NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
9 reportsClear category filter70,000 miles · Oct 4, 2021
Service Brakes
The contact owns a 2009 BMW X5. The contact stated that while approaching a stop, the vehicle would continue to accelerate upon the depression of the brake pedal. The contact also stated that the parking brake failure warning message would appear on the instrument panel. The contact had taken the vehicle to a dealer where they r…
Read full complaint
The contact owns a 2009 BMW X5. The contact stated that while approaching a stop, the vehicle would continue to accelerate upon the depression of the brake pedal. The contact also stated that the parking brake failure warning message would appear on the instrument panel. The contact had taken the vehicle to a dealer where they replaced both front and rear brake pads; however, the failure persisted soon after repair. The dealer was notified of the failure and the contact was given a second appointment. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000. The VIN was not available.
NHTSA ODI #11435342
127,000 miles · Apr 25, 2018
Electrical SystemExterior LightingService Brakes
MY 2009 X5 WITH 127000 MILES RECENTLY INDICATED A BURNT OUT BRAKE LIGHT. WHILE REPLACING THE LIGHT, I FOUND THE REAR UPPER RIGHT BRAKE LIGHT WAS BURNT OUT, THE TAILLIGHT ITSELF IS MELTED, AND THE SOCKET IS SEVERELY MELTED AND SCORCHED. ON FURTHER INVESTIGATION, THE OPPOSITE SIDE (LEFT/DRIVER'S SIDE) WAS ALSO MELTED! CHECKING ON…
Read full complaint
MY 2009 X5 WITH 127000 MILES RECENTLY INDICATED A BURNT OUT BRAKE LIGHT. WHILE REPLACING THE LIGHT, I FOUND THE REAR UPPER RIGHT BRAKE LIGHT WAS BURNT OUT, THE TAILLIGHT ITSELF IS MELTED, AND THE SOCKET IS SEVERELY MELTED AND SCORCHED. ON FURTHER INVESTIGATION, THE OPPOSITE SIDE (LEFT/DRIVER'S SIDE) WAS ALSO MELTED! CHECKING ONLINE, THIS APPEARS TO BE A COMMON PROBLEM. I AM AFRAID THIS COULD BE A FIRE HAZARD AND WAS SURPRISED TO LEARN THERE IS NOT AN OUTSTANDING RECALL ON THE TAILLIGHTS FOR THIS VEHICLE.
NHTSA ODI #11090162
83,000 miles · Sep 1, 2016
Service Brakes
TL* THE CONTACT OWNS A 2009 BMW X5. THE CONTACT STATED THAT THE BRAKES FAILED WITHOUT WARNING. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 13V045000 (SERVICE: BRAKES); BUT, THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED.
NHTSA ODI #10903153
78,000 miles · Aug 31, 2015
Air BagsSeatsService Brakes
WHILE DRIVING ON A FREEWAY MORE THAN A WEEK AGO SUDDENLY THE AIRBAG AND RESTRAINT MALFUNCTION APPEARED FOR NO VALID REASON.THE NEXT DAY MY WIFE HEARD A LOUD METALLIC RUB SOUND AND PARK BRAKE MALFUNCTION APPEARED. SEARCHED ONLINE BUT NO RECALL FOR THIS KIND OF PROBLEMS FOR MY X5 BUT IT LOOKS LIKE ITS VERY COMMON FOR BMWS.NEED HEL…
Read full complaint
WHILE DRIVING ON A FREEWAY MORE THAN A WEEK AGO SUDDENLY THE AIRBAG AND RESTRAINT MALFUNCTION APPEARED FOR NO VALID REASON.THE NEXT DAY MY WIFE HEARD A LOUD METALLIC RUB SOUND AND PARK BRAKE MALFUNCTION APPEARED. SEARCHED ONLINE BUT NO RECALL FOR THIS KIND OF PROBLEMS FOR MY X5 BUT IT LOOKS LIKE ITS VERY COMMON FOR BMWS.NEED HELP!PLS!THANK YOU AND MORE POWER! *TR
NHTSA ODI #10760238
62,000 miles · Mar 10, 2015
Service Brakes
***UPDATE TO NHTSA ID COMPLAINT NUMBER: 10662420.*** VEHICLE VIN IS [XXX]. BMW X5 2009 XDRIVE48I (V8 MODEL). [THIS VIN IS NOT RECOGNIZED BY NHTSA VIN LOOKUP / DATABASE.] BMW INVESTIGATION WAS BEING HANDLED BY [XXX] IN "SPI" (SPECIAL PRODUCTS INVESTIGATION), WHO WAS GENERALLY NON-RESPONSIVE TO PHONE CALLS AND EMAILS. THE FE…
Read full complaint
***UPDATE TO NHTSA ID COMPLAINT NUMBER: 10662420.*** VEHICLE VIN IS [XXX]. BMW X5 2009 XDRIVE48I (V8 MODEL). [THIS VIN IS NOT RECOGNIZED BY NHTSA VIN LOOKUP / DATABASE.] BMW INVESTIGATION WAS BEING HANDLED BY [XXX] IN "SPI" (SPECIAL PRODUCTS INVESTIGATION), WHO WAS GENERALLY NON-RESPONSIVE TO PHONE CALLS AND EMAILS. THE FEW RESPONSES RECEIVED WERE DELIBERATELY EVASIVE AND / OR FALSIFIED PURPORTED ATTEMPTS TO RETURN CALLS. CASE WAS TRANSFERRED TO [XXX] IN EXECUTIVE CUSTOMER CARE, WHO INDICATED THAT SPI WAS UNABLE TO DETERMINE THE CAUSE OF THE BRAKE FAILURE BECAUSE THEY NEVER RECEIVED THE DEFECTIVE COMPONENT. (NOTE: THE FAULTY COMPONENT WAS HANDLED BY BMW SERVICE AT CENTURY WEST BMW IN LOS ANGELES, WHO STATED THAT THE PARTS HAD BEEN SENT TO SPI FOR INVESTIGATION.) BMW STATES THAT SINCE THEY HAVE BEEN UNABLE TO ANALYZE THE FAILED COMPONENT, IT IS POSSIBLE THAT THE FAILURE WAS DUE TO REASONABLE WEAR AND TEAR AND NOT DUE TO A MANUFACTURER'S DEFECT. (THEY ARE THEREFORE TAKING THE POSITION THAT THEY ARE UNWILLING TO COVER THE MINOR DAMAGE THAT WAS SUSTAINED TO THE REAR OF THE VEHICLE WHEN THE BRAKES FAILED WHILE REVERSING.) I AM VERY CONCERNED THAT BMW HAS NOT HANDLED A POTENTIALLY DEADLY FAULT WITH DUE CARE. IT IS UNACCEPTABLE THAT 3 MONTHS AFTER A BRAKE FAILURE EVENT, THEY HAVE BEEN UNABLE TO CARRY OUT A PROPER INVESTIGATION INTO THE CAUSE OF THE FAILURE. IT IS ALSO UNACCEPTABLE THAT BMW BELIEVES A 5 YEAR OLD VEHICLE COULD SUFFER A CATASTROPHIC BRAKE FAILURE AND THAT SUCH A FAULT COULD BE WITHIN THE REASONABLY EXPECTED WEAR AND TEAR CYCLE OF THE COMPONENTS. THIS POSITION PUTS THE LIVES OF ROAD USERS IN THE VICINITY OF A 5 YEAR OLD OR 60,000 MILE BMW WITH POTENTIALLY DEFECTIVE BRAKING COMPONENTS IN PERIL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10693402
62,000 miles · Dec 5, 2014
Service Brakes
BMW X5 2009 4.8IS (V8). BRAKE MASTER CYLINDER AND BRAKE BOOSTER FAILED CAUSING SUDDEN AND UNEXPECTED LOSS OF BRAKING WHILE DRIVING. NO IN DASH ALERTS OR DIAGNOSIS SHOWN BEFORE OR AFTER THE INCIDENT. BRAKING FAULT WAS PERMANENT NOT INTERMITTENT. VEHICLE IS UNDER BMW WARRANTY. UPON INSPECTION, BMW TECHNICIANS HAVE ADVISED BRA…
Read full complaint
BMW X5 2009 4.8IS (V8). BRAKE MASTER CYLINDER AND BRAKE BOOSTER FAILED CAUSING SUDDEN AND UNEXPECTED LOSS OF BRAKING WHILE DRIVING. NO IN DASH ALERTS OR DIAGNOSIS SHOWN BEFORE OR AFTER THE INCIDENT. BRAKING FAULT WAS PERMANENT NOT INTERMITTENT. VEHICLE IS UNDER BMW WARRANTY. UPON INSPECTION, BMW TECHNICIANS HAVE ADVISED BRAKE MASTER LEAKED FLUID INTO BOOSTER AND THAT THEY FOUND OIL CONTAMINATION IN THE MASTER CYLINDER. THIS SUDDEN BRAKING FAILURE COULD HAVE RESULTED IN SERIOUS DAMAGE AND FATALITIES. (PREVIOUSLY EXPERIENCED AUTO HOLD PARKING BRAKE FAILURE WHICH WAS NOT FIXED FOR OVER A YEAR DUE TO BACKORDERED PARTS.) FOLLOWING THE TECHNICAL DIAGNOSIS, BMW IS YET TO RESPOND TO DRIVER. *TR
NHTSA ODI #10662420
79,900 miles · Nov 7, 2014
Service Brakes
TL* THE CONTACT OWNS A 2009 BMW X5. THE CONTACT STATED THAT WHEN ENGAGING THE BRAKES, THE BRAKE PEDAL BECAME DIFFICULT TO DEPRESS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FA…
Read full complaint
TL* THE CONTACT OWNS A 2009 BMW X5. THE CONTACT STATED THAT WHEN ENGAGING THE BRAKES, THE BRAKE PEDAL BECAME DIFFICULT TO DEPRESS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 79,900.
NHTSA ODI #10653519
Mileage unknown · May 13, 2013
Service BrakesService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2009 BMW X5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 13V045000 (SERVICE BRAKES, SERVICE BRAKES, HYDRAULIC) AND CONTACTED THE DEALER TO SCHEDULE AN APPOINTMENT. THE DEALER WAS UNABLE TO PERFORM THE RECALL SERVICE AND ADVISED THE CONTACT THAT THE PART NEEDED TO COMPLETE THE REPAIR WAS UNA…
Read full complaint
TL* THE CONTACT OWNS A 2009 BMW X5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 13V045000 (SERVICE BRAKES, SERVICE BRAKES, HYDRAULIC) AND CONTACTED THE DEALER TO SCHEDULE AN APPOINTMENT. THE DEALER WAS UNABLE TO PERFORM THE RECALL SERVICE AND ADVISED THE CONTACT THAT THE PART NEEDED TO COMPLETE THE REPAIR WAS UNAVAILABLE. THE DEALER COULD NOT PROVIDE AN EXPECTED DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE SITUATION. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE CURRENT MILEAGE WAS 49,000. THE CONTACT HAD NOT EXPERIENCED A FAILURE. *TR
NHTSA ODI #10511748
70,000 miles · Mar 26, 2013
Service BrakesUnknown Or OtherVehicle Speed Control
WHEN LET GO OF BRAKE AFTER STOPPING AT RED LIGHT, VERY OFTEN THAT THIS VEHICLE MAKES A SUDDENT JUMP. THIS HAPPENS SO OFTEN THAT CAUSE A SAFETY CONCERN. *TR
NHTSA ODI #10504514
Official recalls
12Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2009-2012 X5 xDrive35d, 2008-2012 X6 xDrive35i, X6 xDrive50i and X6 M, 2007-2012 X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M and 2010-2011 X6 ActiveHybrid vehicles equipped with non-desiccated, passenger frontal air bag inflators containing phase stabilized ammonium nitrate (PSPI-2) propellant that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until this remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag, free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Jan 14, 2019
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, 2008-2014 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, 2009-2013 X5 xDrive35d vehicles and 2010-2011 X6 ActiveHybrid vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 14, 2019. Owners may contact BMW customer service at 1-800-525-7417.
May 23, 2018
BMW of North America, LLC (BMW) is recalling certain 2009-2013 X5 xDrive 35d diesel vehicles. The engine idler pulley bolt may loosen over time and break.
Consequence & remedy
Consequence: If the idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the idler pulley bolt with an improved part, free of charge. The recall began March 11, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Jan 9, 2018
BMW of North America, LLC (BMW) is recalling certain 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, 2009-2010 X5 xDrive35d vehicles and 2009-2013 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." BMW is also recalling certain 2007-2010 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." BMW is also recalling certain 2007-2009 X5 xDrive30i, X5 xdrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X5 xDrive35d, X6 xDrive35i, X6 xDrive50i and X6M vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the passenger front air bag module, free of charge. The recall is expected to begin March 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Jan 10, 2017
BMW of North America, LLC (BMW) is recalling certain 2012 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, X5 M, X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain 2009 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i, and X5 M vehicles, 2008-2009 X6 xDrive 35i, X6 xDrive50i, X6 M, and 2009 X5 xDrive35d vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, BMW is recalling certain 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M vehicles, and 2008 X6 xDrive35i, X6 xDrive50i, and X6 M vehicles originally sold, or ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the remedy is performed. BMW will notify owners, and dealers will replace the front passenger air bag inflator or air bag module, free of charge. Interim letters were mailed March 2017. Owners will receive a second notice when remedy parts become available. Owners may contact BMW customer service at 1-800-525-7417.
Oct 17, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Consequence & remedy
Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
May 25, 2016
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, 2009-2011 X5 xDrive35d vehicles, 2008-2011 X6 xDrive35i, X6 xDrive50i and X6 M vehicles, and 2010-2011 X6 ActiveHybrid vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, BMW is recalling certain model year 2007-2008 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5M vehicles, and 2008 BMW X6 xDrive35i, X6 xDrive50i and X6 M vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to high absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until they have been repaired. BMW will notify owners, and dealers will replace the passenger frontal air bag inflator or air bag module, free of charge. The recall began July 28, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Aug 7, 2013
BMW is recalling certain model year 2009-2010 X5 xDrive35d vehicles equipped with a diesel engine and manufactured from June 13, 2009, through November 9, 2009. The fuel filter heater, which is used for warming up the diesel fuel during vehicle operation at low outside temperatures, could experience an electrical overload condition and become permanently activated.
Consequence & remedy
Consequence: The fuel filter heater could remain activated even when the ignition is off and lead to a dead battery. The unit could also overheat, possibly resulting in a vehicle fire.
Remedy: BMW will notify owners, and dealers will replace the fuel filter heater, free of charge. The safety recall began on September 26, 2013. Owners may contact BMW customer relations at 1-800-525-7417.
Aug 19, 2011
BMW IS RECALLING CERTAIN MODEL YEAR 2009 X5 XDRIVE35D VEHICLES EQUIPPED WITH A DIESEL ENGINE AND MANUFACTURED FROM OCTOBER 1, 2008, THROUGH JUNE 12, 2009. THE FUEL FILTER HEATER, WHICH IS USED FOR WARMING UP THE DIESEL FUEL DURING VEHICLE OPERATION AT LOW OUTSIDE TEMPERATURES, COULD EXPERIENCE AN ELECTRICAL OVERLOAD CONDITION AND BECOME PERMANENTLY ACTIVATED.
Consequence & remedy
Consequence: THE FUEL FILTER HEATER COULD REMAIN ACTIVATED EVEN WHEN THE IGNITION IS OFF AND LEAD TO A DEAD BATTERY. THE UNIT COULD ALSO OVERHEAT, POSSIBLY LEADING TO A VEHICLE FIRE.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE FUEL FILTER HEATER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 11, 2011. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Jul 8, 2009
BMW IS RECALLING MY 2009 X5 AND X6 VEHICLES. THE REAR BRAKE DISCS MAY NOT HAVE BEEN MANUFACTURED ACCORDING TO SPECIFICATIONS. AS A RESULT, A REDUCTION IN BRAKING PERFORMANCE AT THE AFFECTED REAR WHEEL COULD OCCUR.
Consequence & remedy
Consequence: IN AN EXTREME CASE, THE AFFECTED REAR BRAKE DISC COULD BREAK RESULTING IN A LOSS OF BRAKING AT THAT WHEEL INCREASING STOPPING DISTANCES AND THE RISK OF A CRASH.
Remedy: BMW WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES BY INSPECTING THE REAR BRAKE DISCS AND, IF NECESSARY, REPLACE THEM FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 11, 2009. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES TOLL-FREE AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration