLOBAL IMPORTS BMW (500 INTERSTATE N PKWY, ATLANTA, GA 303369 (800) 294-1853) WHERE IT WAS DIAGNOSED THAT THE OIL FILTER HOUSING GASKET NEEDED REPLACEMENT AND THE COOLANT WAS CONTAMINATED DUE TO FRACTURED COOLANT AND OIL LINES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE OF THE FAILURE AND STATED THAT THE WARRANTY WAS EXPIRED. NO FURTHER ASSISTANCE COULD BE OFFERED. THE CONTACT SPOKE WITH THE MANUFACTURER AND THE DEALER AND A REDUCED REPAIR PRICE WAS AGREED UPON. THE CONTACT ALSO SPOKE WITH SEVERAL UNKNOWN BMW DEALERS WHO INFORMED HIM THAT MANY OTHER VEHICLE OWNERS HAD THE SAME FAILURE AND IT WAS A DESIGN FLAW IN THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 59,800.
NHTSA ODI #11013943
29,000 miles · Jul 14, 2017
Engine
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING 20 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE CHECK ENGINE INDICATOR ILLUMINATED. IN ADDITION, A MESSAGE DISPLAYED INDICATING THAT THE VEHICLE EXPERIENCED AN ENGINE FAILURE. THE VEHICLE WAS TAKEN TO VALENCIA BMW (23435 VALENCIA BLVD, VALENCIA, CA 91355) WHERE THE DEALER PROVID…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING 20 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE CHECK ENGINE INDICATOR ILLUMINATED. IN ADDITION, A MESSAGE DISPLAYED INDICATING THAT THE VEHICLE EXPERIENCED AN ENGINE FAILURE. THE VEHICLE WAS TAKEN TO VALENCIA BMW (23435 VALENCIA BLVD, VALENCIA, CA 91355) WHERE THE DEALER PROVIDED AN UNKNOWN DIAGNOSIS AND UNKNOWN REPAIRS. THE FAILURE RECURRED AND THE VEHICLE FAILED TO ACCELERATE AGAIN. THE VEHICLE WAS TAKEN BACK TO VALENCIA BMW WHERE THE DEALER AGAIN PROVIDED AN UNKNOWN DIAGNOSIS AND UNKNOWN REPAIRS. THE FAILURE RECURRED TWO MORE TIMES, AND THE VEHICLE WAS TAKEN BACK TO VALENCIA BMW AND GIVEN AN UNKNOWN DIAGNOSIS AND UNKNOWN REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THEY WOULD TRY TO REPAIR THE VEHICLE, BUT THAT IT WOULD TAKE TIME TO REVIEW THE CASE; HOWEVER, A CASE MANAGER WOULD BE IN TOUCH. THE APPROXIMATE FAILURE MILEAGE WAS 29,000.
NHTSA ODI #11005387
54,100 miles · May 16, 2017
Engine
SCR CATALYTIC CONVERTER FAILURE AND NOX SENSOR FAILURE IN DIESEL EXHAUST SYSTEM ON A 54,1XX MILE VEHICLE -- MUCH TOO EARLY FOR THESE SYSTEMS TO FAIL . THE SYSTEM ALERTED ME OF A "EXHAUST FLUID INCORRECT" CEL WITH A 200 MIL COUNT DOWN TIMER. THIS COUNT DOWN TIME RENDERS THE VEHICLE IMMOBILE IF YOU DO NOT BRING IT INTO THE BMW DEA…
Read full complaint
SCR CATALYTIC CONVERTER FAILURE AND NOX SENSOR FAILURE IN DIESEL EXHAUST SYSTEM ON A 54,1XX MILE VEHICLE -- MUCH TOO EARLY FOR THESE SYSTEMS TO FAIL . THE SYSTEM ALERTED ME OF A "EXHAUST FLUID INCORRECT" CEL WITH A 200 MIL COUNT DOWN TIMER. THIS COUNT DOWN TIME RENDERS THE VEHICLE IMMOBILE IF YOU DO NOT BRING IT INTO THE BMW DEALER WITHIN THIS MILEAGE. THIS COUNT DOWN TIMER COULD HAVE LEFT ME LITERALLY STRANDED IN THE MIDDLE OF NO WHERE IF I WERE TO TAKE THIS VEHICLE ON ANY ROAD TRIP OR EXTENDED TRAVEL. I BELIEVE IT IS ABSOLUTELY CRIMINAL THAT BMW CAN DISABLE YOUR VEHICLE ON AN EMISSION RELATED ISSUE POTENTIALLY LEAVING YOU STRANDED. YES, I WOULD HAVE (AND HAVE) BROUGHT THE VEHICLE IN FOR REPAIR -- IMMOBILIZING THE VEHICLE IS ABSOLUTELY RIDICULOUS AND SHOULD NOT BE ALLOWED AND IS VERY UNSAFE AND COULD HAVE CAUSED ME AND MY FAMILY HARM. I HAVE A 2 YEAR OLD AND A 3 MONTH OLD THAT COULD HAVE BEEN LEFT STRANDED. I'M AFRAID TO DRIVE THIS VEHICLE WITH MY FAMILY NOW.
NHTSA ODI #10985993
75,138 miles · Nov 10, 2016
Engine
THE EGR COOLER WAS DISCOVERED TO BE LEAKING HARMFUL EXHAUST UNDERNEATH THE VEHICLE. THIS HARMFUL EXHAUST COULD EVENTUALLY BE BREATHED IN WHILE THE ENGINE IS RUNNING AND THE VEHICLE REMAINS PARKED TO RUN THE AIR CONDITIONER. BASED ON THE MILEAGE OF MY VEHICLE WHICH IS AT 75,000 MILES, THE PART IS NOT COVERED UNDER THE EMISSIONS…
Read full complaint
THE EGR COOLER WAS DISCOVERED TO BE LEAKING HARMFUL EXHAUST UNDERNEATH THE VEHICLE. THIS HARMFUL EXHAUST COULD EVENTUALLY BE BREATHED IN WHILE THE ENGINE IS RUNNING AND THE VEHICLE REMAINS PARKED TO RUN THE AIR CONDITIONER. BASED ON THE MILEAGE OF MY VEHICLE WHICH IS AT 75,000 MILES, THE PART IS NOT COVERED UNDER THE EMISSIONS WARRANTY. THE ODD PART HERE IS THAT MY VEHICLE RECEIVED A FULL INSPECTION AT 60,000 MILES AND THERE WAS NO SIGN OF ANY EXHAUST LEAK AT THIS TIME. ALL THAT THE VEHICLE IS USED FOR IS TO GET GROCERIES AND BRING THE KIDS BACK AND FORTH TO SCHOOL. RIGHT NOW I AM IN A BAD POSITION WHERE THE COST TO REPLACE THE EGR COOLER IS NEARLY $2,000. IF AN INSPECTION WAS PERFORMED JUST PRIOR TO 70,000 MILES THEN THIS PART WOULD HAVE BEEN COVERED UNDER THE EMISSIONS WARRANTY BECAUSE I LIVE IN CALIFORNIA.
NHTSA ODI #10925462
88,000 miles · Sep 23, 2016
Engine
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE SEIZED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FA…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE SEIZED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.
NHTSA ODI #10908889
50,000 miles · Sep 19, 2016
Engine
ONE WEEK AGO, COOLING FAN MADE HIGH SPEED NOISE. IT KEPT WENT ON AND OFF. ONE WEEK LATER, "ENGINE HOT" SIGN TURNED ON WHILE I'M DRIVING ON HIGHWAY. I TURNED OFF THE ENGINE AND TURNED ON 20 MINUTES LATER. AFTER I TURNED ON, ENGINE OIL LEVEL SHOWS UP EMPTY, 0. WE CHANGED ENGINE OIL WHEN 45,000 MILES AND CURRENT IS 50,000 MILES.
NHTSA ODI #10907701
56,000 miles · Sep 1, 2016
Electrical SystemEngine
VEHICLE MILEAGE 56,341MI. VEHICLE ENGINE WOULD CRANK BUT NOT START AFTER COMING OUT OF BUSINESS WHILE RUNNING ERRANDS. DASH WARNING MESSAGE "ENGINE MALFUNCTION" WAS PRESENT. CODES READ VIA GENERIC OBD2 DEVICE WERE P10E4, P10F5,P10E5,B2AAA. THESE CODES ARE RELATED TO THE VALVETRONIC SYSTEM IN THE ENGINE. CHECKED RELATED FUSES AND…
Read full complaint
VEHICLE MILEAGE 56,341MI. VEHICLE ENGINE WOULD CRANK BUT NOT START AFTER COMING OUT OF BUSINESS WHILE RUNNING ERRANDS. DASH WARNING MESSAGE "ENGINE MALFUNCTION" WAS PRESENT. CODES READ VIA GENERIC OBD2 DEVICE WERE P10E4, P10F5,P10E5,B2AAA. THESE CODES ARE RELATED TO THE VALVETRONIC SYSTEM IN THE ENGINE. CHECKED RELATED FUSES AND NO PROBLEM. HAD TO GET VEHICLE TOWED TO DEALER. DEALER DIAGNOSED THAT THE VALVETRONIC SYSTEM ERROR. VEHICLE WAS FIRST REPROGRAMMED AND ISSUE REMAINED. VALVETRONIC SYSTEM WAS REPLACED DUE TO DTCS THAT LED THEM TO BELIEVE ECCENTRIC SHAFT WAS STUCK. TALKING WITH THE TECHNICIAN THE ECCENTRIC SHAFT WAS NOT STUCK AND HE ASSUMED THE ACTUATOR\ MOTOR HAD FAILED. PER BMW INSTRUCTIONS THE ENTIRE SYSTEM WAS REPLACED THOUGH. TECHNICIAN STATED THAT HE HAS DONE MANY REPLACEMENTS OF VALVETRONIC SYSTEMS AND THE PARTS WERE ALREADY IN STOCK WHICH RAISED A FLAG TO ME. THE ENGINE WAS REASSEMBLED AND THE ENGINE WOULD STILL NOT START. THERE WERE FAULTS LEFT IN THE ENGINE CONTROL UNIT. APPARENTLY THE ENGINE CONTROL UNIT WAS DAMAGED BY ACTUATOR\ MOTOR THAT WAS DRAWING HIGH CURRENT.(CONFIRMED BY BMW SERVICE ENGINEER) ENGINE CONTROL UNIT WAS REPLACED AND REPROGRAMMED AND ENGINE IS NOW REPORTED TO BE IN OPERATIONAL CONDITION. BMW AND DEALER HAS DISCOUNTED THE SERVICE AND PROVIDED A LOANER VEHICLE BUT BASED ON INFORMATION FROM THE TECHNICIAN THIS ENTIRE REPAIR COULD POSSIBLY BE A RECALLABLE ITEM AS IT CAN LEAVE THE END USER STRANDED AND WITH A HEALTHY REPAIR BILL WITH A VEHICLE THAT IS NOT TOO FAR OUT OF WARRANTY. REPAIR BILL HAS BEEN UPLOADED.
NHTSA ODI #10902991
16,000 miles · Aug 17, 2016
Engine
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING 50 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE STALLED. THE CONTACT STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE BECAUSE IT STALLED ABRUPTLY WHILE IN TRAFFIC. ACCORDING TO THE CONTACT, THE VEHICLE WAS DIAGNOSED THIRTEEN TIMES FOR ENGINE FA…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. WHILE DRIVING 50 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE STALLED. THE CONTACT STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE BECAUSE IT STALLED ABRUPTLY WHILE IN TRAFFIC. ACCORDING TO THE CONTACT, THE VEHICLE WAS DIAGNOSED THIRTEEN TIMES FOR ENGINE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INSISTED THAT THE CONTACT BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 16,000. ..UPDATED 10/18/16 *BF *TR
NHTSA ODI #10896685
Mileage unknown · Aug 16, 2016
EngineSteering
TL* THE CONTACT OWNS A 2012 BMW X5. THE CONTACT STATED THAT THE CHECK ENGINE, BRAKE LIGHT, AND TIRE PRESSURE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE OIL PAN GASKET AND POWER STEERING PUMP HAD LEAKED AND NEEDED TO BE REPLACED. THE CONTACT HAD THE SOFTWARE UPDATED; HOWEVE…
Read full complaint
TL* THE CONTACT OWNS A 2012 BMW X5. THE CONTACT STATED THAT THE CHECK ENGINE, BRAKE LIGHT, AND TIRE PRESSURE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE OIL PAN GASKET AND POWER STEERING PUMP HAD LEAKED AND NEEDED TO BE REPLACED. THE CONTACT HAD THE SOFTWARE UPDATED; HOWEVER, THE POWER STEERING PUMP AND OIL PAN GASKET WERE NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS NOT PROVIDED.
NHTSA ODI #10896363
50,000 miles · Dec 21, 2015
Engine
AT 50,000 MILES WATER PUMP MALFUNCTION. COST TO REPAIR A PRODUCT WITH LESS LIFESPAN THAN A SET OF TIRES, $1400. NO RECALL LISTED, DELEAR SAID THAT THIS IS A NORMAL OCCURRENCE WITH THIS MODEL.
NHTSA ODI #10811518
Official recalls
10Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Jan 10, 2017
BMW of North America, LLC (BMW) is recalling certain 2012 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain 2009 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, and X5 M vehicles, 2008-2009 X6 xDrive 35i, X6 xDrive50i, X6 M, and 2009 X5 xDrive35d vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, BMW is recalling certain 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, and 2008 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the front passenger air bag inflator or air bag module, free of charge. Interim letters were mailed March 2017. Owners will receive a second notice when remedy parts become available. Owners may contact BMW customer service at 1-800-525-7417.
Jun 13, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 VEHICLES EQUIPPED WITH A DIESEL ENGINE AND 2013 X5 AND X6 VEHICLES. DUE TO A MACHINING ERROR OF THE STEERING GEAR SURFACE, POWER STEERING FLUID MAY LEAK.
Consequence & remedy
Consequence: LEAKING POWER STEERING FLUID CAN SPRAY ONTO HOT EXHAUST PARTS, INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT, AND IF NECESSARY, REPLACE THE STEERING GEAR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 20, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jan 23, 2012
BMW IS RECALLING CERTAIN MODEL YEAR 2012 X5 XDRIVE 35I SPORTS ACTIVITY VEHICLES, MANUFACTURED FROM DECEMBER 19, 2011, THROUGH DECEMBER 21, 2011. DUE TO A MANUFACTURING ERROR, ENGAGEMENT OF THE TRANSMISSIONS PARKING LOCK MAY NOT OCCUR EVEN IF THE P POSITION HAS BEEN SELECTED AND IS DISPLAYED.
Consequence & remedy
Consequence: IF THE DRIVER BELIEVES THAT THE TRANSMISSION IS IN PARK AND DOES NOT USE THE PARKING BRAKE, THE VEHICLE COULD ROLL AWAY AFTER EXITING THE VEHICLE INCREASING THE RISK OF A CRASH OR INJURY.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 2, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ18001 · Idler Pulley Bolt Failure
Opened Apr 18, 2018 · Closed Dec 1, 2018
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Additional source detail variants (3)
Steering
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist:hose, Piping, And Connections
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Steering:hydraulic Power Assist System
In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.
Illustration