NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
110 reportsClear category filter61,400 miles · Mar 14, 2016
EnginePower TrainFire
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE PARKED, THE ENGINE WAS RUNNING HOWEVER, A LARGE AMOUNT OF COOLANT LEAKED ONTO THE GROUND AND THE ENGINE COMPARTMENT. THE OIL RESERVOIR MELTED ONTO THE ENGINE. THERE WAS NO FLAME VISIBLE. IN ADDITION, THE VEHICLE FAILED TO SHIFT OUT OF THE PARK POSITION. THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE PARKED, THE ENGINE WAS RUNNING HOWEVER, A LARGE AMOUNT OF COOLANT LEAKED ONTO THE GROUND AND THE ENGINE COMPARTMENT. THE OIL RESERVOIR MELTED ONTO THE ENGINE. THERE WAS NO FLAME VISIBLE. IN ADDITION, THE VEHICLE FAILED TO SHIFT OUT OF THE PARK POSITION. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WATER PUMP WOULD NEED TO BE REPLACED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V521000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 61,400.
NHTSA ODI #10846430
66,000 miles · Feb 13, 2016
Engine
PREVIOUS VANOS RECALL CAMPAING FIX IS NOT WORKING. AFTER ONE YEARS REPLACEMENT BOLTS ARE LOOSE AND LOUD ENGINE KNOCKING IS BACK. IF CONTINUE DRIVING BOLTS WILL BE SHEARED AND BREAK TIMING CHAIN CAUSING ENGINE TO SUDDENLY LOOSE POWER AND SHUT DOWN WITH NO PREVIOUS WARNING. WHEN ENGINE RPM REACHES THE 2000 MARK ENGINE STARTS TO…
Read full complaint
PREVIOUS VANOS RECALL CAMPAING FIX IS NOT WORKING. AFTER ONE YEARS REPLACEMENT BOLTS ARE LOOSE AND LOUD ENGINE KNOCKING IS BACK. IF CONTINUE DRIVING BOLTS WILL BE SHEARED AND BREAK TIMING CHAIN CAUSING ENGINE TO SUDDENLY LOOSE POWER AND SHUT DOWN WITH NO PREVIOUS WARNING. WHEN ENGINE RPM REACHES THE 2000 MARK ENGINE STARTS TO LOOSE POWER AND HESITATES DUE TO THE BAD VANOS BOLTS. BMW IS REFUSING TO REPAIR THE VANOS UNIT AND REPLACE THE BOLTS UNDER WARRANTY.
NHTSA ODI #10825972
75,000 miles · Feb 10, 2016
EngineInjury
MARGINING ONTO FREEWAY ACCELERATED CAR SUDDENLY LOST POWER WENT INTO NEUTRAL AND BRAKES WENT HARD ENGINE MALFUNCTION LIGHTS ON THE DASH BUILD DATE DEC 2010 FALLS INTO VANOS REPAIR FIXED ONCE ALREADY AND HAS MADE THE VEHICLE INOPERABLE BMW CORPORATE IS CLAIMING NOT AT FAULT WHEN HUNDREDS OF CASES HAVE BEEN REPORTED ONLINE EVERY V…
Read full complaint
MARGINING ONTO FREEWAY ACCELERATED CAR SUDDENLY LOST POWER WENT INTO NEUTRAL AND BRAKES WENT HARD ENGINE MALFUNCTION LIGHTS ON THE DASH BUILD DATE DEC 2010 FALLS INTO VANOS REPAIR FIXED ONCE ALREADY AND HAS MADE THE VEHICLE INOPERABLE BMW CORPORATE IS CLAIMING NOT AT FAULT WHEN HUNDREDS OF CASES HAVE BEEN REPORTED ONLINE EVERY VEHICLE MADE FROM FEB 2010-DEC 2010 IS A TICKING BOMB
NHTSA ODI #10825256
69,716 miles · Jan 28, 2016
EngineFire
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE WAS OVERHEATING CAUSING SMOKE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WATER PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO TH…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE WAS OVERHEATING CAUSING SMOKE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WATER PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE COOLING PRESSURE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V521000 (ENGINE, ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 69,716.
NHTSA ODI #10822907
59,100 miles · Jan 25, 2016
Engine
ENGINE MALFUNCTION REDUCED POWER OUTPUT. DRIVING ON A HIGHWAY MY BMW X5 SUDDENLY STARTED MISFIRING AND HEARD NOISE FROM THE ENGINE. AFTER COUPLE OF MISFIRES IT HAVE ENINGE MALFUNCTION REDUCED POWER OUTPUT WARNING. HAD A VANOS BOLT REPLACED AS PART OF RECALL BUT THIS IS HAPPENING MORE OFTEN. I THINK THERE IS SERIOUS ISSUE WITH BM…
Read full complaint
ENGINE MALFUNCTION REDUCED POWER OUTPUT. DRIVING ON A HIGHWAY MY BMW X5 SUDDENLY STARTED MISFIRING AND HEARD NOISE FROM THE ENGINE. AFTER COUPLE OF MISFIRES IT HAVE ENINGE MALFUNCTION REDUCED POWER OUTPUT WARNING. HAD A VANOS BOLT REPLACED AS PART OF RECALL BUT THIS IS HAPPENING MORE OFTEN. I THINK THERE IS SERIOUS ISSUE WITH BMW ENINGE. CAN ANYONE HELP.
NHTSA ODI #10822113
60,000 miles · Jan 12, 2016
EngineSteering
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AFTER THE ENGINE AND BATTERY WARNING INDICATORS ILLUMINATED. THE CONTACT RESTARTED THE VEHICLE HOWEVER THE FAILURE PERSISTED. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND WAS EXAMI…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AFTER THE ENGINE AND BATTERY WARNING INDICATORS ILLUMINATED. THE CONTACT RESTARTED THE VEHICLE HOWEVER THE FAILURE PERSISTED. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND WAS EXAMINED BY AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE IDLER PULLEY BOLT HAD FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V550000 (ENGINE AND ENGINE COOLING , STEERING) HOWEVER, THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10819617
45,000 miles · Dec 14, 2015
Engine
ELECTRIC WATER PUMP FAILED AT ONLY 40K-50K MILES. ENGINE OVERHEATED AND RISKY FOR SAFE DRIVING. I CHECKED ONLINE FOR ANY RELATED RECALL AND FIND THE FOLLOWING, WHICH IS THE SAME PROBLEM FOR MY VEHICLE. BUT IT WAS NOT COVERED BY THE RECALL. THIS RECALL SHOULD COVER MORE VEHICLES. ELECTRIC AUXILIARY WATER PUMP REPORT RECEIPT …
Read full complaint
ELECTRIC WATER PUMP FAILED AT ONLY 40K-50K MILES. ENGINE OVERHEATED AND RISKY FOR SAFE DRIVING. I CHECKED ONLINE FOR ANY RELATED RECALL AND FIND THE FOLLOWING, WHICH IS THE SAME PROBLEM FOR MY VEHICLE. BUT IT WAS NOT COVERED BY THE RECALL. THIS RECALL SHOULD COVER MORE VEHICLES. ELECTRIC AUXILIARY WATER PUMP REPORT RECEIPT DATE: OCT 20, 2011 NHTSA CAMPAIGN NUMBER: 11V521000 COMPONENT(S): ENGINE AND ENGINE COOLING
NHTSA ODI #10810129
25 miles · Nov 9, 2015
Engine
I RECEIVED A NOISE FROM THE ENGINE AND STARTED AN ALERT ON DASHBOARD ENGINE MALFUNCTION REDUCED POWER DRIVE SAFELY TO THE BMW DEALER. BMW DEALER LOOKED AT THE VEHICLE AND SUGGESTED TO CHANGE ENGINE OIL, SOLENOIDS, BELT TENSIONER AND DEFLECTION PULLY, HOWEVER THE ENGINE SOUND DID NOT GO OFF. NOW THEY ASKING ME TO CHANGE THE ENGIN…
Read full complaint
I RECEIVED A NOISE FROM THE ENGINE AND STARTED AN ALERT ON DASHBOARD ENGINE MALFUNCTION REDUCED POWER DRIVE SAFELY TO THE BMW DEALER. BMW DEALER LOOKED AT THE VEHICLE AND SUGGESTED TO CHANGE ENGINE OIL, SOLENOIDS, BELT TENSIONER AND DEFLECTION PULLY, HOWEVER THE ENGINE SOUND DID NOT GO OFF. NOW THEY ASKING ME TO CHANGE THE ENGINE AND TURBO. THE ONLY SERVICE DID EARLIER WAS THE VANOS GEAR BOLT RECALL. DEALER AND BMW NA SAYS IT'S BECAUSE OF AFTERMARKET OIL FILTER. I THINK AFTERMARKET OIL FILTER DAMAGING THE ENGINE IS IRRELEVANT. I THINK THERE IS A SERIOUS PROBLEM IS GETTING HIDDEN BY BMW. CAN ANYONE PLEASE HELP.
NHTSA ODI #10789164
65,000 miles · Sep 8, 2015
Engine
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING AT APPROXIMATELY 40 MPH, AN ABNORMAL LOUD NOISE WAS HEARD FROM THE VEHICLE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED. IN ADDITION, THE BRAKE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING AT APPROXIMATELY 40 MPH, AN ABNORMAL LOUD NOISE WAS HEARD FROM THE VEHICLE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED. IN ADDITION, THE BRAKE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
NHTSA ODI #10762158
79,800 miles · Jul 12, 2015
Engine
DRIVING FROM HIGHWAY SPEED TO EXIT THEN AROUND 20MPH, ENGINE JUST STOPPED, WENT INTO NEUTRAL, STEERING LOCKED, CHECK ENGINE LIGHTS. DEPRESSED BRAKE AND WAS ABLE TO RESTART CAR. IT HAPPENED 2 MORE TIMES WITHIN THE NEXT 2 HOURS. WILL BE GETTING TO DEALER OR BMW SHOP.
NHTSA ODI #10733472
Official recalls
14Oct 20, 2023
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.
Oct 20, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.
Consequence & remedy
Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jun 2, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2011 X5 SAV AND X6 SAV PASSENGER VEHICLES MANUFACTURED FROM APRIL 1 THROUGH MAY 8, 2010. THE TIRE LABEL DOES NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE VEHICLES ARE EQUIPPED WITH 20-INCH WHEELS, BUT THE LABEL STATES THAT THE VEHICLES WERE EQUIPPED WITH 19-INCH WHEELS AND THE STATED TIRE PRESSURE IS INCORRECT FOR THE EQUIPPED WHEELS.
Consequence & remedy
Consequence: IMPROPER TIRE INFLATION CAN RESULT IN PREMATURE TIRE FAILURE OR REDUCED VEHICLE HANDLING PERFORMANCE, EITHER OF WHICH CAN INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND PROVIDE CORRECT LABELS FREE OF CHARGE. THE OWNER WILL HAVE THE OPTION TO AFFIX THE LABEL THEMSELVES OR THEY MAY TAKE THEIR VEHICLE TO A BMW DEALER WHO WILL AFFIX THE LABEL FOR THEM AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration