Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
WHILE DRIVING ON INTERSTATE IN HIGH SPEED LANE ENGINE SUDDENLY LOST POWER CREATING DANGER OF REAR END COLLISION. IN MOVING TO BREAK DOWN LANE ENGINE CONTINUED TO RUN BUT WOULD NOT PROPEL THE VEHICLE OVER 5 MPH. THIS PROBLEM HAD OCCURRED TWO WEEKS PREVIOUSLY WHEN THE VEHICLE WAS TOWED TO BMW DEALER FOR SERVICE. AT THAT TIME THE V…
Read full complaint
WHILE DRIVING ON INTERSTATE IN HIGH SPEED LANE ENGINE SUDDENLY LOST POWER CREATING DANGER OF REAR END COLLISION. IN MOVING TO BREAK DOWN LANE ENGINE CONTINUED TO RUN BUT WOULD NOT PROPEL THE VEHICLE OVER 5 MPH. THIS PROBLEM HAD OCCURRED TWO WEEKS PREVIOUSLY WHEN THE VEHICLE WAS TOWED TO BMW DEALER FOR SERVICE. AT THAT TIME THE VEHICLE WAS ELECTRONICALLY DIAGNOSED AND NO FAULTS WERE FOUND OR REPAIRS MADE.THE VEHICLE WAS AGAIN TOWED TO THE BMW DEALER AND NO ELECTRONIC FAULTS WERE FOUND. THIS TIME A MECHANICAL DIAGNOSIS WAS PERFORMED AND FUEL PRESSURE WAS FOUND TO BE 12 PSI RATHER THAT THE 55 PSI SPECIFIED. SUBSEQUENTLY THE CONTACTS IN THE FUEL PUMP RELAY WERE FOUND TO BE BURNED, THE FUEL FILTER AND PRESSURE REGULATOR WERE FOUND TO CONTAIN METAL SHARDS, THE FUEL PUMP SHOWED NO EXTERNAL SIGNS OF DAMAGE. ALL ITEMS WERE REPLACED AT WHICH TIME FUEL PRESSURE RETURNED TO 55 PSI AND THE VEHICLE WAS ABLE TO BE DRIVEN NORMALLY. THE CONCLUSION IS THAT THE FUEL PUMP CAN FAIL INTERNALLY WHICH CANNOT BE DETECTED BY ELECTRONIC DIAGNOSIS AND RETURNING A CAR TO THE ROAD WITHOUT PERFORMING THE MECHANICAL DIAGNOSES SPECIFIED IN THE FACTORY SERVICE LITERATURE IS A DANGEROUS AND NEGLIGENT PRACTICE BY THIS PARTICULAR BMW DEALER'S SERVICE DEPARTMENT AND MAY INDICATE AN INHERENT FLAW IN THE MANUFACTURE OF THE FUEL PUMP. PARTS REPLACED: 61 36 8 373 700 RELAY 16 12 6 754 016 FUEL FILTER PRESSURE REGULATOR 16 11 6 768 357 FUEL PUMP
NHTSA ODI #10916165
90,000 miles · Mar 25, 2015
EngineFuel/propulsion SystemFire
TL* THE CONTACT OWNS A 2006 BMW X5. WHILE THE VEHICLE WAS IDLING, THERE WAS SMOKE COMING FROM THE PASSENGER EXHAUST PIPE. THE VEHICLE WAS TAKEN TO BOTH A DEALER AND INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE VALVE STEM HAD A LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW X5. WHILE THE VEHICLE WAS IDLING, THERE WAS SMOKE COMING FROM THE PASSENGER EXHAUST PIPE. THE VEHICLE WAS TAKEN TO BOTH A DEALER AND INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE VALVE STEM HAD A LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #10701807
110,000 miles · Jun 11, 2012
EngineFuel/propulsion System
APPROXIMATELY 1 MONTH AFTER HAVING OUR BMW SERVICED FOR AN OIL CHANGE AT OUR LOCAL DEALER, THE "CHECK ENGINE OIL LEVEL" LIGHT ILLUMINATED. WE IMMEDIATELY CALLED THE DEALER, AND UPON THEM LOOKING AT IT, IT WAS DETERMINED THAT THE CRANKCASE VENT VALVE (OIL SEPARATOR), NEEDS TO BE REPLACED, AT A COST OF $1,300. WE HAVE BEEN HAVIN…
Read full complaint
APPROXIMATELY 1 MONTH AFTER HAVING OUR BMW SERVICED FOR AN OIL CHANGE AT OUR LOCAL DEALER, THE "CHECK ENGINE OIL LEVEL" LIGHT ILLUMINATED. WE IMMEDIATELY CALLED THE DEALER, AND UPON THEM LOOKING AT IT, IT WAS DETERMINED THAT THE CRANKCASE VENT VALVE (OIL SEPARATOR), NEEDS TO BE REPLACED, AT A COST OF $1,300. WE HAVE BEEN HAVING THIS LIGHT COME ON NUMEROUS TIMES OVER THE PAST COUPLE OF YEARS, AND ALWAYS CALL THE DEALER WHEN IT DOES. EVERY TIME WE CALL, THEY EITHER TELL ME TO TOP THE OIL OFF MYSELF, OR WE BRING IT TO THE DEALER FOR THEM TO TOP OFF. NOT ONCE DID SOMEONE MENTION THAT THIS ISSUE COULD BE A PROBLEM, AND THEY CONTINUED TO LET US DRIVE EVEN THOUGH THE ENGINE COULD HAVE BEEN DAMAGED IN DOING SO. A VERY QUICK INTERNET SEARCH REVEALS THAT THIS IS A VERY COMMON PROBLEM WITH THESE VEHICLES, AND BMW'S IN GENERAL, AND I THINK THEY SHOULD BE HELD RESPONSIBLE AND THE PART SHOULD BE COVERED. I NOW HAVE TO GET THIS DONE IMMEDIATELY, DUE TO THE FACT THAT THE CAR IS BURNING SO MUCH OIL DAILY, AROUND A QUART PER 1,000 MILES. I AM REACHING OUT TO HELP GET A RECALL ON THIS ISSUE. IF THERE IS ANY OTHER INFORMATION I CAN PROVIDE, PLEASE DO NOT HESITATE TO CONTACT ME. THANK YOU. *TR
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.
Consequence & remedy
Consequence: THIS COULD CAUSE THE PARKING LOCK SYSTEM NOT TO ENGAGE, AFTER THE TRANSMISSION IS PLACED IN THE PARK ("P") POSITION. IF THE VEHICLE WAS PARKED ON AN INCLINE, AND THE PARKING BRAKE WAS NOT ENGAGED, THIS COULD RESULT IN A VEHICLE ROLLAWAY CONDITION.
Remedy: DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT BMW AT 1-800-332-4269.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
1
EA08001 · BMW Airbag Light Illumination
Opened Jan 4, 2008 · Closed Dec 31, 2008
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Additional source detail variants (3)
Air Bags
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
Air Bags:frontal:sensor/control MODULE-INACTIVE
BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND MY06/ 3-SERIES WITH SPORT SEATS. IN ADDITION, BMW WILL EXTEND THE WARRANTY COVERAGE OF THE PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT TO 10-YEAR/UNLIMITED MILEAGE ON APPROXIMATELY 120,000 REMAINING MY04-06 SUBJECT VEHICLES BUILT THROUGH 11/30/05. THE SPECIFIC VEHICLES INCLUDED IN THE EXTENDED WARRANTY ARE MY 06/ 6 SERIES, MY 06/ 3-SERIES WITH STANDARD SEATS, MY04-05/ Z4, MY04-06/ 7 SERIES, MY 06/ X5, AND MY04-06/ 5-SERIES WITH COMFORT SEATS.THE AVERAGE FREQUENCY OF FAILURES AMONG THE EXTENDED WARRANTY GROUPS WAS LESS THAN 1/7TH OF THE RECALL VEHICLE GROUPS.PLEASE SEE BMW'S 08V-384 RECALL NOTIFICATION FOR FURTHER DETAILSDEPENDING ON SEAT CONFIGURATION AND VEHICLE GEOMETRY, THE OCCUPANT DETECTION MAT CAN FATIGUE DURING USE DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT.SPECIFICALLY, OVER TIME, MICRO-CRACKS COULD DEVELOP IN THE SIDE FLANKS OF THE MAT CAUSING A BROKEN CIRCUIT.A BROKENCIRCUIT CAN LEAD TO THE DEACTIVATION OF THE PASSENGER AIR BAG AND THE ILLUMINATION OF BOTH THE AIR BAG WARNING LIGHT AND THE PASSENGER AIR BAG LIGHT.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration