NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
40 reportsClear category filter125,321 miles · Jul 31, 2018
EngineEngine And Engine Cooling
TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 18V336000 (ENGINE AND ENGINE COOLING) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION THE THIRD WEEK ON MAY 23, 2018. THE MANUFACTURER STATED THAT THE PARTS WERE NOT AVAILABLE FOR THE REPAIR. THE DEALE…
Read full complaint
TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 18V336000 (ENGINE AND ENGINE COOLING) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE CONTACT RECEIVED THE RECALL NOTIFICATION THE THIRD WEEK ON MAY 23, 2018. THE MANUFACTURER STATED THAT THE PARTS WERE NOT AVAILABLE FOR THE REPAIR. THE DEALER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *TT *TR
NHTSA ODI #11114753
145,000 miles · May 23, 2018
Electrical SystemEngineSteering
THE ENGINE BELT IDLER PULLEY BOLT BROKE CAUSING A SUDDEN LOSS OF POWER STEERING WHEN THE SERPENTINE BELT CAME OFF THE ALTERNATOR AND POWER STEERING PUMP. THIS IS THE SAME PROBLEM ASSOCIATED WITH RECALL 12V550000 A FEW YEARS AGO. THE DEALER SAID THE VEHICLE WAS FIXED UNDER THE RECALL BUT IT WAS BEFORE I OWNED IT SO I DON'T KNOW …
Read full complaint
THE ENGINE BELT IDLER PULLEY BOLT BROKE CAUSING A SUDDEN LOSS OF POWER STEERING WHEN THE SERPENTINE BELT CAME OFF THE ALTERNATOR AND POWER STEERING PUMP. THIS IS THE SAME PROBLEM ASSOCIATED WITH RECALL 12V550000 A FEW YEARS AGO. THE DEALER SAID THE VEHICLE WAS FIXED UNDER THE RECALL BUT IT WAS BEFORE I OWNED IT SO I DON'T KNOW FOR SURE. I BELIEVE THE RECALL SHOULD BE REINSTATED. THE VEHICLE WAS MOVING ON A RESIDENTIAL STREET AT LESS THAN 25 MPH AND MY MOM WAS DRIVING. IF SHE HAD BEEN GOING ANY FASTER SHE WOULD HAVE CRASHED.
NHTSA ODI #11097562
47,000 miles · Feb 7, 2018
EnginePower TrainFire
TL* THE CONTACT OWNED A 2010 BMW X5. WHILE DRIVING 35 MPH, THE CONTACT OBSERVED AND SMELLED SMOKE. THE CONTACT PULLED THE VEHICLE INTO A PARKING LOT WHERE IT CAUGHT FIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT EXTINGUISHED THE FIR…
Read full complaint
TL* THE CONTACT OWNED A 2010 BMW X5. WHILE DRIVING 35 MPH, THE CONTACT OBSERVED AND SMELLED SMOKE. THE CONTACT PULLED THE VEHICLE INTO A PARKING LOT WHERE IT CAUGHT FIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING) AND WAS INFORMED PARTS WERE NOT AVAILABLE. THE FAILURE MILEAGE WAS 47,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11071587
79,000 miles · Sep 21, 2017
EngineSteering
TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THAT THE POWER MALFUNCTION WARNING LIGHT ILLUMINATED AND THE POWER STEERING FAILED. IN ADDITION, THE 'POWER LOSS PLEASE REDUCE SPEED' WARNING MESSAGE ILLUMINATED. THE CONTACT WAS ABLE TO PULL THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACT TURN…
Read full complaint
TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THAT THE POWER MALFUNCTION WARNING LIGHT ILLUMINATED AND THE POWER STEERING FAILED. IN ADDITION, THE 'POWER LOSS PLEASE REDUCE SPEED' WARNING MESSAGE ILLUMINATED. THE CONTACT WAS ABLE TO PULL THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACT TURNED THE IGNITION OFF AND ATTEMPTED TO RESTART THE VEHICLE BUT FAILED TO START. THE VEHICLE WAS NOT ABLE TO RESTART. THE VEHICLE WAS LEFT IN THAT AREA, AND WAS NOT TOWED AT THE TIME. THE LOCAL DEALER (SANTA MONICA BMW, SANTA MONICA BLVD, SANTA MONICA, CA, 90401) WAS CONTACTED AT 310-829-3535 AND MADE AWARE OF THE FAILURE, WHERE THEY ADVISED TO SCHEDULE AN APPOINTMENT TO HAVE THE VEHICLE DIAGNOSED. THE CONTACT WAS DELIBERATED ON THE USE OF AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V550000 (STEERING, ENGINE AND ENGINE COOLING), AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 79,000.
NHTSA ODI #11024812
70,000 miles · Aug 31, 2017
EngineService BrakesVisibility/wiper
MAY 10, 2017 WE PURCHASED A 2010 BMW X5 WITH APPROX 70KMILES FROM EAST PROVIDENCE AUTO FOR $16,000. TWO DAYS LATER WE BROUGHT THE VEHICLE BACK BECAUSE THE WINDSHIELD WIPER FLUID LEAKED ONTO THE DRIVER SIDE FLOOR, THE SUNROOF WOULDN'T CLOSE AND A BURNING OIL SMELL WAS COMING FROM THE INSIDE OF THE VEHICLE. AFTER INSPECTING, THE M…
Read full complaint
MAY 10, 2017 WE PURCHASED A 2010 BMW X5 WITH APPROX 70KMILES FROM EAST PROVIDENCE AUTO FOR $16,000. TWO DAYS LATER WE BROUGHT THE VEHICLE BACK BECAUSE THE WINDSHIELD WIPER FLUID LEAKED ONTO THE DRIVER SIDE FLOOR, THE SUNROOF WOULDN'T CLOSE AND A BURNING OIL SMELL WAS COMING FROM THE INSIDE OF THE VEHICLE. AFTER INSPECTING, THE MECHANIC SAID THE HOSE FROM THE WINDSHIELD WIPER TANK WAS NEEDED REPLACEMENT, HE UNJAMMED THE SUNROOF AND ADDED 2 QUARTS OF OIL; HOWEVER, HE COULDN'T FIX ANYTHING. MAY 22 WE RETURNED B/C THE OIL LIGHT WAS ON AND THE BURNING OIL SMELL STILL EXISTED. BUT THE GARAGE WAS LOCKED. THE SALESMAN SAID WE WOULD HAVE TO COME BACK. MAY 24 WE RETURNED AFTER BLUE SMOKE WAS COMING FROM THE EXHAUST. THE MECHANIC SAID THE OWNER WAS IN PORTUGAL FOR TWO WEEKS AND HE COULDN'T WORK ON THE VEHICLE WITHOUT PERMISSION. AFTER RETURNING AND CALLING MANY TIMES OVER THE NEXT MONTH WE MET WITH THE OWNER WHO SAID HIS MECHANIC LEFT, WE WOULD HAVE TO WAIT. JULY 3 WE HAD THE VEHICLE INDEPENDENTLY INSPECTED (SEE ATTACHED REPORT). HE INSPECTED THE ENGINE AND DRAINED THE OIL. HE RECOMMENDED THE ENGINE BE REMOVED FOR FURTHER DIAGNOSIS AND IF NOT RESOLVED THE ENGINE WILL EVENTUALLY NEED TO BE REPLACED. AFTER RETURNING TO EP AUTO THE OWNER SAID THE 30 DAY WARRANTY WAS UP SO WE FILED A COMPLAINT WITH THE RHODE ISLAND DEALERS LICENSE AND REGULATIONS OFFICE (COMPLAINT NUMBER AM-1702213). WE ARE AWAITING A RESPONSE FROM THE HEARING BOARD. THE CASE MANAGER ADVISED THAT IT'S IMPOSSIBLE TO FORCE EP AUTO TO TAKE THE VEHICLE BACK BECAUSE WE HAVE TO PROVE THE ISSUES ARE PRE-EXISTING AND SHE IS ANTICIPATING THE HEARING BOARD WILL NOT RULE IN OUR FAVOR. AT THIS POINT WE ARE EXTREMELY RELUCTANT TO DRIVE THE VEHICLE DUE TO THE SAFETY CONCERNS. I RECENTLY RECEIVED A RECALL NOTICE FROM YOU ALLEGING DEFECTIVE AIRBAGS MADE BY TAKATA. PLEASE FEEL FREE TO CONTACT ME. THANK YOU FOR YOUR HELP.
NHTSA ODI #11020720
48,000 miles · Aug 22, 2017
Air BagsEngineFuel/propulsion System
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW X5. WHILE DRIVING VARIOUS SPEEDS, ABNORMAL FUMES ENTERED THE VEHICLE AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AUTOGERMANA BMW (LOCATED AT 298 CALLE CARLOS F CHARDON, HATO REY, PR 00919), BUT WAS NOT REPAIRED DUE TO LACK OF PARTS. THE CONTACT RECEI…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2010 BMW X5. WHILE DRIVING VARIOUS SPEEDS, ABNORMAL FUMES ENTERED THE VEHICLE AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AUTOGERMANA BMW (LOCATED AT 298 CALLE CARLOS F CHARDON, HATO REY, PR 00919), BUT WAS NOT REPAIRED DUE TO LACK OF PARTS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V071000 (AIR BAGS), 16V364000 (AIR BAGS), AND 16V746000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS NEEDED FOR THE REPAIRS WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 48,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #11018920
Mileage unknown · Aug 9, 2017
Engine
MY VEHICLE IS HAVING ENGINE LIGHT AND STRON FUEL SMELL. I TOOK VECHIE TO BMW SERVICE CENTER AND BEEN TOLD THAT CAR HAS EGR COOLANT PROBLEM. ACCORDING TO SERVICE CENTER THAT REPAIR FOR RECALL #11E-A03 FOR EGR VALVE WAS PERFOMED IN 2016 WHICH I NOT BEEN TOLD. NOW I AM GETTING EGR COOLANT ISSUE AND BMW IS RECOGNIZED THAT THIS IS R…
Read full complaint
MY VEHICLE IS HAVING ENGINE LIGHT AND STRON FUEL SMELL. I TOOK VECHIE TO BMW SERVICE CENTER AND BEEN TOLD THAT CAR HAS EGR COOLANT PROBLEM. ACCORDING TO SERVICE CENTER THAT REPAIR FOR RECALL #11E-A03 FOR EGR VALVE WAS PERFOMED IN 2016 WHICH I NOT BEEN TOLD. NOW I AM GETTING EGR COOLANT ISSUE AND BMW IS RECOGNIZED THAT THIS IS RELATED TO EGR SYSTEM RELATED ISSUE. IT IS COMMON COMPLIANT AMONG VEHICLE OWNERS BUT BMW IS NOT ACCEPTING THAT THIS MANUFACTURING FAULT AND MAY CAUSE SOME TERRIBLE OUTCOME IF VEHICLE STOPPED WHILE DRIVING ON THE FREEWAY. I AM REQUESTING NHTSA TO DEMAND BMW TO RECOGNIZE THIS ISSUE AND FIX IT AS RECALL OR UNDER WARRANTY.
NHTSA ODI #11014071
91,500 miles · May 1, 2017
Engine
THIS CAR HAS AN EXCESSIVE OIL CONSUMPTION ISSUE THAT THE MANUFACTURER WAS AWARE OF WHICH EXPLAINS WHY THEY NO LONGER MAKE THIS ENGINE. IN A 30 DAY PERIOD I PUT ABOUT 2 ADDITIONAL QUARTS OF OIL IN THE VEHICLE. THE TAIL PIPE IS SMOKING AND LIQUID IS COMING OUT OF IT WHEN THE VEHICLE IS RUNNING FOR A LONG PERIOD OF TIME AND IS IDLE…
Read full complaint
THIS CAR HAS AN EXCESSIVE OIL CONSUMPTION ISSUE THAT THE MANUFACTURER WAS AWARE OF WHICH EXPLAINS WHY THEY NO LONGER MAKE THIS ENGINE. IN A 30 DAY PERIOD I PUT ABOUT 2 ADDITIONAL QUARTS OF OIL IN THE VEHICLE. THE TAIL PIPE IS SMOKING AND LIQUID IS COMING OUT OF IT WHEN THE VEHICLE IS RUNNING FOR A LONG PERIOD OF TIME AND IS IDLE. THE COST TO REPAIR IT AT A BMW DEALER IS $6,000. I HAVE ALREADY PAID $2,500 TO REPLACE THE VACCUM PUMP AND O RINGS DUE TO AN OIL LEAK. ALSO HAVE ALSO EXPERIENCED A TOTAL ENGINE SHUT DOWN WHICH COST ME $3,300 TO REPLACE THE BELT TENSIONER AND DEFLECTION PULLEY AND RIBBED V BELT AND AIR COMPRESSOR. THE CAR GAVE NO WARNINGS AND IT THE ENGINE JUST STARTED STALLING AND THEN IT JUST DIED AND AT THAT POINT A COOLANT LIGHT CAME ON BUT IT WOULD NOT DRIVE ANYMORE AT THAT POINT. THIS ISSUE SHOULD BE COVERED BY THE MANUFACTURER. THE ENTIRE ENGINE NEEDS TO BE REPLACED.
NHTSA ODI #10982955
92,000 miles · Feb 15, 2017
Engine
TL* THE CONTACT OWNS A 2010 BMW X5. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 92,000.
NHTSA ODI #10954952
89,000 miles · Jan 6, 2017
EngineFuel System, GasolineFire
TL* THE CONTACT OWNS A 2010 BMW X5. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND A FUEL AND SMOKE ODOR WAS PRESENT. IN ADDITION, BLACK SMOKE EMITTED FROM THE EXHAUST PIPE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.
NHTSA ODI #10940121
Official recalls
14Oct 20, 2023
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Apr 18, 2018
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence & remedy
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Additional source detail variants (2)
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Engine And Engine Cooling:engine
BMW of North America, LLC (BMW) is recalling certain 2011-2012 BMW 550i, 550i xDrive, 550i Gran Turismo, 550i Gran Turismo xDrive, 750i, 750Li, 750i xDrive, 750Li xDrive, 760Li, X5 xDrive50i, X5 M, X6 xDrive50i, X6 M, ActiveHybrid7, MINI Cooper S Convertible, John Cooper Works (JCW) Convertible, Cooper S Countryman, Cooper S Countryman ALL4, Cooper S, JCW, Cooper S Clubman, JCW Clubman, Cooper S Roadster, JCW Roadster, Cooper S Coupe, JCW Coupe and Rolls-Royce Ghost, 2011 BMW X6 Hybrid and 2012 BMW 650i Coupe, 650i xDrive Coupe, 650i Convertible and 650i xDrive Convertible vehicles. The electric auxiliary water pump may fail and cause the circuit board to overheat.
Consequence: If the circuit board were to overheat, it can increase the risk of a fire.
Remedy: BMW will notify owners, and dealers will replace the electric auxiliary water pump, free of charge. Depending on the model, there are currently limited parts available, however not all parts are available at this time. Owners will be notified of the recall beginning June 11, 2018, and will receive a second notification when remedy parts become available. Owners may contact BMW customer service at BMW 1-800-525-7417, MINI at 1-866-825-1525, or Rolls-Royce at 1-877-877-3735. Note: BMW recommends that owners park their vehicle outdoors until the recall remedy has been performed.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Aug 7, 2013
BMW is recalling certain model year 2009-2010 X5 xDrive35d vehicles equipped with a diesel engine and manufactured from June 13, 2009, through November 9, 2009. The fuel filter heater, which is used for warming up the diesel fuel during vehicle operation at low outside temperatures, could experience an electrical overload condition and become permanently activated.
Consequence & remedy
Consequence: The fuel filter heater could remain activated even when the ignition is off and lead to a dead battery. The unit could also overheat, possibly resulting in a vehicle fire.
Remedy: BMW will notify owners, and dealers will replace the fuel filter heater, free of charge. The safety recall began on September 26, 2013. Owners may contact BMW customer relations at 1-800-525-7417.
Oct 20, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2011 5-SERIES, MODEL YEAR 2010-2011 5-SERIES GRAN TURISMO, MODEL YEAR 2009-2011 7-SERIES, MODEL YEAR 2010-2011 X5 SAV, AND MODEL YEAR 2008-2011 X6 SAV VEHICLES EQUIPPED WITH 8- OR 12-CYLINDER, TURBOCHARGED, ENGINES BECAUSE THE CIRCUIT BOARD FOR THE ELECTRIC AUXILIARY WATER PUMP CAN OVERHEAT.
Consequence & remedy
Consequence: THIS COULD LEAD TO A SMOLDERING OF THE PUMP OR AN ENGINE COMPARTMENT OR VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE AUXILIARY WATER PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 19, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Apr 15, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2010 X5 M SAV VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT," THESE VEHICLE'S WERE EQUIPPED WITH SIDE MARKER LAMPS, BUT NOT THE POWER SUPPLY CABLES LEADING TO THE LAMPS. AS A RESULT, THE SIDE MARKER LAMPS DO NOT ILLUMINATE.
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: BMW WILL INSTALL POWER SUPPLY CABLES FOR THE FRONT SIDE MARKER LAMPS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT BMW AT 800-525-7417.
Jan 28, 2010
BMW IS RECALLING CERTAIN MODEL YEAR 2010 X5 AND X6 SPORT ACTIVITY VEHICLES MANUFACTURED BETWEEN DECEMBER 14, 2009 AND DECEMBER 16, 2009. IN THE UPPER RIGHT AREA OF THE WINDSHIELD, BONDING MAY BE INSUFFICIENT OVER A LENGTH OF APPROXIMATELY 50CM.
Consequence & remedy
Consequence: IN THE CASE OF A ROLLOVER, THE STABILITY OF THE ROOF COULD BE AFFECTED INCREASING THE RISK OF INJURIES.
Remedy: BMW WILL NOTIFY OWNERS AND AUTHORIZED DEALERS WILL REMOVE THE WINDSHIELD AND THEN REINSTALL WITH THE PROPER BONDING FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 30, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration