TL*THE CONTACT OWNS A 2004 BMW X5. WHILE DRIVING APPROXIMATELY 35 MPH THE BATTERY, 4X4, AND TRANS FAIL SAFE LIGHTS ILLUMINATED ON THE DASHBOARD. THE WINDSHIELD WIPERS TURNED ON AND THE VEHICLE STALLED. ONCE THE VEHICLE STALLED THE BRAKES NO LONGER FUNCTIONED CAUSING THE CONTACT TO COAST IN ORDER TO STOP THE VEHICLE. THE VEHICL…
Read full complaint
TL*THE CONTACT OWNS A 2004 BMW X5. WHILE DRIVING APPROXIMATELY 35 MPH THE BATTERY, 4X4, AND TRANS FAIL SAFE LIGHTS ILLUMINATED ON THE DASHBOARD. THE WINDSHIELD WIPERS TURNED ON AND THE VEHICLE STALLED. ONCE THE VEHICLE STALLED THE BRAKES NO LONGER FUNCTIONED CAUSING THE CONTACT TO COAST IN ORDER TO STOP THE VEHICLE. THE VEHICLE WOULD NOT RESTART SO IT WAS TOWED TO AN AUTHORIZED DEALER WHERE THE FAILURE WAS IN THE PROCESS OF BEING DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 102,000.
NHTSA ODI #10371269
Mileage unknown · Feb 7, 2005
Engine And Engine CoolingFuel System, Gasoline
NHTSA RECALL CAMPAIGN 04V344000 CONCERNING ENGINE CONTROL MODULE/ENGINE STALLING. AFTER HAVING THE NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT INSTALLED THE VEHICLE STALLED. VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES, BUT MECHANIC COULD NOT DUPLICATE THE PROBLEM. WHILE THE VEHICLE WAS PARKED THE DRIVER NOTICED FLUID LEA…
Read full complaint
NHTSA RECALL CAMPAIGN 04V344000 CONCERNING ENGINE CONTROL MODULE/ENGINE STALLING. AFTER HAVING THE NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT INSTALLED THE VEHICLE STALLED. VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES, BUT MECHANIC COULD NOT DUPLICATE THE PROBLEM. WHILE THE VEHICLE WAS PARKED THE DRIVER NOTICED FLUID LEAKING FROM UNDERNEATH HE VEHICLE. IT WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC REPLACED THE FUEL HOSE. HOWEVER, THE PROBLEM RECURRED. *AK
ON CERTAIN PASSENGER VEHICLES WITH 3.0 L ENGINES AND MANUAL TRANSMISSIONS, IF THE VEHICLE IS IN FIRST GEAR, AND MOVING SLOWLY, WITH THE ACCELERATOR PEDAL HELD IN A CONSTANT POSITION OF LOW ENGINE SPEED AND WITH THE CLUTCH PEDAL HELD IN A PARTIALLY DEPRESSED POSITION, ENGINE SPEED MAY INCREASE.
Consequence & remedy
Consequence: THE VEHICLE COULD ACCELERATE UNEXPECTEDLY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN SPORT UTILITY VEHICLES, THE IN-TANK FUEL LINE MAY HAVE BEEN ATTACHED INCORRECTLY.
Consequence & remedy
Consequence: ENGINE STALLING COULD OCCUR, EVEN THOUGH THE VEHICLE'S FUEL GAUGE INDICATES THAT FUEL IS PRESENT IN THE TANK. DEPENDING UPON TRAFFIC AND ROAD CONDITIONS, THIS COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE IN-TANK SUCTION JET PUMP FUEL LINE AND IF NECESSARY, REATTACH ACCORDING TO SPECIFICATIONS. THIS RECALL BEGAN SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.
Consequence & remedy
Consequence: AS A RESULT, ENGINE STALLING WILL OCCUR AFTER A SHORT PERIOD OF OPERATION. THE VEHICLE MAY NOT BE ABLE TO RESTART. ALSO, A LOSS OF POWER STEERING AND, AFTER REPEATED ACTUATION OF THE BRAKE PEDAL, A LOSS OF BRAKE POWER ASSIST WILL OCCUR. THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN SPORT UTILITY VEHICLES, THE BOLTS THAT HOLD THE FRONT DIFFERENTIAL, THE RIGHT OUTPUT SHAFT HOUSING FLANGE AT THE ENGINE, AND THE RIGHT-HAND ENGINE SUPPORT MAY BE INSUFFICIENTLY TIGHTENED.
Consequence & remedy
Consequence: WITH PROLONGED DRIVING, THESE BOLTS COULD BECOME LOOSE, CAUSE DAMAGE TO THE ENGINE AND TRANSMISSION HOUSINGS. THE RIGHT OUTPUT SHAFT COULD BECOME DISCONNECTED, AFFECTING THE ABILITY TO CONTROL THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND RETIGHTEN THE DRIVETRAIN FASTENERS. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 BMW X5 Problems, Complaints & Recalls | Skip That Year
Illustration