IllustrationVehicle rpm’s rev wildly in park and neutral. When driving vehicle speeds up on its own and rpm’s climbs out of control. When stopped at a light or in traffic, car leaps forward against the break .
2004 BMW X5
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 BMW X5 do not stand out strongly from the model-year median of 100.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all X5 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
725–50K
950–75K
1275–100K
11100–150K
9150K+
55 reports with mileage · 9 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports10 fire reports5 injury reports
Unknown Or Other complaints
3 reportsVEHICLE STARTED SMOKING FROM UNDER THE CAR AND AIR VENTS WHILE CAR WAS IN MOTION AIR CONDITIONING WAS RUNNING AND THE OWNER PULLED OVER AND THE FIRE DEPARTMENT PUT OUT THE FIRE AND BROKE 3 WINDOWS UNNECESSARILY IN THE PROCESS. CAR ENDED UP BEING TOTALED AND RESIDES AT OWNERS PROPERTY. COULD BE BASED ON OTHER REPORTS AND A POSSIB…
Read full complaint
VEHICLE STARTED SMOKING FROM UNDER THE CAR AND AIR VENTS WHILE CAR WAS IN MOTION AIR CONDITIONING WAS RUNNING AND THE OWNER PULLED OVER AND THE FIRE DEPARTMENT PUT OUT THE FIRE AND BROKE 3 WINDOWS UNNECESSARILY IN THE PROCESS. CAR ENDED UP BEING TOTALED AND RESIDES AT OWNERS PROPERTY. COULD BE BASED ON OTHER REPORTS AND A POSSIBLE RECALL ON BLOWER MOTOR ON 2001-2003 RECALLS WERE CHECKED AND ARE CURRENT ON THIS VEHICLE CHECKED BY DEALER AND NHTSA WEBSITE
WATER DAMAGE. THE VEHICLE HAS TAKEN WATER IN THE REAR TRUNK AREA. WHEN LOOKED AT, THERE IS A PUDDLE OF STANDING WATER COVERING THE ELECTRONIC COMPONENTS SUCH AS THE RADIO AMPLIFIER AND OTHER ELECTRONICS. VEHICLE WAS STATIONARY AND NOT MOVING. WATER SEEMS TO OCCUR ONLY WHEN RAINING. RADIO AND SPEAKERS DO NOT WORK AND GIVE OFF A R…
Read full complaint
WATER DAMAGE. THE VEHICLE HAS TAKEN WATER IN THE REAR TRUNK AREA. WHEN LOOKED AT, THERE IS A PUDDLE OF STANDING WATER COVERING THE ELECTRONIC COMPONENTS SUCH AS THE RADIO AMPLIFIER AND OTHER ELECTRONICS. VEHICLE WAS STATIONARY AND NOT MOVING. WATER SEEMS TO OCCUR ONLY WHEN RAINING. RADIO AND SPEAKERS DO NOT WORK AND GIVE OFF A RUFFLING SOUND EVEN WHEN KEY IS OUT OF THE IGNITION. WE HAVE DISCONNECTED THE BATTERY FROM THE CAR TO PREVENT ANY FURTHER DAMAGES.
Official recalls
404V409000 · Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
Aug 18, 2004
ON CERTAIN PASSENGER VEHICLES WITH 3.0 L ENGINES AND MANUAL TRANSMISSIONS, IF THE VEHICLE IS IN FIRST GEAR, AND MOVING SLOWLY, WITH THE ACCELERATOR PEDAL HELD IN A CONSTANT POSITION OF LOW ENGINE SPEED AND WITH THE CLUTCH PEDAL HELD IN A PARTIALLY DEPRESSED POSITION, ENGINE SPEED MAY INCREASE.
Consequence & remedy
Consequence: THE VEHICLE COULD ACCELERATE UNEXPECTEDLY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
04V402000 · Fuel System, Gasoline:delivery:fuel Pump
Aug 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE IN-TANK FUEL LINE MAY HAVE BEEN ATTACHED INCORRECTLY.
Consequence & remedy
Consequence: ENGINE STALLING COULD OCCUR, EVEN THOUGH THE VEHICLE'S FUEL GAUGE INDICATES THAT FUEL IS PRESENT IN THE TANK. DEPENDING UPON TRAFFIC AND ROAD CONDITIONS, THIS COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE IN-TANK SUCTION JET PUMP FUEL LINE AND IF NECESSARY, REATTACH ACCORDING TO SPECIFICATIONS. THIS RECALL BEGAN SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
04V344000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jul 14, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.
Consequence & remedy
Consequence: AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION. THE VEHICLE MAY NOT BE ABLE TO RESTART. ALSO, A LOSS OF POWER STEERING AND, AFTER REPEATED ACTUATION OF THE BRAKE PEDAL, A LOSS OF BRAKE POWER ASSIST WILL OCCUR. THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
03V475000 · Power Train:driveline:differential Unit
Nov 14, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE BOLTS THAT HOLD THE FRONT DIFFERENTIAL, THE RIGHT OUTPUT SHAFT HOUSING FLANGE AT THE ENGINE, AND THE RIGHT-HAND ENGINE SUPPORT MAY BE INSUFFICIENTLY TIGHTENED.
Consequence & remedy
Consequence: WITH PROLONGED DRIVING, THESE BOLTS COULD BECOME LOOSE, CAUSE DAMAGE TO THE ENGINE AND TRANSMISSION HOUSINGS. THE RIGHT OUTPUT SHAFT COULD BECOME DISCONNECTED, AFFECTING THE ABILITY TO CONTROL THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE DRIVETRAIN FASTENERS. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.