NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
110 reportsClear category filter70,000 miles · Jul 7, 2015
Engine
I WAS DRIVING AT THE HALLWAY AT 65 MPH AND THE POWER TO THE CAR SHUT OFF. I ALMOST CRASHED INTO OTHER CARS, WHEN THE ENGINE REDUCE POWER LIGHT CAME ON. I PULLED OVER AND WAITED 10 MINUTES TO START THE CAR. I WENT BACK HOME AND IT HAPPENED AGAIN .....UPDATED 09/28/15 *BF THE WENT TO THE SHOP FOUR TIMES, AND NO ONE WAS ABLE T…
Read full complaint
I WAS DRIVING AT THE HALLWAY AT 65 MPH AND THE POWER TO THE CAR SHUT OFF. I ALMOST CRASHED INTO OTHER CARS, WHEN THE ENGINE REDUCE POWER LIGHT CAME ON. I PULLED OVER AND WAITED 10 MINUTES TO START THE CAR. I WENT BACK HOME AND IT HAPPENED AGAIN .....UPDATED 09/28/15 *BF THE WENT TO THE SHOP FOUR TIMES, AND NO ONE WAS ABLE TO DIAGNOSE THE PROBLEM. UPDATED 10/08/15*JB
NHTSA ODI #10732397
40,375 miles · May 5, 2015
Electrical SystemEngine
MY WIFE AND A TODDLER WERE DRIVING HOME GETTING OFF THE BRIDGE AND ABOUT TO GET ON THE ON RAMP TO HIGHWAY IN NYC (BQE). ALL THE SUDDEN THE CAR OVERHEATED AND WENT INTO LIMP MODE. LUCKILY THERE WERE NO CAR BEHIND HER OTHERWISE WOULD BE REAR ENDED. SHE WAS ABLE TO PULL TO THE RIGHT FROM THE LEFT LANE AND GOT ONTO LOCAL STREET T…
Read full complaint
MY WIFE AND A TODDLER WERE DRIVING HOME GETTING OFF THE BRIDGE AND ABOUT TO GET ON THE ON RAMP TO HIGHWAY IN NYC (BQE). ALL THE SUDDEN THE CAR OVERHEATED AND WENT INTO LIMP MODE. LUCKILY THERE WERE NO CAR BEHIND HER OTHERWISE WOULD BE REAR ENDED. SHE WAS ABLE TO PULL TO THE RIGHT FROM THE LEFT LANE AND GOT ONTO LOCAL STREET TO WAIT FOR IT TO COOL DOWN. THIS CAR HAD MANY CLOSE CALLS FOR SERIOUS OR FATAL ACCIDENT. THIS CAR ONLY HAS A LITTLE OK 40K MILES. THIS IS TOO EARLY FOR A WATER PUMP TO FAIL. THIS CAR IS OUT OF WARRANTY AND THE COST OF FIX WILL BE OVER $1000. THE WORST IS MY WIFE USES THIS CAR FOR WORK AND DRIVE THE KID TO SCHOOL. CAN BMWNA BE CONTACTED AND PUT THIS FAILURE INTO RECALL. THANKS *TR
NHTSA ODI #10714798
74,000 miles · Apr 13, 2015
EngineFuel System, Gasoline
I WAS ON MY WAY OUT OF TOWN ON INTERSTATE 94W, WHEN WITHOUT WARNING MY VEHICLE STARTED TO SLOW DOWN AND I COULD NOT ACCELERATE. A SENSOR DISPLAYED STATING THE VEHICLE WAS OVERHEATING AND TO DRIVE MODERATELY. I WAS IN THE FAST LANE AND HAD TO GET OVER AT A MOMENT'S NOTICE EVEN WITH THE VEHICLE SLOWING DOWN. THE SECOND OCCURRENCE …
Read full complaint
I WAS ON MY WAY OUT OF TOWN ON INTERSTATE 94W, WHEN WITHOUT WARNING MY VEHICLE STARTED TO SLOW DOWN AND I COULD NOT ACCELERATE. A SENSOR DISPLAYED STATING THE VEHICLE WAS OVERHEATING AND TO DRIVE MODERATELY. I WAS IN THE FAST LANE AND HAD TO GET OVER AT A MOMENT'S NOTICE EVEN WITH THE VEHICLE SLOWING DOWN. THE SECOND OCCURRENCE WAS ON A BUSY STREET WITH A SPEED LIMIT OF 45 MPH, AND THE CAR OVERHEATED, AND STATED "ENGINE HOT" AND IT PROCEEDED TO SHUT DOWN. I COULD NOT ACCELERATE AND WAS ALMOST HIT FROM BEHIND BUT THE CAR SWITCHED TO ANOTHER LANE AT THE LAST MINUTE. THIS CAR PUT MY LIFE INTO DANGER 2 TIMES TO MANY. SOMETHING NEEDS TO HAPPEN BEFORE SOMEONE DIES. *TR
NHTSA ODI #10705307
48,000 miles · Apr 8, 2015
Engine
TL*THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE WATER PUMP FRACTURED. THE CONTACT HEARD THE FAN RUNNING EXTREMELY HIGH. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE WATER PUMP, THE COOLING SYSTEM AND THE THERMOSTAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN…
Read full complaint
TL*THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE WATER PUMP FRACTURED. THE CONTACT HEARD THE FAN RUNNING EXTREMELY HIGH. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE WATER PUMP, THE COOLING SYSTEM AND THE THERMOSTAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V161000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.
NHTSA ODI #10704427
69,569 miles · Jan 30, 2015
Electrical SystemElectronic Stability Control (esc)Engine
BMW X5 35I 2011 AWD , I WAS ON MAJOR DEEGAN HIGHWAY EXITING AT 230 ST WHEN THE MY BMW X5 35I 2011 AWD SUDDEN STOPPED AND MY HEART WHEN TOO MY FEET . THE PANEL READ "ENGINE MALFUNCTION " I WAS IN A DAZE NOT KNOWING WHAT HAPPEN TO THE BMW X5 35I 2011 AWD AND WHY DID IT STOP ALL OF SUDDEN !!! I STARTED AGAIN AT A VERY SLOW PACE L…
Read full complaint
BMW X5 35I 2011 AWD , I WAS ON MAJOR DEEGAN HIGHWAY EXITING AT 230 ST WHEN THE MY BMW X5 35I 2011 AWD SUDDEN STOPPED AND MY HEART WHEN TOO MY FEET . THE PANEL READ "ENGINE MALFUNCTION " I WAS IN A DAZE NOT KNOWING WHAT HAPPEN TO THE BMW X5 35I 2011 AWD AND WHY DID IT STOP ALL OF SUDDEN !!! I STARTED AGAIN AT A VERY SLOW PACE LESS THAN 10 MPH AND TRYING TO GET OUT OF THE WAY OF TRAFFIC ON THE EXIT ON 230 STREET , I MADE IT TOO THE VETERANS AFFAIRS HOSPITAL AT 8:30 OR 9:00 AM IN THE MORNING . I CALLED AAA TO TOW TO A SHOP THAN I WAS FOUND OUT THIS BMW X5 35I 2011 AWD HAD A RECALL SO I GOT IT TOW TOO PORTCHESTER BMW WHERE THE VEHICLE IS AT NOW AND DON'T WHEN I WILL GET BACK . IF THIS IS THE PROBLEM WITH THIS BMW X5 35I 2011 AWD THIS BMW X5 35I 2011 AWD SHOULD NEVER BE ON ANY US ROAD AT ALL ITS AN ACCIDENT READY TO HAPPEN VERY DANGEROUS ,VERY DANGEROUS FOR A BMW X5 35I 2011 AWD TO HAVE A SUDDEN STOP " ENGINE MALFUNCTION " SOME ONE IS GOING TOO DIE IN THIS BMW X5 35I 2011 ITS TOO DANGEROUS TO DRIVE AND RISK MY LIFE A US MARINE VETERAN . TAKE THIS BMW X5 35I 2011 OFF THE ROADS OF THE UNITED STATES BEFORE SOME WANT GETS KILLED !!!!!!! *TR
NHTSA ODI #10680093
59,600 miles · Jan 15, 2015
Engine
WHILE DRIVING ON THE HIGHWAY SUDDENLY CAR REGISTERED A FAULT SAYING "ENGINE PROBLEMS - REDUCED POWER" CAUSING ME TO SWERVE AND NEARLY CAUSING AN ACCIDENT ... THE CAR DRASTICALLY REDUCED POWER AND I WAS ABLE TO LIMP HOME WITH REDUCED SPEED. *TR
NHTSA ODI #10672839
58,000 miles · Dec 22, 2014
Engine
WHILE DRIVING ON HIGHWAY 121 SUDDENLY THE LIGHTS CAME ON AND I WAS WARNED THAT IF I DON'T PULL OVER AND REDUCE MY SPEED MY ENGINE WILL SUFFER DAMAGE. THIS CAUSED ME TO SWERVE AND TRY TO TAKE THE FIRST EXIT, WHICH LUCKILY WAS COMING UP. THERE WAS A LIQUID DISCHARGE UNDER THE CAR. WATER PUMP FAILED AND THERMOSTAT BURNED OU…
Read full complaint
WHILE DRIVING ON HIGHWAY 121 SUDDENLY THE LIGHTS CAME ON AND I WAS WARNED THAT IF I DON'T PULL OVER AND REDUCE MY SPEED MY ENGINE WILL SUFFER DAMAGE. THIS CAUSED ME TO SWERVE AND TRY TO TAKE THE FIRST EXIT, WHICH LUCKILY WAS COMING UP. THERE WAS A LIQUID DISCHARGE UNDER THE CAR. WATER PUMP FAILED AND THERMOSTAT BURNED OUT ... DAMAGES OVER 1000 USD. THIS SEEMS TO BE A THEME WITH 3.0I VEHICLES OF THAT YEAR. BMW WOULD NOT REPAIR EVEN THOUGH HIGHER CYLINDER ENGINES ARE COVERED UNDER RECALL. *TR
NHTSA ODI #10667703
40,000 miles · Nov 26, 2014
Engine
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT THE VEHICLE OVER HEATED WITHOUT WARNING AND WAS NOT ABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR FURTHER INSPECTION AND DIAGNOSIS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V521000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. THE CONTACT STATED THAT THE VEHICLE OVER HEATED WITHOUT WARNING AND WAS NOT ABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR FURTHER INSPECTION AND DIAGNOSIS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V521000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
NHTSA ODI #10661083
52,560 miles · Nov 17, 2014
EngineSteering
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING 55 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE ENGINE STALLED. THE CHECK ENGINE AND BRAKE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE IDLE PULLEY BAR AND BELT NEEDED TO BE REPLACED. THE MANUFACTU…
Read full complaint
TL* THE CONTACT OWNS A 2011 BMW X5. WHILE DRIVING 55 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE ENGINE STALLED. THE CHECK ENGINE AND BRAKE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE IDLE PULLEY BAR AND BELT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 52,560.
NHTSA ODI #10655424
78,000 miles · Sep 8, 2014
EnginePower Train
THE CAR WARNING LIGHT CAME ON AS "REDUCED POWER". TOOK THE CAR INTO CREVIER BMW IN SANTA ANA. THERE IS A RECALL ON THE VANOS SYSTEM FOR OUR CAR. WE HAVE HAD MULTIPLE PROBLEMS BEFORE THIS AS WELL. LAST JUNE, THE ENGINE OIL HOUSING UNIT WAS REPLACED. NOW THE PROBLEM POINTS TO THE VANOS ON THE DIAGNOSTIC TEST DONE AT THE DEALE…
Read full complaint
THE CAR WARNING LIGHT CAME ON AS "REDUCED POWER". TOOK THE CAR INTO CREVIER BMW IN SANTA ANA. THERE IS A RECALL ON THE VANOS SYSTEM FOR OUR CAR. WE HAVE HAD MULTIPLE PROBLEMS BEFORE THIS AS WELL. LAST JUNE, THE ENGINE OIL HOUSING UNIT WAS REPLACED. NOW THE PROBLEM POINTS TO THE VANOS ON THE DIAGNOSTIC TEST DONE AT THE DEALER. HOWEVER, THE DEALER AND BMW NORTH AMERICA WILL NOT ADDRESS THE ISSUES. BOTH KEEP TELLING US THAT THE "PARTS ARE NOT AVAILABLE" AND THAT THERE IS A RECALL ON THE VEHICLE BUT WILL LOOK INTO IT ONLY WHEN OR IF THE PARTS BECOME AVAILABLE. THUS, FOR THEM TO REPAIR THE ISSUES RIGHT NOW, WE WOULD NEED TO PAY. THIS SEEMS TO BE A SCAM AND CONVENIENCE ON THEIR PART NOT TO ADDRESS THE ISSUES. I WOULD ASK NHTSA TO PLEASE LOOK INTO THIS TYPE OF PRACTICE AND MAKE BMW RESPONSIBLE AND ACCOUNTABLE TO THEIR CUSTOMERS. THANK YOU. *TR
NHTSA ODI #10631473
Official recalls
14Oct 20, 2023
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Mar 2, 2017
BMW of North America, LLC, (BMW) is recalling certain 2011-2013 X5 xDrive35i, X5 xDrive50i, X5 M and X5 xDrive35d vehicles, 2011-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles, and 2011 x6 ActiveHybrid Vehicles. Water and debris may enter the front driveshaft's universal joint, causing excessive wear and possibly resulting in the joint's failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on April 18, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2011 X5 xDrive 35i, xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles manufactured April 5, 2010, to November 20, 2010, 2011 X5 xDrive35d diesel vehicles manufactured April 7, 2010, to November 20, 2010, and 2011 X6 Active Hybrid vehicles manufactured April 15, 2010, to November 17, 2010. The affected vehicles have a front driveshaft universal joint that may not seal out water and debris from getting in and damaging the joint, which could lead to its failure.
Consequence & remedy
Consequence: If the front universal joint fails, the front wheels would not be driven, affecting vehicle traction. Additionally, continued driving of the vehicle with a broken front universal joint may damage other components. Either condition may increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the front driveshaft, free of charge. The recall began on July 8, 2016. Owners may contact BMW customer service at 1-800-525-7417.
Oct 20, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.
Consequence & remedy
Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jun 2, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2011 X5 SAV AND X6 SAV PASSENGER VEHICLES MANUFACTURED FROM APRIL 1 THROUGH MAY 8, 2010. THE TIRE LABEL DOES NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE VEHICLES ARE EQUIPPED WITH 20-INCH WHEELS, BUT THE LABEL STATES THAT THE VEHICLES WERE EQUIPPED WITH 19-INCH WHEELS AND THE STATED TIRE PRESSURE IS INCORRECT FOR THE EQUIPPED WHEELS.
Consequence & remedy
Consequence: IMPROPER TIRE INFLATION CAN RESULT IN PREMATURE TIRE FAILURE OR REDUCED VEHICLE HANDLING PERFORMANCE, EITHER OF WHICH CAN INCREASE THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND PROVIDE CORRECT LABELS FREE OF CHARGE. THE OWNER WILL HAVE THE OPTION TO AFFIX THE LABEL THEMSELVES OR THEY MAY TAKE THEIR VEHICLE TO A BMW DEALER WHO WILL AFFIX THE LABEL FOR THEM AT NO COST. THE SAFETY RECALL BEGAN ON OCTOBER 8, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration